service KIA Rondo 2016 3.G Service Manual

Maintenance
87
SCHEDULED MAINTENANCE SERVICE
Follow Normal Maintenance
Schedule if the vehicle is usually
operated where none of the following
conditions apply. If any of the following
conditions apply, follow Maintenance
Under Severe Usage Conditions.
Repeated short distance driving.
Driving in dusty conditions orsandy areas.
Extensive use of brakes.
Driving in areas where salt or other corrosive materials are being used.
Driving on rough or muddy roads.
Driving in mountainous areas.
Extended periods of idling or low speed operation.
Driving for a prolonged period in cold temperatures and/or extreme-
ly humid climates.
More than 50% driving in heavy city traffic during hot weather
above 32°C (90°F).If your vehicle is operated under theabove conditions, you shouldinspect, replace or refill more fre-quently than the following NormalMaintenance Schedule. After theperiods or distance shown in thechart, continue to follow the pre-scribed maintenance intervals.

79
Maintenance
NORMAL MAINTENANCE SCHEDULE
The following maintenance services must be performed to ensure good emission control and performance.
Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the
frequency of service is determined by whichever occurs first.
*1: Fuel filter & Fuel tank air filter are considered to be maintenance free\
but periodic inspection is recommended for this mainte-nance schedule depends on fuel quality. If there are some important safety matters like fuel flow restriction, surging, loss of
power, hard starting problem etc, replace the fuel filter immediately regardless of maintenance schedul\
e and consult an author -
ized Kia dealer for details.
*
2: If TOP TIER Detergent Gasoline is not available, one bottle of additive is recommended. Additives are available from your authorized Kia dealer along with information on how to use them. Do not mix other additives.
*
3: The drive belt should be replaced when cracks occur or tension is reduced excessively.

Maintenance
22
7
No check, No service required
❑ Automatic transaxle fluid (if equipped)
240,000 km (150,000 miles) or 120 months
❑Rotate tire
❑ Inspect battery condition
❑ Inspect air conditioning refrigerant
❑ Inspect brake hoses and lines
❑ Inspect drive belts *
3
(First, 96,000 km (60,000 miles) or 72 months
after every 24,000 km (15,000 miles) or 24 months)
❑ Inspect drive shafts and boots
❑ Inspect exhaust pipe and muffler
❑ Inspect front brake disc/pads, calipers and rotors
❑ Inspect steering gear box, linkage & boots/lower arm ball
joint, upper arm ball joint
❑ Inspect suspension mounting bolts
❑ Inspect brake/clutch (if equipped) fluid
❑ Inspect fuel filter *
1
❑Inspect fuel lines, fuel hoses and connections
❑ Inspect fuel tank air filter (if equipped) *1
❑Inspect rear brake disc/pads, parking brake
❑ Inspect vapor hose and fuel filler cap, fuel tank
❑ Inspect vacuum hose
❑ Inspect manual transaxle fluild (if equipped)
(Continued)
(Continued)
❑Replace climate control air filter
(for evaporator and blower unit)
❑ Replace air cleaner filter
❑ Replace engine oil and filter
(240,000 km (150,000 miles) or 240 months)
❑ Replace coolant
(First, 192,000 km (120,000 miles) or 120 months
after every 48,000 km (30,000 miles) or 24 months)
❑ Add fuel additive *
2
(12,000 km (7,500 miles) or 12 months)
❑ Inspect cooling system hoses and connections
❑ Inspect brake pedal free play
❑ Inspect all latch, hinges and locks
❈ Inspect : Inspect and if necessary, adjust, correct, clean or
replace.
NORMAL MAINTENANCE SCHEDULE

723
Maintenance
MAINTENANCE UNDER SEVERE USAGE CONDITIONS
The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer
to the chart below for the appropriate maintenance intervals.
R : Replace I : Inspect and, after inspection, clean, adjust, repair or replace if neces\
sary
MAINTENANCE ITEMMAINTENANCEOPERATIONMAINTENANCE INTERVALSDRIVING
CONDITION
ENGINE OIL AND FILTERREVERY 6,000 KM (3,750 MILES) OR 6 MONTHSA, B, C, D, E, F,G, H, I, J, K
AIR CLEANER FILTERRMORE FREQUENTLYC, E
SPARK PLUGSRMORE FREQUENTLYB, H
AUTOMATIC TRANSAXLE FLUIDREVERY 96,000 KM (60,000 MILES) A, C, E, F, G, I
MANUAL TRANSAXLE FLUIDREVERY 120,000 KM (75,000 MILES) A, C, E, F, G, I
(Continued)

