air condition KIA CEED 2011 Workshop Manual

751
Maintenance
Remove the valve cap from the tire
valve stem. Press the tire gage firm-
ly onto the valve to get a pressure
measurement. If the cold tire inflationpressure matches the recommendedpressure on the tire and loading
information label, no further adjust-
ment is necessary. If the pressure is
low, add air until you reach the rec-ommended amount.
If you overfill the tire, release air by pushing on the metal stem in the
center of the tire valve. Recheck the
tire pressure with the tire gage. Be
sure to put the valve caps back on
the valve stems. They help prevent
leaks by keeping out dirt and mois-
ture.Tire rotation
To equalize tread wear, it is recom- mended that the tires be rotated
every 12,000 km (7,500 miles) or
sooner if irregular wear develops.
During rotation, check the tires for
correct balance.
When rotating tires, check for uneven
wear and damage. Abnormal wear is
usually caused by incorrect tire pres-
sure, improper wheel alignment, out-
of-balance wheels, severe braking or
severe cornering. Look for bumps or
bulges in the tread or side of tire.
Replace the tire if you find either of
these conditions. Replace the tire if
fabric or cord is visible. After rotation,
be sure to bring the front and rear tire
pressures to specification and check
lug nut tightness.
Refer to “Tire and wheels” in section 8.
WARNING
 Inspect your tires frequently for proper inflation as well as
wear and damage. Always use
a tire pressure gauge.
 Tires with too much or too little pressure wear unevenly caus-
ing poor handling, loss of vehi-
cle control, and sudden tirefailure leading to accidents,
injuries, and even death. Therecommended cold tire pres-
sure for your vehicle can be
found in this manual and onthe tire label located on the dri-
ver's side center pillar.
 Worn tires can cause acci- dents. Replace tires that are
worn, show uneven wear, or
are damaged.
 Remember to check the pres- sure of your spare tire. KIA
recommends that you check
the spare every time you
check the pressure of the
other tires on your vehicle.
ED(FL) ENG 7.QXP 10/28/2010 6:27 PM Page 51

757
Maintenance
5. Maximum permissible inflationpressure
This number is the greatest amount of air pressure that should be put in
the tire. Do not exceed the maximum
permissible inflation pressure. Refer
to the Tire and Loading Information
label for recommended inflation
pressure.
6. Maximum load rating
This number indicates the maximum
load in kilograms and pounds that
can be carried by the tire. When
replacing the tires on the vehicle,
always use a tire that has the same
load rating as the factory installed
tire.
7. Uniform tire quality grading
Quality grades can be found where
applicable on the tire sidewall
between tread shoulder and maxi-
mum section width.
For example:
TREAD wear 200
TRACTION AA
TEMPERATURE A
Tread wear
The tread wear grade is a compara-
tive rating based on the wear rate ofthe tire when tested under controlled
conditions on a specified govern-
ment test course. For example, a tire
graded 150 would wear one-and-a-
half times (1½) as well on the gov-
ernment course as a tire graded 100.
The relative performance of tires depends upon the actual conditions
of their use, however, and may
depart significantly from the norm
due to variations in driving habits,
service practices and differences in
road characteristics and climate. These grades are molded on the
side-walls of passenger vehicle tires.
The tires available as standard or
optional equipment on your vehicle
may vary with respect to grade.
Traction - AA, A, B & C
The traction grades, from highest to
lowest, are AA, A, B and C. Those
grades represent the tire’s ability to
stop on wet pavement measuredunder controlled conditions on spec-
ified government test surfaces of
asphalt and concrete. A tire marked
C may have poor traction perform-
ance.
WARNING
The traction grade assigned to this tire is based on straight-ahead braking traction tests,
and does not include accelera-
tion, cornering, hydroplaning,
or peak traction characteristics.
ED(FL) ENG 7.QXP 10/28/2010 6:27 PM Page 57

Maintenance
64
7
Inner fuse panel
Description Fuse rating Protected component
START 10A Start motor solenoid
A/CON SW 10A Air-conditioning system HTD MIRR 10A Outside review mirror defrosterSEAT HTR 15A Seat warmer A/CON 10A Air-conditioning system
HEAD LAMP 10A Headlight FR WIPER 25A Wiper (front)
RR WIPER 15A Rear wiper DRL OFF - Daytime running light offRR FOG 10A Fog light (rear)
P/WDW (LH) 25A Power window (left) CLOCK 10A Clock
C/LIGHTER 15A Cigar lighter DR LOCK 20A Sunroof, Door lock/unlockDEICER 15A Front deicer STOP 15A Stop lamp switch
ROOM LP 15A Room lamp AUDIO 15A Audio, Trip ComputerT/LID 15A Tailgate, Folding mirror
SAFETY P/WDW RH 25A Safety power window (right) SAFETY P/WDW LH 25A Safety power window (left) P/WDW(RH) 25A Power window (right)P/OUTLET 15A Power outlet T/SIG 10A Switch module
ED(FL) ENG 7.QXP 10/28/2010 6:28 PM Page 64

