check engine KIA Carens 2017 3.G Repair Manual
[x] Cancel search | Manufacturer: KIA, Model Year: 2017, Model line: Carens, Model: KIA Carens 2017 3.GPages: 625, PDF Size: 19.69 MB
Page 601 of 625
8101
Maintenance
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in
the canister are drawn into the surge
tank through the purge control sole-
noid valve.
Purge Control Solenoid Valve(PCSV)
The purge control solenoid valve is
controlled by the Engine Control
Module (ECM); when the engine
coolant temperature is low during
idling, the PCSV closes so that evap-
orated fuel is not taken into the
engine. After the engine warms up
during ordinary driving, the PCSV
opens to introduce evaporated fuel to
the engine.
3. Exhaust emission control system
The Exhaust Emission Control
System is a highly effective system
which controls exhaust emissions
while maintaining good vehicle per-
formance.
Vehicle modifications
This vehicle should not be modified.
Modification of your vehicle could
affect its performance, safety or
durability and may even violate gov-
ernmental safety and emissions reg-
ulations.
In addition, damage or performance
problems resulting from any modifi-
cation may not be covered under
warranty.
If you use unauthorized electronic
devices, it may cause the vehicle to
operate abnormally, wire damage,
battery discharge and fire. For your
safety, do not use unauthorized
electronic devices.
Engine exhaust gas precautions(carbon monoxide)
Carbon monoxide can be present with other exhaust fumes.
Therefore, if you smell exhaust
fumes of any kind inside your vehi-
cle, have it inspected and repaired
immediately. If you ever suspect
exhaust fumes are coming into
your vehicle, drive it only with all
the windows fully open. Have your
vehicle checked and repaired
immediately.
WARNING- Exhaust
Engine exhaust gases contain
carbon monoxide (CO). Though
colorless and odorless, it is
dangerous and could be lethal if
inhaled. Follow the instructions
on this page to avoid CO poi-
soning.
Page 610 of 625
97
Specifications & Consumer information
Recommended SAE viscosity
number
Always be sure to clean the area
around any filler plug, drain plug, or
dipstick before checking or draining
any lubricant. This is especially
important in dusty or sandy areas
and when the vehicle is used on
unpaved roads. Cleaning the plug
and dipstick areas will prevent dirt
and grit from entering the engine and
other mechanisms that could be
damaged.Engine oil viscosity (thickness) has
an effect on fuel economy and cold
weather operation (engine start and
engine oil flowability). Lower viscosi-
ty engine oils can provide better fuel
economy and cold weather perform-
ance, however, higher viscosity
engine oils are required for satisfac-
tory lubrication in hot weather.
Using oils of any viscosity other than
those recommended could result in
engine damage.
When choosing an oil, consider the
range of temperature your vehicle will
be operated in before the next oil
change. Proceed to select the recom-
mended oil viscosity from the chart
Temperature Range for SAE Viscosity Numbers
Temperature
Engine Oil *
1
°C
(°F)-30 -20 -10 0 10 20 30 40 50 -10 0 20 40 60 80 100 120
10W-30
5W-20, 5W-30
*1For better fuel economy, it is recommended to use the
engine oil of a viscosity grade SAE 5W-20 (API SM / ILSAC
GF-4). However, if the engine oil is not available in your
country, select the proper engine oil using the engine oil vis-
cosity chart.
Page 615 of 625
I3
Index
Battery........................................................................\
....8-45For best battery service ..............................................8-45
Battery recharging ......................................................8-46
Reset items ..................................................................8-47
Battery replacement ........................................................4-7
Battery saver function..................................................4-104
Before driving ..................................................................6-4
Blind Spot Detection System(BSD) ..............................6-49 BSD (Blind Spot Detection) /LCA (Lane Change Assist) ......................................6-50
RCTA (Rear cross traffic alert) ..................................6-53
Driver's Attention ........................................................6-56
Bonnet see the hood ......................................................4-35
Brake fluid ....................................................................8-35\
Checking the brake fluid level ....................................8-35
Brake system..................................................................6-23 Power brakes ..............................................................6-23
Parking brake - Hand type ..........................................6-25
Electronic parking brake (EPB) ..................................6-27
Anti-lock brake system (ABS)....................................6-32
Electronic stability control (ESC) ..............................6-35
Vehicle stability management (VSM) ........................6-39
Hill-start assist control (HAC) ....................................6-40
Bulb wattage ....................................................................9-3 Camera (Rear view) ......................................................4-87
Capacities (Lubricants) ....................................................9-6
Care
Care of seat belts ........................................................3-40
SRS Care ....................................................................3-79\
Tire care ......................................................................8-\
48
Exterior care ................................................................8-92
Interior care ................................................................8-97
Cargo security screen ..................................................4-167
Center console storage ................................................4-152
Central door lock switch................................................4-23
Checking tire inflation pressure ....................................8-51
Child restraint system ....................................................3-42 Securing a child restraint withthe LATCHanchors system ..........................................................3-48
Securing a child restraint seatwith "Tether Anchor" system ......................................................................3-\
47
Placing a passenger seat beltinto the auto lock mode ...... 3-44
Child-protector rear door lock ......................................4-26
Clean air ......................................................................4-\
151
Climate control air filter ................................................8-40 Filter inspection ..........................................................8-40
Coat hook ....................................................................4-16\
4
Combined instrument, see instrument cluster ..............4-58
Coolant ........................................................................\
..8-31
Cooling fluid, see engine coolant ..................................8-31
BC
Page 617 of 625
I5
Index
Engine compartment ........................................................2-6
Engine compartment ........................................................8-3
