maintenance KIA STINGER 2018 Warranty and Consumer Information Guide

21
Federal
Emission Control Warranty
6. Repair or Replacement by an Authorized Kia
Dealer
Your Kia Dealer shall make all adjustments, repairs
or replacements necessary to assure the Kia Vehicle
complies with applicable emission standards of the
EPA and that the Kia Vehicle will continue to
comply during the remainder of the term of this
warranty (if proper maintenance and operation are
continued).
7. Warranty Claim Procedures A warranty claim may be submitted by presenting
the Kia Vehicle to any Authorized Kia Dealer during
the Authorized Kia Dealer’s regular business hours,
together with a copy of a failed emissions test. Upon
presentation of a claim, Kia shall notify the Owner
within 30 days, or such shorter period of time within
which repair is required by local, state or federal
law, that the claim will be honored or shall provide
the Owner in writing with an explanation of the
basis upon which the claim is being denied.
Failure to notify the Owner within such time period
shall cause Kia to be responsible for repairing the
Kia Vehicle free of charge to the Owner, unless such failure is attributable to the Owner or to events
beyond the control of Kia or the Authorized Kia
Dealer.
8. Maintenance by Other Than an Authorized Kia Dealer
Maintenance, replacement, or repair of the emission
control devices and systems covered by this
warranty may be performed by any automotive
repair establishment or individual using Certified
Parts. However, such non-Kia Certified Parts will
not be covered by Kia’s emission system warranties
should such parts fail at a later date.
9. Consumer Assistance If you have any questions regarding your warranty
rights and responsibilities, you should contact the
Kia Motors America, Inc. Consumer Affairs
Department toll-free at 1-800-333-4Kia.Or you
may write to: U.S. Environmental Protection
Agency Office of Transportation and Air Quality
Compliance Division, Light-Duty Vehicle Group
Attn: Warranty Complaints 2000 Traverwood Drive
Ann Arbor, MI 48105
Email: [email protected]

23
Federal
Emission Control Warranty
Federal Emission Control Warranty
Air Induction System
Air Cleaner Assembly
Intake Manifold
Surge Tank-Air Intake
Turbo Charger
Fuel Metering System Engine Coolant Temperature Sensor (ECT)
Mass Air Flow Sensor (MAF)
Manifold Absolute Pressure Sensor (MAP)
Vehicle Speed Sensor (VSS)
Wheel Speed Sensor (WSS)
Fuel Injector
Fuel Delivery Line
Throttle Body (ETC Actuator)
Throttle Position Sensor (TPS)
Idle Speed Control System
Oxygen Sensor
Pulsation Damper
Engine Control Module (ECM)
* 8/80 All vehiclesHigh Pressure Pump
High Pressure Sensor
Ignition System Spark Plugs
Spark Plugs Cable Set
Ignition Coil
Camshaft Position Sensor (CMPS)
Crankshaft Position Sensor (CKPS)
Generator Valve Timing System
CVVT Assy
Oil Control Valve Assy
Oil Temperature Sensor
Evaporative Control System Vapor Storage Canister
Canister Close Valve (CCV)
Purge Control Solenoid Valve (PCSV)
Fuel Pump
Fuel Pump Module
Fuel Tank
Fuel Filler Cap
Fuel Tank Pressure Sensor (FTP)
ORVR(Vent) Valve
Rollover(Cut) Valve
Positive Crankcase Ventilation System PCV Valve and Hose
Catalyst and Exhaust System Exhaust Manifold
Exhaust Manifold Catalytic Assembly * 8/80 All vehiclesExhaust Pipe (Manifold to Catalyst)
Catalytic Converter Assembly * 8/80 All vehiclesMiscellaneous Items Used In Above SystemsHose, Clamps,Gasket or Seals
Wires, Harnesses Connectors
All Sensor(Switches,Solenoid Valves, Battery) associated with the ECMOnboard Emission Diagnostic Device Malfunction Indicator Light and Bulb * 8/80 All vehiclesData Link Connector * 8/80 All vehicles
Spark Plugs shall be warranted for the emissions warranty period, or the\
first scheduled replacement time or mileage, whichever occurs first.
NOTE 1 : Specific emission parts covered up to 5 years or 60,000 miles, whichever\
occurs first, or up to the first required scheduled maintenance, whichever occurs first (See Owner's Manual for required scheduled maint\
enance).
NOTE 2 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, wh\
ichever occurs first.

