catalytic converter KIA SORENTO 2017 Warranty and Consumer Information Guide
[x] Cancel search | Manufacturer: KIA, Model Year: 2017, Model line: SORENTO, Model: KIA SORENTO 2017Pages: 115, PDF Size: 0.8 MB
Page 17 of 115
16
(a) “EPA” means the U.S. Environmental Protection
Agency.
(b) “Owner” means the original and each subsequent
owner of a Kia Vehicle.
(c) “Kia Part” means a part sold by an Authorized
Kia Dealer, whether new or remanufactured,
and supplied by Kia.
(d) “Emission Warranty Part” means a catalytic
converter, thermal reactor, or other component
installed on or in a Kia Vehicle by or at the
direction of Kia for the sole or primary purpose
of reducing the Kia Vehicle’s emissions (not
including those vehicle components which
were in general use prior to model year 1968
and the primary function of which is not related
to emission control). A list of typical Emission
Warranty Parts is set forth at the end of this
warranty. (e) “Certified Part” means a replacement part for a
Kia Vehicle certified in accordance with after
market part certification regulations issued by
the EPA.
(f) “Written Maintenance Instructions” means those
maintenance and operation instructions,
together with the time and/or mileage interval
at which such maintenances are to be
performed, specified in the Owner’s Manual for
the Kia Vehicle or this Warranty and Consumer
Information Manual as being necessary to
assure compliance of the Kia Vehicle with
applicable emission standards during the term
of this warranty, as specified by law.
Emission Warranty Definitions
Federal
Emission Control Warranty
Page 24 of 115
23
Federal
Emission Control Warranty
Federal Emission Control Warranty
Air Induction System
Air Cleaner Assembly
Intake Manifold
Surge Tank-Air Intake
Turbo Charger
Fuel Metering System
Engine Coolant Temperature Sensor (ECT)
Mass Air Flow Sensor (MAF)
Manifold Absolute Pressure Sensor (MAP)
Vehicle Speed Sensor (VSS)
Wheel Speed Sensor (WSS)
Fuel Injector
Fuel Delivery Line
Throttle Body (ETC Actuator)
Throttle Position Sensor (TPS)
Idle Speed Control System
Oxygen Sensor
Pulsation Damper
Engine Control Module (ECM)
* 8/80 All vehiclesHigh Pressure Pump
High Pressure Sensor
Ignition System
Spark Plugs
Spark Plugs Cable Set
Ignition Coil
Camshaft Position Sensor (CMPS)
Crankshaft Position Sensor (CKPS)
GeneratorValve Timing System
CVVT Assy
Oil Control Valve Assy
Oil Temperature Sensor
Evaporative Control System
Vapor Storage Canister
Canister Close Valve (CCV)
Purge Control Solenoid Valve (PCSV)
Fuel Pump
Fuel Pump Module
Fuel Tank
Fuel Filler Cap
Fuel Tank Pressure Sensor (FTP)
ORVR(Vent) Valve
Rollover(Cut) Valve
Positive Crankcase Ventilation System
PCV Valve and Hose
Catalyst and Exhaust System
Exhaust Manifold
Exhaust Manifold Catalytic Assembly * 8/80 All vehiclesExhaust Pipe (Manifold to Catalyst)
Catalytic Converter Assembly * 8/80 All vehiclesMiscellaneous Items Used In Above Systems
Hose, Clamps,Gasket or Seals
Wires, Harnesses Connectors
All Sensor(Switches,Solenoid Valves, Battery) associated with the ECMOnboard Emission Diagnostic Device
Malfunction Indicator Light and Bulb * 8/80 All vehiclesData Link Connector * 8/80 All vehicles
Spark Plugs shall be warranted for the emissions warranty period, or the first scheduled replacement time or mileage, whichever occurs first.
NOTE 1 : Specific emission parts covered up to 5 years or 60,000 miles, whichever occurs first, or up to the first required scheduled maintenance,
whichever occurs first (See Owner's Manual for required scheduled maintenance).
NOTE 2 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, whichever occurs first.
Page 25 of 115
24California
Emission Control Warranty
Your Warranty Rights And Obligations
The California Air Resources Board and Kia Motors
America, Inc., are pleased to explain the emission
control system warranty on your 2017 Kia vehicle. In
California, new motor vehicles must be designed, built
and equipped to meet the State’s stringent anti-smog
standards. Kia must warrant the emission control
system on your Kia vehicle for the periods of time
listed below provided there has been no abuse, neglect
or improper maintenance of your Kia vehicle.
Your emission control system may include parts such
as the carburetor or fuel-injection system, the ignition
system, catalytic converter, and engine computer. Also
included may be hoses, belts, connectors and other
emission-related assemblies. Where a warrantable
condition exists, Kia will repair your Kia vehicle at no
cost to you including diagnosis, parts and labor.
Manufacturer’s Warranty Coverage
For 3 years or 50,000 miles, whichever first occurs:
1.If your Kia vehicle fails a Smog Check inspection,
all necessary repairs and adjustments will be made
by Kia to ensure that your vehicle passes the
inspection. This is your emission control system
PERFORMANCE WARRANTY.
2. If any emission-related part on your Kia vehicle is
defective, the part will be repaired or replaced by
Kia. This is your short-term emission control
system DEFECTS WARRANTY.
For 7 years or 70,000 miles for emission related parts,
whichever first occurs (8 years or 80,000 miles for
Federal Emission Control Warranty) :
If an emission-related part listed in this warranty
booklet specially noted with coverage for 7 years
or 70,000 miles is defective, the part will be
repaired or replaced by Kia. This is your long-term
emission control system DEFECTS WARRANTY.
