Headlight Lancia Thesis 2007 Owner handbook (in English)

318
1) Engine oil
2) Brake fluid
3) Windscreen/rear window and
headlight washer fluid
4) Engine coolant
5) Power steering fluid
L0A0345b
L0A0341b
fig. 3 - 2.4 JTD version
fig. 4 - 2.4 JTD
20V- 2.4 JTD 20VCAE versions

319
1) Engine oil
2) Brake fluid
3) Windscreen/rear window and
headlight washer fluid
4) Engine coolant
5) Power steering fluid
L0A0342b
L0A0358b
fig. 5 - 3.0 V6 CAE version
fig. 6 - 3.2 V6 CAE version

324
WINDSCREEN/REAR
WINDOW/HEADLIGHT
WASHER FLUID (fig. 17)
To top up, remove cap Aand filler
B.
Pour in a mixture of water and
TUTELA PROFESSIONAL SC 35
fluid in the following concentrations:
– 30% of the above specified fluid
and 70% water in summer
– 50% of the above specified fluid
and 50% water in winter
– if the temperature falls below –20
°C use TUTELA PROFESSIONAL
SC 35undiluted.Certain commercial
additives for windscreen
washers are inflammable.
The engine compartment con-
tains hot components which may
set it on fire.
Do not travel with the
windscreen washer reser-
voir empty. The wind-
screen washer is fundamental for
improving visibility.
fig. 17
L0A0295b
To prevent damages to
the pump motor, do not
use the windscreen/rear
window/headlight washers when
the reservoir is empty.
The symbol πon the
container indicates syn-
thetic brake fluid, distin-
guishing it from the mineral kind.
Using mineral fluids irreversibly
damages the special braking sys-
tem rubber seals.
Brake fluid is poisonous
and highly corrosive. In
the event of accidental
contact, wash the parts involved
immediately with neutral soap and
water, then rinse thoroughly. Call
the doctor immediately if the fluid
is swallowed.

335
HEADLIGHT
WASHERS
Regularly check that the nozzles
(fig. 22) are intact and clean.
The headlight washers are auto-
matically switched on when the
windscreen washer is operated and
the headlights are on.
CLIMATE
CONTROL SYSTEM
During the winter, the climate con-
trol system must be turned on at
least once a month for about ten
minutes.
Before summer, have the system
checked at a Lancia Dealership.INITIALISING THE AIR
CONDITIONING CONTROL UNIT
Whenever the battery is electrically
connected again or it is reloaded after
being completely flat or after replac-
ing one of the protection fuses, to re-
store the correct operation of the air
conditioning, of the door locking and
of the ESP system. It is necessary to
perform the initialisation operations
contained in the paragraph “If battery
is to be disconnected” in the chapter
“In an emergency”.
fig. 22
L0A0122b
The system is filled with
R134a refrigerant which
will not pollute the envi-
ronment in the event of leakage.
Under no circumstances should
R12 fluid be used as it is incom-
patible with the system compo-
nents and contains CFC.

338
Outside plastic parts must be
cleaned following the usual car
washing procedure.
Where possible avoid parking the
car under trees; the resinous sub-
stance that certain species of tree
shed dull the paintwork and increase
the possibility of rust forming.
IMPORTANTBird droppings
must be washed off immediately and
with great care as their acid is par-
ticularly aggressive.
Windows
Use specific window cleaners to
clean the windows. Use very clean
cloths to avoid scratching the glass
or damaging the transparency.
IMPORTANTTo prevent damage
to the electric heater element, wipe
the inside of the heated rear window
gently in the same direction as the
elements. To wash the car properly:
1) Remove the aerial from the roof
to prevent damaging it when wash-
ing the car in an automatic carwash.
2) Wash the body using a low pres-
sure jet of water.
3) Wipe a sponge with a light neu-
tral PH detergent solution over the
bodywork, frequently rinsing the
sponge.
4) Rinse well with water and dry
with a jet of air or a chamois leather.
When drying the car, be careful to
get at those parts which are not so
easily seen e.g. the door frames, bon-
net and around the headlights where
water can most readily collect.
You should leave the car out in the
open so that any water remaining
can evaporate more easily.
Do not wash the car after it has
been parked in the sun or while the
bonnet is hot: it could take the shine
off the paint. Cleaning chromium
plated/anodized bodywork parts
To clean body parts such as mold-
ings, cappings, etc., use neutral pH
detergents. Avoid generic cleaning
products.
These parts shall be rinsed well with
water and then dried with a jet of air
or a chamois leather.
For further treatment use special
polish for chromium plated/anodized
parts.
Suitable car cleaning products are
available at Lancia Dealerships.

CAPACITIES
Prescribed fuels
Recommended product
Unleaded petrol with a RON
not lower than 95
Diesel fuel for motor
vehicles (Specification EN590)
50-50 mixture of distilled water
and PARAFLU UP
SELENIA RACING
SELENIA WR
TUTELA CAR
TECHNYX
TUTELA CAR GI/V
TUTELA CAR GI/E
TUTELA TOP 4
Mixture of water and TUTELA
PROFESSIONAL SC 35
362
2.4
75
10
–
–
8.6
5.50
–
1.70
–
1.05
approx 1.5
4.5 2.0 TB
75
10
–
–
8.6
5.50
–
1.70
–
1.05
approx 1.5
4.52.4 CAE
75
10
–
–
8.6
5.50
–
–
7.25
1.05
approx 1.5
4.5
Fuel tank: litres– including a reserve of litres
Fuel tank: litres
– including a reserve of litres
Engine cooling system litres
Engine oil (amount for periodical change – sump and filter) litres
Engine oil (amount for periodical
change – sump and filter) litres
Manual gearbox/differential kg
Electronic automatic gearbox litres
Hydraulic power steering litres
Hydraulic brake circuit
with ABS litres
Windscreen headlight washer
reservoir litres

3.2 V6
CAE
75
10
–
–
12.2
5.90
–
–
1.05
approx 1.5
4.5
363
Prescribed fuels
Recommended product
Unleaded petrol with a RON
not lower than 95
Diesel fuel for motor vehicles
(Specification EN590)
50-50 mixture of
distilled water and PARAFLU UP
SELENIA RACING
SELENIA WR
TUTELA CAR GI/V
TUTELA CAR GI/E
TUTELA TOP 4
Mixture of water and TUTELA
PROFESSIONAL SC 35 2.4 JTD
20VCAE
–
–
75
10
8.6
–
5.0
–
1.05
approx 1.5
4.5
Fuel tank: litres
– including a reserve of litres
Fuel tank: litres
– including a reserve of litres
Engine cooling system litres
Engine oil (amount for periodical
change – sump and filter) litres
Engine oil (amount for periodical
change – sump and filter) litres
Electronic automatic gearbox litres
Hydraulic power steering litres
Hydraulic brake circuit
with ABS litres
Windscreen headlight washer
reservoir litres

365
Use
(*) IMPORTANT Do not top up or mix with fluids having characteristics different from those specified.Applications
Mechanical gearbox and
differential petrol version
Mechanical gearbox and
differentials, diesel versions
Power steering
5-speed automatic
transmission
CV joints on wheel side
CV joints on differential side
Brake and clutch hydraulic
control
Cooling circuits
Proportion:
50% water and
50% Paraflu UP
To be used diluted
or undiluted Original fluids
and lubricants
TUTELA CAR
TECHNYX
TUTELA CAR
MATRYX
TUTELA GI/E
TUTELA GI/V
TUTELA STAR 500
TUTELA
MRM ZERO
TUTELA TOP 4
PARAFLU UP (*)
TUTELA
PROFESSIONAL
SC 35 Fluid and lubricant specifications
for correct car operation
Synthetic-based oil, grade SAE 75W-85 that passes
API GL 4 specifications Plus, Fiat 9.55550.
Synthetic-based oil, grade SAE 75W-85, that pass
API GL4 specifications.
"ATF DEXRON III" oil..
Special lubricant for 5-speed transmissions with
controlled slip torque converters
Lithium-soap-based grease with molybdenum
bisulphate. Consistency NLGI 2
Lithium soap based grease. NLGI 0 consistency
Synthetic fluid FMVSS no. 116, DOT 4, ISO 4925,
SAE J-1704 CUNA NC 956-01
Protective with antifreeze action, red colour based on
inhibited monoethylen glycol and organic formula, that
passes CUNA NC 956-16, ASTM D 3306 specifications
Mixture of alcohol, water and surfactants
CUNA NC 956-11 Brake fluid Transmission
and hydraulic
power steering
lubricants and
greases
Protective agent
for radiators
Windscreen/
headlight washer
fluid

372
Dead lock device (doors) ......... 56
Delayed light switching off
(Follow me home) ............... 99
Diesel filter
- draining the condense ....... 325
Dimensions ............................. 359
Dipped beam headlights
- control .............................. 97
Direction indicators
- control .............................. 100
- side bulb replacement ....... 285
Door lights
- bulb replacement .............. 291
- puddle lights ..................... 213
Doors ..................................... 54
- Autoclose function ............. 50
- automatic door locking ..... 58
- child lock safety device ..... 58
- dead lock device ............... 56
- disabling rear door locking/
unlocking controls ............ 58
- door open indication ......... 57- door pockets ..................... 218
- initialising the control
units of the door locks,
air conditioner and ESP
system................................ 303
- lock release in case
of accident ......................... 59
- opening/closing
from the inside ................. 57
- opening/closing
from the outside................. 54
Drink compartment
(climate-controlled) ............. 217
Driving your car................... 250
Easy Entry/Exit (system) ..... 43
EBD (electronic brakeforce
distributor)........................... 245
E.G.R. (exhaust gas
recirculation system) ........... 7
Electric parking brake(EPB) .. 175- emergency
disengagement .................. 178
Electric sunshade ................... 220
Electric windows .................... 73
- anti-trap safety system ..... 73
- centralised window and
sunroof opening/closing
system................................ 75
- controls ............................. 74
- manual and automatic
operation .......................... 75
Electronic alarm ..................... 39
- anti-lifting sensor............... 41
- deactivating the alarm ...... 42
- functions that can be
deactivated or modified .... 42
- indications of attempts
to break in ......................... 42
- ministerial homologation ... 43
- switching the alarm off ...... 41
- switching the alarm on ..... 40
- volumetric protection ........ 41

373
- what triggers the alarm
off ..................................... 42
Electronic automatic gearbox
(COMFORTRONIC) ............. 180
- automatic operation ........... 182
- bump starting .................... 188
- failure indication ............... 187
- gearbox display.................. 110
- manual sequential
operation ........................... 186
- moving off ......................... 180
- selecting the automatic/
manual sequential
operation ........................... 182
- sound signal ..................... 188
- starting the engine ............ 180
- stopping ............................. 181
- technical specifications ..... 348
- towing the car ................... 189
Electronic brakeforce
distributor (EBD) .................... 245
Electronic control units
(important) ......................... 330Engine
- identification code ............ 341
- marking ............................ 341
- technical specifications ..... 344
Engine compartment
(cleaning) ............................ 339
Engine coolant ........................ 321
Engine coolant temperature
gauge .................................. 108
Engine oil
- checking level ................... 320
- specifications ..................... 364
Engine oil consumption .......... 321
Engine oil level ....................... 320
Engine warming up ................ 252
Environment
(safety and protection) ......... 4-5
EOBD system ......................... 244
EPB (electric parking brake) .. 175
- emergency disengagement.. 178
ESP system ............................ 189
- ASR function .................... 191- ESP system action ............. 192
- failure indication .............. 192
- initialising the control units
of the door locks, air
conditioner and ESP
system................................ 303
- MSR system ....................... 192
- operation .......................... 190
Exhaust gas
(recirculation system) .......... 7
External lights (controls) ........ 97
Flash consumption
gauge .................................. 109
Flashing the headlights
(main beam) ....................... 100
Fluids and lubricants .............. 364
Follow me home
(delayed light switching off) 99
Front ceiling light ................... 212
- bulb replacement .............. 287