automatic transmission JEEP LIBERTY 2004 KJ / 1.G Owner's Manual

To check the automatic transmission fluid level properly,
the following procedure must be used:
1. The vehicle must be on level ground.
2. The engine should be running at curb idle speed for a
minimum of 60 seconds.
3. Fully apply parking brake.
4. Apply the brakes and shift the transmission into P
(Park).
5. The fluidMUSTbe checked with the transmission in
P (Park) to be sure that the fluid level is accurate.
6. Wipe the dipstick clean and reinsert until seated.
Remove dipstick and note reading.
At normal operating temperature (approximately 180É F
(82É C), the fluid level is correct if it is in the HOT region(cross-hatched area) on the oil level indicator. The fluid
level indicator should be in the COLD region at 70É F (21É
C) fluid temperature.
If the fluid level is low, add sufficient fluid to bring to the
proper level. Refer to Recommended Fluids, Lubricants
and Genuine Parts for correct fluid type.
Fluid is added through the dipstick tube.
NOTE:To prevent dirt and water from entering the
transmission after checking or replenishing fluid, make
certain that the dipstick cap is properly reseated.
Special Additives
The manufacturer recommends against the addition of
any additives to the transmission. Exception to this
policy is the use of special dyes to aid in detecting fluid
leaks.
312 MAINTAINING YOUR VEHICLE

Cavity Fuse Description
37 10 Amp Red Airbag Control Module
38 10 Amp Red ABS Controller/Shifter As-
sembly
39 10 Amp Red Hazard Flasher (Turn
Signals)/Backup Lamp
Switch (Manual Transmission
Only)/Transmission Range
Switch (Automatic Transmis-
sion Only)
Underhood Fuses (Power Distribution Center)
Your vehicle is equipped with an electrical power distri-
bution center located in the engine compartment near the
battery. This power center houses plug-in ªCartridgeº
fuses which replace in-line fusible links. The power
center also contains ªMiniº fuses and plug-in full and
micro ISO relays. A label inside the latching cover of thecenter identifies each component for ease of replacement,
if necessary. ªCartridgeº fuses and relays can be obtained
from your authorized dealer.
MAINTAINING YOUR VEHICLE 323
7

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission MopartATF+4 Automatic Transmission Fluid
Manual Transmission MopartManual Transmission Lubricant (P/N 04874464)
Transfer Case MopartATF+4 Automatic Transmission Fluid
Axle Differential (front-rear) MopartSAE 75W-140 (API GL5) Synthetic Gear Lubricant or equivalent.
The 8.25 Corporate Rear Axle should use a SAE 75W-90 Gear Lubricant.
For trailer towing, the lubricant should be replaced with SAE 75W-140
Synthetic Gear Lubricant. Models equipped with Trac-LokŸ require a fric-
tion modifier additive.
Brake Master Cylinder MopartDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Power Steering Reservoir MopartATF+4 Automatic Transmission Fluid
Ball Joints, Prop Shafts, U-Joints,
Yokes, & Wheel BearingsMopartMulti-Purpose Lube NLGI Grade 2 EP, GC-LB
328 MAINTAINING YOUR VEHICLE

Miles 48,000 51,000 54,000 57,000 60,000
(Kilometers) (77 000) (82 000) (86 000) (91 000) (96 000)
Change the engine oil and engine oil filter. X X X X X
Inspect the engine air filter element, replace if
necessary.X
Replace the spark plugs.X
Inspect and replace the PCV valve, if necessary.LX
Replace the ignition cables (2.4L Only).X
Inspect the brake linings. X X
Drain and refill the front and rear axle fluid³ X X
Drain and refill the automatic transmission fluid,
and replace main sump filter.X
Inspect the drive belt and replace as needed. Not
required if belt was previouslyX
Drain and refill the transfer case fluid. X
336 SCHEDULE ªBº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108,000 111,000 114,000 117,000 120,000
(Kilometers) (173 000) (178 000) (182 000) (187 000) (192 000)
Change the engine oil and engine oil filter. X X X X X
Inspect the engine air filter element, replace if
necessary.X
Replace the spark plugs.X
Inspect and replace the PCV valve, if necessary.LX
Replace the ignition cables (2.4L Only).X
Inspect the brake linings. X X
Drain and refill the front and rear axle fluid³ X X
Drain and refill the automatic transmission fluid,
and replace main sump filter.X
Inspect the drive belt and replace as needed. Not
required if belt was previously replaced.X
Drain and refill the transfer case fluid. X
340 SCHEDULE ªBº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Washer Fluid..................... 204
Air Cleaner, Engine...................... 297
Air Conditioner Maintenance............... 299
Air Conditioning........................ 200
Air Conditioning Controls...............200,201
Air Conditioning, Operating Tips............ 202
Air Conditioning Refrigerant............... 300
Air Conditioning System.................. 200
Air Filter.............................. 297
Air Pressure, Tires....................... 249
Airbag................................ 46
Airbag Deployment....................... 55
Airbag Light.......................51,58,157
Airbag Maintenance....................... 57
Airbag, Window......................... 47
Alarm................................ 28
Alarm, Panic............................ 25
Alignment and Balance................... 253
Alterations/Modifications, Vehicle............. 8Antenna, Satellite Radio................... 193
Antifreeze (Engine Coolant)................ 326
Anti-Lock Brake System................... 234
Anti-Lock Warning Light.................. 152
Appearance Care........................ 315
Arming Theft System...................... 28
Auto Down Power Windows................ 33
Automatic Dimming Mirror................. 76
Automatic Door Locks..................... 21
Automatic Transmission................216,311
Adding Fluid......................... 312
Fluid and Filter Changes................. 311
Fluid Level Check...................... 311
Fluid Type........................... 311
Gear Ranges.......................... 217
Shifting............................. 216
Special Additives...................... 312
Torque Converter...................... 221
Auxiliary Electrical Outlet.................. 133
358 INDEX

