belt KIA QUORIS 2014 Repair Manual

723
Maintenance
Steering gear box, linkage &
boots/lower arm ball joint
With the vehicle stopped and engine
off, check for excessive free-play in
the steering wheel.
Check the linkage for bends or dam-
age. Check the dust boots and ball
joints for deterioration, cracks, or
damage. Replace any damaged
parts.
Power steering pump, belt and hoses
Check the power steering pump and
hoses for leakage and damage.
Replace any damaged or leaking
parts immediately. Inspect the power
steering belt (or drive belt) for evi-
dence of cuts, cracks, excessive
wear, oiliness and proper tension.
Replace or adjust it if necessary.Drive shafts and boots
Check the drive shafts, boots and
clamps for cracks, deterioration, or
damage. Replace any damaged
parts and, if necessary, repack the
grease.
Air conditioning refrigerant (if equipped)
Check the air conditioning lines and
connections for leakage and dam-
age.

751
Maintenance
4. Tire ply composition and mate-rial
The number of layers or plies of rub-
ber-coated fabric in the tire. Tire
manufacturers also must indicate the
materials in the tire, which include
steel, nylon, polyester, and others.
The letter "R" means radial ply con-
struction; the letter "D" means diago-
nal or bias ply construction; and theletter "B" means belted-bias ply con-
struction.
5. Maximum permissible inflationpressure
This number is the greatest amount of air pressure that should be put in
the tire. Do not exceed the maximum
permissible inflation pressure. Refer
to the Tire and Loading Information
label for recommended inflation
pressure.
6. Maximum load rating
This number indicates the maximum
load in kilograms and pounds that
can be carried by the tire. When
replacing the tires on the vehicle,
always use a tire that has the same
load rating as the factory installed
tire.
7. Uniform tire quality grading
Quality grades can be found where
applicable on the tire sidewall
between tread shoulder and maxi-
mum section width.
For example:
TREADWEAR 200
TRACTION AA
TEMPERATURE A Tread wear
The tread wear grade is a compara-
tive rating based on the wear rate ofthe tire when tested under controlled
conditions on a specified govern-
ment test course. For example, a tire
graded 150 would wear one-and-a-
half times (1½) as well on the gov-
ernment course as a tire graded 100.
The relative performance of tires depends upon the actual conditions
of their use, however, and may
depart significantly from the norm
due to variations in driving habits,
service practices and differences in
road characteristics and climate.
These grades are molded on the
side-walls of passenger vehicle tires.
The tires available as standard or
optional equipment on your vehicle
may vary with respect to grade.

Maintenance
62
7
Fuse NameSymbolFuse rastingCircuit Protected
MODULE 66
MODULE10ASmart Key Control Module, BCM
A/BAG15ADriver Seat Belt Pretensioner, Passenger Seat Belt Pretensioner, SRS Control Module
A/BAG IND10AInstrument Cluster
IGN 1IG 120AE/R Fuse & Relay Box LH (FUSE : F20, F21, F23, F25, F26, F27)
MEMORY 11 MEMORY10APassenger IMS Control Module, Driver/Passenger Door Module, Driver/Passenger Power Seat
Switch, Rear Door Module LH/RH, Power Trunk Module, Instrument Cluster, BCM,
Security Sensor, Analogue Clock, A/C Control Module, Head-Up Display
MULTI MEDIA10ARear Monitor Module, Keyboard, A/V Navigation Head Unit, Front Monitor,
Rear Monitor LH/RH, LVDS, MTS_UNIT
ROOM LAMP10ARear Seat Foot Lamp LH/RH, Trunk Room Lamp LH/RH, Driver/Passenger Foot Lamp,
Room Lamp, Overhead Console Lamp, Front Vanity Lamp Switch LH/RH, Rear Vanity Lamp
Switch LH/RH, Garnish Lamp LH/RH, Garnish Center Lamp, Glove Box Lamp
MEMORY 33MEMORY10ARF Receiver
EPB 115AElectric Parking Brake Module
SPARE15ASpare
IGN 2IG 220AE/R Fuse & Relay Box LH (Fuse : F29, F30)
A/CON 110AA/C Control Module, Ionizer, AQS Sensor, Incar Sensor, Metal Core Block (PCB #2) (Blower Relay)
AFLS15AAdaptive Front Lighting Module, HEAD LAMP LH/RH
SPARE10ASpare
P/OUTLET FR15AFront Power Outlet

