battery KIA AMANTI 2006 Owner's Guide

Maintenance34
7
1
2
3
4
5
6
7
8
910
4. Carefully insert a new rubber
blade and install the blade assem-
bly in the reverse order of removal.Install the blade with the tabs facingtowards the bottom of the wiper arm.
BATTERY
MMSA7017
WARNING
- Battery
dangers
Always read the follow-
ing instructions carefully
when handling a battery.
Keep lighted cigarettes and all other flames or
sparks away from the
battery.
Hydrogen, which is a highly combustible gas,
is always present in bat-
tery cells and may
explode if ignited.
Keep batteries out of the reach of children
because batteries con-
tain highly corrosive
SULFURIC ACID. Do not
allow battery acid to con-
tact your skin, eyes,
clothing or paint finish.
(Continued)
(Continued)If any electrolyte getsinto your eyes, flush your
eyes with clean water for
at least 15 minutes and
get immediate medical
attention. If possible,
continue to apply water
with a sponge or cloth
until medical attention is
received.
If electrolyte gets on
your skin, thoroughly
wash the contacted area.
If you feel a pain or a
burning sensation, get
medical attention imme-
diately.
Wear eye protection when charging or work-
ing near a battery.
Always provide ventila-
tion when working in an
enclosed space.
(Continued)

735
Maintenance
1
2
3
4
5
6
7
8
910
For best battery service :Keep the battery securely mount-
ed.
 Keep the battery top clean and dry.
 Keep the terminals and connec-
tions clean, tight, and coated with
petroleum jelly or terminal grease.
 Rinse any spilled electrolyte from
the battery immediately with a
solution of water and baking soda.
 If the vehicle is not going to be
used for an extended time, discon-
nect the battery cables.
Battery recharging Your vehicle has a maintenance-free,
calcium-based battery.
If the battery becomes discharged
in a short time (because, for exam-
ple, the headlights or interior lights
were left on while the vehicle was
not in use), recharge it by slow
charging (trickle) for 10 hours.
 If the battery gradually discharges
because of high electric load while
the vehicle is being used, recharge
it at 20-30A for two hours.
CBGQ0705
(Continued)
When lifting a plastic-cased
battery, excessive pressure on
the case may cause battery
acid to leak, resulting in per-
sonal injury. Lift with a battery
carrier or with your hands on
opposite corners.
 Never attempt to charge the
battery when the battery
cables are connected.
 The electrical ignition system
works with high voltage.
Never touch these compo-
nents with the engine running
or the ignition switched on.

Maintenance36
7
1
2
3
4
5
6
7
8
910
Items to be reset after the battery
has been discharged or the bat-tery has been disconnected. Driver seat position memory sys-
tem (See page 3-34)
 Power window (See page 3-15)
 Clock (See page 3-106)
 Climate control system (See pages
4-59)
 Audio (See the audio manual)
 Sunroof (See page 3-110)
✽ ✽
NOTICE• Before performing maintenance
or recharging the battery, turn off
all accessories and stop the engine.
• The negative battery cable must be removed first and installed last
when the battery is disconnected.
WARNING
- Recharging
battery
When recharging the battery,
observe the following precau-
tions:
 The battery must be removed
from the vehicle and placed in
an area with good ventilation.
 Do not allow cigarettes,
sparks, or flame near the bat-
tery.
 Watch the battery during
charging, and stop or reduce
the charging rate if the battery
cells begin gassing (boiling)
violently or if the temperature
of the electrolyte of any cell
exceeds 120°F (49°C).
 Wear eye protection when
checking the battery during
charging.
(Continued)
(Continued)
Disconnect the battery charg-
er in the following order.
1. Turn off the battery charger main switch.
2. Unhook the negative clamp from the negative battery ter-
minal.
3. Unhook the positive clamp from the positive battery ter-
minal.

