steering KIA RIO HATCHBACK 2018 Repair Manual

Maintenance
72
8
Engine room compartment fuse panel
Fuse NameFuse ratingCircuit Protected
MDPS80AMDPS (Motor Driven Power Steering) Unit
ALT150AFuse - ABS1, BAS2, BLOWER, REAR HEATED
REAR HEATED40AInstrument Panel Junction Block (Rear Defogger Relay)
ABS140AESC (Electronic Stability Control) Module, Multipurpose Check Connector
ABS240AESC (Electronic Stability Control) Module
BLOWER40ABlower Relay
WIPER10AFront Wiper Motor, Multifunction Switch, Wiper Low Relay
ECU415AECM (Engine Control Module)/PCM (Power train Control Module)
SENSOR10AOil Control Valve #1/#2, Cooling Fan1/2 Relay, Oxygen Sensor (Up), Oxygen Sensor (Down), Variable
Intake Solenoid Valve, Air Conditioner Relay, Purge Control Solenoid Valve, Canister Close Valve
ECU215AECM (Engine Control Module)/PCM (Power train Control Module)
ECU320AECM (Engine Control Module)/PCM (Power train Control Module)
HEAD LAMP RH10AHead Lamp Right Handle side
HEAD LAMP LH10AHead Lamp Left Handle side
IGN COIL20AIgnition Coil #1~#4, Condenser
ECU515AECM (Engine Control Module)/PCM (Power train Control Module), Fuel Pump Relay

Maintenance
108
8
Cleaning the leather seats
Remove all contaminations instant-
ly. Refer to instructions below for
removal of each contaminant.
Cosmetic products(sunscreen, foundation, etc.)
- Apply cleansing cream on a clothand wipe the contaminated point.
Wipe off the cream with a wet cloth
and remove water with a dry cloth.
Beverages(coffee, soft drink, etc.) - Apply a small amount of neutraldetergent and wipe until contami-
nations do not smear.
Oil - Remove oil instantly withabsorbable cloth and wipe with
stain remover for natural leather
only.
Chewing gum - Harden the gum with ice andremove gradually.
Fabric seat cover using precau-
tions (If equipped)
Please clean the fabric seats regu-
larly with a vacuum cleaner in con-
sideration of fabric material charac-
teristics. If they are heavily soiled
with beverage stains, etc., use a suit-
able interior cleaner. To prevent dam-
age to seat covers, wipe off the seat
covers down to the seams with a
large wiping motion and moderate
pressure using a soft sponge or
microfiber cloth.
Velcro closures on clothing or sharp
objects may cause snagging or
scratches on the surface of the seats.
Make sure not to rub such objects
against the surface.
CAUTION - Leather
When cleaning leather products(steering wheel, seats etc.), useneutral detergents or low alco-hol content solutions. If you usehigh alcohol content solutionsor acid/alkaline detergents, thecolor of the leather may fade orthe surface may get stripped off.

Index
4I
To cancel cruise control ..............................................6-51
To resume cruising speed at more than approximately 20 mph (3 0km/h) ....................................................6-51
To turn cruise control off ............................................6-52
Cup holder ..................................................................4-131
Curtain air bag ..............................................................3-48
Dashboard illumination, see instrument panel illumination..................................................................4-53
Dashboard, see instrument cluster ................................4-52
Day/night rearview mirror ............................................4-49
Declaration of Conformity ............................................5-39
Defogging (Windshield) ..............................................4-123
Defroster (Rear window) ............................................4-103
Defrosting (Windshield) ..............................................4-123
Dimensions ......................................................................9-\
2
Display illumination, see instrument panel illumination ..4-53
Displays, see instrument cluster ....................................4-52
Door locks......................................................................4-\
17 from outside the vehicle..............................................4-17
from inside the vehicle................................................4-18
Central door lock switch ............................................4-18
Child-protector rear door lock ....................................4-20
Driver's and passenger's front air bag ............................3-44
Driving at night ..............................................................6-58
Driving in flooded areas ................................................6-59 Driving in the rain..........................................................6-59
Driving off-road ............................................................6-60
DRL (Bulb type) bulb replacement ..............................8-85
Economical operation ....................................................6-55
Electric power steering ..................................................4-46
Electrical equipment (U.S. ONLY) ..............................9-15
Electronic stability control (ESC) ................................6-29
Emergency starting ..........................................................7-5
Jump starting ................................................................7-5
Emergency while driving ................................................7-3
Emission control system ..............................................8-109 Crankcase emission control system ..........................8-109
Evaporative emission control (including ORVR: Onboard Refueling Vapor Recovery) system ........8-109
Exhaust emission control system ..............................8-110
Engine ........................................................................\
......9-2
Engine compartment ........................................................8-4
Engine coolant ..............................................................8-28 Checking the coolant level..........................................8-28
Changing the coolant ..................................................8-30
Engine coolant temperature gauge ................................4-55
Engine number ..............................................................9-11
Engine oil ......................................................................8-\
26 Checking the engine oil level ....................................8-26
Changing the engine oil and filter ..............................8-27
D
E