24California
Emission Control Warranty
Your Warranty Rights And Obligations
The California Air Resources Board and Kia Motors
America, Inc., are pleased to explain the emission
control system warranty on your 2018 Kia vehicle. In
California, new motor vehicles must be designed, built
and equipped to meet the State’s stringent anti-smog
standards. Kia must warrant the emission control
system on your Kia vehicle for the periods of time
listed below provided there has been no abuse, neglect
or improper maintenance of your Kia vehicle.
Y our emission control system may include parts such
as the carburetor or fuel-injection system, the ignition
system, catalytic converter, and engine computer. Also
included may be hoses, belts, connectors and other
emission-related assemblies. Where a warrantable
condition exists, Kia will repair your Kia vehicle at no
cost to you including diagnosis, parts and labor.
Manufacturer’s Warranty Coverage
For 3 years or 50,000 miles, whichever first occurs:
1. If your Kia vehicle fails a Smog Check inspection,
all necessary repairs and adjustments will be made
by Kia to ensure that your vehicle passes the
inspection. This is your emission control system
PERFORMANCE WARRANTY.
2. If any emission-related part on your Kia vehicle is defective, the part will be repaired or replaced by
Kia. This is your short-term emission control
system DEFECTS WARRANTY.
For 7 years or 70,000 miles for emission related parts,
whichever first occurs (8 years or 80,000 miles for
Federal Emission Control Warranty) : If an emission-related part listed in this warranty
booklet specially noted with coverage for 7 years
or 70,000 miles is defective, the part will be
repaired or replaced by Kia. This is your long-term
emission control system DEFECTS WARRANTY.
For 2018 SULEV (Super Ultra Low Emission Vehicle)
vehicle certified as partial zero-emission vehicle
(PZEV) only, all parts covered under the
PERFORMANCE WARRANTY and the DEFECT
W ARRANTY, which are listed in this warranty booklet
on the Emission Warranty Parts List, are warranted for
15 years or 150,000 miles, whichever occurs first.
California Emission Control Warranty Statement

25
California
Emission Control Warranty
Owner’s Warranty Responsibilities
As the Kia vehicle owner, you are responsible for the
performance of the required maintenance listed in your
owner’s manual. Kia recommends that you retain all
receipts covering maintenance on your vehicle but Kia
cannot deny warranty solely for the lack of receipts or
for your failure to ensure the performance of all
scheduled maintenance.
Y ou are responsible for presenting your Kia vehicle to a
Kia dealer as soon as a problem exists. The warranty
repairs should be completed in a reasonable amount of
time, not to exceed 30 days.
As the Kia vehicle owner, you should also be aware that
Kia may deny you warranty coverage if your Kia vehicle
or a part has failed due to abuse, neglect, improper
maintenance or unapproved modifications.
If you have any questions regarding your warranty rights
and responsibilities, you should contact Kia Motors
America Inc., Consumer Affairs Department at 1-800-
333-4542 or the California Air Resource Board, 9528
T elstar Avenue, El Monte, CA 91731 (1-800-242-4450).
Coverage
Kia Motors America, Inc. (Kia), warrants to the owner
that any vehicle certified for sale in the State of California
and registered in the State of California is designed, built
and equipped so as to conform with the emissions
standards adopted by the California Air Resources Board.
Kia warrants that this vehicle is free from defects in
material and workmanship which would cause any part on
this vehicle which affects emissions to fail to conform
with applicable requirements or to fail to pass a required
state smog check test for 3 years or 50,000 miles,
whichever occurs first. Kia also warrants that, any part on
the warranted emissions parts list in this warranty and
installed as original equipment, is free from defects in
material and workmanship which would cause this
vehicle to fail to conform with applicable regulations for 7
years or 70,000 miles, whichever first occurs.

