engine light KIA SOUL 2017 Repair Manual

89
Maintenance
At least monthly:
Check the coolant level in theengine coolant reservoir.
Check the operation of all exterior lights, including the stoplights, turn
signals and hazard warning flash-
ers.
Check the inflation pressures of all tires including the spare.
At least twice a year
(i.e., every Spring and Fall):
Check the radiator, heater and air conditioning hoses for leaks or
damage.
Check the windshield washer spray and wiper operation. Clean
the wiper blades with clean cloth
dampened with washer fluid.
Check the headlight alignment.
Check the muffler, exhaust pipes, shields and clamps.
Check the lap/shoulder belts for wear and function.
Check for worn tires and loose wheel lug nuts.
At least once a year:
Clean the body and door drainholes.
Lubricate the door hinges and checks, and hood hinges.
Lubricate the door and hood locks and latches.
Lubricate the door rubber weather- strips.
Check the air conditioning system.
Inspect and lubricate the automat- ic transaxle linkage and controls.
Clean the battery and terminals.
Check the brake fluid level.

Maintenance
74
8
FUSES
A vehicle’s electrical system is pro-
tected from electrical overload dam-
age by fuses.
This vehicle has 2 (or 3) fuse panels,
one located in the driver’s side panel
bolster, the other in the engine com-
partment near the battery.
If any of your vehicle’s lights, acces-
sories, or controls do not work, check
the appropriate circuit fuse. If a fuse
has blown, the element inside the
fuse will melt.
If the electrical system does not
work, first check the driver’s side
fuse panel.
Always replace a blown fuse with
one of the same rating.
If the replacement fuse blows, this
indicates an electrical problem. Avoid
using the system involved and imme-
diately consult an authorized Kia
dealer.
Three kinds of fuses are used: micro
mini type for lower amperage rating,cartridge type, and multi fuse forhigher amperage ratings.
Do not arbitrarily modify or add-on electric wiring to the vehicle.
WARNING- Fuse
replacement
Never replace a fuse with any- thing but another fuse of the
same rating.
A higher capacity fuse could cause damage and possibly a
fire.
Never install a wire or alu- minum foil instead of the
proper fuse - even as a tempo-
rary repair. It may cause
extensive wiring damage and
a possible fire.
OPS073054
Normal
Normal
■
Micro mini type
■ Cartridge type
■ Multi fuse
Blown
Blown
Normal
Blown

Maintenance
76
8
Inner panel fuse replacement
1. Turn the ignition switch and all
other switches off.
2. Open the fuse panel cover. 3. Pull the suspected fuse straight
out. Use the fuse puller provided
on the engine compartment fuse
panel cover.
4. Check the removed fuse; replace it if it is blown.
Spare fuses are provided in theengine compartment fuse panel.
5. Push in a new fuse of the same rating, and make sure it fits tightly
in the clips.
If it fits loosely, consult an authorized
Kia dealer.
If you do not have a spare, use a fuse of the same rating from a circuityou may not need for operating thevehicle, such as the power outletfuse.
If the headlights or other electrical
components do not work and the
fuses are OK, check the fuse panel
in the engine compartment. If a fuse
is blown, it must be replaced.
OPS073017
OPS073014

