brake fluid JEEP WRANGLER 2016 JK / 3.G User Guide
[x] Cancel search | Manufacturer: JEEP, Model Year: 2016, Model line: WRANGLER, Model: JEEP WRANGLER 2016 JK / 3.GPages: 705, PDF Size: 5.5 MB
Page 634 of 705
WARNING!(Continued)
cause it to boil unexpectedly during hard or pro-
longed braking, resulting in sudden brake failure.
This could result in a collision.
• Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.
• Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in a collision.
Automatic Transmission — If Equipped
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life. Use only the manufacturer’s specified transmission fluid.
Refer to “Fluids, Lubricants, And Genuine Parts” in this
section for fluid specifications. It is important to maintain
the transmission fluid at the correct level using the
recommended fluid.
NOTE:
No chemical flushes should be used in any
transmission; only the approved lubricant should be
used.
CAUTION!
Using a transmission fluid other than the manufac-
turer’s recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder, and will require more frequent fluid and
filter changes. Refer to “Fluids, Lubricants, And
Genuine Parts” in this section for fluid specifica-
tions.
632 MAINTAINING YOUR VEHICLE
Page 635 of 705
Special Additives
The manufacturer strongly recommends against using
any special additives in the transmission.
Automatic Transmission Fluid (ATF) is an engineered
product and its performance may be impaired by supple-
mental additives. Therefore, do not add any fluid addi-
tives to the transmission. The only exception to this
policy is the use of special dyes for diagnosing fluid
leaks. Avoid using transmission sealers as they may
adversely affect seals.
CAUTION!
Do not use chemical flushes in your transmission as
the chemicals can damage your transmission compo-
nents. Such damage is not covered by the New
Vehicle Limited Warranty.
Fluid Level Check
It is best to check the fluid level when the transmission is
at normal operating temperature (approximately 180°F/
82°C). This occurs after at least 15 miles (25 km) of
driving. At normal operating temperature, the fluid
cannot be held comfortably between the fingertips.
Use the following procedure to check the transmission
fluid level properly:
1. Park the vehicle on level ground.
2. Remove the engine cover by pulling it up off themounting studs (two in the front and two in the rear).
3. Run the engine at idle speed and normal operating temperature.
4. Fully apply the parking brake, and press the brake pedal.
7
MAINTAINING YOUR VEHICLE 633
Page 637 of 705
CAUTION!
If the fluid temperature is below 50°F (10°C) it may
not register on the dipstick. Do not add fluid until
the temperature is elevated enough to produce an
accurate reading. Run the engine at idle, in PARK, to
warm the fluid.
8. Reinstall the engine cover and snap it down securely onto the four mounting studs.
9. Check for leaks. Release the parking brake.
NOTE: To prevent dirt and water from entering the
transmission after checking or replenishing fluid, make
sure that the dipstick cap is properly reseated. It is
normal for the dipstick cap to spring back slightly from
its fully seated position, as long as its seal remains
engaged in the dipstick tube.
Fluid And Filter Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
In addition, change the fluid and filter if the fluid
becomes contaminated (with water, etc.), or if the trans-
mission is disassembled for any reason.
Clutch Hydraulic System (Manual Transmission)
— If Equipped
The clutch hydraulic system is fed by a segregated
volume of fluid within the brake system master cylinder
reservoir. In the event of leakage or wear, use only the
manufacturer’s recommended brake fluid. Refer to “Flu-
ids, Lubricants, And Genuine Parts” in “Maintaining
Your Vehicle” for further information.
7
MAINTAINING YOUR VEHICLE 635
Page 664 of 705
Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission –
If Equipped Use only ATF+4 Automatic Transmission Fluid. Failure to use ATF+4 fluid may affect
the function or performance of your transmission. We recommend MOPAR ATF+4
fluid.
Manual Transmission – If
Equipped We recommend you use MOPAR Manual Transmission Lubricant meeting the
requirements of FCA Material Standard MS-9224.
Transfer Case We recommend you use MOPAR ATF+4 Automatic Transmission Fluid.
Axle Differential (Front) We recommend you use MOPAR Gear & Axle Lubricant (SAE 80W-90) (API GL-5).
Axle Differential (Rear) 226 RBI (Model 44)– We recommend you use MOPAR Gear & Axle Lubricant (SAE
80W-90) (API GL-5) or equivalent. For trailer towing, use MOPAR Synthetic Gear &
Axle Lubricant (SAE 75W-140). Models equipped with Trac-Lok require an additive.
Brake Master Cylinder We recommend you use MOPAR DOT 3 Brake Fluid, SAE J1703. If DOT 3, SAE J1703 brake fluid is not available, then DOT 4 is acceptable.
Power Steering Reservoir We recommend you use MOPAR Power Steering Fluid +4, MOPAR ATF+4 Automatic Transmission Fluid.
662 MAINTAINING YOUR VEHICLE
Page 667 of 705
NOTE:Under no circumstances should oil change inter-
vals exceed 10,000 miles (16,000 km), twelve months or
350 hours of engine run time, whichever comes first. The
350 hours of engine run or idle time is generally only a
concern for fleet customers.
Severe Duty All Models
Change Engine Oil at 4,000 miles (6,500 km) if the vehicle
is operated in a dusty and off road environment or is
operated predominately at idle or only very low engine
RPM’s. This type of vehicle use is considered Severe
Duty. Once A Month Or Before A Long Trip:
•
Check engine oil level
• Check windshield washer fluid level
• Check the tire inflation pressures and look for unusual
wear or damage
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and automatic trans-
mission, and fill as needed
• Check function of all interior and exterior lights
8
MAINTENANCE SCHEDULES 665
Page 668 of 705
Required Maintenance Intervals
Refer to the maintenance schedules on the following
page for the required maintenance intervals.