Flashers
Hazard Warning....................... 272
Turn Signal.......................... 151
Flat Tire Changing....................... 274
Flooded Engine Starting................... 211
Fluid Capacities......................... 326
Fluid Leaks............................. 70
Fluid Level Checks....................... 70
Automatic Transmission................. 311
Clutch Fluid.......................... 313
Engine Oil........................... 290
Manual Transmission................... 313
Power Steering........................ 300
Fog Lights............................. 102
Folding Rear Seat........................ 94
Four Wheel Drive....................... 222
Operation........................... 222
Shifting..........................225,230
Systems..........................222,226Four-Way Hazard Flasher.................. 272
Front Axle............................. 315
Fuel................................. 259
Filler Cap............................ 262
Filler Door........................... 262
Gasoline............................ 259
Gauge.............................. 157
Materials Added....................... 262
Octane Rating........................ 259
Requirements......................259,326
Tank Capacity........................ 326
Fuel System Caution..................... 263
Fuses................................ 320
Garage Door Opener..................... 125
GasCap .............................. 262
Gasoline.............................. 259
Gasoline, Reformulated................... 260
Gasoline/Oxygenate Blends................ 260
INDEX 363
10

Dome.............................. 111
Fog ................................ 102
Four-Wheel Drive Indicator............... 152
Fuses............................... 320
Hazard Warning Flasher................. 272
Headlight Switch...................... 101
Headlights........................... 101
Headlights On Reminder................. 102
Headlights On With Wipers............... 101
High Beam Indicator.................... 151
Instrument Cluster..................... 101
Intensity Control....................... 99
Interior.............................. 98
Lights On Reminder.................... 102
Low Fuel............................ 157
Malfunction Indicator................... 152
Map Reading......................... 100
Oil Pressure.......................... 155
Park............................... 101Passing............................. 101
Reading............................. 111
Seat Belt Reminder..................... 157
Sentry Key........................... 157
Transfer Case......................155,156
Transmission Warning................... 155
Turn Signal........................101,151
Warning (Instrument Cluster Description)..... 151
Loading Vehicle
Tires ............................... 244
Locks
Automatic Door........................ 21
Child Protection........................ 22
Door................................ 18
Power Door........................... 21
Steering Wheel......................... 17
Lower Anchors and Tether for CHildren
(LATCH)............................62,63
Lubrication, Body....................... 301
366 INDEX

Lug Nuts............................. 278
Luggage Carrier......................... 142
Luggage Rack.......................... 142
Maintenance Free Battery.................. 298
Maintenance Procedures................... 290
Maintenance Schedule.................... 330
Light Duty Schedule9A9................. 342
Light Duty Schedule9B9................. 333
Schedule9A9......................... 342
Schedule9B9.......................... 333
Maintenance, Sunroof..................... 132
Malfunction Indicator Light..............152,288
Manual, Service......................... 354
Manual Transmission..................213,313
Fluid Level Check...................... 313
Lubricant Selection..................... 313
Shift Speeds.......................... 215
Map/Reading Lights..................... 111Master Cylinder......................... 310
Mini-Trip Computer...................... 120
Mirrors................................ 75
Automatic Dimming..................... 76
Electric Remote........................ 77
Heated.............................. 78
Outside.............................. 76
Rearview............................. 75
Vanity............................... 78
Modifications/Alterations, Vehicle............. 8
Monitor, Tire Pressure System............ 113,254
Mopar Parts.........................289,353
Multi-Function Control Lever............... 100
New Vehicle Break-In Period................ 68
Occupant Classification System............... 51
Occupant Restraints....................... 34
Octane Rating, Gasoline................... 259
INDEX 367
10

Security Against Theft...................20,28
Security Alarm.......................... 28
Selection of Oil......................... 293
Selec-Trac Operation...................... 226
Sentry Key............................. 14
Sentry Key Programming................... 16
Sentry Key Replacement................... 15
Service Assistance....................... 348
Service Contract......................... 350
Service Manuals........................ 354
Setting the Clock........................ 158
Shift Speeds, Manual Transmission........... 215
Shifting............................... 213
Automatic Transmission................. 216
Manual Transmission................... 213
Transfer Case......................225,230
Shoulder Belt Upper Anchorage.............. 40
Shoulder Belts........................... 35
Signals, Turn........................101,151Slippery Surfaces, Driving On............... 237
Snow Chains........................... 257
Snow Plow............................ 270
Spare Tire............................. 275
Spark Plugs............................ 295
Specifications
Fuel................................ 259
Oil ................................ 293
Speed Control.......................... 108
Speedometer........................... 151
Starting............................... 210
Automatic Transmission................. 210
Cold Weather......................... 211
Emergency (Jump Starting)............... 279
Engine Block Heater.................... 212
Engine Fails to Start.................... 211
Manual Transmission................... 210
Starting Procedures...................... 210
INDEX 371
10