Maintenance
82
7
Corrosion protection
Protecting your vehicle from corrosion
By using the most advanced design and
construction practices to combat corro-
sion, we produce vehicles of the highest
quality. However, this is only part of the
job. To achieve the long-term corrosion
resistance your vehicle can deliver, the
owner's cooperation and assistance isalso required.
Common causes of corrosion The most common causes of corrosion
on your vehicle are:
 Road salt, dirt and moisture that is
allowed to accumulate underneath the
vehicle.
 Removal of paint or protective coatings by stones, gravel, abrasion or minor
scrapes and dents which leave unpro-
tected metal exposed to corrosion. High-corrosion areas
If you live in an area where your vehicle
is regularly exposed to corrosive materi-
als, corrosion protection is particularly
important. Some of the common causes
of accelerated corrosion are road salts,
dust control chemicals, ocean air and
industrial pollution.
Moisture breeds corrosion Moisture creates the conditions in which
corrosion is most likely to occur. For
example, corrosion is accelerated by
high humidity, particularly when tempera-
tures are just above freezing. In such
conditions, the corrosive material is kept
in contact with the vehicle’s surface by
moisture that slowly evaporates.
Mud is particularly corrosive because it
dries slowly and holds moisture in con-
tact with the vehicle. Although the mud
appears to be dry, it can still retain mois-ture and promote corrosion.
High temperatures can also accelerate
corrosion of parts that are not properly
ventilated so the moisture can be dis-
persed. For all these reasons, it is par-
ticularly important to keep your vehicle
clean and free of mud or accumulations
of other materials. This applies not only
to the visible surfaces but particularly to
the underside of the vehicle.
ED(FL) ENG 7.QXP 10/28/2010 6:30 PM Page 82

Maintenance
88
7
Diesel Particulate Filter (if equipped)
The Diesel Particulate Filter (DPF) sys-
tem removes the soot emitted from the
vehicle.
Unlike a disposable air filter, the DPF
system automatically burns (oxidizes)
and removes the accumulated soot
according to the driving condition. In
other words, the active burning by engine
control system and high exhaust gas
temperature caused by normal/high driv-
ing condition burns and removes the
accumulated soot.
However, if the vehicle continues to be
driven at low speed for long time, the
accumulated soot may not be automati-
cally removed because of low exhaust
gas temperature. In this particular case,the amount of soot is out of detection
limit, the soot oxidation process by
engine control system may not happen
and the malfunction indicator light may
blink. When the malfunction indicator light
blinks, it may stop blinking by driving the
vehicle at more than 60km/h (37 mph) orat more than second gear with 1500 ~
2000 engine rpm for a certain time (for
about 25 minutes). If the malfunction indicator light contin-
ues to be blinked in spite of the proce-
dure, please visit an authorized KIA deal-
er and then check the DPF system.
If you continue to drive with the malfunc-
tion indicator light blinking for a long
time, the DPF system can be damaged
and fuel consumption can be worsen.
CAUTION -
Diesel Fuel
(if equipped with DPF)
It is recommended to use the regu- lated automotive diesel fuel for diesel vehicle equipped with the
DPF system.
If you use diesel fuel including highsulfur (more than 50 ppm sulfur) and unspecified additives, it can
cause the DPF system to be dam- aged and white smoke can be emit-ted.
ED(FL) ENG 7.QXP 10/28/2010 6:30 PM Page 88

Index
2
I
Air bags ···········································································3-37
Air bag warning label................................................3-58
Air bag warning light ................................................3-40
Curtain air bag ..........................................................3-50
Driver's and passenger's front air bag ......................3-43
Passenger’s front air bag ON/OFF indicator ............3-47
Passenger’s front air bag ON/OFF switch ................3-46
Side impact air bag....................................................3-48
Air cleaner·······································································7-39
Alarm system ····································································4-8
Antenna ·········································································4-104
Anti-lock brake system (ABS) ·······································5-21
Appearance care······························································7-79 Exterior care ······························································7-79
Interior care ·······························································7-84
Armrest ···········································································3-14
Ashtray ············································································4-93
Audio system ································································4-104 Antenna ···································································4-104
Aux, USB and iPod ···················································4-96
Automatic climate control system ··································4-79 Air conditioning ························································4-85
Automatic heating and air conditioning····················4-80
Manual heating and air conditioning ························4-81
Automatic transaxle ························································5-12 Shift lock system ·······················································5-15 Barrier net ·······································································4-99
Battery ·············································································7-46
Battery saver function ·····················································4-59
Before driving ···································································5-3
Bottle holders, see cup holders ·······································4-49
Brake system ···································································5-18
Anti-lock brake system (ABS) ··································5-21
Electronic stability program (ESP) ···························5-23
Hill-start assist control (HAC) ··································5-27
Parking brake ····························································5-19
Power brakes ·····························································5-18
Vehicle stability management (VSM) ······················5-26
Brakes/clutch fluid ··························································7-34
Bulb replacement ····························································7-68 Front fog light bulb replacement ······························7-72
Headlight bulb replacement ······································7-69
High mounted stop light replacement ·······················7-77
Interior light bulb replacement··································7-78
License plate light bulb replacement ························7-77
Position light bulb replacement ································7-71
Rear combination light bulb replacement ·················7-74
Rear fog light bulb replacement································7-77Side repeater light bulb replacement·························7-72
Turn signal light bulb replacement ···························7-70
Bulb wattage ·····································································8-3
AB
ED(FL) Index.qxp 6/28/2010 11:04 AM Page 2

I3
Index
Capacities (Lubricants) ·····················································8-5 Care
Exterior care ······························································7-79
Interior care ·······························································7-84
Tire care ····································································7-49
Cargo weight ···································································5-53
Center console storage ····················································4-90
Central door lock switch ·················································4-11
Changing a tire with TPMS ············································6-18
Changing tires ···································································6-8Chains Tire chains ·································································5-42
Checking tire inflation pressure ······································7-50
Child restraint system ·····················································3-26 Tether anchor system ················································3-31
ISOFIX system ·························································3-32
Child-protector rear door lock ·······································4-13
Cigarette lighter ······························································4-93
Climate control air filter ·················································7-41
Climate control system (Automatic) ·····························4-79 Air conditioning ·······················································4-85Automatic heating and air conditioning ···················4-80
Manual heating and air conditioning ·······················4-81
Climate control system (Manual) ··································4-70 Air conditioning ·······················································4-75
Climate control air filter ··········································4-78 Heating and air conditioning·····································4-71
Clothes hanger ································································4-97
Combined instrument, see instrument cluster ················4-36
Cool box··········································································4-91Coolant ···········································································7-31
Cooling fluid, see engine coolant ··································7-31
Crankcase emission control system ·······························7-85
Cruise control system ····················································5-29
Cup holder ·····································································4-94
Curtain air bag ·······························································3-50
Dashboard, see instrument cluster ·································4-36 Dashboard illumination, see instrument panel illumination ·······················································4-38
Daytime running light ·····················································4-63
Defogging (Windshield) ················································4-87
Defroster ·········································································4-69 Outside mirror defroster ············································4-69
Rear window defroster ··············································4-69
Defrosting (Windshield) ················································4-87Dimensions ······································································8-2
Displays, see instrument cluster ····································4-36Display illumination, see instrument panel illumination ·······················································4-38
Door locks ·······································································4-10 Central door lock switch ··········································4-11
C
D
ED(FL) Index.qxp 6/28/2010 11:04 AM Page 3

I5
Index
Fuel requirements ····························································1-3 Fuses ··············································································7-59
Fuse/relay panel description ····································7-63
Main fuse···································································7-62
Memory fuse ·····························································7-61
Gauge Engine temperature gauge·········································4-39
Fuel gauge ································································4-39
Glassroof, see panorama sunroof····································4-26
Glove box ·······································································4-90
Glove box cooling···························································4-91
Hazard warning flasher ··················································4-58
Hazardous driving conditions ········································5-37
Headlight bulb replacement ···········································7-69
Headlight escort function ···············································4-59
Headlight leveling device ··············································4-63
Headrest ··································································3-6, 3-12
Heating and air conditioning ·········································4-71
High beam operation·······················································4-61High mounted stop light replacement ····························7-77
Highway driving ····························································5-40
Hill-start assist control (HAC)········································5-27 Hood ···············································································4-21Horn ···············································································4-31
How to use this manual ···················································1-2
ISG (Idle Stop and Go) system·········································5-7
ISOFIX system ······························································3-32
Immobilizer system ·························································4-3
Indicators and warnings ·················································4-43Indicator symbols on the instrument cluster ····················1-6
Instrument cluster ··························································4-36
Engine temperature gauge ········································4-39
Fuel gauge ································································4-39
Instrument panel illumination ··································4-38Odometer ··································································4-40Speedometer ·····························································4-38Tachometer ·······························································4-38
Tripmeter ···································································4-40
Trip computer ···························································4-40
Warning and indicators ············································4-43
Instrument panel illumination ········································4-38
Instrument panel overview ··············································2-3
Interior care ····································································7-84
Interior features ······························································4-93 Ashtray ·····································································4-93
Cigarette lighter ························································4-93
Clothes hanger···························································4-97
G
H
I
ED(FL) Index.qxp 6/28/2010 11:04 AM Page 5

I7
Index
Main fuse ········································································7-62 Maintenance
Explanation of scheduled maintenance items ···········7-27Maintenance services ················································· 7-4
Maintenance under severe usage conditions (1.4/1.6L Gasoline) ················································7-13
Maintenance under severe usage conditions (2.0L Gasoline) ······················································7-19
Maintenance under severe usage conditions (1.6L Diesel) ··························································7-25
Normal maintenance schedule (1.4/1.6L Gasoline)····7-9 Normal maintenance schedule (2.0L Gasoline) ········7-15
Normal maintenance schedule (1.6L Diesel) ············7-21
Owner maintenance ····················································7-6
Scheduled maintenance service ·································7-8
Tire maintenance ······················································7-54
Maintenance services ·······················································7-4
Manual climate control system ······································4-70 Air conditioning ·······················································4-75
Climate control air filter ··········································4-78
Heating and air conditioning ····································4-71
Manual heating and air conditioning ·····························4-81
Manual transaxle ······························································5-9
Map lamp ········································································4-68
Memory fuse ··································································7-61 Mirrors ···········································································4-32
Day/night rearview mirror ·······································4-32
Electric chromic mirror (ECM) ·······························4-32
Inside rearview mirror ··············································4-32
Outside rearview mirror ···········································4-33
Moonroof, see panorama sunroof ··································4-26
Mounting bracket for roof carrier ·································4-102
Multi box·········································································4-91
Neck restraints, see headrest ··································3-6, 3-12Odometer ·······································································4-40
Oil (Engine) ···································································7-30
Outside mirror defroster ················································4-69
Outside rearview mirror ·················································4-33Overheats ·········································································6-6
Owner maintenance ·························································7-6
Panorama sunroof ··························································4-26
Parking brake inspect ·····················································7-37
Parking brake ·································································5-19
Passenger's front air bag ················································3-43
M
O
N
P
ED(FL) Index.qxp 6/28/2010 11:04 AM Page 7

I9
Index
Side impact air bag ························································3-48
Side repeater light bulb replacement ·····························7-72
Smooth cornering ···························································5-38
Snow tires ······································································5-41Spare tire
Removing and storing the spare tire ··························6-8
Special driving conditions ·············································5-37 Driving at night ························································5-38
Driving in flooded areas ··········································5-39
Driving in the rain ····················································5-39
Hazardous driving conditions ··································5-37
Highway driving ······················································5-40
Rocking the vehicle ··················································5-37
Smooth cornering ·····················································5-38
Speedometer ···································································4-39
Speed limit control system ·············································5-33
Starting difficulties, see engine will not start ··················6-3
Starting the engine ···························································5-5
Steering wheel ·······························································4-30 Horn ··········································································4-31
Electric power steering ············································4-30
Tilt steering ······························································4-30
Storage compartment ·····················································4-90 Center console storage ·············································4-90
Cool box, Glove box cooling ··························4-76, 4-91
Glove box ·································································4-90
Luggage box ·····························································4-92
Multi box ··································································4-91 Sunglass holder ························································4-92
Sunroof, see panorama sunroof ·····································4-26Sunvisor ·········································································4-95
Super lock system ···························································4-11 Tachometer ····································································4-38 Tailgate ··········································································4-14 Emergency tailgate safety release ····························4-15
Tether anchor system ·····················································3-31
Theft-alarm system ··························································4-8
Tilt steering ····································································4-30
Tire Pressure Monitoring System (TPMS) ·····················6-15 Changing a tire with TPMS ······································6-18
Tire specification and pressure label ·······························8-8
Tires and wheels ·····················································7-49, 8-4 Checking tire inflation pressure ·······························7-50
Recommended cold tire inflation pressures ·············7-49
Tire care ···································································7-49
Tire maintenance ······················································7-54
Tire replacement ······················································7-53
Tire rotation ······························································7-51
Tire sidewall labeling ···············································7-55
Tire traction ······························································7-54
Wheel alignment and tire balance ····························7-52
Wheel replacement ···················································7-54
Tonneau cover·······························································4-101
T
ED(FL) Index.qxp 6/28/2010 11:04 AM Page 9