Maintenance
88
8
LIGHT BULBS
Bulb replacement precaution
Please keep extra bulbs on hand
with appropriate wattage ratings in
case of emergencies.
Refer to “Bulb Wattage” in chapter 9.
When changing lamps, first turn off
the engine at a safe place, firmly
apply the parking brake and detach
the battery’s negative (-) terminal.
Use only bulbs of the specified
wattage.✽ ✽ NOTICE
• If the light bulb or lamp connector
is removed while the lamp is still
on, the fuse box's electronic sys-
tem may log it as a malfunction.
Therefore, a lamp malfunction
incident may be recorded as a
Diagnostic Trouble Code (DTC) in
the fuse box.
• It is normal for an operating lamp to flicker momentarily. This is due
to a stabilization function of the
vehicle’s electronic control device.
If the lamp lights up normally
after momentarily blinking, then
it is functioning as normal.
However, if the lamp continues to
flicker several times or turns off
completely, there may be an error
in the vehicle’s electronic control
device. Please have the vehicle
checked by an authorized Kia
dealer immediately.
WARNING- Working on
the lights
Prior to working on the light,
firmly apply the parking brake,
ensure that the ignition switch
is turned to the LOCK position
and turn off the lights to avoid
sudden movement of the vehi-
cle and burning your fingers or
receiving an electric shock.
CAUTION -Light replace-
ment
Be sure to replace the burned- out bulb with one of the samewattage rating. Otherwise, itmay cause damage to the fuseor electric wiring system.
CAUTION -Headlamp
Lens
To prevent damage, do notclean the headlamp lens withchemical solvents or strongdetergents.

Index
6I
Brake discs, pads, calipers and rotors . . . . . . . . . . . 8-37
Exhaust pipe and muffler . . . . . . . . . . . . . . . . . . . . . 8-37
Suspension mounting bolts . . . . . . . . . . . . . . . . . . . 8-38
Steering gear box, linkage & boots/lower arm ball joint . . . . . . . . . . . . . . . . . . . . . . . . 8-38
Drive shafts and boots . . . . . . . . . . . . . . . . . . . . . . . 8-38
Air conditioning refrigerant . . . . . . . . . . . . . . . . . . 8-38
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-106
Exterior features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-147 Mounting bracket for roof carrier . . . . . . . . . . . . . 4-148
Exterior overview (Front) . . . . . . . . . . . . . . . . . . . . . . . . 2-2
Exterior overview (Rear) . . . . . . . . . . . . . . . . . . . . . . . . 2-3
Flat tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 7-15 Jack and tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-15
Removing and storing thespare tire . . . . . . . . . . . . . 7-16
Changing tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16
Removing and storing the spare tire . . . . . . . . . . . . 7-16
Changing tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16
Flex steer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
4-42
Floor mat anchor(s) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-143
Fluid Brake/clutch fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-45
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-47
Folding the outside rearview mirror . . . . . . . . . . . . . . . 4-46 Foward Collision Warning System . . . . . . . . . . . . . . . . 6-65
FCWS Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-65
Limitations of the System . . . . . . . . . . . . . . . . . . . . 6-67
Front fog lamp bulb replacement . . . . . . . . . . . . . . . . . 8-96
Front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-92
Front seat adjustment (manual) . . . . . . . . . . . . . . . . . . . 3-7
Front seat adjustment (power) . . . . . . . . . . . . . . . . . . . . 3-8
Front side marker bulb replacement . . . . . . . . . . . . . . . 8-95
Front turn signal lamp bulb replacement . . . . . . . . . . . 8-93
Fuel filler lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31 Opening the fuel filler lid. . . . . . . . . . . . . . . . . . . . . 4-31
Closing the fuel filler lid . . . . . . . . . . . . . . . . . . . . . 4-31
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52\
Fuel requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 8-74 Inner panel fuse replacement . . . . . . . . . . . . . . . . . 8-76
Engine compartment fuse replacement . . . . . . . . . . 8-77
Fuse/relay panel description. . . . . . . . . . . . . . . . . . . 8-79
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-50
Glove box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13\
3
Glove box lamp. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-100
Glove box lamp bulb replacement . . . . . . . . . . . . . . . 8-104
F
G

