maintenance KIA SOUL 2015 Owners Manual

Maintenance
94
7
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in
the canister are drawn into the surge
tank through the purge control sole-
noid valve.
Purge Control Solenoid Valve
(PCSV)
The purge control solenoid valve is
controlled by the Engine Control
Module (ECM); when the engine
coolant temperature is low during
idling, the PCSV closes so that evap-
orated fuel is not taken into the
engine. After the engine warms up
during ordinary driving, the PCSV
opens to introduce evaporated fuel to
the engine.
3. Exhaust emission control
system
The Exhaust Emission Control
System is a highly effective system
which controls exhaust emissions
while maintaining good vehicle per-
formance.
Vehicle modifications
This vehicle should not be modified.
Modification of your vehicle could
affect its performance, safety or
durability and may even violate gov-
ernmental safety and emissions reg-
ulations.
In addition, damage or performance
problems resulting from any modifi-
cation may not be covered under
warranty.
If you use unauthorized electronic
devices, it may cause the vehicle to
operate abnormally, wire damage,
battery discharge and fire. For your
safety, do not use unauthorized
electronic devices.
Engine exhaust gas precautions
(carbon monoxide)
Carbon monoxide can be present with other exhaust fumes.
Therefore, if you smell exhaust
fumes of any kind inside your vehi-
cle, have it inspected and repaired
immediately. If you ever suspect
exhaust fumes are coming into
your vehicle, drive it only with all
the windows fully open. Have your
vehicle checked and repaired
immediately.
WARNING - Exhaust
Engine exhaust gases contain
carbon monoxide (CO). Though
colorless and odorless, it is
dangerous and could be lethal if
inhaled. Follow the instructions
on this page to avoid CO poi-
soning.

795
Maintenance
Do not operate the engine in con-fined or closed areas (such as
garages) any more than what is
necessary to move the vehicle in or
out of the area.
When the vehicle is stopped in an open area for more than a short
time with the engine running,
adjust the ventilation system (as
needed) to draw outside air into the
vehicle.
Never sit in a parked or stopped vehicle for any extended time with
the engine running.
When the engine stalls or fails to start, excessive attempts to restart
the engine may cause damage to
the emission control system.Operating precautions for catalyt-
ic converters
WARNING- Catalytic converter
Keep away from the catalytic
converter and exhaust system
while the vehicle is running or
immediately thereafter. The
exhaust and catalytic systems
are very hot and may burn you.
WARNING- Fire
Do not park, idle or drive the vehicle over or near flamma-
ble objects, such as grass,
vegetation, paper, leaves, etc.
A hot exhaust system can
ignite flammable items under
your vehicle.
Also, do not remove the heat sink around the exhaust sys-
tem, do not seal the bottom of
the vehicle or do not coat the
vehicle for corrosion control.
It may present a fire risk under
certain conditions.

Maintenance
96
7
Your vehicle is equipped with a cat-
alytic converter emission control
device.
Therefore, the following precautions
must be observed:
Use only UNLEADED FUEL for
gasoline engines.
Do not operate the vehicle when there are signs of engine malfunc-
tion, such as misfire or a noticeable
loss of performance.
Do not misuse or abuse the engine. Examples of misuse are
coasting with the ignition off and
descending steep grades in gear
with the ignition off.
Do not operate the engine at high idle speed for extended periods (5
minutes or more).
Do not modify or tamper with any part of the engine or emission con-
trol system. All inspections and
adjustments must be made by an
authorized Kia dealer.
Avoid driving with a extremely low fuel level. Running out of fuel could
cause the engine to misfire, dam-
aging the catalytic converter. Failure to observe these precautions
could result in damage to the catalyt-
ic converter and to your vehicle.
Additionally, such actions could void
your warranties.
Perchlorate Material-special handling
may apply, See www.dtsc.ca.gov/haz-
ardouswaste/ perchlorate.
Notice to California Vehicle Dismantlers:
Perchlorate containing materials,
such as air bag inflators, seatbelt
pretensioners and keyless remote
entry batteries, must be disposed of
according to Title 22 California Code
of Regulations Section 67384.10 (a).
CALIFORNIA
PERCHLORATE NOTICE

815
Specifications, Consumer information, Reporting safety defects
If you believe that your vehicle has a defect which could
cause a crash or could cause injury or death, you should
immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying Kia
Motors America, Inc.
If NHTSA receives similar complaints, it may open an
investigation, and if it finds that a safety defect exists in a
group of vehicles, it may order a recall and remedy cam-
paign. However, NHTSA cannot become involved in indi-
vidual problems between you, your dealer, or Kia Motors
America, Inc.
To contact NHTSA, you may call the Vehicle Safety
Hotline toll-free at 1-888-327-4236 (TTY: 1-800-424-
9153); go to http://www.safercar.gov; or write to:
Administrator, NHTSA, 1200 New Jersey Ave., SE., West
Building, Washington, DC 20590. You can also obtain
other information about motor vehicle safety from
http://www.safercar.gov.The following publications are available on
www.KiaTechinfo.com at no charge.
Service manual:
This manual covers maintenance and recommended pro-
cedures for repair to engine and chassis components. It
is written for the Journeyman mechanic, but is simple
enough for most mechanically inclined owners to under-
stand.
Electrical troubleshooting manual:
This manual complements the Service Manual by provid-
ing indepth troubleshooting information for each electrical
circuit in your vehicle.
Owner's manual:
This manual describes the overall features and operating
procedures for the vehicle.
REPORTING SAFETY DEFECTS
(U.S. ONLY)
ONLINE FACTORY AUTHORIZED MANUALS
(U.S. ONLY)

I5
Index
Engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Engine Coolant Temperature guage . . . . . . . . . . . . . . . 4-53
Engine number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-10
Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
27
Engine overheats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7
Engine start/stop button . . . . . . . . . . . . . . . . . . . . . . . . . 5-9Engine start/stop button . . . . . . . . . . . . . . . . . . . . . . . 5-9
Illuminated engine start/stop button. . . . . . . . . . . . . . 5-9
Starting the engine with a smart key . . . . . . . . . . . . 5-11
Engine will not start . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
Evaporative emission control System . . . . . . . . . . . . . . 7-93
Exhaust emission control system . . . . . . . . . . . . . . . . . 7-94
Explanation of scheduled maintenance items . . . . . . . 7-23
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-86
Exterior features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-141 Mounting bracket for roof carrier . . . . . . . . . . . . . 4-141
Exterior overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
Flat tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 6-13 Changing tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-15
Compact spare tire . . . . . . . . . . . . . . . . . . . . . . . . . . 6-20
Jack and tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-13
Removing and storing the spare tire . . . . . . . . . . . . 6-15
Tire Mobility Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-23
Floor mat anchor(s) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-137 Fluid
Brakes/clutch fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 7-32
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-34
Folding the rear seat . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-89
Front seat adjustment - Manual . . . . . . . . . . . . . . . . . . . 3-5
Front seat adjustment - power . . . . . . . . . . . . . . . . . . . . 3-6
Front wiper deicer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-99
Fuel Economy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-70
Fuel filler lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-54\
Fuel requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 Do not use methanol . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
Fuel Additives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
Gasoline containing alcohol and methanol . . . . . . . . 1-3
Gasoline containing MMT . . . . . . . . . . . . . . . . . . . . . 1-4
Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-63\
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 7-61 Fuse switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-63
Fuse/relay panel description. . . . . . . . . . . . . . . . . . . 7-66
Instrument panel fuse . . . . . . . . . . . . . . . . . . . . . . . . 7-62
Multi fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-65
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-52 Engine Coolant Temperature guage . . . . . . . . . . . . . 4-53
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-54
F
G

Index
8I
User Settings Mode . . . . . . . . . . . . . . . . . . . . . . . . . 4-60
Warning Messages . . . . . . . . . . . . . . . . . . . . . . . . . . 4-63
LCD Display Control . . . . . . . . . . . . . . . . . . . . . . . . . . 4-51
LCD modes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-58\
LCD Warning Messages . . . . . . . . . . . . . . . . . . . . . . . . 4-63
Light bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-74\
Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-85 Auto light position . . . . . . . . . . . . . . . . . . . . . . . . . . 4-87
Battery saver function . . . . . . . . . . . . . . . . . . . . . . . 4-85
Daytime running light . . . . . . . . . . . . . . . . . . . . . . . 4-85
Front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-89
Headlamp escort . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-85
Headlight position . . . . . . . . . . . . . . . . . . . . . . . . . . 4-86
High beam operation . . . . . . . . . . . . . . . . . . . . . . . . 4-87
Lighting control . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-86
One-touch lane change function . . . . . . . . . . . . . . . 4-89
Parking light position . . . . . . . . . . . . . . . . . . . . . . . . 4-86
Turn signals and lane change signals . . . . . . . . . . . . 4-88
Lighting control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-86
Lower anchor system . . . . . . . . . . . . . . . . . . . . . . . . . . 3-35
Lubricants and capacities . . . . . . . . . . . . . . . . . . . . . . . . 8-6
Luggage box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-130
Luggage net holder . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-139
Luggage room lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-95
Luggage volume . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5 Maintenance
Explanation of scheduled maintenance items . . . . . 7-23
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . 7-7
Scheduled maintenance service . . . . . . . . . . . . . . . . . 7-9
Tire maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-51
Maintenance schedule. . . . . . . . . . . . . . . . . . . . . . . . . . 7-10
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
Manual climate control system. . . . . . . . . . . . . . . . . . 4-100 Air Conditioning refrigerant label . . . . . . . . . . . . . 4-109
Checking the amount of air conditionerrefrigerant and compressor lubricant . . . . . . . . . . 4-108
Climate control air filter. . . . . . . . . . . . . . . . . . . . . 4-108
Heating and air conditioning . . . . . . . . . . . . . . . . . 4-101
System operation . . . . . . . . . . . . . . . . . . . . . . . . . . 4-106
Manual transaxle. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14 Good driving practices . . . . . . . . . . . . . . . . . . . . . . . 5-16
Manual transaxle operation . . . . . . . . . . . . . . . . . . . 5-14
Map lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
93
Master Warning Mode . . . . . . . . . . . . . . . . . . . . . . . . . 4-60
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-45 Day/night rearview mirror . . . . . . . . . . . . . . . . . . . . 4-45
Electric chromic mirror (ECM) . . . . . . . . . . . . . . . . 4-46
Inside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . 4-45
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . 4-47
Moonroof, see Panoramic sunroof . . . . . . . . . . . . . . . . 4-34M

I9
Index
Mounting bracket for roof carrier . . . . . . . . . . . . . . . . 4-141
Multi fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
65
Occupant Detection System (ODS) . . . . . . . . . . . . . . . 3-44
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
55
ODS see the Occupant Detection System . . . . . . . . . . 3-44
Oil (Engine) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-27
One-touch lane change function . . . . . . . . . . . . . . . . . . 4-89
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . . 4-47
Outside rearview mirror defroster . . . . . . . . . . . . . . . . 4-99
Outside Temperature Gauge . . . . . . . . . . . . . . . . . . . . . 4-55
Overheats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
6-8
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-7
Panoramic sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-34Sunroof open warning . . . . . . . . . . . . . . . . . . . . . . . 4-35
Parking brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-34
Parking brake - Hand type . . . . . . . . . . . . . . . . . . . . . . 5-25
Parking light position . . . . . . . . . . . . . . . . . . . . . . . . . . 4-86
Portable lamp usage . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-95
Power brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-23
Power outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-136
Power window lock button . . . . . . . . . . . . . . . . . . . . . . 4-28
Pre-tensioner seat belt. . . . . . . . . . . . . . . . . . . . . . . . . . 3-24 Rear camera display . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-84
Rear center belt - 3 Point . . . . . . . . . . . . . . . . . . . . . . . 3-22
Rear seat adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Rear seat warmer . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-135
Rear window defroster . . . . . . . . . . . . . . . . . . . . . . . . . 4-98
Rear window wiper and washer switch . . . . . . . . . . . . 4-92
Rear window wiper/washer . . . . . . . . . . . . . . . . . . . . . 4-90
Recommended cold tire inflation pressures . . . . . . . . . 7-46
Recommended lubricants and capacities . . . . . . . . . . . . 8-6
Recommended SAE viscosity number. . . . . . . . . . . . 8-8
Record your key number . . . . . . . . . . . . . . . . . . . . . . 4-4,10
Reducing the risk of a rollover . . . . . . . . . . . . . . . . . . . 5-50
Refrigerant label . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-10
Replacement light bulb . . . . . . . . . . . . . . . . . . . . . . . . . 7-74
Road warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
Rocking the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-51
Room lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-94\
Rotation (Tire) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48
Scheduled maintenance service . . . . . . . . . . . . . . . . . . . 7-9
Seat air ventilation . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-134
Seat belt Precautions. . . . . . . . . . . . . . . . . . . . . . . . . . . 3-27
Seat belt warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-17
O
R
S
P

I11
Index
Glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-128
Luggage box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-130
Sunglass holder . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-129
Sunglass holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-129
Sunroof open warning . . . . . . . . . . . . . . . . . . . . . . . . . 4-35
Sunvisor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
132
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52\
Tailgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-22
Tether anchor system . . . . . . . . . . . . . . . . . . . . . . . . . . 3-34
Tire and loading information label . . . . . . . . . . . . . . . . 5-59
Tire chains. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-\
56
Tire pressure monitoring system . . . . . . . . . . . . . . . . . . 6-9
Tire rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48
Tire specification and pressure label . . . . . . . . . . . . . . 8-10
Tires and wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-46,8-4 Checking tire inflation pressure . . . . . . . . . . . . . . . . 7-47
Compact spare tire replacement . . . . . . . . . . . . . . . . 7-50
Low aspect ratio tire. . . . . . . . . . . . . . . . . . . . . . . . . 7-59
Recommended cold tire inflation pressures . . . . . . . 7-46
Tire care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-46\
Tire maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-51
Tire replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-50
Tire rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-48
Tire sidewall labeling . . . . . . . . . . . . . . . . . . . . . . . . 7-51
Tire traction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-51 Wheel alignment and tire balance . . . . . . . . . . . . . . 7-49
Wheel replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 7-51
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 6-30 Emergency towing . . . . . . . . . . . . . . . . . . . . . . . . . . 6-32
Removable towing hook. . . . . . . . . . . . . . . . . . . . . . 6-31
Transaxle Shift Indicator . . . . . . . . . . . . . . . . . . . . . . . 4-56
Trip A/B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
4-69
Trip computer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-68 Fuel Economy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-70
Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-68
Trip A/B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-69\
Turn By Turn Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-62
Turn signals and lane change signals . . . . . . . . . . . . . . 4-88
User Settings Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-60
Vanity mirror lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-97
Vehicle curb weight . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-65
Vehicle data collection and event data recorders . . . . . . 1-6
Vehicle identification number (VIN) . . . . . . . . . . . . . . . 8-9
Vehicle load limit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-59 Certification label . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-63
Tire and loading information label. . . . . . . . . . . . . . 5-59
Vehicle stability management (VSM) . . . . . . . . . . . . . 5-33
T
U
V