743
Maintenance
BATTERY
For best battery service
Keep the battery securely mount-ed.
Keep the battery top clean and dry.
Keep the terminals and connec- tions clean, tight, and coated with
petroleum jelly or terminal grease.
Rinse any spilled electrolyte from the battery immediately with a
solution of water and baking soda.
If the vehicle is not going to be used for an extended time, discon-
nect the battery cables.
WARNING- Battery dan-
gers
Always read the follow-
ing instructions carefully
when handling a battery.
Keep lighted cigarettes and all other flames or
sparks away from the
battery.
Hydrogen, a highly com- bustible gas, is always
present in battery cells
and may explode if ignit-
ed.
Keep batteries out of the reach of children
because batteries con-
tain highly corrosive
SULFURIC ACID. Do not
allow battery acid to
contact your skin, eyes,
clothing or paint finish.
(Continued)(Continued)If any electrolyte getsinto your eyes, flush
your eyes with clean
water for at least 15 min-
utes and get immediate
medical attention.
If electrolyte gets on
your skin, thoroughly
wash the contacted
area. If you feel pain or
burning sensation, get
medical attention imme-
diately.
Wear eye protection when charging or work-
ing near a battery.
Always provide ventila-
tion when working in an
enclosed space.
(Continued)
OGD071015

Maintenance
54
7
4. Tire ply composition and mate-
rial
The number of layers or plies of rub-
ber-coated fabric in the tire. Tire
manufacturers also must indicate the
materials in the tire, which include
steel, nylon, polyester, and others.
The letter "R" means radial ply con-
struction; the letter "D" means diago-
nal or bias ply construction; and the
letter "B" means belted-bias ply con-
struction.
5. Maximum permissible inflationpressure
This number is the greatest amount
of air pressure that should be put in
the tire. Do not exceed the maximum
permissible inflation pressure. Refer
to the Tire and Loading Information
label for recommended inflation
pressure.
6. Maximum load rating
This number indicates the maximum
load in kilograms and pounds that
can be carried by the tire. When
replacing the tires on the vehicle,
always use a tire that has the same
load rating as the factory installed
tire.
7. Uniform tire quality grading
Quality grades can be found, where
applicable, on the tire sidewall
between tread shoulder and maxi-
mum section width.
For example:
TREADWEAR 440
TRACTION A
TEMPERATURE A
WARNING- Tire age
Tires degrade over time, even
when they are not being used.
Regardless of the remaining
tread, we recommend that tires
be replaced after approximately
six (6) years of normal service.
Heat caused by hot climates or
frequent high loading condi-
tions can accelerate the aging
process. Failure to follow this
warning can result in sudden
tire failure, which could lead to
a loss of control and an acci-
dent involving serious injury or
death.

755
Maintenance
Tread wear
The tread wear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specified govern-
ment test course. For example, a tire
graded 150 would wear one-and-a-
half times (1½) as well on the gov-
ernment course as a tire graded 100.
The relative performance of tires
depends upon the actual conditions
of their use, however, and may
depart significantly from the norm
due to variations in driving habits,
service practices and differences in
road characteristics and climate.
Tires degrade over time, even when
they are not being used. Regardless
of the remaining tread, we recom-
mend that tires be replaced after
approximately six (6) years of normal
service. Heat caused by hot climates
or frequent high loading conditions
can accelerate the aging process.
These grades are molded on the
side-walls of passenger vehicle tires.
The tires available as standard or
optional equipment on your vehicles
may vary with respect to grade.Traction - AA, A, B & C
The traction grades, from highest to
lowest, are AA, A, B, and C. Those
grades represent the tire’s ability to
stop on wet pavement as measured
under controlled conditions on spec-
ified government test surfaces of
asphalt and concrete. A tire marked
C may have poor traction perform-
ance.
The traction grade assigned to this tire
is based on straight-ahead braking
traction tests, and does not include
acceleration, cornering, hydroplaning,
or peak traction characteristics.
Temperature -A, B & C
The temperature grades are A (the
highest), B and C representing the
tire’s resistance to the generation of
heat and its ability to dissipate heat
when tested under controlled condi-
tions on a specified indoor laboratory
test wheel.
Sustained high temperature can
cause the material of the tire to
degenerate and reduce tire life, and
excessive temperature can lead to
sudden tire failure. Grades B and A
represent higher levels of perform-
ance on the laboratory test wheel
than the minimum required by law.
WARNING
The traction grade assigned to
this tire is based on straight-
ahead braking traction tests,
and does not include accelera-
tion, cornering, hydroplaning,
or peak traction characteristics.