83
1
2
3
4
5
6
7
8
910
Specifications
EngineElectrical system
ItemGasoline Engine
BoreXStroke 3.66 in X 3.38 in (93 mm X 85.8 mm)
Displacement 3497 cc (213.3 cu.in)
Compression Ratio 10.0
SizeGasoline Engine
Battery 12V / 80AH (20HR)
Alternator 13.5V / 120A
Starter 12V-1.2kW
Spark Plug Gap
1.0 mm ~ 1.1 mm
Specification PFR5N-11, RC10PYPB4

Consumer assistance29Roadside Assistance is provided on all new 2006 model
Kia Vehicles from the date the vehicle is delivered to the
first retail buyer or otherwise put into use (in-service
date), whichever is earlier, for a period of 60
months/60000 miles.Toll Free Consumer AssistanceKia's toll-free Consumer Assistance hot line is staffed
from 5:00 AM to 6:00 PM PST, Monday through Friday
and is accessible by dialing 1-800-333-4Kia.
For more information regarding assistance available,
please refer to your Kia Warranty & Consumer
Information Manual.Emergency Roadside AssistanceKia's toll free Roadside Assistance hot line is staffed 24
hours a day, 365 days a year and is accessible by dialing
1-800-333-4Kia.
Kia has set up a network of over 17,000 roadside assis-
tance providers. Should you accidentally run out of fuel,
require a battery jump, or need help changing a tire, a Kia
Roadside Assistance Representative will dispatch (at no
charge to you) someone to deliver a small quantity of
gas, change a flat tire with your inflated spare, or arrange
a battery jump to allow you to proceed to your destina-
tion. Kia also has a network of over 10,000 locksmiths to
help you when you’re locked out of your Kia, also at no
charge.In the event that mechanical difficulty renders your vehi-
cle undriveable, Kia’s Roadside Assistance
Representative will arrange to transport your vehicle to
the nearest Kia dealer or to an alternative service loca-
tion.
Your vehicle must be accessible to our dispatch transport
vehicle, as determined by our driver, to receive this serv-
ice. In the event that Kia does not have a dealer or an
alternative service location available in a particular loca-
tion, Kia will work with a reputable local service facility to
ensure that you receive prompt service. Warranty repairs
are performed at no cost.
Trip InterruptionTrip interruption expense benefits are provided in the
event that a warranty-related disablement occurs more
than 150 miles from your home, and the repairs require
more than 24 hours to complete. Reasonable reimburse-
ment is included for meals, lodging, or rental car expens-
es. Trip interruption coverage is limited to $100 per day
subject to a three day maximum limit per incident, and
you are required to contact the Kia Roadside Assistance
Center to obtain pre-authorization of expenses. Once the
Kia Roadside Assistance Center gives authorization for
trip interruption benefits, they will assist you in making
the necessary arrangements. Insurance deductibles,
expenses, and claims paid by your insurance company or
other providers are not eligible for reimbursement.
1
2
3
4
5
6
7
8
910