At Every Oil Change Interval As Indicated By OilChange Indicator System:
•Change oil and filter
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required
• Inspect automatic transmission fluid if equipped
with dipstick
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake
At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
•Inspect engine cooling system protection and
hoses
• Inspect exhaust system
• Inspect engine air cleaner if using in dusty or
off-road conditions
• Inspect all door latches for presence of grease,
reapply if necessary.
Maintenance Chart
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
666 MAINTENANCE SCHEDULES
Page 669 of 705
Mileage or time passed (whichevercomes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Additional Inspections
Inspect the CV/Universal joints. X X X X XXX
Inspect front suspension, tie rod ends,
and replace if necessary. XXX X X X X
Inspect the front and rear axle fluid. X XX X
Inspect the brake linings, replace as
necessary XXX X X X X
Adjust parking brake on vehicles
equipped with four wheel disc brakes. XXX X X X X
Inspect transfer case fluid. XX X
Additional Maintenance
Replace engine air cleaner filter. XX X X X
8
MAINTENANCE SCHEDULES 667
Page 685 of 705
Automatic Dimming Mirror..................112
Automatic Door Locks ......................41
Automatic Headlights ..................... .169
Automatic Oil Change Indicator ...............353
Automatic Temperature Control (ATC) ..........419
Automatic Transmission ..............445, 632, 635
Adding Fluid ......................... .635
Fluid And Filter Changes ..................635
Fluid Change ......................... .635
Fluid Level Check ...................... .633
Fluid Type ........................ .632, 662
Special Additives ...................... .633
Autostick .............................. .451
Auxiliary Electrical Outlet (Power Outlet) ........185
Auxiliary Power Outlet .....................185
Axle Fluid ............................. .662
Axle Lock .............................. .459
Battery ............................ .315, 609Charging System Light
...................315
Keyless Transmitter Replacement (RKE) ........27
Belts, Seat .............................. .101
Body Mechanism Lubrication .................614
B-Pillar Location ......................... .505
Brake Assist System ...................... .484
Brake Control System, Electronic ..............481
Brake Fluid ............................ .662
Brakes ................................ .480
Brake System ........................ .480, 630
Master Cylinder ....................... .631
Parking ............................. .478
Warning Light ..................... .318, 480
Brake/Transmission Interlock .................444
Bulb Replacement ..................... .654, 656
Bulbs, Light ......................... .104, 654
Calibration, Compass .................. .341, 349
Capacities,
Fluid ......................... .659
10
INDEX 683
Page 689 of 705
Compartment Identification................595
Coolant (Antifreeze) .....................660
Cooling ............................. .624
Exhaust Gas Caution .................100, 538
Fails To Start ......................... .435
Flooded, Starting ...................... .435
Fuel Requirements ...................534, 659
Jump Starting ......................... .581
Oil .......................... .600, 659, 660
Oil Change Interval ..................... .353
Oil Filter ............................ .603
Oil Selection ...................... .601, 659
Oil Synthetic ......................... .602
Overheating .......................... .570
Starting .......................... .434, 435
Engine Oil Viscosity ...................... .602
Engine Oil Viscosity Chart ...................602
Enhanced Accident Response Feature ............71
Entry System, Illuminated ....................21 Ethanol
............................... .535
Event Data Recorder ........................74
Exhaust Gas Caution ...................100, 538
Exhaust System ...................... .100, 622
Exterior Lights .......................... .104
Fabric Care ............................. .644
Fabric Top ............................. .644
Filters Air Cleaner .......................... .603
Air Conditioning ....................427, 612
Engine Oil ........................ .603, 660
Engine Oil Disposal .....................602
Flashers Hazard Warning ....................... .570
Turn Signal .....................104, 657, 658
Flash-To-Pass ........................... .171
Flooded Engine Starting ....................435
Fluid, Brake ............................ .662
10
INDEX 687
Page 693 of 705
Leaks, Fluid............................ .104
Life Of Tires ............................ .519
Light Bulbs ......................... .104, 654
Lights ............................. .104, 168
AirBag ........................71, 101, 320
Automatic Headlights ....................169
Back-Up ............................. .658
Brake Assist Warning ....................494
Brake Warning ..................... .318, 480
Bulb Replacement ...................... .656
Cargo .............................. .174
Center Mounted Stop ....................658
Daytime Running ...................... .172
Exterior ............................. .104
Fog............................. .171, 657
Hazard Warning Flasher ..................570
Headlights ........................ .169, 656
Headlight Switch ...................... .169
Hill Descent Control Indicator ..............497Illuminated Entry
........................21
Instrument Cluster ..................... .169
Interior ............................. .173
Lights On Reminder .....................171
Malfunction Indicator (Check Engine) .........326
Passing ............................. .171
Rear Servicing ........................ .658
Rear Tail Lamps ....................... .658
Seat Belt Reminder ..................... .316
Security Alarm ........................ .322
Service .............................. .656
Side Marker .......................... .658
Tire Pressure Monitoring (TPMS) ............328
Traction Control ....................... .494
Turn Signal ..................104, 170, 657, 658
Loading Vehicle ......................... .541
Tires ............................... .505
Locking
Axle........................... .459
Locks ..................................3810
INDEX 691