I5
Index
Engine overheats ..............................................................7-6
Engine start/stop button ..................................................6-8Illuminated engine start/stop button ............................6-8
Engine start/stop button position ..................................6-8
Engine start/stop button illumination ..............................6-8
Engine start/stop button position ....................................6-8
Engine will not start ........................................................7-4
Evaporative emission control (including ORVR: Onboard Refueling Vapor Recovery) system ............8-109
Exhaust emission control system ................................8-110
Explanation of scheduled maintenance items ..............8-21 Engine oil and filter ....................................................8-21
Drive belts ..................................................................8-21
Fuel filter (for gasoline) ..............................................8-21
Fuel lines, fuel hoses and connections ......................8-21
Vapor hose and fuel filler cap ....................................8-21
Vacuum crankcase ventilation hoses ..........................8-22
Air cleaner filter ..........................................................8-22
Spark plugs ................................................................8-22
Valve clearance ..........................................................8-22
Cooling system ..........................................................8-22
Coolant ........................................................................\
8-22
Manual transaxle fluid ................................................8-22
Automatic transaxle fluid............................................8-2\
2
Brake hoses and lines..................................................8-23
Brake/clutch fluid........................................................8-24
Parking brake ..............................................................8-24
Brake discs, pads, calipers and rotors ........................8-24 Exhaust pipe and muffler ............................................8-24
Suspension mounting bolts ........................................8-24
Steering gear box, linkage & boots/lower arm ball joint ....................................................................8-24\
Drive shafts and boots ................................................8-24
Air conditioning refrigerant ........................................8-24
Exterior care ................................................................8-101
Flat tire ........................................................................\
..7-18 Jack and tools ..............................................................7-18
Removing and storing the spare tire ..........................7-19
Changing tires ............................................................7-20
Floor mat anchor(s) ....................................................4-136
Fluid Brake/clutch fluid........................................................8-31
Washer fluid ................................................................8-32
Folding the outside rearview mirror ..............................4-51
Front fog lamp bulb replacement ..................................8-84
Front fog light ................................................................4-92
Front seat adjustment ......................................................3-4
Front turn signal lamp bulb replacement (Headlamp Type A) ....................................................8-81
Front turn signal lamp bulb replacement (Headlamp Type B) ....................................................8-83
F

Index
6I
Fuel filler lid ..................................................................4-38Opening the fuel filler lid ..........................................4-38
Closing the fuel filler lid ............................................4-38
Fuel gauge......................................................................4-\
55
Fuses ........................................................................\
......8-60 Inner panel fuse replacement ......................................8-62
Memory fuse ..............................................................8-63
Engine compartment fuse replacement ......................8-64
Fuse/relay panel description ......................................8-66
Gauges ........................................................................\
..4-54
Glove box ....................................................................4-12\
8
Glove box lamp............................................................4-101
Glove box lamp bulb replacement ................................8-99
Hazard warning flasher ....................................................7-2
Hazardous driving conditions ........................................6-57
Headlamp (Low/High beam) bulb replacement (Headlamp type B) ......................................................8-82
Headlamp (Low/High beam) bulb replacement (Headlamp Type A) ....................................................8-80
Headlight escort function ..............................................4-87
Headlight position..........................................................4-89
Headlight welcome function..........................................4-87 Headrest (Front) ..............................................................3-6
Heated steering wheel....................................................4-48
High - beam operation ..................................................4-90
High mounted stop lamp bulb replacement (4 door) ....8-96
High mounted stop lamp bulb replacement (5 door) ....8-91
Highway driving ............................................................6-60
Hill-start assist control (HAC) ......................................6-33
Hood ........................................................................\
......4-36
Opening the hood ........................................................4-36
Closing the hood ........................................................4-37
Hood open warning ....................................................4-37
Horn ........................................................................\
......4-47
Ignition switch position ..................................................6-6
Indicator lights ..............................................................4-82
Inside rearview mirror ..................................................4-49
Instrument cluster ..........................................................4-52 Instrument cluster control ..........................................4-53
LCD window control ..................................................4-53
Gauges ........................................................................\
4-54
Warning lights ............................................................4-74
Indicator lights ............................................................4-82
Interior care..................................................................8-106
Interior features............................................................4-131 Cup holder ................................................................4-131
Sunvisor ....................................................................4-13\
1
G
H
I

I11
Index
Side repeater lamp (Bulb type) bulb replacement ........8-86
Side repeater lamp (LED type) bulb replacement ........8-85
Sliding the sunroof ........................................................4-42
Smart key ........................................................................\
4-6Smart key functions ......................................................4-6
Smart key precautions ..................................................4-7
Smart key functions ........................................................4-6
Smart trunk (4 door) How to use the smart trunk ........................................4-23
How to deactivate the smart trunkfunction using the smart key ..................................................................4-25
Detecting area ............................................................4-25
Smooth cornering ..........................................................6-58
Snow tires ......................................................................6-\
61
Spare tire Jack and tools ..............................................................7-18
Removing and storing the spare tire ..........................7-19
Changing tires ............................................................7-20
Special driving conditions ............................................6-57 Hazardous driving conditions ....................................6-57
Rocking the vehicle ....................................................6-57
Smooth cornering ........................................................6-58
Driving at night ..........................................................6-58
Driving in the rain ......................................................6-59
Driving in flooded areas ............................................6-59
Driving off-road ..........................................................6-60
Highway driving ........................................................6-60
Speedometer ..................................................................4-54 Sport mode integrated control system ..........................6-53
SRS care ......................................................................3-\
54
SRS components and functions ..................................3-34
Starting difficulties, see engine will not start ..................7-4
Starting the engine ........................................................6-12 Starting the engine with an ignition key ....................6-12
Starting the engine with a smart key ..........................6-13
Steering wheel ..............................................................4-46 Electric power steering ..............................................4-46
Tilt and telescopic steering ........................................4-47
Heated steering wheel ................................................4-48
Horn ........................................................................\
....4-47
Stop and tail lamp (LED type) bulb replacement (4 door) ........................................................................\
8-96
Stop and tail lamp (LED type) bulb replacement (5 door) ........................................................................\
8-89
Stop and tail lamp/Side marker (Bulb type) replacement (4 door) ........................................................................\
8-93
Stop and tail lamp bulb replacement (5 door) ..............8-86
Storage compartment ..................................................4-128 Center console storage ..............................................4-128
Glove box ..................................................................4-128
Sunglass holder ........................................................4-129
Luggage net holder ..................................................4-129
Sunglass holder ............................................................4-129
Sunroof ........................................................................\
..4-41 Sliding the sunroof ......................................................4-42
Sunroof open warning ................................................4-42

Index
12I
Tilting the sunroof ......................................................4-44
Sunshade ....................................................................4-44\
Resetting the sunroof ..................................................4-45
Sunroof open warning ..................................................4-42
Sunshade ........................................................................\
4-44
Sunvisor ......................................................................4-\
131
Tachometer ....................................................................4-54\
Tail lamp (Bulb type) bulb replacement (4 door)..........8-95
Tail lamp (Inside) bulb replacement (5 door)................8-90
Tailgate room lamp bulb replacement (5 door) ..........8-100
Tailgate (5 door) ............................................................4-27 Opening tailgate ..........................................................4-27
Closing tailgate ..........................................................4-27
Emergency tailgate safety release ..............................4-28
Theft alarm system ........................................................4-14 Armed stage ................................................................4-14
Theft-alarm stage ........................................................4-15
Disarmed stage ............................................................4-16
Tilt and telescopic steering ............................................4-47
Tilting the sunroof ........................................................4-44
Tire chains......................................................................6-\
62
Tire pressure monitoring system (Type A) ......................7-7
Tire pressure monitoring system (Type B) ....................7-12
Tire replacement ............................................................8-49
Tire rotation ..................................................................8-47 Tire specification and pressure label ............................9-11
Tires and wheels ............................................................8-45
Tire care ......................................................................8-\
45
Recommended cold tire inflation pressures................8-45
Tire pressure................................................................8-46
Checking tire inflation pressure ..................................8-46
Tire rotation ................................................................8-47
Wheel alignment and tire balance ..............................8-48
Tire replacement ........................................................8-49
Wheel replacement ....................................................8-50
Tire traction ................................................................8-50
Tire maintenance ........................................................8-50
Tire sidewall labeling ................................................8-50
Tire terminology and definitions ................................8-54
All season tires ............................................................8-57
Summer tires ..............................................................8-57
Snow tires....................................................................8-57\
Tire chains ..................................................................8-57
Radial-ply tires ............................................................8-58
Low aspect ratio tire ..................................................8-58
Tires and wheels ..........................................................9-5
Towing Towing service ............................................................7-28
Emergency towing ......................................................7-29
Transaxle - Automatic transaxle ....................................6-18
Transaxle - Manual transaxle ........................................6-15
Transaxle shift indicator ................................................4-57
Trip information ............................................................4-59
T