spare wheel KIA OPTIMA HYBRID 2015 User Guide

749
Maintenance
Underinflation also results inexcessive wear, poor handling and
reduced fuel economy. Wheel
deformation also is possible. Keep
your tire pressures at the proper
levels. If a tire frequently needs
refilling, have it checked by an
authorized Kia dealer.
Overinflation produces a harsh ride, excessive wear at the center
of the tire tread, and a greater pos-
sibility of damage from road haz-
ards.
Warm tires normally exceed rec- ommended cold tire pressures by 4
to 6 psi (28 to 41 kPa). Do not
release air from warm tires to
adjust the pressure or the tires will
be underinflated.
Be sure to reinstall the tire inflation valve caps. Without the valve cap,
dirt or moisture could get into the
valve core and cause air leakage. If
a valve cap is missing, install a
new one as soon as possible. Always observe the following:
Check tire pressure when the tires
are cold. (After vehicle has been
parked for at least three hours or
hasn't been driven more than one
mile (1.6 km) since startup.)
Check the pressure of your spare tire each time you check the pres-
sure of other tires.
Never overload your vehicle. Be careful not to overload a vehicle
luggage rack if your vehicle is
equipped with one.Checking tire inflation pres-
sure
Check your tires once a month or
more.
Also, check the tire pressure of the
spare tire.
How to check
Use a good quality gauge to check
tire pressure. You can not tell if your
tires are properly inflated simply by
looking at them. Radial tires may
look properly inflated even when
they're underinflated.
Check the tire's inflation pressure
when the tires are cold. - "Cold"
means your vehicle has been sitting
for at least three hours or driven no
more than 1 mile (1.6 km).

Maintenance
50
7
Remove the valve cap from the tire
valve stem. Press the tire gauge firm-
ly onto the valve to get a pressure
measurement. If the cold tire inflation
pressure matches the recommended
pressure on the tire and loading
information label, no further adjust-
ment is necessary. If the pressure is
low, add air until you reach the rec-
ommended amount.
If you overfill the tire, release air by
pushing on the metal stem in the
center of the tire valve. Recheck the
tire pressure with the tire gauge. Be
sure to put the valve caps back on
the valve stems. They help prevent
leaks by keeping out dirt and mois-
ture. Inspect your tires frequently for
proper inflation as well as wear and
damage. Always use a tire pres-
sure gauge.
Tires with too much or too little pressure wear unevenly causing
poor handling, loss of vehicle con-
trol, and sudden tire failure leading
to accidents, injuries, and even
death. The recommended cold tire
pressure for your vehicle can be
found in this manual and on the tire
label located on the driver's side
center pillar.
Remember to check the pressure of your spare tire. Kia recommends
that you check the spare every
time you check the pressure of the
other tires on your vehicle.Tire rotation
To equalize tread wear, it is recom-
mended that the tires be rotated
every 7,500 miles (12,000 km) or
sooner if irregular wear develops.
During rotation, check the tires for
correct balance.
When rotating tires, check for uneven
wear and damage. Abnormal wear is
usually caused by incorrect tire pres-
sure, improper wheel alignment, out-
of-balance wheels, severe braking or
severe cornering. Look for bumps or
bulges in the tread or side of tire.
Replace the tire if you find either of
these conditions. Replace the tire if
fabric or cord is visible. After rotation,
be sure to bring the front and rear tire
pressures to specification and check
lug nut tightness.
Refer to “Tire and wheels” in chapter
8.

751
Maintenance
Disc brake pads should be inspectedfor wear whenever tires are rotated.
Rotate radial tires that have an
asymmetric tread pattern only from
front to rear and not from right to left.
Do not use the compact spare tire for
tire rotation.Wheel alignment and tire bal-
ance
The wheels on your vehicle were
aligned and balanced carefully at the
factory to give you the longest tire life
and best overall performance.
In most cases, you will not need to
have your wheels aligned again.
However, if you notice unusual tire
wear or your vehicle pulling one way
or the other, the alignment may need
to be reset.
If you notice your vehicle vibrating
when driving on a smooth road, your
wheels may need to be rebalanced.
WARNING- Mixing tire
types
Do not mix bias ply and radial
ply tires under any circum-
stances. This may cause unusu-
al handling characteristics.
S2BLA790A
CBGQ0707A
Without a spare tire
Directional tires (if equipped)
CAUTION - Wheel weight
Improper wheel weights can damage your vehicle's alu-minum wheels. Use onlyapproved wheel weights.

Maintenance
52
7
Tire replacement
If the tire is worn evenly, a tread wear
indicator will appear as a solid band
across the tread. This shows there is
less than 1/16 inch (1.6 mm) of tread
left on the tire. Replace the tire when
this happens.
Do not wait for the band to appear
across the entire tread before replac-
ing the tire. The ABS works by comparing the
speed of the wheels. Tire size can
affect wheel speed. When replacing
tires, all 4 tires must use the same
size originally supplied with the vehi-
cle. Using tires of a different size can
cause the ABS (Anti-lock Brake
System) and ESC (Electronic
Stability Control) to work irregularly.
✽ ✽
NOTICE
We recommend that when replacing
tires, use the same originally sup-
plied with the vehicles.
If not, that affects driving perform-
ance.
Compact spare tire replacement
A compact spare tire has a shorter
tread life than a regular size tire.
Replace it when you can see the
tread wear indicator bars on the tire.
The replacement compact spare tire
should be the same size and design
tire as the one provided with your
new vehicle and should be mounted
on the same compact spare tire
wheel. The compact spare tire is not
designed to be mounted on a regular
size wheel, and the compact spare
tire wheel is not designed for mount-
ing a regular size tire.
OEN076053
Tread wear indicator

755
Maintenance
3. Checking tire life (TIN : TireIdentification Number)
Any tires that are over 6 years old,
based on the manufacturing date,
(including the spare tire) should be
replaced by new ones. You can find
the manufacturing date on the tire
sidewall (possibly on the inside of the
wheel), displaying the DOT Code.
The DOT Code is a series of num-
bers on a tire consisting of numbers
and English letters. The manufactur-
ing date is designated by the last four
digits (characters) of the DOT code.
DOT : XXXX XXXX OOOO
The front part of the DOT means a
plant code number, tire size and
tread pattern and the last four num-
bers indicate week and year manu-
factured.
For example:
DOT XXXX XXXX 1614 represents
that the tire was produced in the 16th
week of 2014.
4. Tire ply composition and mate-rial
The number of layers or plies of rub-
ber-coated fabric in the tire. Tire
manufacturers also must indicate the
materials in the tire, which include
steel, nylon, polyester, and others.
The letter "R" means radial ply con-
struction; the letter "D" means diago-
nal or bias ply construction; and the
letter "B" means belted-bias ply con-
struction.
5. Maximum permissible inflationpressure
This number is the greatest amount
of air pressure that should be put in
the tire. Do not exceed the maximum
permissible inflation pressure. Refer
to the Tire and Loading Information
label for recommended inflation
pressure.
6. Maximum load rating
This number indicates the maximum
load in kilograms and pounds that
can be carried by the tire. When
replacing the tires on the vehicle,
always use a tire that has the same
load rating as the factory installed
tire.
WARNING - Tire age
Replace tires within the recom-
mended time frame. Failure to
replace tires as recommended
can result in sudden tire failure,
which could lead to a loss of
control and an accident.