California
Emission Control Warranty26
Warranty Service
To obtain warranty service, return the vehicle to any
authorized Kia dealer. Service will be performed without
charge for diagnosis, parts and labor. In case of
emergency, see Emergency Service Instructions.
Exclusions
This warranty does not apply to failures caused by abuse,
tampering or lack of maintenance; or to any vehicle on
which the odometer mileage has been altered so that the
vehicle’s actual mileage cannot be determined.
STATEMENT OF OWNER’S RIGHTS AND
OBLIGATIONS
What Is Covered By The Warranty
If a vehicle fails a state Smog Check test during the
coverage period, Kia will repair the vehicle so that it will
pass a state Smog Check retest. The owner should take the
vehicle to any authorized dealer for Warranty repairs and
present a copy of the failed Smog Check test report to the
dealer. If the owner is not notified within 30 days that a
performance warranty claim is not valid then the
manufacture is required to repair the vehicle free of charge. In addition, if a warranted part fails because of a defect,
Kia will repair or replace it at any authorized Kia dealer.
Any other parts damaged by the failure of a warranted
part will also be repaired or replaced. The repair and/or
replacement will be made at no charge to the owner for
parts, labor and diagnosis. For emergency situations, see
the instructions under Emergency Service.
How Long Does The Warranty Last
The warranty shall apply for 3 years or 50,000 miles,
whichever occurs first, except that those parts listed on
the warranted parts list are covered for 7 years or 70,000
miles, whichever first occurs. For 2018 SULEV(Super
Ultra Low Emission Vehicle) vehicle certified as partial
zero-emission vehicle(PZEV) only, all parts covered
under the PERFORMANCE WARRANTY and the
DEFECT WARRANTY, which are listed in this warranty
booklet on the Emission Warranty Parts List, are
warranted for 15 years or 150,000 miles, whichever
occurs first. Where parts are scheduled for replacement as
required maintenance, the warranty shall apply until the
first scheduled maintenance point listed in the Owner’s
Manual. This warranty begins on the date the vehicle is
delivered to the original purchaser or on the date the
vehicle is first placed in service, whichever occurs first.

27
California
Emission Control Warranty
What The Owner Must Do
It is your responsibility to perform the required
maintenance and use the vehicle in accordance with
Kia’s written instructions. Warranty coverage will not be
denied solely because there is no record of maintenance.
However, failures caused by lack of required
maintenance are not covered by the warranty. To avoid
questions as to whether the vehicle maintenance has
been performed, Kia urges that you retain all receipts
and/or maintenance records indicating that service has
been performed on the vehicle and these documents
should be transferred to any subsequent owner of the
vehicle.
Service
MAINTENANCE SERVICE CAN BE PERFORMED
BY ANY QUALIFIED SERVICE OUTLET OR BY
THE OWNER. HOWEVER, EXCEPT IN AN
EMERGENCY SITUATION (SEE EMERGENCY
SERVICE), WARRANTY SERVICE MUST BE
PERFORMED BY AN AUTHORIZED KIA DEALER.
Parts
IT IS RECOMMENDED THAT ANY REPLACEMENT
PA R TS USED FOR MAINTENANCE OR FOR THE
REPAIR OF EMISSIONS CONTROL SYSTEMS BE
NEW, KIA GENUINE PARTS. However, the warranty
obligations are not dependent upon the use of any
particular brand of replacement parts. The owner may
elect to use non-Kia parts for maintenance purposes. Use
of replacement parts which are not of equivalent quality
may impair the effectiveness of emissions control
systems.
What Is Not Covered By Emission Warranty
Malfunctions in any part caused by misuse, alteration,
tampering, disconnection or improper or inadequate
maintenance.
Damage to catalytic converter due to use of leaded
gasoline.
Damage resulting from fire, accident, negligence, act of
God or other events beyond the control of Kia.
Maintenance replacement parts (such as spark plugs)
beyond the first scheduled replacement point.