Index
6I
LCD Display Control . . . . . . . . . . . . . . . . . . . . . . . . 4-59
Trip computer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-75
Warnings and indicator lights . . . . . . . . . . . . . . . . . 4-79
Instrument panel fuse . . . . . . . . . . . . . . . . . . . . . . . . . . 7-63
Instrument panel overview . . . . . . . . . . . . . . . . . . . . . . . 2-5
Interior care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-81\
Interior features. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-156 Air ventilation seat . . . . . . . . . . . . . . . . . . . . . . . . . 4-161
Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15\
6
Aux, USB and iPod . . . . . . . . . . . . . . . . . . . . . . . . 4-164
Bottle holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-158
Cargo security screen . . . . . . . . . . . . . . . . . . . . . . . 4-167
Cigarette lighter . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-156
Clothes hanger . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-165
Cup holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-157
Floor mat anchor(s) . . . . . . . . . . . . . . . . . . . . . . . . 4-165
Luggage net holder. . . . . . . . . . . . . . . . . . . . . . . . . 4-167
Portable lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-170
Power outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-163
Seat warmer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-159
Side curtain. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-171
Sunvisor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-162
Interior lamp AUTO cut . . . . . . . . . . . . . . . . . . . . . . . 4-118
Interior light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-118 Interior lamp AUTO cut . . . . . . . . . . . . . . . . . . . . . 4-118
Luggage room lamp . . . . . . . . . . . . . . . . . . . . . . . . 4-120
Map lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-118
Room lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-119 Vanity mirror lamp . . . . . . . . . . . . . . . . . . . . . . . . . 4-120
Interior light welcome . . . . . . . . . . . . . . . . . . . . . . . . 4-121
Interior overview. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
Jack and tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-15
Jump starting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
Key positions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
Label Air bag warning label. . . . . . . . . . . . . . . . . . . . . . . . 3-80
Tire sidewall labeling . . . . . . . . . . . . . . . . . . . . . . . . 7-52
Tire specification and pressure label . . . . . . . . . . . . . 8-9
LCD display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-64 A/V Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-68
LCD Modes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-64
Service Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-65
Turn By Turn Mode . . . . . . . . . . . . . . . . . . . . . . . . . 4-68
User Settings Mode . . . . . . . . . . . . . . . . . . . . . . . . . 4-66
Warning Messages . . . . . . . . . . . . . . . . . . . . . . . . . . 4-69
LCD Display Control . . . . . . . . . . . . . . . . . . . . . . . . . . 4-59
LCD Modes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-64
J
K
L

I7
Index
Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
4-104Auto light position . . . . . . . . . . . . . . . . . . . . . . . . . 4-106
Battery saver function . . . . . . . . . . . . . . . . . . . . . . 4-104
Daytime running light (DRL) . . . . . . . . . . . . . . . . 4-105
Front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-109
Headlamp delay function . . . . . . . . . . . . . . . . . . . . 4-104
Headlight welcome function . . . . . . . . . . . . . . . . . 4-105
High beam operation . . . . . . . . . . . . . . . . . . . . . . . 4-107
Lighting control . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-105
Turn signals and lane change signals . . . . . . . . . . . 4-108
Lighting control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-105
Loss of the smart key . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
Lower anchor system . . . . . . . . . . . . . . . . . . . . . . . . . . 3-47
Lubricants and capacities . . . . . . . . . . . . . . . . . . . . . . . . 8-6
Luggage net holder . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-167
Luggage room lamp . . . . . . . . . . . . . . . . . . . . . . . . . . 4-120
Luggage tray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-154
Luggage volume . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Main fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
65
Maintenance Explanation of scheduled maintenance items . . . . . 7-25
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . 7-4
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6
Scheduled maintenance service . . . . . . . . . . . . . . . . . 7-8
Tire maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-52 Maintenance schedule. . . . . . . . . . . . . . . . . . . . . . . . . . . 7-8
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-4
Manual climate control system. . . . . . . . . . . . . . . . . . 4-124
Manual transaxle. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-13
Map lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11\
8
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-53
Day/night rearview mirror . . . . . . . . . . . . . . . . . . . . 4-53
Electric chromic mirror with compass . . . . . . . . . . . 4-54
Inside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . 4-53
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . 4-55
Moonroof, see panoramic sunroof . . . . . . . . . . . . . . . . 4-42
Multi fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
66
Occupant Detection System . . . . . . . . . . . . . . . . . . . . . 3-56
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
62
Oil (Engine) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . . 4-55 Folding the outside rearview mirror. . . . . . . . . . . . . 4-56
Outside Temperature Gauge . . . . . . . . . . . . . . . . . . . . . 4-62
Overheats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
6-8
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6
Paddle shifter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-21
Panoramic sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-42
P
O
M

Index
8I
Resetting the sunroof . . . . . . . . . . . . . . . . . . . . . . . . 4-46
Sunroof open warning . . . . . . . . . . . . . . . . . . . . . . . 4-43
Sunshade. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-45\
Parking assist system . . . . . . . . . . . . . . . . . . . . . . . . . . 4-96
Parking brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-28 Checking the parking brake . . . . . . . . . . . . . . . . . . . 7-37
Portable lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-170
Power brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-26
Power outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-163
Power window lock button . . . . . . . . . . . . . . . . . . . . . . 4-33
Pre-tensioner seat belt. . . . . . . . . . . . . . . . . . . . . . . . . . 3-33
Precautions (seat belt). . . . . . . . . . . . . . . . . . . . . . . . . . 3-36
Puddle lamp welcome. . . . . . . . . . . . . . . . . . . . . . . . . 4-121
Rear parking assist system . . . . . . . . . . . . . . . . . . . . . . 4-92
Rear seat adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
Rear view camera . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-102
Rear window wiper and washer switch . . . . . . . . . . . 4-117
Recommended cold tire inflation pressures . . . . . . . . . 7-46 Recommended SAE viscosity number. . . . . . . . . . . . 8-7
Recommended lubricants and capacities . . . . . . . . . . . . 8-6
Resetting the sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 4-46
Road warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
Rocking the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-55
Roof rack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17\
2
Room lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-119 Rotation (Tire) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-49
Scheduled maintenance service . . . . . . . . . . . . . . . . . . . 7-8
Seat belt restraint system . . . . . . . . . . . . . . . . . . . . . . . 3-21
Seat belt warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-23
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
3-21
3- point rear seat belt . . . . . . . . . . . . . . . . . . . . . . . . 3-28
3- point system seat belt. . . . . . . . . . . . . . . . . . . . . . 3-27
Height adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 3-25
Precautions (seat belt) . . . . . . . . . . . . . . . . . . . . . . . 3-36
Pre-tensioner seat belt . . . . . . . . . . . . . . . . . . . . . . . 3-33
Seat belt restraint system . . . . . . . . . . . . . . . . . . . . . 3-21
Seat belt warning . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-23
Stowing the rear seat belt . . . . . . . . . . . . . . . . . . . . . 3-32
Seat warmer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-159
Seatback pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . 3-2 Front seat adjustment - Manual . . . . . . . . . . . . . . . . . 3-5
Front seat adjustment - power . . . . . . . . . . . . . . . . . . 3-6
Headrest (front) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-9
Headrest (rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-18
Rear seat adjustment . . . . . . . . . . . . . . . . . . . . . . . . 3-13
Seatback pocket . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Service Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-65
Shift lock system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-22
Side air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-70\
R
S