maintenance schedule KIA RIO HATCHBACK 2018 Owner's Manual

827
Maintenance
Changing the engine oil and
filter
Have engine oil and filter changed by
an authorized Kia dealer according
to the Maintenance Schedule at the
beginning of this chapter.
CALIFORNIA PROPO-
SITION 65 WARNING
Engine oil contains chemicals
known to the State of California
to cause cancer, birth defects
and reproductive harm. Used
engine oil may cause irritation or
cancer of the skin if left in con-
tact with the skin for prolonged
periods of time. Always protect
your skin by washing your
hands thoroughly with soap and
warm water as soon as possible
after handling used oil.

Maintenance
30
8
For mixture percentage, refer to the
following table.Changing the coolant
Have the coolant changed by an
authorized Kia dealer according to
the Maintenance Schedule at the
beginning of this chapter.
Put a thick cloth around the radiator
cap before refilling the coolant in
order to prevent the coolant from
overflowing into engine parts such as
the alternator.
OSC077017N
Ambient
Temperature Mixture Percentage
(volume)
Antifreeze Water
5°F (-15°C)35 65
-13°F (-25°C)4060
-31°F (-35°C)5050
-49°F (-45°C)6040
WARNING
Radiator cap
Do not remove the radiator cap
when the engine and radiator
are hot. Scalding hot coolant
and steam may blow out under
pressure which may result in
serious injury.
CAUTION
Put a thick cloth or fabric around the radiator cap beforerefilling the coolant in order toprevent the coolant from over-flowing into engine parts suchas the generator.

835
Maintenance
Replace the filter according to the
Maintenance Schedule.
If the vehicle is operated in extreme-ly dusty or sandy areas, replace theelement more often than the usualrecommended intervals. (Refer to“Maintenance under severe usageconditions” in this chapter.)
CAUTION - Air filter
maintenance
Do not drive with the air clean- er removed; this will result inexcessive engine wear.
When removing the air cleaner filter, be careful that dust ordirt does not enter the airintake, or damage may result.
Use a Kia genuine part. Use of a non-genuine part coulddamage the air flow sensor.

Maintenance
36
8
CLIMATE CONTROL AIR FILTER
Filter inspection
The climate control air filter should
be replaced according to the
Maintenance Schedule. If the vehicle
is operated in severely air-polluted
cities or on dusty rough roads for a
long period, it should be inspected
more frequently and replaced earlier.
When you replace the climate control
air filter, replace it performing the fol-
lowing procedure, and be careful to
avoid damaging other components.
1. Open the glove box and removethe stoppers on both sides. 2. With the glove box open, pull the
support strap (1).
OYB076023OYB076022

I5
Index
Engine overheats ..............................................................7-6
Engine start/stop button ..................................................6-8Illuminated engine start/stop button ............................6-8
Engine start/stop button position ..................................6-8
Engine start/stop button illumination ..............................6-8
Engine start/stop button position ....................................6-8
Engine will not start ........................................................7-4
Evaporative emission control (including ORVR: Onboard Refueling Vapor Recovery) system ............8-109
Exhaust emission control system ................................8-110
Explanation of scheduled maintenance items ..............8-21 Engine oil and filter ....................................................8-21
Drive belts ..................................................................8-21
Fuel filter (for gasoline) ..............................................8-21
Fuel lines, fuel hoses and connections ......................8-21
Vapor hose and fuel filler cap ....................................8-21
Vacuum crankcase ventilation hoses ..........................8-22
Air cleaner filter ..........................................................8-22
Spark plugs ................................................................8-22
Valve clearance ..........................................................8-22
Cooling system ..........................................................8-22
Coolant ........................................................................\
8-22
Manual transaxle fluid ................................................8-22
Automatic transaxle fluid............................................8-2\
2
Brake hoses and lines..................................................8-23
Brake/clutch fluid........................................................8-24
Parking brake ..............................................................8-24
Brake discs, pads, calipers and rotors ........................8-24 Exhaust pipe and muffler ............................................8-24
Suspension mounting bolts ........................................8-24
Steering gear box, linkage & boots/lower arm ball joint ....................................................................8-24\
Drive shafts and boots ................................................8-24
Air conditioning refrigerant ........................................8-24
Exterior care ................................................................8-101
Flat tire ........................................................................\
..7-18 Jack and tools ..............................................................7-18
Removing and storing the spare tire ..........................7-19
Changing tires ............................................................7-20
Floor mat anchor(s) ....................................................4-136
Fluid Brake/clutch fluid........................................................8-31
Washer fluid ................................................................8-32
Folding the outside rearview mirror ..............................4-51
Front fog lamp bulb replacement ..................................8-84
Front fog light ................................................................4-92
Front seat adjustment ......................................................3-4
Front turn signal lamp bulb replacement (Headlamp Type A) ....................................................8-81
Front turn signal lamp bulb replacement (Headlamp Type B) ....................................................8-83
F