Engine coolant ..............................................................8-31Checking the coolant level..........................................8-31\
Changing the coolant ..................................................8-33
Engine Coolant Temperature Gauge..............................4-61
Engine number ................................................................9-9
Engine oil ......................................................................8-\
29 Checking the engine oil level ....................................8-29
Changing the engine oil and filter ..............................8-30
Engine overheats..............................................................7-8
Engine start/stop button ..................................................6-9 Illuminated engine start/stop button ............................6-9
Engine start/stop button position ..................................6-9
Starting the engine ......................................................6-12
Engine start/stop button illumination ..............................6-9
Engine start/stop button position ....................................6-9
Engine will not start ........................................................7-4
Evaporative emission control (including ORVR: Onboard Refueling Vapor Recovery) system ............8-100
Exhaust emission control system ................................8-101
Explanation of scheduled maintenance items ..............8-25 Engine oil and filter ....................................................8-25
Drive belts ..................................................................8-25
Fuel filter ..................................................................8-25
Fuel lines, fuel hoses and connections ......................8-25
Vapor hose and fuel filler cap ....................................8-25
Vacuum crankcase ventilation hoses ..........................8-26 Air cleaner filter ..........................................................8-26
Spark plugs ................................................................8-26
Cooling system ..........................................................8-26
Coolant ................................................................\
......8-26
Automatic transaxle fluid............................................8-2\
6
Brake hoses and lines..................................................8\
-27
Brake fluid ..................................................................8-27
Parking brake ............................................................8-27
Brake discs, pads, calipers and rotors ........................8-27
Suspension mounting bolts ........................................8-27
Steering gear box, linkage & boots/lower arm ball joint ........................................8-28
Drive shafts and boots ................................................8-28
Air conditioning refrigerant ......................................8-28
Exterior care ..................................................................8-92
Exterior features ..........................................................4-172 Roof rack ..................................................................4-172
Exterior overview (Front) ................................................2-2
Exterior overview (Rear) ................................................2-3
Flat tire ........................................................................\
..7-15 Jack and tools ..............................................................7-15
Removing and storing the spare tire ..........................7-16
Changing tires ............................................................7-17
Removing and storing the spare tire ..........................7-16
Changing tires ............................................................7-17
F
Page 621 of 625
I9
Index
MaintenanceEngine compartment ....................................................8-3
Maintenance services ....................................................8-4
Owner maintenance ......................................................8-6
Scheduled maintenance service ....................................8-8
Explanation of scheduled maintenance items ............8-25
Tire maintenance ........................................................8-56
Maintenance schedule......................................................8-8 Normal Maintenance Schedule ....................................8-9
Maintenance Under Severe Usage Conditions ..........8-23
Maintenance services ......................................................8-4 Owner’s responsibility ..................................................8-4
Owner maintenance precautions ..................................8-5
Manual Climate Control system ..................................4-124 Heating and air conditioning ....................................4-125
System operation ......................................................4-130
Climate control air filter ..........................................4-132
Checking the amount of air conditioner refrigerant and compressor lubricant ......................4-133
Map lamp ....................................................................4-118
Mirrors ........................................................................\
..4-53 Inside rearview mirror ................................................4-53
Day/night rearview mirror ..........................................4-53
Electrochromic mirror (ECM) ..................................4-54
Outside rearview mirror ..............................................4-55
Remote control ............................................................4-56
Folding the outside rearview mirror ..........................4-56 Occupant Detection System ..........................................3-57
Odometer ......................................................................4-\
62
Oil (Engine) ..................................................................8-29
Outside rearview mirror ................................................4-55
Overheats ........................................................................\
7-8
Owner maintenance ........................................................8-6
Owner maintenance schedule ......................................8-6
Paddle shifter - Automatic transaxle ............................6-19
Parking assist system ....................................................4-97 Operation of the parking assist system ......................4-98
Non-operational conditions of parking assist system ..4-100
Self-diagnosis............................................................4-102
Parking brake ................................................................8-37 Checking the parking brake ........................................8-37
Parking brake - Hand type ............................................6-25
Parking light position ..................................................4-106
Placing a passenger seat beltinto the auto lock mode ...... 3-44
Portable lamp usage ....................................................4-169
Power outlet ................................................................4-163
Power window lock button ............................................4-33
Precautions ....................................................................3-37\
Pre-tensioner seat belt....................................................3-34
M
P
O