Index
8I
Vanity mirror lamp . . . . . . . . . . . . . . . . . . . . . . . . . 4-100
Interior overview. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
Jack and tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-15
Jump starting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
Key operations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
Key positions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6 Illuminated ignition switch . . . . . . . . . . . . . . . . . . . . 6-6
Ignition switch position . . . . . . . . . . . . . . . . . . . . . . . 6-6
Starting the engine . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . 4-4 Record your key number . . . . . . . . . . . . . . . . . . . . . . 4-4
Key operations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
Transmitter precautions . . . . . . . . . . . . . . . . . . . . . . . 4-6
Battery replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7
Immobilizer system . . . . . . . . . . . . . . . . . . . . . . . . . . 4-8
Label Air bag warning label. . . . . . . . . . . . . . . . . . . . . . . . 3-68
Tire sidewall labeling . . . . . . . . . . . . . . . . . . . . . . . . 8-64
Vehicle certification label. . . . . . . . . . . . . . . . . . . . . 9-10 Tire specification and pressure label . . . . . . . . . . . . 9-11
Refrigerant label . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-11
Lane Departure Warning System (LDWS) . . . . . . . . . 6-52 Warning indicator . . . . . . . . . . . . . . . . . . . . . . . . . . 6-54
The LDWS does not operate when . . . . . . . . . . . . . 6-55
The LDWS may not warn you even if the vehicleleaves the lane, or may warn you even if the
vehicle does not leave the lane when; . . . . . . . . . . 6-55
LCD Display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56 LCD Modes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
Service mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-57
User Settings Mode . . . . . . . . . . . . . . . . . . . . . . . . . 4-58
Turn by turn Mode . . . . . . . . . . . . . . . . . . . . . . . . . . 4-64
Warning messages . . . . . . . . . . . . . . . . . . . . . . . . . . 4-64
LCD Modes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
License plate lamp bulb replacement . . . . . . . . . . . . 8-102
Liftgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-22 Opening Liftgate . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-22
Closing Liftgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-22
Emergency Liftgate safety release . . . . . . . . . . . . . . 4-23
Light bulb position (Front) . . . . . . . . . . . . . . . . . . . . . . 8-89
Light bulb position (Rear) . . . . . . . . . . . . . . . . . . . . . . 8-90
Light bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-88\
Bulb replacement precaution . . . . . . . . . . . . . . . . . . 8-88
Light bulb position (Front). . . . . . . . . . . . . . . . . . . . 8-89
Light bulb position (Rear) . . . . . . . . . . . . . . . . . . . . 8-90
Headlamp (HID type) bulb replacement . . . . . . . . . 8-90
Headlamp (Low/High beam) bulb replacement . . . . 8-91
K
J
L

I9
Index
Front turn signal lamp bulb replacement . . . . . . . . . 8-93
Front side marker bulb replacement. . . . . . . . . . . . . 8-95
Position lamp + DRL (LED type) bulb replacement 8-96
Front fog lamp bulb replacement . . . . . . . . . . . . . . . 8-96
Side repeater lamp (LED type) bulb replacement . 8-97
Rear turn signal lamp bulb Replacement . . . . . . . . . 8-98
Stop and tail lamp bulb replacement . . . . . . . . . . . 8-99
Back-up lamp bulb replacement . . . . . . . . . . . . . . 8-100
Stop and tail lamp (LED type) bulb replacement . . 8-101
High mounted stop lamp bulb replacement . . . . . . 8-101
High mounted stop lamp (LED type) bulb replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-102
License plate lamp bulb replacement . . . . . . . . . . 8-102
Map lamp bulb replacement. . . . . . . . . . . . . . . . . . 8-102
Room lamp bulb replacement . . . . . . . . . . . . . . . . 8-103
Glove box lamp bulb replacement . . . . . . . . . . . . . 8-104
Luggage lamp bulb replacement . . . . . . . . . . . . . . 8-104
Vanity mirror lamp bulb replacement . . . . . . . . . . 8-105
Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-88 Battery saver function . . . . . . . . . . . . . . . . . . . . . . . 4-88
Headlight (Headlamp) escort function . . . . . . . . . . . 4-88
Daytime running light . . . . . . . . . . . . . . . . . . . . . . . 4-88
Parking light position . . . . . . . . . . . . . . . . . . . . . . . . 4-89
Auto light position . . . . . . . . . . . . . . . . . . . . . . . . . . 4-90
Headlight position . . . . . . . . . . . . . . . . . . . . . . . . . . 4-89
High - beam operation . . . . . . . . . . . . . . . . . . . . . . . 4-90
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-91
Front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-92 Loss of the smart key . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13
Lubricants and capacities . . . . . . . . . . . . . . . . . . . . . . . . 9-7
Luggage box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-135
Luggage lamp bulb replacement. . . . . . . . . . . . . . . . . 8-104
Luggage room lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-98
Maintenance
Engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . 8-3
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
Scheduled maintenance service . . . . . . . . . . . . . . . . 8-10
Explanation of scheduled maintenance items . . . . . 8-34
Tire maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-64
Maintenance schedule. . . . . . . . . . . . . . . . . . . . . . . . . . 8-10 Normal Maintenance Schedule . . . . . . . . . . . . . . . . 8-11
Maintenance Under Severe Usage Conditions. . . . . 8-32
Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5 Owner’s responsibility . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Owner maintenance precautions . . . . . . . . . . . . . . . . 8-6
Manual Climate Control system . . . . . . . . . . . . . . . . . 4-103 Heating and air conditioning . . . . . . . . . . . . . . . . . 4-104
System operation . . . . . . . . . . . . . . . . . . . . . . . . . . 4-109
Climate control air filter. . . . . . . . . . . . . . . . . . . . . 4-111
Air Conditioning refrigerant label . . . . . . . . . . . . . 4-112
Manual transaxle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-14 Manual transaxle operation . . . . . . . . . . . . . . . . . . . 6-14
M

Index
10I
Good driving practices . . . . . . . . . . . . . . . . . . . . . . . 6-17
Map lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
96
Map lamp bulb replacement . . . . . . . . . . . . . . . . . . . . 8-102
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-43 Inside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . 4-43
Day/night rearview mirror . . . . . . . . . . . . . . . . . . . . 4-43
Electrochromic mirror (ECM) . . . . . . . . . . . . . . . . 4-44
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . 4-45
Remote control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-46
Folding the outside rearview mirror. . . . . . . . . . . . . 4-46
Occupant Detection System . . . . . . . . . . . . . . . . . . . . . 3-49
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-\
52
Oil (Engine) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-39
ONLINE FACTORY AUTHORIZED MANUALS . . . 9-16
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . . 4-45
Overheats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
7-8
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8 Owner maintenance schedule. . . . . . . . . . . . . . . . . . . 8-8
Parking brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-34 Checking the parking brake . . . . . . . . . . . . . . . . . . . 8-48
Parking light position . . . . . . . . . . . . . . . . . . . . . . . . . . 4-89 Portable lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-98
Position lamp + DRL (LED type) bulb replacement . . 8-96
Power outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-141
Power window lock button . . . . . . . . . . . . . . . . . . . . . . 4-28
Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-24\
Pre-tensioner seat belt. . . . . . . . . . . . . . . . . . . . . . . . . . 3-26
Rear camera display . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-87
Rear seat adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
Rear turn signal lamp bulb Replacement . . . . . . . . . . . 8-98
Recommended lubricants and capacities . . . . . . . . . . . . 9-7
Recommended SAE viscosity number. . . . . . . . . . . . 9-9
Record your key number . . . . . . . . . . . . . . . . . . . . . . . . 4-4
Reducing the risk of a rollover . . . . . . . . . . . . . . . . . . . 6-71
Refrigerant label . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-11
Remote control (outside rear view mirror) . . . . . . . . . . 4-46
REPORTING SAFETY DEFECTS . . . . . . . . . . . . . . . 9-16
Resetting the sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 4-38
Road warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
Rocking the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-72
Room lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-97\
Room lamp bulb replacement . . . . . . . . . . . . . . . . . . . 8-103
Rotation (Tire) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-61
O
P
R