air KIA OPTIMA PHEV 2018 Warranty and Consumer Information Guide

4
Subject to the other terms and conditions of this limited
warranty manual, Kia Motors America, Inc. (“Kia”)
warrants that it will arrange for an authorized Kia dealer
at locations of its choice to provide for the repair of your
vehicle if it fails to function properly during normal use.
Such service facilities will remedy such failures to
function properly at KMA’s expense, if you present your
vehicle to such a service facility during its normal
operating hours, provide sufficient information to permit
a proper identification and diagnosis of the failure to
function, and permit the facility adequate time to
perform the necessary repair. As this obligation is
subject to the terms, conditions and limitations of this
Manual, you should refer to the manual to understand
which repairs and replacements are covered by this
warranty. If an Authorized Kia Dealer declines or fails to
carry out a proper repair or replacement of a factory
installed part covered by this limited warranty without
charge to you, Kia will (a) determine if the repair or
replacement requested by you is covered by this New
Vehicle Limited Warranty and, if so, (b) obtain
cooperation from an Authorized Kia Dealer to conduct
such repair or replacement without charge to you.However, Kia’s obligation to do (a) and (b) requires you
to contact the Kia Consumer Assistance Center and
provide all materials needed by them to carry out those
obligations to you. The Center can be contacted at the
address or phone number provided in the Kia Owner
Satisfaction and Assistance Section of this manual, or
can also be found at the Kia website at
http://www.kia.com.
Parts replaced under any warranties in the Manual
become the property of Kia.
1. The Warranty Period
The New Vehicle Limited Warranty is divided into
various warranty periods. For the purpose of all
warranties contained in this Manual(other than
warranties on replacement parts or accessories
installed after the Kia Vehicle was placed into use),
the warranty period begins on the Date of First
Service. “Date of First Service” means the first date
the Kia Vehicle is delivered to the first retail
purchaser, is leased or is placed into service as a
company vehicle use (e.g., as a demonstrator, rental
What is Covered
New Vehicle Limited Warranty
New Vehicle Limited Warranty

-In the Differentials:Front and rear differential
assemblies, cases, all internal parts, seals and
gaskets.
-In the Propeller Shafts:Drive shafts, universal
joints.
*Auto Transmission of HEV vehicle is covered
under HYBRID SYSTEM WARRANTY. See the
detailed information in the Hybrid Warranty section
on page14.
•Original Owner
An Original Owner is defined as the first retail
purchaser or lessee of the Kia Vehicle who takes
delivery of the Kia Vehicle on its Date of First
Service. If the Kia Vehicle was first placed in service
as a lease vehicle, and the lessee purchases the
vehicle at the end of the lease, the 120
month/100,000 mile Power Train Limited Warranty
remains in effect. The Power Train Limited
Warranty is not transferable to subsequent owners.
•Vehicles Placed in Commercial Service
The 120 month/100,000 mile Power Train Limited
Warranty also excludes all coverage for any Kia
Vehicle that has been placed into any form of
commercial service, including but not limited to taxi,
route delivery, livery service, or rental.
•Adjustment Coverage
Service Adjustments are covered for the first 12
months/12,000 miles. Service adjustments means
minor repairs not usually associated with the
replacement of parts, such as wheel balance and
alignment, freeplay or tension adjustments of cables,
belts, levers and pedals, engine adjustments (idle
speed, etc.), body parts and fittings.
3. Exceptions
The items specified below are covered for periods
different from the basic coverage.
New Vehicle Limited Warranty6

