radiator cap JEEP GRAND CHEROKEE 2015 WK2 / 4.G SRT Owners Manual

supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If the temperature gauge reads HOT
(H), pull over and stop the vehicle. Idle the vehicle
with the air conditioner turned off until the pointer
drops back into the normal range. If the pointer
remains on HOT (H), and you hear continuous
chimes, turn the engine off immediately and call for
service.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
WHEEL AND TIRE TORQUE SPECIFICATIONS
Proper lug nut/bolt torque is very important to ensure
that the wheel is properly mounted to the vehicle. Any
time a wheel has been removed and reinstalled on the
vehicle the lug nuts/bolts should be torqued using a
properly calibrated torque wrench.
6
WHAT TO DO IN EMERGENCIES 501

ENGINE COMPARTMENT — 6.4L
1 — Power Distribution Center (Fuses) 6 — Air Cleaner Filter
2 — Engine Oil Dipstick 7 — Power Steering Fluid Reservoir
3 — Engine Oil Fill 8 — Coolant Pressure Cap (Radiator)
4 — Brake Fluid Reservoir 9 — Engine Coolant Reservoir
5 — Washer Fluid Reservoir
7
MAINTAINING YOUR VEHICLE 527

Installing The Rear Wiper
1. Lift the rear wiper arm pivot cap away from the glass
to allow the rear wiper blade to be raised off of the
glass.
NOTE:The rear wiper arm cannot be fully raised off the
glass unless the wiper arm pivot cap is unsnapped first.
Attempting to fully raise the rear wiper arm without
unsnapping the wiper arm pivot cap may damage the
vehicle.
2. Lift the rear wiper arm fully off the glass.
3. Insert the wiper blade pivot pin into the opening on
the end of the wiper arm. Grab the bottom end of the
wiper arm with one hand, and press the wiper blade
flush with the wiper arm until it snaps into place.
4. Lower the wiper blade onto the glass and snap the
wiper arm pivot cap back into place.Adding Washer Fluid
This vehicle is equipped with a Driver Information
Display (DID), the DID will indicate when the washer
fluid level is low. When the sensor detects a low fluid
level, the windshield will light on the vehicle graphic
outline and the “WASHER FLUID LOW” message will be
displayed.
The fluid reservoir for the windshield washers and the
rear window washer is shared. The fluid reservoir is
located in the engine compartment, be sure to check the
fluid level at regular intervals. Fill the reservoir with
windshield washer solvent only (not radiator antifreeze).
When refilling the washer fluid reservoir, take some
washer fluid and apply it to a cloth or towel and wipe
clean the wiper blades, this will help blade performance.
To prevent freeze-up of your windshield washer system
in cold weather, select a solution or mixture that meets or
exceeds the temperature range of your climate. This
7
MAINTAINING YOUR VEHICLE 553

In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune-up to manufacturer’s specifica-
tions, should be obtained immediately.
To minimize the possibility of catalytic converter dam-
age:
•Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion.
•Do not try to start the engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idle or malfunctioning operating conditions.Cooling System
WARNING!
•When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the OFF position. The fan is temperature
controlled and can start at any time the ignition
switch is in the ON position.
•You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had
time to cool. Never try to open a cooling system
pressure cap when the radiator is hot.
Coolant Checks
Check the engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
556 MAINTAINING YOUR VEHICLE

applicable). If the engine coolant (antifreeze) is dirty, the
system should be drained, flushed, and refilled with
fresh OAT coolant (conforming to MS.90032) only by an
authorized dealer. Check the front of the A/C condenser
for any accumulation of bugs, leaves, etc. If dirty, clean by
gently spraying water from a garden hose vertically
down the face of the condenser.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
engine coolant (antifreeze) from the radiator drain cock.
If the cap is sealing properly, the engine coolant (anti-
freeze) will begin to drain from the coolant recoverybottle. DO NOT REMOVE THE COOLANT PRESSURE
CAP WHEN THE COOLING SYSTEM IS HOT.
Cooling System — Drain, Flush And Refill
NOTE:Some vehicles require special tools to add coolant
properly. Failure to fill these systems properly could lead
to severe internal engine damage. If any coolant is
needed to be added to the system please contact your
local authorized dealer.
If the engine coolant (antifreeze) is dirty or contains
visible sediment, have an authorized dealer clean and
flush with OAT coolant (antifreeze) (conforming to
MS.90032).
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
7
MAINTAINING YOUR VEHICLE 557

HOAT and OAT coolant are mixed in an emergency,
have a authorized dealer drain, flush, and refill with
OAT coolant (conforming to MS.90032) as soon as
possible.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
recovery tank.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is
overheated. Do not loosen or remove the cap to cool
(Continued)
WARNING!(Continued)
an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scalding
or injury, do not remove the pressure cap while the
system is hot or under pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant in open containers or allow it to remain in
560 MAINTAINING YOUR VEHICLE

puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine OFF and cold, the level of the engine coolant
(antifreeze) in the bottle should be between the ranges
indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator/coolant pressure cap
unless checking for engine coolant (antifreeze) freeze
point or replacing coolant. Advise your service attendant
of this. As long as the engine operating temperature is
satisfactory, the coolant bottle need only be checked once
a month.When additional engine coolant (antifreeze) is needed to
maintain the proper level, only OAT coolant that meets
the requirements of FCA Material Standard MS.90032
should be added to the coolant bottle. Do not overfill.Points To Remember
NOTE:When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
7
MAINTAINING YOUR VEHICLE 561

Master Cylinder........................563
Parking..............................423
Warning Light.........................286
Brake/Transmission Interlock.................405
Bulb Replacement......................583, 585
Bulbs, Light.............................111
Camera, Rear............................237
Capacities, Fluid..........................591
Caps, Filler
Oil (Engine)........................533, 534
Radiator (Coolant Pressure)................560
Carbon Monoxide Warning...............108, 474
Cargo Area Cover.........................272
Cargo Area Features.......................270
Cargo Compartment.......................270
Light................................271
Cargo Light.............................271
Cargo Tie-Downs.........................274Car Washes.............................569
Cellular Phone...........................364
Center High Mounted Stop Light..............590
Certification Label.........................479
Chains, Tire.............................460
Chart, Tire Sizing.........................437
Check Engine Light (Malfunction Indicator Light) . .528
Checking Your Vehicle For Safety..............107
Checks, Safety...........................107
Child Restraint............................82
Child Restraints
Booster Seats...........................87
Child Restraints.........................82
Child Seat Installation....................101
How To Stow An Unused ALR Seat Belt........98
Infants And Child Restraints................85
Install A LATCH-Compatible Child Restraint....97
Installing Child Restraints Using The Vehicle Seat
Belt..................................99
616 INDEX

LATCH Positions........................90
Lower Anchors And Tethers For Children.......89
Older Children And Child Restraints..........85
Seating Positions........................88
Child Safety Locks.........................34
Clean Air Gasoline........................471
Cleaning
Wheels...............................570
Climate Control..........................366
Automatic............................366
Cold Weather Operation....................402
Compact Disc (CD) Maintenance..............363
Compact Spare Tire........................455
Console, Overhead........................240
Contract, Service..........................607
Coolant Pressure Cap (Radiator Cap)...........560
Cooling System...........................556
Adding Coolant (Antifreeze)...............558
Coolant Capacity.......................591Coolant Level......................556, 561
Disposal Of Used Coolant.................560
Drain, Flush, And Refill...................557
Inspection............................561
Points To Remember.....................561
Pressure Cap..........................560
Radiator Cap..........................560
Selection Of Coolant (Antifreeze)......558, 591, 592
Corrosion Protection.......................568
Cruise Control (Speed Control)................187
Cupholders.............................265
Customer Assistance.......................605
Data Recorder, Event.......................81
Daytime Running Lights....................167
Dealer Service............................530
Defroster, Rear Window.....................277
Defroster, Windshield......................110
10
INDEX 617

Pregnant Women And Seat Belts...............59
Preparation For Jacking.....................505
Pretensioners
Seat Belts..............................60
Programming Transmitters (Remote Keyless Entry) . .22
Radial Ply Tires..........................451
Radiator Cap (Coolant Pressure Cap)...........560
Radio Operation..........................364
Radio Remote Controls.....................362
Radio (Sound Systems).....................340
Rain Sensitive Wiper System.................179
Rear Axle (Differential).....................564
Rear Camera............................237
Rear Cross Path..........................138
Rear Cupholder..........................265
Rear ParkSense System..................218, 227
Rear Seat, Folding.........................156
Rear Window Features.....................276Rear Wiper/Washer........................276
Reclining Front Seats.......................146
Recorder, Event Data.......................81
Recreational Towing.......................497
Reformulated Gasoline.....................471
Refrigerant..............................542
Reminder, Seat Belt.........................51
Remote Control
Starting System.......................24, 28
Remote Keyless Entry (RKE)..................22
Arm The Alarm.........................20
FCC General Information..................27
Panic Alarm............................25
Programming Additional Key Fobs.........19, 26
Programming Additional Transmitters.......19, 26
Remote Sound System (Radio) Controls.........362
Remote Starting System...................24, 28
Replacement Bulbs........................583
Replacement Keys.........................18
626 INDEX