Maintenance
70
7
Description Fuse Rating Protected Component
EPB10AEPB
HEV ECU20AHCU UNIT IG1
IG 125AE/R BOX IG1
BMS 10A BMS UNIT B+
POWER OUTLET 20A Front Power Outlet
MODULE 1 10AAuto Head Lamp Leveling Device Module (Auto HLLD), Head Lamp Leveling Device Switch (Manual
HLLD), Head Lamp Leveling Device Actuator LH/RH, BCM, Front Smart Parking Assist Sensor Module,
Instrument Cluster, Electro Chromic Mirror, A/C Control Module, Driver IMS Module, Rear Parking
Assist Buzzer, Lane Keeping Assist Module
START 7.5A B/ALARM RLY
HTD STRG 15A Steering Wheel Heater
MODULE 5 7.5ASmart Key Control Module (With Smart Key), Rear Seat, Warmer Relay LH/RH, E/R Fuse & Relay Box
(RLY.2), Diesel Box (Fuel Filter Relay)
A/CON 7.5A A/C Control Module, E/R Fuse & Relay Box (RLY.14)
SPARE 15A -
WIPER 25A E/R BOX WIPER RLY
C/LIGHTER 20A Cigarette Lighter
MODULE 6 7.5A PANORAMA SUNROOF (IG2), IONIZER, DSL_BOX, RR_SEAT_WARMER
HTD MIRR 10A Driver/Passenger Power Outside Mirror

I5
Index
Flat tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 6-14Jack and tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-14
Removing and storing the spare tire . . . . . . . . . . . . 6-15
Changing tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-15
Compact spare tire . . . . . . . . . . . . . . . . . . . . . . . . . . 6-19
Floor mat anchor(s) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-125
Fluid Brakes fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-36
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-37
Fog light (front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-93
Front seat adjustment - Manual . . . . . . . . . . . . . . . . . . . 3-4
Front seat adjustment - power . . . . . . . . . . . . . . . . . . . . 3-6
Fuel Economy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-67
Fuel filler lid Emergency fuel filler lid release . . . . . . . . . . . . . . . 4-30
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-47\
Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-64\
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 7-62 Instrument panel fuse . . . . . . . . . . . . . . . . . . . . . . . . 7-63
Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-64
Multi fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-66
Fuse/relay panel description. . . . . . . . . . . . . . . . . . . 7-67 Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-47
Glass antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-126
Glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11\
9
Glove box lamp. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-100
Gross vehicle weight. . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
Hazard warning flasher . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
Hazardous driving conditions . . . . . . . . . . . . . . . . . . . . 5-53
Headlight bulb replacement . . . . . . . . . . . . . . . . . . . . . 7-77
Headlight delay function . . . . . . . . . . . . . . . . . . . . . . . 4-88
Headlight leveling device . . . . . . . . . . . . . . . . . . . . . . . 4-88
Headlight position. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-90
Headrest(front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
Headrest(rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
Heated steering wheel. . . . . . . . . . . . . . . . . . . . . . . . . . 4-39
Heater
Automatic climate control system . . . . . . . . . . . . . 4-102
High - beam operation . . . . . . . . . . . . . . . . . . . . . . . . . 4-91
Hight adjustment (front seat belt). . . . . . . . . . . . . . . . . 3-21
Highway driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-56
Hill-start assist control (HAC) . . . . . . . . . . . . . . . . . . . 5-35
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 4-26
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 4-38
Hybrid information modes . . . . . . . . . . . . . . . . . . . . . . 4-52
FG
H