•Air Conditioner Refrigerant Charge
Air conditioner refrigerant charge is covered for the
first 12 months of the warranty period regardless of
mileage. Over the balance of the warranty period,
refrigerant charge is covered only when replenished
as part of a warranty repair.
•Audio / Entertainment System
An original equipment radio, compact disk player,
OE DVD / RSE (Rear Seat Entertainment System)
or navigation system is covered for the first
36months/36,000 miles.
•Battery (Non Hybrid)
The original equipment battery is covered by a
limited warranty for a period of 36 months / 36,000
miles. During 36 months / 36,000 miles of the
warranty period, a defective battery will be replaced
at no cost to you. Kia will cover diagnostic,
installation and replacement battery costs.
Kia will not reimburse you for any portion of the
cost of a non-Kia replacement battery.
* Refer to page 24 for Hybrid Battery Pack
Coverage.
•Brake and Clutch Linings
Brake linings, including pads and shoes, and clutch
linings are warranted for 12 months/12,000 miles,
whichever comes first, if they fail to function
properly during normal use. Brake linings are
designed to wear out as part of the process of
stopping your vehicle safely and consistently while
providing reasonable levels of noise and vibration
during normal use. Brake or clutch linings function
properly during normal use even if they need
replacement in less than the full warranty period.
Rather, most replacements at lower mileage are
required by driver usage habits which can cause high
rates of wear. In addition, brake lining wear is
substantially increased by environmental conditions
such as exposure to road salt or due to regular
driving in stop and go rush hour traffic. The more
wear factors which are present, the more rapid the
wear. Resulting repairs and replacements of linings
are not covered by your warranty.
New Vehicle Limited Warranty
7

New Vehicle Limited Warranty8
•Paint
Paint repairs due to non-impact discoloration,
fading, cracking, chipping, or flaking are covered for
the first 36 Months/36,000 miles.
•Seat Belt Warranty-Kansas
The seat belts in Kia Vehicles originally sold in the
State of Kansas are covered under the New Vehicle
Limited Warranty for a period of 10 years,
regardless of mileage, when the repairs are
performed by an Authorized Kia Dealer in Kansas.
4. Limited Liability
Liability under this warranty is limited solely to the
repair or replacement of factory installed parts if
they fail to function properly during normal use.
Such repair or replacement shall be carried out by an
Authorized Kia Dealer at its place of business. This
warranty does not include any other expense,
including but not limited to those for any
replacement transportation or for the loss of use of
your Kia vehicle.

9
New Vehicle Limited Warranty
The following items are not covered:
Damage due to Factors Beyond the Manufacturer’s
Control.
Examples of these factors include, but are not limited to:
•Misuse of your Kia Vehicle such as driving over
curbs, or other hazardous objects or road structures
or into roadway maintenance or construction areas,
overloading the vehicle, racing or engaging in
activities or uses not described in your owner ’s
manual or in Kia’s product literature.
•Accidents and incidents that damage your Kia
vehicle including but not limited to collision, fire,
theft, riot.
•Alteration, modification, tampering, rewiring.
•Damage or corrosion from the environment such as
acid rain, airborne fallout (chemicals, tree sap, etc.),
road salt, hail, wind storm, lightning, floods and acts
of God. This limitation also includes damage to
vehicle assemblies such as brakes and suspension.
•Changes to vehicle appearance caused by normal
use and exposure, corrosion to underlying metalwhen paint integrity is not consistently maintained.
•Consumer induced damage caused by fluid spills,
burns in carpet, seats, trim or other damage that is
not considered a defect in material or workmanship.
•Window glass that is broken, chipped, scratched or
damage from outside influence is not considered a
defect in material or workmanship
•Paint or vehicle finish damage caused by applying
chemicals to the paint surface
•Damage caused by installing incorrect tires(size etc)
•Damage caused by the installation of any part that is
not equal to the OE part in quality of material or
workmanship
Damage due to Lack of Maintenance or the Use of
Wrong Fuel, Oil or Lubricants.
•Improper maintenance or the use of other than the
specified fuel, oil or lubricants recommended in
your Owner’s Manual. It is your obligation to ensure
that you obtain all fuels, oils and lubricants from
reliable vendors using quality products which meet
the Kia specifications identified in your Owner’s
What is Not Covered

New Vehicle Limited Warranty10
Manual. In the event that problems result to your
vehicle due to service from vendors who use
reduced quality products, your vehicle warranties
will not provide coverage.
•Damaged brake rotors and drums resulting from
failing to replace brake pads and/or shoes before
they have worn sufficiently to damage such rotors
and drums. It is your obligation to ensure adequate
inspections to prevent rotor and drum damage due to
pad/shoe wear.
Manufacturer Design Choices
•The choices made in designing your vehicle,
including the materials chosen for parts and
components.
•Note: A material is not defective or underperforming
under your warranty because a better, stronger, more
durable or more suitable material could have been
used.
•Note: All vehicle dimensions and measurements are
made solely at the discretion of the manufacturer
and are not warranted to be suitable for you or
anyone else who uses your vehicle.
Normal Deterioration
•Replacement or repair of parts intended to wear
including the friction wear parts of the brakes,
including brake pads and shoes, spark plugs, belts,
clutch linings, filters, wiper blades, bulbs, fuses, and
other wear and consumable items.
•Surface corrosion on any part other than the body
sheet metal panels forming the exterior appearance
of a Kia Vehicle.
Normal Maintenance
•Normal maintenance services such as: cleaning and
polishing, minor adjustments, lubrication, oil/fluid
changes, filters, anti- freeze coolant replenishment,
wheel alignment and tire rotation unless such services
are performed as part of a covered warrantable repair.
•Normal maintenance items including but not limited
to spark plugs, engine belts, filters, wiper blades, and
bulbs are not warranted. However, as a matter of
policy, Kia will repair or replace such maintenance
items of a new vehicle during the vehicle’s initial
ownership period, but only up to the first service
interval or 12 months/12,000 miles, whichever
comes first.

11
New Vehicle Limited Warranty
•Maintenance services described as “Scheduled
Maintenance Services”, “Owner Maintenance
Services” or “Appearance Care” in your Owner ’s
Manual.
Altered Mileage
•Any repair of a Kia Vehicle on which the odometer
has been altered or on which the actual mileage
cannot be reasonably determined.
(When replacing the speedometer, the “Speedo-
meter Replacement Record” on the inside front
cover of this manual must be filled in by an
Authorized Kia Dealer).
Extra Expenses and Damages
•Any economic loss or other incidental, special,
consequential, or exemplary damages. This includes,
without limitation, payment for loss of use of the
Kia Vehicle, lodging, car rentals, travel costs, loss of
pay and any other expenses or damages.
Tires
•Tires are warranted by the tire manufacturers and not
by Kia. In the event that you need assistance, please
contact your Kia dealer or refer to the tire warranty
pamphlets provided with your Kia Vehicle for
details.
Salvage or Total-Loss Vehicles
•Any Kia Vehicle that has ever been or should have
been issued a “salvage” title or similar
“branded”title under any state’s law; or has been
declared a “total loss” or equivalent by a financial
institution or insurance company. This exclusion
does not apply to Emission Warranties, Replacement
Parts Limited Warranty or any recalls or campaigns.
Production Changes
•Kia and its Authorized Kia Dealers reserve the right
to make changes in vehicles built and/or sold by Kia
and its Authorized Kia Dealers at any time without
incurring any obligation to make the same or similar
changes on vehicles previously built and/or sold.

Hybrid System Warranty14
What is Covered
Repair or replacement of HYBRID SYSTEM
components listed below, originally manufactured or
installed by Kia Motor Company, Kia Motors
Manufacturing Georgia (KMMG) or Kia Motor America
(KMA) that are found to be defective in material or
factory workmanship under normal use and maintenance,
except any item specifically referred to in the section
“What is Not Covered”. Towing expense to the nearest
Kia Dealership or authorized service location is covered
when the vehicle is inoperable due to a warrantable
defect within 10 years from the date of original retail
delivery or date of first use, or 100,000 miles, whichever
occurs first. “Owner’s Responsibilities” and “Obtaining
Warranty Service” are the same as specified under the
Kia New Vehicle Limited Warranty. Repairs will be
made using new Kia Genuine Parts or Kia authorized
remanufactured parts.
The Warranty Period
The Warranty period for the following HYBRID
SYSTEM components is limited to 10 years from the
date of original retail delivery or date of first use, or
100,000 miles, whichever occurs first.Note : For California Emissions Vehicles (excluding
Pennsylvania and Washington), the Hybrid System is
covered for 10 years from the date of original retail
delivery or date of first use, or 150,000 miles, whichever
occurs first.
Hybrid System
Hybrid Battery Pack Assy, Hybrid Starter & Generator,
Hybrid Power Control Unit, Auto Transmission &
Traction Motor including housing case, clutch, On board
charger(OBC) and all internal parts.
Owner’s Responsibilities
Your responsibilities are the same as those described in
the Kia New Vehicle Limited Warranty.
What is Not Covered
Items not covered by this warranty and any exclusion or
limitations relating to this warranty are the same as those
set forth in the "What is Not Covered" section of the Kia
New Vehicle Limited Warranty already described in this
handbook. INCIDENTAL OR CONSEQUENTIAL
DAMAGES, INCLUDING WITHOUT LIMITATION,
LOSS OF TIME, INCONVENIENCE, LOSS OF USE
OF THE VEHICLE, OR COMMERCIAL LOSS ARE
NOT COVERED UNDER THIS WARRANTY.

15
Subject to the other terms and conditions of this limited
warranty manual, Kia Motors America, Inc. (“Kia”)
warrants that it will arrange for independent Kia brand
service facilities at locations of its choice to provide for the
repair of your vehicle if it fails to function properly during
normal use. Such service facilities will remedy such failures
to function properly at KMA’s expense, if you present your
vehicle to such a service facility during its normal operating
hours, provide sufficient information to permit a proper
identification and diagnosis of the failure to function, and
permit the facility adequate time to perform the necessary
repair. As this obligation is subject to the terms, conditions
and limitations of this Manual, you should refer to the
manual to understand which repairs and replacements are
covered by this warranty. If an Authorized Kia Dealer
declines or fails to carry out a proper repair or replacement
of a factory installed part covered by this limited warranty
without charge to you, Kia will (a) determine if the repair or
replacement requested by you is covered by this Anti
Perforation Limited Warranty and, if so, (b) obtain
cooperation from an Authorized Kia Dealer to conduct
such repair or replacement without charge to you. However,
Kia’s obligation to do (a) and (b) requires you to contact the
Kia Consumer Assistance Center and provide all materials
needed by them to carry out those obligations to you. TheCenter can be contacted at the address or phone number
provided in the Kia Owner Satisfaction and Assistance
Section of this manual, or can also be found at the Kia
website at http://www.kia.com.
1. Warranty Period
The warranty period is for the first 60 month/100,000
miles from the date of first retail delivery or when it is
first put into service, whichever comes first.
2. What is Not Covered
• Any perforation due to corrosion of the Kia Vehicle
which is caused by industrial fallout, accident,
damage, abuse, vehicle modifications or damaging
or corrosive cargo in the Kia Vehicle.
• Any surface corrosion of the Kia Vehicle which
does not result in perforation, such as that caused
typically by sand, salt, hail or stones.
• Any perforation due to corrosion of a part of the Kia
Vehicle which is not a body sheet metal panel. As
used herein, “body sheet metal panel” specifically
excludes all parts which are components of the
exhaust system of the Kia Vehicle.
• Defects or damage resulting from the use of parts
not sold or approved by Kia including the resultant
damage to associated parts or systems.
Anti-Perforation Limited Warranty

16
Anti-Perforation Limited Warranty
• Any perforation due to corrosion of the Kia Vehicle
caused in whole or in part by a failure to maintain
the Kia Vehicle in accordance with the procedures
specified in paragraph 3. “Your Responsibilities”
3. Your Responsibilities
Inspect the body sheet metal panels of your Kia Vehicle
on a regular basis (at least monthly) to detect any chips
or scratches in the paint or protective coating and to
repair them immediately.
Special care should be taken to protect your Kia Vehicle
from corrosion under the following conditions:
• If you drive on salted roads, or if you drive near the
ocean, flush the underbody as needed, and at least
weekly with clean unsalted water.
• It is important to keep the drain holes in the lower
edges of the body clear.
• If your Kia Vehicle is damaged due to an accident or
any event which may cause damage to the paint,
have your Kia Vehicle repaired as soon as possible.
•If you carry special cargo, such as chemicals,
fertilizers, deicing salt, or other corrosive substances,
be sure that such materials are well packaged and
sealed. Any leakage of such materials will void this
warranty where the leakage has occurred.
• If you drive frequently on gravel roads, werecommend that you install stone guards behind
each wheel.
4. To Get Warranty Service
You must take your Kia Vehicle, along with this
manual, to any Authorized Kia Dealer in the United
States during its normal service hours.
If you have any questions or need assistance regarding
this warranty, refer to the “When You Need to Talk to
Kia” starting on Page 40.
5. Limited Liability
Liability under this warranty is limited solely to the
repair or replacement of factory installed parts that fails
to function properly. Such repair or replacement shall be
carried out by an Authorized Kia Dealer at its place of
business. This warranty does not include any other
expense, including but not limited to those for any
replacement transportation or for the loss of use of your
Kia vehicle.
6. Other Terms
The “Other Terms” stated on page 12 in the New
Vehicle Limited Warranty section of this manual also
apply to this warranty.