29
California
Emission Control Warranty
California Emission Control Warranty
Air Induction System
Air Cleaner Assembly
Intake Manifold
* 7/70 Rio, Soul, Forte 1.8, Optima, Sportage, Sorento 2.4, K900 5.0, Cade\
nzaSurge Tank -Air Intake * 7/70 Sorento 3.3, Cadenza, Sedona, K900 3.8Turbo Charger
Fuel Metering System Engine Coolant Temperature Sensor (ECT)
Mass Air Flow Sensor (MAF)
Manifold Absolute Pressure Sensor (MAP)
Vehicle Speed Sensor (VSS)
Wheel Speed Sensor (WSS)
Fuel Injector
Fuel Delivery Line
Throttle Body (ETC Actuator)
*7/70 Forte 1.6Throttle Position Sensor (TPS)
Idle Speed Control System
Oxygen Sensor
Pulsation Damper
Engine Control Module (ECM)
* 8/80 All vehiclesHigh Pressure Pump * 7/70 Rio, Soul, Forte 1.6, 2.0, Optima 2.0, 2.4, Sportage, Sorento, C\
adenza, K900, SedonaHigh Pressure Sensor
Ignition System Generator
*7/70 Forte, Soul, Optima 2.0, 2.4, Sportage, Sorento, Rio, K900, Sedona\
Spark Plugs
Spark Plugs Cable Set
Ignition Coil
Camshaft Position Sensor (CMPS)
Crankshaft Position Sensor (CKPS) Valve Timing System
CVVT Assy
Oil Control Valve Assy
Oil Temperature Sensor
Evaporative Control System Vapor Storage Canister
Canister Close Valve (CCV)
Purge Control Solenoid Valve (PCSV)
Fuel Pump
Fuel Pump Module
Fuel Tank
*7/70 Rio, Soul, Forte, Optima, Sportage, Sorento, Cadenza, Sedona, K900\
Fuel Filler Cap
Fuel Tank Pressure Sensor (FTP)
ORVR(Vent) Valve
Rollover(Cut) Valve
Fuel Pump & Sender Assy
* 7/70 Sportage 2.0, K900 3.8Positive Crankcase Ventilation SystemPCV Valve and Hose
Catalyst and Exhaust System Exhaust Manifold
Exhaust Manifold Catalytic Assembly
* 8/80 All vehiclesExhaust Pipe (Manifold to Catalyst) * 7/70 Sorento 3.3, Cadenza, Sedona, K900 Catalytic Converter Assembly * 8/80 All vehiclesMiscellaneous Items Used In Above SystemsHose, Clamps,Gasket or Seals
Wires, Harnesses Connectors
All Sensor(Switches, Solenoid Valves, Battery) associated with the ECM\
Onboard Emission Diagnostic DeviceMalfunction Indicator Light and Bulb * 8/80 All vehiclesData Link Connector * 8/80 All vehiclesSpark Plugs shall be warranted for the emissions warranty period, or the\
first scheduled replacement time or mileage, whichever occurs first.
NOTE 1 : Specific emission parts covered up to 5 years or 60,000 miles, whichever\
occurs first, or up to the first required scheduled maintenance, whichever occurs first (See Owner's Manual for required scheduled maint\
enance.)
NOTE 2 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, wh\
ichever occurs first.
NOTE 3 : Parts designated by "7/70" are warranted for 7 years or 70,000 miles, wh\
ichever occurs first.
NOTE 4 : The above parts for a Forte & Forte Koup, Optima 2.4, Sportage SULEV veh\
icle, certified as a partial zero-emission vehicle(PZEV) only, are warranted for 15 years or 150,000 miles, whichever occurs first.

Scheduled Maintenance Record34
The service records on this and the following pages have
been designed to include the signature of your Authorized
Kia Dealer representative or other repair establishment
representative. This signed form is evidence of completion
of maintenance services and should be kept with the
receipts, repair orders and invoices in the glove box. All
records should be given to any subsequent owner of the Kia
Vehicle. Claims made during the warranty term will not
qualify under the warranty if resulting from lack of
maintenance rather than from defective material or
workmanship. Alternatively, for your convenience, you
have been provided with a vehicle maintenance Log booklet
for your use in recording your Kia vehicle’s maintenance.
Y ou may use either to organize and maintain your records.
Scheduled Maintenance Intervals
Refer to your Owner’s Manual for the specific conditions. Pre-Delivery Inspection
Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #1 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #2 Mileage:
R.O. Number: Date:
Authorized Signature:
Dealership:

35
Scheduled Maintenance Record
Service #3Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #4 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #5 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:Service #6 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #7 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #8 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:

Scheduled Maintenance Record36
Service #9Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #10 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #11 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:Service #12 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #13 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership:
Service #14 Mileage:
R.O. Number:
Date:
Authorized Signature:
Dealership: