cooling Lancia Thema 2012 Owner handbook (in English)

When adding engine coolant (anti-
freeze):
Use only high purity water such as
distilled or deionized water when
mixing the water/engine coolant (an-
tifreeze) solution. The use of lower
quality water will reduce the amount
of corrosion protection in the engine
cooling system.
Please note that it is theowner's re-
sponsibility to maintain the proper
level of protection against freezing ac-
cording to the temperatures occurring
in the area where the vehicle is oper-
ated.
NOTE:
Mixing engine coolant (antifreeze)
types will decrease the life of the
engine coolant (antifreeze) and
will require more frequent engine
coolant (antifreeze) changes.
Cooling System Pressure Cap
The cap must be fully tightened to
prevent loss of engine coolant (anti-
freeze), and to ensure that engine
coolant (antifreeze) will return to the
radiator from the coolant recovery
bottle. The cap should be inspected and
cleaned if there is any accumulation
of foreign material on the sealing sur-
faces.
WARNING!
 The warning words “DO NOT
OPEN HOT” on the cooling sys-
tem pressure cap are a safety pre-
caution. Never add engine coolant
(antifreeze) when the engine is
overheated. Do not loosen or re-
move the cap to cool an over-
heated engine. Heat causes pres-
sure to build up in the cooling
system. To prevent scalding or in-
jury, do not remove the pressure
cap while the system is hot or un-
der pressure.
 Do not use a pressure cap other
than the one specified for your
vehicle. Personal injury or engine
damage may result.
Disposal Of Used Coolant
Used ethylene glycol-based engine
coolant (antifreeze) is a regulated
substance requiring proper disposal.
Check with your local authorities to
determine the disposal rules for your community. To prevent ingestion by
animals or children, do not store eth-
ylene glycol-based engine coolant
(antifreeze) in open containers or al-
low it to remain in puddles on the
ground. If ingested by a child or pet,
seek emergency assistance immedi-
ately. Clean up any ground spills im-
mediately.
Coolant Level
The coolant bottle provides a quick
visual method for determining that
the coolant level is adequate. With the
engine OFF and cold, the level of the
coolant in the bottle should be be-
tween the ranges indicated on the
bottle.
The radiator normally remains com-
pletely full, so there is no need to
remove the radiator cap unless check-
ing for engine coolant (antifreeze)
freeze point or replacing engine cool-
ant (antifreeze). Advise your service
attendant of this. As long as the en-
gine operating temperature is satis-
factory, the coolant bottle need only
be checked once a month.
267

When additional engine coolant (an-
tifreeze) is needed to maintain the
proper level, it should be added to the
coolant bottle. Do not overfill.
Points To Remember
NOTE:
When the vehicle is stopped after a
few kilometers of operation, you
may observe vapor coming from
the front of the engine compart-
ment. This is normally a result of
moisture from rain, or high hu-
midity accumulating on the radia-
tor and being vaporized when the
thermostat opens, allowing hot en-
gine coolant (antifreeze) to enter
the radiator.
If an examination of your engine com-
partment shows no evidence of radia-
tor or hose leaks, the vehicle may be
safely driven. The vapor will soon dis-
sipate.
 Do not overfill the coolant recoverybottle.
 Check engine coolant (antifreeze) freeze point in the radiator and in
the coolant recovery bottle. If en-
gine coolant (antifreeze) needs to be added, contents of coolant re-
covery bottle must also be pro-
tected against freezing.
 If frequent engine coolant (anti- freeze) additions are required, or if
the level in the coolant recovery
bottle does not drop when the en-
gine cools, the cooling system
should be pressure tested for leaks.
 Maintain engine coolant (anti- freeze) concentration at 50% en-
gine coolant (antifreeze) (mini-
mum) and distilled water for
proper corrosion protection of your
engine, which contains aluminum
components.
 Make sure that the radiator and coolant recovery bottle overflow
hoses are not kinked or obstructed.
 Keep the front of the radiator clean. If your vehicle is equipped with air
conditioning, keep the front of the
condenser clean.
 Do not change the thermostat for Summer or Winter operation. If re-
placement is ever necessary, install
ONLY the correct type thermostat.
Other designs may result in unsat- isfactory engine coolant (anti-
freeze) performance, poor gas mile-
age, and increased emissions.
BRAKE SYSTEM
In order to assure brake system per-
formance, all brake system compo-
nents should be inspected periodi-
cally. Refer to the “Maintenance
Schedule” for the proper maintenance
intervals.
WARNING!
Riding the brakes can lead to brake
failure and possibly an accident.
Driving with your foot resting or rid-
ing on the brake pedal can result in
abnormally high brake tempera-
tures, excessive lining wear, and pos-
sible brake damage. You would not
have your full braking capacity in an
emergency.
268

LICENSE LAMP
1. Remove the screws securing the
lamp to the rear fascia.
2. Remove the bulb and socket as-
sembly.
3. Disconnect the bulb from the
socket assembly and install the re-
placement bulb.4. Reinstall the bulb and socket as-
sembly.5. Reattach the lamp to the rear fas-
cia, and then install the screws.
FLUID CAPACITIES
Metric
Fuel (Approximate)
All Engines 72 Liters
Engine Oil with Filter
3.6 Liter Engine 5.6 Liters
3.0L Diesel Engine 9.2 Liters
Cooling System *
3.6 Liter Engine 9.5 Liters
3.0L Diesel Engine 12 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
1 — License Lamp Bulb
2 — Socket
283

Break-In Recommendations,
New Vehicle . . . . . . . . . . . . . . 50
Brightness, Interior Lights . . . 109
Bulb Replacement . . . . . . 280,281
Bulbs, Light . . . . . . . . . . . 53,280
Camera, Rear . . . . . . . . . . . . 134
Capacities, Fluid . . . . . . . . . . 283
Caps, FillerRadiator
(Coolant Pressure) . . . . . . . 267
Car Washes . . . . . . . . . . . . . . 271
Carbon Monoxide Warning . . . . 51
Cargo (Vehicle Loading) . . . . . 227
Cellular Phone . . . . . . . . . . . . 180
Certification Label . . . . . . . . . 227
Chains, Tire . . . . . . . . . . . . . 218
Check Engine Light(Malfunction Indicator Light)
. . 156
Checking Your Vehicle For
Safety . . . . . . . . . . . . . . . . . . . 50
Checks, Safety . . . . . . . . . . . . . 50
Child Restraint . . . . . 42,45,47,49
Child Restraint Tether
Anchors . . . . . . . . . . . . . . . 46,47
Child Safety Locks . . . . . . . . . . 20
Child Seat . . . . . . . . . . . . . . . . 43
Clean Air Gasoline . . . . . . . . . 224 Cleaning
Wheels . . . . . . . . . . . . . . . 272
Windshield Wiper Blades . . . 263
Climate Control . . . . . . . . . . . 180
Clock . . . . . . . . . . . . . . . . . . 178
Coin Holder . . . . . . . . . . . . . 143
Cold Weather Operation . . . . . 192
Compact Disc (CD)
Maintenance . . . . . . . . . . . . . 179
Compact Spare Tire . . . . . . . . 216
Computer, Trip/Travel . . . . . . 166
Connector UCI . . . . . . . . . . . . . . . . . . 178
Universal Consumer
Interface (UCI) . . . . . . . . . . 178
Conserving Fuel . . . . . . . . . . . 165
Console, Floor . . . . . . . . . . . . 143
Console, Overhead . . . . . . . . . 135
Coolant Pressure Cap
(Radiator Cap) . . . . . . . . . . . 267
Cooling System . . . . . . . . . . . 265 Adding Coolant
(Antifreeze) . . . . . . . . . . . . 266
Coolant Capacity . . . . . . . . 283
Coolant Level . . . . . . . 265,267
Disposal of Used Coolant . . . 267
Drain, Flush, and Refill . . . . 266
Inspection . . . . . . . . . . . . . 267
Points to Remember . . . . . . 268 Pressure Cap . . . . . . . . . . . 267
Radiator Cap . . . . . . . . . . . 267
Selection of Coolant
(Antifreeze) . . . . . 266,283,284
Corrosion Protection . . . . . . . 271
Cruise Control
(Speed Control) . . . . . . . . . . . 117
Cupholders . . . . . . . . . . . 142,274
Data Recorder, Event . . . . . . . . 41
Daytime Brightness, Interior
Lights . . . . . . . . . . . . . . . . . . 109
Deck Lid, Emergency Release . . 25
Deck Lid, Power Release . . . . . 24
Defroster, Rear Window . . . . . 145
Defroster, Windshield . . . . 52,183
Delay (Intermittent) Wipers . . 110
Diagnostic System, Onboard . . 257
Diesel Fuel . . . . . . . . . . . . . . 225
Dimmer Switch, Headlight . . . 107
Dipsticks Oil (Engine) . . . . . . . . . . . . 258
Disposal
Antifreeze (Engine Coolant)
. . 267
Engine Oil . . . . . . . . . . . . . 259
Door Locks . . . . . . . . . . . . . . . 18
Door Locks, Automatic . . . . . . 19
Driving On Slippery Surfaces . . . . . 204
299

Through Flowing, Rising, or
Shallow Standing Water . . . 204
Driving to Achieve Maximum
Fuel Economy . . . . . . . . . . . . 165
Electric Rear Window
Defrost . . . . . . . . . . . . . . . . . 145
Electric Remote Mirrors . . . . . . 64
Electrical Power Outlets . . . . . 140
Electronic Brake Control
System . . . . . . . . . . . . . . . . . 209
Anti-Lock Brake System . . . 209
Brake Assist System . . . . . . 209
Traction Control System . . . 209
Electronic Power Distribution
Center (Fuses) . . . . . . . . . . . . 274
Electronic Speed Control
(Cruise Control) . . . . . . . 115,117
Electronic Stability Control
(ESC) . . . . . . . . . . . . . . . . . . 210
Electronic Vehicle Information
Center (EVIC) . . . . . . . . 134,159
Emergency Deck Lid Release . . 25
Emergency Trunk Release . . . . 25
Emergency, In Case of Freeing Vehicle When
Stuck . . . . . . . . . . . . . . . . 248
Hazard Warning Flasher . . . 240
Jump Starting . . . . . . . . . . 246 Overheating . . . . . . . . . . . . 240
Towing . . . . . . . . . . . . . . . 251
Engine Air Cleaner . . . . . . . . . . . . 259
Break-In Recommendations . . 50
Compartment . . . . . . . 255,256
Compartment
Identification . . . . . . . . 255,256
Coolant (Antifreeze) . . . 265,284
Cooling . . . . . . . . . . . . . . . 265
Exhaust Gas Caution . . . . . . 51
Fails to Start . . . . . . . . . . . 192
Flooded, Starting . . . . . . . . 192
Fuel Requirements . . . . . . . 223
Jump Starting . . . . . . . . . . 246
Oil . . . . . . . . . . . . 258,283,284
Oil Change Interval . . . 164,258
Oil Disposal . . . . . . . . . . . . 259
Oil Filter . . . . . . . . . . . . . . 259
Oil Selection . . . . . 258,259,283
Oil Synthetic . . . . . . . . . . . 259
Overheating . . . . . . . . . . . . 240
Starting . . . . . . . . . . . . . . . 191
Temperature Gauge . . . . . . 159
Enhanced Accident Response
Feature . . . . . . . . . . . . . . . . . . 39
Entry System, Illuminated . . . . 16
Ethanol . . . . . . . . . . . . . . . . 224
Event Data Recorder . . . . . . . . 41 Exhaust Gas Caution . . . . . 51,264
Exhaust System . . . . . . . . 51,264
Exterior Folding Mirrors . . . . . . 63
Exterior Lighting . . . . . . . . . . 104
Exterior Lights . . . . . . . . . . . . 53
Filler Location Fuel . . . . . . . . 156
Filters
Air Cleaner . . . . . . . . . . . . 259
Air Conditioning . . . . . 185,261
Engine Oil . . . . . . . . . . 259,284
Flash-To-Pass . . . . . . . . . . . . 108
Flashers Hazard Warning . . . . . . . . . 240
Turn Signal . . . . . . . 53,107,154
Flooded Engine Starting . . . . . 192
Floor Console . . . . . . . . . . . . 143
Fluid Capacities . . . . . . . . . . . 283
Fluid Leaks . . . . . . . . . . . . . . 53
Fluid Level Checks Automatic Transmission . . . 270
Brake . . . . . . . . . . . . . . . . 269
Cooling System . . . . . . . . . 265
Engine Oil . . . . . . . . . . . . . 258
Fluid, Brake . . . . . . . . . . . . . 285
Fluids . . . . . . . . . . . . . . . . . . 284
Fluids, Lubricants and
Genuine Parts . . . . . . . . . . . . 284
Fog Lights . . . . . . . . . . . . . . 154
300

Tongue Weight/Trailer
Weight . . . . . . . . . . . . . . . . . 231
Towing . . . . . . . . . . . . . . . . . 228Behind a Motorhome . . . . . . 237
Disabled Vehicle . . . . . . . . . 251
Guide . . . . . . . . . . . . . . . . 231
Recreational . . . . . . . . . . . . 237
Weight . . . . . . . . . . . . . . . 231
Towing Eyes . . . . . . . . . . . . . 249
Towing Vehicle Behind a
Motorhome . . . . . . . . . . . . . . 237
Traction Control . . . . . . . . . . 209
Trailer Towing . . . . . . . . . . . . 228 Cooling System Tips . . . . . . 236
Hitches . . . . . . . . . . . . . . . 236
Minimum Requirements . . . 232
Tips . . . . . . . . . . . . . . . . . 235
Trailer and Tongue
Weight . . . . . . . . . . . . . . . 231
Wiring . . . . . . . . . . . . . . . . 233
Trailer Towing Guide . . . . . . . 231
Trailer Weight . . . . . . . . . . . . 231
Transfer Case
Fluid . . . . . . . . . . . . . . . . . 285
Transmission . . . . . . . . . . . . . 270 Automatic . . . . . . . 196,199,270
Fluid . . . . . . . . . . . . . . . . . 285
Shifting . . . . . . . . . . . . . . . 195 Transmitter Battery Service
(Remote Keyless Entry) . . . . . . 17
Transmitter Programming
(Remote Keyless Entry) . . . . . . 16
Transmitter, Remote Keyless
Entry (RKE) . . . . . . . . . . . . . . 16
Transporting Pets . . . . . . . . . . 50
Tread Wear Indicators . . . . . . 217
Trip Odometer . . . . . . . . . . . . 154
Trunk Lid (Deck Lid) . . . . . 24,25
Trunk Release Remote
Control . . . . . . . . . . . . . . . . . . 24
Trunk Release, Emergency . . . . 25
Turn Signals . . . . . . . . . . 107,154
UCI Connector . . . . . . . . . . . 178
Universal Child Seat Position
Chart . . . . . . . . . . . . . . . . . . . 43
Universal Consumer Interface
(UCI) Connector . . . . . . . . . . 178
Untwisting Procedure, Seat
Belt . . . . . . . . . . . . . . . . . . . . 29
Vanity Mirrors . . . . . . . . . . . . . 65
Vehicle Certification Label . . . 227
Vehicle Identification Number
(VIN) . . . . . . . . . . . . . . . . . . . . 7
Vehicle Loading . . . . . . . 227,228 Vehicle Modifications/
Alterations . . . . . . . . . . . . . . . . 7
Vehicle Storage . . . . . . . . 185,279
Wait to Start Light . . . . . . . . . 162
Warning Flasher, Hazard . . . . 240
Warning Lights (Instrument
Cluster Description) . . . . . . . . 154
Warnings and Cautions . . . . . . . 7
Washer
Adding Fluid . . . . . . . . . . . 263
Washers, Headlight . . . . . . . . 112
Washers, Windshield . . . . 111,263
Washing Vehicle . . . . . . . . . . 271
Water Driving Through . . . . . . . . 204
Wheel and Wheel Trim . . . . . . 272
Wheel and Wheel Trim Care . . 272
Wind Buffeting . . . . . . 24,137,139
Window Fogging . . . . . . . . . . 185
Windows . . . . . . . . . . . . . . . . . 22 Power . . . . . . . . . . . . . . . . . 22
Windshield Defroster . . . . . . . . 52
Windshield Washers . . . . . 110,111
Windshield Wiper Blades . . . . 263
Windshield Wipers . . . . . . . . . 110
Wiper Blade Replacement . . . . 263
Wipers, Intermittent . . . . . . . . 110
Wipers, Rain Sensitive . . . . . . 111
306