Index
8I
Front turn signal lamp bulb replacement (Headlamp Type A) ..................................................8-81
Headlamp (Low/High beam) bulb replacement (Headlamp Type B) ..................................................8-82
Front turn signal lamp bulb replacement (Headlamp Type B) ..................................................8-83
Front fog lamp bulb replacement................................8-84
Position lamp + DRL (LED type) bulb replacement..8-84
DRL (Bulb type) bulb replacement ............................8-85
Side repeater lamp (LED type) bulb replacement ......8-85
Side repeater lamp (Bulb type) bulb replacement ......8-86
Stop and tail lamp bulb replacement (5 door) ............8-86
Rear turn signal lamp bulb replacement (5 door) ......8-88
Stop and tail lamp (LED type) bulb replacement (5 door) ....................................................................8-89\
Back-up lamp bulb replacement (5 door) ..................8-89
Tail lamp (inside) bulb replacement (5 door) ............8-90
High mounted stop lamp bulb replacement (5 door)..8-91
License plate lamp bulb replacement (5,4 door) ........8-91
Rear turn signal lamp bulb replacement (4 door) ......8-92
Stop and tail lamp/Side marker (Bulb type) replacement (4 door) ................................................8-93
Back-up lamp bulb replacement (4 door) ..................8-94
Tail lamp (Bulb type) bulb replacement (4 door) ......8-95
Stop and tail lamp (LED type) bulb replacement (4 door) ....................................................................8-96\
High mounted stop lamp bulb replacement (4 door)..8-96
Trunk lamp bulb replacement (4 door) ......................8-97 Map lamp bulb replacement ......................................8-97
Vanity mirror lamp bulb replacement ........................8-98
Room lamp bulb replacement ....................................8-99
Glove box lamp bulb replacement ..............................8-99
Tailgate room lamp bulb replacement (5 door) ........8-100
Lighting........................................................................\
..4-88 Battery saver function ................................................4-87
Headlight welcome function ......................................4-87
Parking light position ..................................................4-88
Headlight position ......................................................4-89
Auto light position ......................................................4-89
High - beam operation ................................................4-90
Turn signals ................................................................4-91
Front fog light ............................................................4-92
Lubricants and capacities ................................................9-7
Luggage net holder ......................................................4-129
Luggage room lamp ....................................................4-101
Maintenance Engine compartment ....................................................8-4
Maintenance services ....................................................8-5
Owner maintenance ......................................................8-7
Scheduled maintenance service ....................................8-9
Explanation of scheduled maintenance items ............8-21
Tire maintenance ........................................................8-50
M

I9
Index
Maintenance schedule......................................................8-9Normal maintenance schedule ....................................8-10
Maintenance under severe usage conditions ..............8-20
Maintenance services ......................................................8-5 Owner’s responsibility ..................................................8-5
Owner maintenance precautions ..................................8-6
Manual climate control system....................................4-104 Heating and air conditioning ....................................4-105
System operation ......................................................4-110
Climate control air filter ..........................................4-112
Checking the amount of air conditioner refrigerant and compressor lubricant ..............................................4-113
Manual transaxle............................................................6-15 Manual transaxle operation ........................................6-15
Good driving practices ................................................6-17
Manual windows ............................................................4-35
Map lamp ......................................................................4-\
98
Map lamp bulb replacement ..........................................8-97
Mirrors ........................................................................\
..4-49 Inside rearview mirror ................................................4-49
Day/night rearview mirror ..........................................4-49
Outside rearview mirror ..............................................4-49
Remote control ............................................................4-50
Folding the outside rearview mirror ..........................4-51 Occupant detection system ............................................3-37
Odometer ......................................................................4-\
56
Oil (Engine) ..................................................................8-26
Online factory authorized manuals (U.S. ONLY) ........9-16
Operation(Air bags) ......................................................3-31
Outside rearview mirror ................................................4-49
Outside temperature gauge ............................................4-56
Over view (LCD windows) ..........................................4-59
Overheats ........................................................................\
7-6
Owner maintenance ........................................................8-7
Owner maintenance schedule ......................................8-7
Parking brake........................................................6-25, 8-33 Checking the parking brake ........................................8-33
Parking light position ....................................................4-88
Placing a passenger seat belt into the auto lock mode ..3-25
Position lamp + DRL (LED type) bulb replacement ....8-84
Power outlet ................................................................4-133
Power window lock button ............................................4-34
Precautions ....................................................................3-20\
Pre-tensioner seat belt....................................................3-17O
P

Index
10I
Radar type autonomous emergency braking ................6-37System setting and activation ....................................6-37
AEB warning message and system control ................6-39
Brake operation ..........................................................6-40
System malfunction ....................................................6-42
Limitation of the system ............................................6-43
Rear seat adjustment ........................................................3-9
Rear turn signal lamp bulb replacement (4 door)..........8-92
Rear turn signal lamp bulb replacement (5 door)..........8-88
Rearview camera............................................................4-86
Recommended lubricants and capacities ........................9-7 Recommended SAE viscosity number ........................9-9
Record your key number ................................................4-4
Refrigerent label ............................................................9-11
Remote control (Outside rear view mirror) ..................4-50
Remote keyless entry Remote keyless entry system operations ......................4-9
Transmitter precautions ..............................................4-10
Battery replacement ....................................................4-11
Immobilizer system ....................................................4-12
Reporting safety deffects (U.S. ONLY) ........................9-16
Resetting the sunroof ....................................................4-45
Road warning ..................................................................7-2
Rocking the vehicle ......................................................6-57
Room lamp ....................................................................4-99\
Room lamp bulb replacement ........................................8-99
Rotation (Tire) ..............................................................8-47
Scheduled maintenance service ......................................8-9
Normal maintenance schedule ....................................8-10
Maintenance under severe usage conditions ..............8-20
Seat belt restraint system ..............................................3-12
Seat belt warning ..........................................................3-13
Seat belts ........................................................................\
3-12 Seat belt restraint system ............................................3-12
Seat belt warning ........................................................3-13
Pre-tensioner seat belt ................................................3-17
Precautions ..................................................................3-20
Care of seat belts ........................................................3-22
Seat warmer ................................................................4-132
Seats ........................................................................\
........3-2 Front seat adjustment ....................................................3-4
Headrest (Front) ............................................................3-6
Rear seat adjustment ....................................................3-9
Securing a child restraint seat with child seat lower anchor system ..............................................................3-28
Securing a child restraint seat with tether anchorage system ........................................................................\
..3-27
Service mode ................................................................4-65
Shopping bag holder ....................................................4-136
Side air bag ....................................................................3-47\
S
R