For 2017 SULEV (Super Ultra Low Emission Vehicle)
vehicle certified as partial zero-emission vehicle
(PZEV) only, all parts covered under the
PERFORMANCE WARRANTY and the DEFECT
WARRANTY, which are listed in this warranty booklet
on the Emission Warranty Parts List, are warranted for
15 years or 150,000 miles, whichever occurs first.
California Emission Control Warranty Statement
Page 28 of 115
27
California
Emission Control Warranty
What The Owner Must Do
It is your responsibility to perform the required
maintenance and use the vehicle in accordance with
Kia’s written instructions. Warranty coverage will not be
denied solely because there is no record of maintenance.
However, failures caused by lack of required
maintenance are not covered by the warranty. To avoid
questions as to whether the vehicle maintenance has
been performed, Kia urges that you retain all receipts
and/or maintenance records indicating that service has
been performed on the vehicle and these documents
should be transferred to any subsequent owner of the
vehicle.
Service
MAINTENANCE SERVICE CAN BE PERFORMED
BY ANY QUALIFIED SERVICE OUTLET OR BY
THE OWNER. HOWEVER, EXCEPT IN AN
EMERGENCY SITUATION (SEE EMERGENCY
SERVICE), WARRANTY SERVICE MUST BE
PERFORMED BY AN AUTHORIZED KIA DEALER.
Parts
IT IS RECOMMENDED THAT ANY REPLACEMENT
PARTS USED FOR MAINTENANCE OR FOR THE
REPAIR OF EMISSIONS CONTROL SYSTEMS BE
NEW, KIA GENUINE PARTS. However, the warranty
obligations are not dependent upon the use of any
particular brand of replacement parts. The owner may
elect to use non-Kia parts for maintenance purposes. Use
of replacement parts which are not of equivalent quality
may impair the effectiveness of emissions control
systems.
What Is Not Covered By Emission Warranty
Malfunctions in any part caused by misuse, alteration,
tampering, disconnection or improper or inadequate
maintenance.
Damage to catalytic converter due to use of leaded
gasoline.
Damage resulting from fire, accident, negligence, act of
God or other events beyond the control of Kia.
Maintenance replacement parts (such as spark plugs)
beyond the first scheduled replacement point.
Page 30 of 115
29
California
Emission Control Warranty
California Emission Control Warranty
Air Induction System
Air Cleaner Assembly
Intake Manifold
* 7/70 Rio, Soul, Forte 1.8, Optima, Sportage, Sorento 2.4, K900 5.0, CadenzaSurge Tank -Air Intake * 7/70 Sorento 3.3, Cadenza, Sedona, K900 3.8Turbo Charger
Fuel Metering System
Engine Coolant Temperature Sensor (ECT)
Mass Air Flow Sensor (MAF)
Manifold Absolute Pressure Sensor (MAP)
Vehicle Speed Sensor (VSS)
Wheel Speed Sensor (WSS)
Fuel Injector
Fuel Delivery Line
Throttle Body (ETC Actuator)
*7/70 Forte 1.6Throttle Position Sensor (TPS)
Idle Speed Control System
Oxygen Sensor
Pulsation Damper
Engine Control Module (ECM)
* 8/80 All vehiclesHigh Pressure Pump * 7/70 Rio, Soul, Forte 1.6, 2.0, Optima 2.0, 2.4, Sportage, Sorento, Cadenza, K900, SedonaHigh Pressure Sensor
Ignition System
Generator
*7/70 Forte, Soul, Optima 2.0, 2.4, Sportage, Sorento, Rio, K900, SedonaSpark Plugs
Spark Plugs Cable Set
Ignition Coil
Camshaft Position Sensor (CMPS)
Crankshaft Position Sensor (CKPS)Valve Timing System
CVVT Assy
Oil Control Valve Assy
Oil Temperature Sensor
Evaporative Control System
Vapor Storage Canister
Canister Close Valve (CCV)
Purge Control Solenoid Valve (PCSV)
Fuel Pump
Fuel Pump Module
Fuel Tank
*7/70 Rio, Soul, Forte, Optima, Sportage, Sorento, Cadenza, Sedona, K900Fuel Filler Cap
Fuel Tank Pressure Sensor (FTP)
ORVR(Vent) Valve
Rollover(Cut) Valve
Fuel Pump & Sender Assy
* 7/70 Sportage 2.0, K900 3.8Positive Crankcase Ventilation System
PCV Valve and Hose
Catalyst and Exhaust System
Exhaust Manifold
Exhaust Manifold Catalytic Assembly
* 8/80 All vehiclesExhaust Pipe (Manifold to Catalyst) * 7/70 Sorento 3.3, Cadenza, Sedona, K900 Catalytic Converter Assembly * 8/80 All vehiclesMiscellaneous Items Used In Above Systems
Hose, Clamps,Gasket or Seals
Wires, Harnesses Connectors
All Sensor(Switches, Solenoid Valves, Battery) associated with the ECMOnboard Emission Diagnostic Device
Malfunction Indicator Light and Bulb * 8/80 All vehiclesData Link Connector * 8/80 All vehiclesSpark Plugs shall be warranted for the emissions warranty period, or the first scheduled replacement time or mileage, whichever occurs first.
NOTE 1 : Specific emission parts covered up to 5 years or 60,000 miles, whichever occurs first, or up to the first required scheduled maintenance,
whichever occurs first (See Owner's Manual for required scheduled maintenance.)
NOTE 2 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, whichever occurs first.
NOTE 3 : Parts designated by "7/70" are warranted for 7 years or 70,000 miles, whichever occurs first.
NOTE 4 : The above parts for a Forte & Forte Koup, Optima 2.4, Sportage SULEV vehicle, certified as a partial zero-emission vehicle(PZEV) only,
are warranted for 15 years or 150,000 miles, whichever occurs first.