I9
Index
Shift-lock override . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-16
Side air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-48\
Smart key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
4-4Record your key number . . . . . . . . . . . . . . . . . . . . . . 4-4
Remote keyless entry system operations . . . . . . . . . . 4-7
Smart key precautions . . . . . . . . . . . . . . . . . . . . . . . . 4-8
Battery replacement . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
Immobilizer system . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
Smart key functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
Smart key precautions. . . . . . . . . . . . . . . . . . . . . . . . . . . 4-8
Smooth cornering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-54
Snow tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-\
57
Spare tire Changing tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-15
Compact spare tire . . . . . . . . . . . . . . . . . . . . . . . . . . 6-19
Compact spare tire replacement . . . . . . . . . . . . . . . . 7-52
Special driving conditions . . . . . . . . . . . . . . . . . . . . . . 5-53 Hazardous driving conditions . . . . . . . . . . . . . . . . . 5-53
Rocking the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 5-53
Smooth cornering . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-54
Driving at night . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-54
Driving in the rain . . . . . . . . . . . . . . . . . . . . . . . . . . 5-55
Driving in flooded areas. . . . . . . . . . . . . . . . . . . . . . 5-55
Highway driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-56
Driving off-road . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-56
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-47
Sports mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14
SRS Care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
3-55 SRS components and functions . . . . . . . . . . . . . . . . . . 3-38
Starting difficulties, see engine will not start . . . . . . . . . 6-4
Starting the hybrid system . . . . . . . . . . . . . . . . . . . . . . . 5-9
Starting the hybrid system
With a smart key . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-9
State of charge guage . . . . . . . . . . . . . . . . . . . . . . . . . . 4-48
Steering wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-37 Electric power steering. . . . . . . . . . . . . . . . . . . . . . . 4-37
Tilt and telescopic steering. . . . . . . . . . . . . . . . . . . . 4-38
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-38
Heated steering wheel . . . . . . . . . . . . . . . . . . . . . . . 4-39
Steering wheel audio controls . . . . . . . . . . . . . . . . . . 4-127
Storage compartment . . . . . . . . . . . . . . . . . . . . . . . . . 4-119 Center console storage . . . . . . . . . . . . . . . . . . . . . . 4-119
Glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-119
Cool box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-120
Sunglass holder . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-120
Sunglass holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-120
Sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-31
Sunvisor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
122
Tether anchor system . . . . . . . . . . . . . . . . . . . . . . . . . . 3-31
Theft-alarm system . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-12
Tilt and telescopic steering . . . . . . . . . . . . . . . . . . . . . . 4-38
Tire chains. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-\
58
T

Index
10I
Tire mobility kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-22Components of the Tire Mobility Kit . . . . . . . . . . . 6-24
Using the Tire Mobility Kit . . . . . . . . . . . . . . . . . . . 6-25
Tire pressure monitoring system . . . . . . . . . . . . . . . . . . 6-8
Tire rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-50
Tire specification and pressure label . . . . . . . . . . . . . . . 8-9
Tires and wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48 Recommended cold tire inflationpressures . . . . . . . 7-48
Tire care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48\
Checking tire inflation pressure . . . . . . . . . . . . . . . . 7-49
Tire rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-50
Tire replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-52
Wheel alignment and tire balance . . . . . . . . . . . . . . 7-51
Wheel replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 7-53
Tire maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-53
Tire sidewall labeling . . . . . . . . . . . . . . . . . . . . . . . . 7-53
Tire traction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-53
Compact spare tire replacement . . . . . . . . . . . . . . . . 7-52
Low aspect ratio tire. . . . . . . . . . . . . . . . . . . . . . . . . 7-61
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 6-28 Removable towing hook. . . . . . . . . . . . . . . . . . . . . . 6-29
Emergency towing . . . . . . . . . . . . . . . . . . . . . . . . . . 6-29
Transaxle Automatic transaxle . . . . . . . . . . . . . . . . . . . . . . . . . 5-12
Transaxle Shift Indicator . . . . . . . . . . . . . . . . . . . . . . . 4-50
Trip A/B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
4-69
Trip computer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-67 Trip A/B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-69\
Fuel Economy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-67
One time driving information mode . . . . . . . . . . . . 4-70
Trunk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 4-18 Emergency trunk lid release cable . . . . . . . . . . . . . . 4-19
Emergency trunk safety release . . . . . . . . . . . . . . . . 4-20
Trunk room lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-99
Turn signals. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-92\
User Settings Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
Vanity mirror lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-100
Vehicle identification number (VIN) . . . . . . . . . . . . . . . 8-8
Vehicle load limit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-61 Tire and loading information label. . . . . . . . . . . . . . 5-61
Vehicle stability management (VSM) . . . . . . . . . . . . . 5-36
Vehicle weight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-66
Warning light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-71
Warning Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-59
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-37
Welcome light (position light) . . . . . . . . . . . . . . . . . . . 4-87
Welcome light (room lamp, position light) . . . . . . . . . 4-87
W
U
V