769
Maintenance
FuseFuse NameSymbolFuse rastingCircuit Protected
METALCORE
BLOCK
(PCB #2)
A/C 210AA/C Control Module
Cruise10ASmart Cruise Control Radar
TCU 215ATCM
ECU 210AECM
Blower40AMetal Core Block(PCB) (Blower Relay)
Start 130AE/R Fuse Relay Box LH (RLY.2)
MULTI FUSE
Seat Belt LH40ADriver Seat Belt Pretensioner
Seat Belt RH40APassenger Seat Belt Pretensioner
Battery 260ASmart Junction Box (Fuse : F13~20, F23, F24, F27, F28, IPS5~8, Arisu-LT2)
Battery 160ASmart Junction Box (Fuse : F38, IPS1, 3, Arisu-LT1, Leak Current Autocut Device)
EHPS 280AEHPS Module
FUSEBattery 460AMetal Core Block (PCB #1) (Fuse : F2, F4, F6, F10, F11, F12)
Battery 560AMetal Core Block (PCB #2) (Fuse : F7, F11)

785
Maintenance
Cleaning the upholstery and inte-rior trim
Vinyl
Remove dust and loose dirt from
vinyl with a whisk broom or vacuum
cleaner. Clean vinyl surfaces with a
vinyl cleaner.
Fabric
Remove dust and loose dirt from fab-
ric with a whisk broom or vacuum
cleaner. Clean with a mild soap solu-
tion recommended for upholstery or
carpets. Remove fresh spots imme-
diately with a fabric spot cleaner. If
fresh spots do not receive immediate
attention, the fabric can be stained
and its color can be affected. Also, its
fire-resistant properties can be
reduced if the material is not proper-ly maintained.
Cleaning the lap/shoulder beltwebbing
Clean the belt webbing with any mild
soap solution recommended for
cleaning upholstery or carpet. Follow
the instructions provided with the
soap. Do not bleach or re-dye the
webbing because this may weaken it.
Cleaning the interior windowglass
If the interior glass surfaces of the
vehicle become fogged (that is, cov-
ered with an oily, greasy or waxy
film), they should be cleaned with
glass cleaner. Follow the directions
on the glass cleaner container.
CAUTION
Using anything but recommend-ed cleaners and proceduresmay affect the fabric’s appear- ance and fire-resistant proper-ties.
CAUTION
Do not scrape or scratch theinside of the rear window. Thismay result in damage to the rear window defroster grid.

I3
Index
Blind spot detection system (BSD) . . . . . . . . . . . . . . . 5-89
Bluetooth ®
Wireless Technology hands-free . . . . . . . 4-162
Bottle holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-151
Brake system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-31 Anti-lock brake system (ABS) . . . . . . . . . . . . . . . . . . 5-34
Auto hold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-42
AVSM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-54
Electric parking brake (EPB) . . . . . . . . . . . . . . . . . . . 5-36
Electronic stability control (ESC) . . . . . . . . . . . . . . . 5-46
Hill-start assist control (HAC) . . . . . . . . . . . . . . . . . . 5-51
Power brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-31
Vehicle stability management. . . . . . . . . . . . . . . . . . . 5-50
Brakes/clutch fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Bulb replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-74
Bulb wattage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-3
Button start/stop, see engine start/stop button . . . . . . . . 5-6
Camera (Rear view) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-104
Capacities (Lubricants) . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
Care Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-79
Interior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-84
Tire care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-43
Center console storage . . . . . . . . . . . . . . . . . . . . . . . . 4-146
Central door lock/unlock switch. . . . . . . . . . . . . . . . . . 4-17 Certification label . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9
Chains
Tire chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-102
Checking tire inflation pressure . . . . . . . . . . . . . . . . . . 7-44
Child restraint system . . . . . . . . . . . . . . . . . . . . . . . . . . 3-32 ISOFIX system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-39
Seat belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-35
Tether anchor system . . . . . . . . . . . . . . . . . . . . . . . . . 3-38
Child-protector rear door lock . . . . . . . . . . . . . . . . . . . 4-19
Cigarette lighter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-150
Climate control air filter . . . . . . . . . . . . . . . . . . . . . . . . 7-35
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-157
Clothes hanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-157
Cluster Settings (Type B) . . . . . . . . . . . . . . . . . . . . . . . 4-66
Combined instrument, see instrument cluster . . . . . . . 4-49
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-26
Cooling fluid, see engine coolant . . . . . . . . . . . . . . . . . 7-26
Crankcase emission control system . . . . . . . . . . . . . . . 7-86
Cruise control system . . . . . . . . . . . . . . . . . . . . . . . . . . 5-65
Cup holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-151
Curtain air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-55
Dashboard illumination, see instrument panel illumination . . 4-50
Dashboard, see instrument cluster . . . . . . . . . . . . . . . . 4-49
Daytime running light . . . . . . . . . . . . . . . . . . . . . . . . . 4-110
C
D

I7
Index
Label
Air bag warning label . . . . . . . . . . . . . . . . . . . . . . . . . 3-64
Air conditioner compressor label . . . . . . . . . . . . . . . . 8-10
Tire sidewall labeling . . . . . . . . . . . . . . . . . . . . . . . . . 7-49
Tire specification and pressure label . . . . . . . . . . . . . 8-10
Vehicle certification label . . . . . . . . . . . . . . . . . . . . . . . 8-9
Lane departure warning system (LDWS) . . . . . . . . . . . 5-85
Lap/shoulder belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-21
LCD display (Type A) . . . . . . . . . . . . . . . . . . . . . . . . . 4-56 A/V Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-60
LCD modes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
Turn By Turn Mode . . . . . . . . . . . . . . . . . . . . . . . . . . 4-60
User Settings Mode . . . . . . . . . . . . . . . . . . . . . . . . . . 4-57
LCD display (Type B) . . . . . . . . . . . . . . . . . . . . . . . . . 4-61 Cluster Settings. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-66
Feeling (Haptic switch feeling) . . . . . . . . . . . . . . . . . 4-67
HUD Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-65
LCD Menus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-61
Vehicle Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-63
Warning Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-68
LCD Display Control . . . . . . . . . . . . . . . . . . . . . . . . . . 4-51
LCD Menus (Type B) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-61
LCD modes (Type A) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
Light bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-75 Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-110
AFLS (Adaptive Front Lighting System). . . . . . . . . 4-112
Auto light/AFLS position . . . . . . . . . . . . . . . . . . . . . 4-112
Battery saver function. . . . . . . . . . . . . . . . . . . . . . . . 4-110
Daytime running light. . . . . . . . . . . . . . . . . . . . . . . . 4-110
Front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-116
Headlight (Headlamp) escort function . . . . . . . . . . . 4-110
Headlight leveling device . . . . . . . . . . . . . . . . . . . . . 4-117
Headlight position. . . . . . . . . . . . . . . . . . . . . . . . . . . 4-113
Headlight washer . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-117
High - beam operation . . . . . . . . . . . . . . . . . . . . . . . 4-114
Parking light position . . . . . . . . . . . . . . . . . . . . . . . . 4-113
Rear fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-116
Traffic change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-111
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-115
Lubricants and capacities . . . . . . . . . . . . . . . . . . . . . . . . 8-6
Luggage net (holder) . . . . . . . . . . . . . . . . . . . . . . . . . 4-159
Luggage volume . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Main fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-57
Maintenance Explanation of scheduled maintenance items . . . . . . 7-20
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . . 7-4
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6
Scheduled maintenance service . . . . . . . . . . . . . . . . . . 7-8
L
M

Index
8
I
Tire maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48
Maintenance schedule. . . . . . . . . . . . . . . . . . . . . . . . . . . 7-8
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-4
Manual mode (shift by cable). . . . . . . . . . . . . . . . . . . . 5-14
Manual mode (shift by wire) . . . . . . . . . . . . . . . . . . . . 5-23
Map pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-149
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-44
Electric chromic mirror (ECM) . . . . . . . . . . . . . . . . . 4-44
Inside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . . 4-44
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . 4-45
Moonroof, see sunroof . . . . . . . . . . . . . . . . . . . . . . . . . 4-37
Multi fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-58
Multimedia system . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-161 Antenna. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-163
Audio / Video / Navigation system (AVN) . . . . . . . 4-161
Aux, USB and iPod port. . . . . . . . . . . . . . . . . . . . . . 4-161
Bluetooth® Wireless Technology hands-free. . . . . . 4-162
Driver Information System (DIS) . . . . . . . . . . . . . . 4-162
Steering wheel audio control . . . . . . . . . . . . . . . . . . 4-163
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
Oil (Engine) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-24
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . . 4-45
Outside Temperature Gauge . . . . . . . . . . . . . . . . . . . . . 4-55
Overheats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-8
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6 Parking assist system . . . . . . . . . . . . . . . . . . . . . . . . . . 4-99
Parking guide system . . . . . . . . . . . . . . . . . . . . . . . . . 4-105
Parking light position . . . . . . . . . . . . . . . . . . . . . . . . . 4-113
Power brakes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-31
Power door latch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
Power outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-152
Power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-30
Power window lock button . . . . . . . . . . . . . . . . . . . . . . 4-31
Pre-Safe Seat belt (PSB). . . . . . . . . . . . . . . . . . . . . . . . 3-28
Pre-tensioner seat belt. . . . . . . . . . . . . . . . . . . . . . . . . . 3-25
Puddle lamp and door handle lamp . . . . . . . . . . . . . . 4-126
Rear curtain. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-159
Rear lamp switch (Type A) . . . . . . . . . . . . . . . . . . . . . 4-122
Rear lamp switch (Type B) . . . . . . . . . . . . . . . . . . . . . 4-124
Rear mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-158
Rear seat adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Rear seat storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-146
Rear view camera . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-104
Recommended cold tire inflation pressures . . . . . . . . . 7-43
Recommended lubricants and capacities . . . . . . . . . . . . 8-6
Recommended SAE viscosity number . . . . . . . . . . . . . 8-8
Replacement light bulb . . . . . . . . . . . . . . . . . . . . . . . . . 7-75
O
P
R

I9
Index
Road warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
Rocking the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-96
Rotation (Tire) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-45
Scheduled maintenance service . . . . . . . . . . . . . . . . . . . 7-8
Seat belt warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-21
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-19
Care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-29
Height adjustment(front seat) . . . . . . . . . . . . . . . . . . . 3-22
Lap/shoulder belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-21
Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-29
Pre-Safe Seat belt (PSB) . . . . . . . . . . . . . . . . . . . . . . 3-28
Pre-tensioner seat belt . . . . . . . . . . . . . . . . . . . . . . . . 3-25
Seat belt warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-21
Seat belts Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-29
Seat belts Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 3-29
Seat warmer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-153
Seatback pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-148
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Driver position memory system . . . . . . . . . . . . . . . . . . 3-7
Front seat adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Headrest(front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
Headrest(rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
Rear seat adjustment. . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Shift lock system (shift by cable) . . . . . . . . . . . . . . . . . 5-15 Shift lock system (shift by wire) . . . . . . . . . . . . . . . . . 5-24
Side air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-54
Side curtain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-160
Smart key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
Battery replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
Buttons on the smart key . . . . . . . . . . . . . . . . . . . . . . . 4-6
Immobilizer system . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-9
Restrictions in handling keys . . . . . . . . . . . . . . . . . . . . 4-7
Smart key function . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
Smart key precautions . . . . . . . . . . . . . . . . . . . . . . . . . 4-8
Smooth cornering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-97
Snow tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-101
Spare tire Changing tires. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-16
Removing and storing the spare tire . . . . . . . . . . . . . 6-16
Special driving conditions . . . . . . . . . . . . . . . . . . . . . . 5-96 Driving at night . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-98
Driving in flooded areas . . . . . . . . . . . . . . . . . . . . . . . 5-99
Driving in the rain . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-98
Hazardous driving conditions. . . . . . . . . . . . . . . . . . . 5-96
Highway driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-99
Rocking the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . 5-96
Smooth cornering . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-97
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
SRS components and functions . . . . . . . . . . . . . . . . . . 3-47
Starting difficulties, see engine will not start . . . . . . . . . 6-4
S