Index2
10Air Bag - Advanced Supplemental Restraint System . 3-60
Air Bag Warning Light . . . . . . . . . . . . . . . . . . . . . . . 3-81
Air Cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Air Conditioner (Specifications) . . . . . . . . . . . . . . . . 4-66
Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-30
Air Conditioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-63 Button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-62
System Operation Tips . . . . . . . . . . . . . . . . . . . . . . 4-64
Air Intake Control Button . . . . . . . . . . . . . . . . . . . . . 4-58
Alignment, Tire Balance and Wheel . . . . . . . . . . . . . 7-39
Aluminum Wheel Maintenance . . . . . . . . . . . . . . . . . 7-56
Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-111
Anti-Lock Brake System . . . . . . . . . . . . . . . . . . . . . . 4-15 Warning Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-36
Anti-Theft Steering Column Lock, Ignition Switch and . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-102
Automatic Climate Control System . . . . . . . . . . . . . . . . . . . . . 4-54
Headlight Aiming . . . . . . . . . . . . . . . . . . . . . . . . . 4-47
Power Window . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
Transaxle . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5, 7-25
Transaxle (Specifications) . . . . . . . . . . . . . . . . . . . . 8-5
Transaxle Fluid Level, Checking the . . . . . . . . . . . 7-25
Window Reversal . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
Balance, Wheel Alignment and Tire . . . . . . . . . . . . . 7-39 Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-34
Recharging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-35
Service, for Best . . . . . . . . . . . . . . . . . . . . . . . . . . 7-35
Before Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
Belts, Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-36
Pre-tensioner, seat . . . . . . . . . . . . . . . . . . . . . . . . . 3-36
Blade Replacement, Windshield Wiper . . . . . . . . . . . 7-32
Blades, Wiper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-32
Body Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-28
Brake Fluid Level, Checking . . . . . . . . . . . . . . . . . . . . . . 7-21
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13, 7-22
System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
System, Anti-Lock . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
Wear Indicators, Disc . . . . . . . . . . . . . . . . . . . . . . . 4-12
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
7-21 Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Break-In Process, Vehicle . . . . . . . . . . . . . . . . . . . . . . 1-2
Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-44
Bulbs, Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Capacities (Specifications) . . . . . . . . . . . . . . . . . . . . . 8-5
Capacity, Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-17
Care of the Safety Belt System, Proper Use and . . . . . . . 3-47
Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-53
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . 7-57
1
2
3
4
5
6
7
8
910
AB
C

10 7
Index
Oil And Filter, Changing the Engine . . . . . . . . . . . . . . 7-15
Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-17
Engine and Oil Filter . . . . . . . . . . . . . . . . . . . . . . . 7-15
Filter, Engine Oil and . . . . . . . . . . . . . . . . . . . . . . . 7-15
Level, Checking the Engine . . . . . . . . . . . . . . . . . . 7-15
Pressure Warning, Engine . . . . . . . . . . . . . . . . . . . 4-37
One-Touch Wipers . . . . . . . . . . . . . . . . . . . . . . . . . . 4-50
Outside Rearview Mirrors . . . . . . . . . . . . . . . . . . . . . 3-92
Overheating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-3
Overloading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-20
Owner Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . 7-11 Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-13
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13, 7-22
Brake and Brake Fluid Warning . . . . . . . . . . . . . . . 4-38
Power Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Socket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-105
Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18, 7-24
Steering Fluid Level, Checking the . . . . . . . . . . . . 7-24
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-15
Pregnant Women, Restraint of . . . . . . . . . . . . . . . . . . 3-47
Proper Use and Care of the Safety Belt System . . . . . 3-47
Push-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6 Rain, Driving in the . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
Rear
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-67
Door Child Safety Lock . . . . . . . . . . . . . . . . . . . . . 3-12
Lap/Shoulder Belt . . . . . . . . . . . . . . . . . . . . . . . . . 3-45
Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
3-30
Window Defroster . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
Rearview Mirrors Day/Night . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-94
Outside . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-92
Recharging, Battery . . . . . . . . . . . . . . . . . . . . . . . . . 7-35
Recliner, Adjusting the Driver’s seatback . . . . . . . . . . . . . . . 3-22
Adjusting seatback (Front Passenger Seat) . . . . . . . 3-26
Recommended Lubricants . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-51
SAE Viscosity Number . . . . . . . . . . . . . . . . . . . . . 7-52
Registering Your Vehicle in a Foreign Country . . . . . . 9-3
Relay panel description . . . . . . . . . . . . . . . . . . . . . . . 6-10
Reminder Warning Chime, Key . . . . . . . . . . . . . . . . . 4-43
Remote Keyless entry . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Reporting Safety Defects . . . . . . . . . . . . . . . . . . . . . . 9-4
Restraint Of Infants and Small Children . . . . . . . . . . . . . . . . 3-48
Of Large Children . . . . . . . . . . . . . . . . . . . . . . . . . 3-49
Of Pregnant Women . . . . . . . . . . . . . . . . . . . . . . . . 3-47
System, Child . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-50
System, Safety Belt . . . . . . . . . . . . . . . . . . . . . . . . 3-39
1
2
3
4
5
6
7
8
910
P
R