tires LAND ROVER FRELANDER 2 2006 Owners Manual

Publi s hed: 11-May-2011
Evaporative Emissions - Evaporative Emission Canister
Removal and Inst all ati on
Removal
• NOTE: Removal s t eps in t his procedure may cont ain i nst all ati on det ail s.
Di sconnect t he bat t ery ground cable.
Refer t o: Specificati ons (414-00 Bat tery and Charging Sys tem -General Informat ion, Specificati ons).
1.
2. W ARNING: Do not work on or under a vehi cle s upported onl yby a jack. Al ways support t he vehi cl e on s afet y s tands .
Rais e and s upport t he vehi cl e.
2.
Remove t he rear wheel.
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal andInst all at ion).
3.
4.

Publi s hed: 11-May-2011
Evaporative Emissions - Fuel Tank Leakage Monitoring Pump Filter
Removal and Inst all ati on
Removal
• NOTE: Removal s t eps in t his procedure may cont ain i nst all ati on det ail s.
Di sconnect t he bat t ery ground cable.
Refer t o: Specificati ons (414-00 Bat tery and Charging Sys tem -
General Informat ion, Specificati ons).
1.
2. W ARNING: Do not work on or under a vehi cle s upported onl y
by a jack. Al ways support t he vehi cl e on s afet y s tands .
Rais e and s upport t he vehi cl e.
2.
Remove t he rear wheel.
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal and
Inst all at ion).
3. 4.

Publ is hed: 12-Dec-2011
Evaporative Emissions - Fuel Tank Leakage Monitoring Pump
Removal and Inst all ati on
Removal
• NOTE: Removal s t eps in t his procedure may cont ain i nst all ati on det ail s.
Di sconnect t he bat t ery ground cable.
Refer t o: Specificati ons (414-00 Bat tery and Charging Sys tem -General Informat ion, Specificati ons).
1.
2. W ARNING: Do not work on or under a vehi cle s upported onl yby a jack. Al ways support t he vehi cl e on s afet y s tands .
Rais e and s upport t he vehi cl e.
2.
Remove t he rear wheel.
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal andInst all at ion).
3.
4. NOTE: Right-hand s hown, l eft-hand s imi lar.4.

Publi s hed: 11-May-2011
Electronic Engine Controls - TD4 2.2L Diesel - Crankshaft Position (CKP)
Sensor
Removal and Inst all ati on
Removal
• NOTE: Removal s t eps in t his procedure may cont ain i nst all ati on det ail s.
1. W ARNING: Make sure t o s upport the vehicle wit h axle
s tands .
Rais e and s upport t he vehi cl e.
1.
Remove t he front wheel .
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal and
Inst all at ion).
2. 3.
4. CAUTION: Make s ure that the wiring harnes s es
are correctl y located.
T orque: 8 Nm 4.
Installation To i nst all , revers e t he removal procedure.
1.

Remove t he engi ne mount bracket .
10. Releas e and dis connect the sel ect or l ever cable.
11.
Drai n t he t ransmis s ion fluid.
Refer t o: Transmis s ion Flui d Drai n and Refi ll - TD4 2.2L Dies el (307-01 Automat ic Trans mi s si on/Trans axl e, General Procedures ).
12.
Remove t he front wheel s and ti res .
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal and
Inst all at ion).
13. Remove t he towi ng eye cover.
14.
Remove t he 2 bolt s s ecuring bumper cover.
15.

19. W ARNING: Make sure t hat new nut s are
i ns t alled.
Connect t he ti e-rod end ball joi nts .
T orque: 80 Nm 19.
20. W ARNING: Make sure t hat new nut s are
i ns t alled. CAUTION: Make s ure that t he bal l joi nt bal l does
not rot ate.
Connect both front s t abi li zer bar li nks to the s t abi li zer
bar.
T orque: 55 Nm 20.
21.
NOTE: RH i llus t rati on s hown, LH is s imil ar.
Inst all t he LH fender s pl ash s hi eld ext ens ion panel.
21.
Inst all t he front wheel s and ti res .
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal and
Inst all at ion).
22. Inst all t he towi ng eye cover.
T orque: Bumper cover securi ng bol ts 10 Nm 23.
Secure and connect the sel ect or lever cable.
24.

12.
13.
Drai n t he t ransmis s ion fluid.
Refer t o: Transmis s ion Draining and Fi lli ng (308-03 Manual
Trans mi ss ion/Transaxle, General Procedures).
14.
Remove t he front wheel s and ti res .
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal and
Inst all at ion).
15. Us ing t he s peci al t ool, rel ease the LH and RH t ie-rod
end ball joi nts .
Speci al Tool (s ): 211-316 16.

12.
13.
Drai n t he t ransmis s ion fluid.
Refer t o: Transmis s ion Draining and Fi lli ng (308-03 Manual
Trans mi ss ion/Transaxle, General Procedures).
14.
Remove t he front wheel s and ti res .
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal and
Inst all at ion).
15. Us ing t he s peci al t ool, rel ease the LH and RH t ie-rod
end ball joi nts .
Speci al Tool (s ): 211-316 16.

19. W ARNING: Make sure t hat new nut s are
i ns t alled. CAUTION: Make s ure that t he bal l joi nt bal l does
not rot ate.
Connect both front s t abi li zer bar li nks to the s t abi li zer
bar.
T orque: 55 Nm 19.
20.
NOTE: RH i llus t rati on s hown, LH is s imil ar.
Inst all both the fender s plas h s hield ext ensi on panel s.
20.
Inst all t he front wheel s and ti res .
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal and
Inst all at ion).
21. Inst all t he 2 bolt s s ecuring t he t ransmis s ion mount ing
t o t he body mount ing.
T orque: 175 Nm 22.
Remove t he engi ne s upport .
23. Inst all t he s tart er mot or.
Refer t o: Start er Motor (303-06B Starti ng Sys t em - TD4
2.2L Dies el , Removal and Inst all at ion).
24.
Inst all t he gear s elector as s embl y.
Refer t o: Gears hi ft Li nkage (308-06 Manual Trans mi s si on/Trans axl e
External Controls , Removal and Inst all at ion).
25.

Publi s hed: 11-May-2011
Fuel Tank and Lines - I6 3.2L Petrol - Fuel Tank Filler Pipe
Removal and Inst all ati on
Removal
• NOTE: Removal s t eps in t his procedure may cont ain i nst all ati on det ail s.
1. W ARNING: Do not work on or under a vehi cle s upported onl yby a jack. Al ways support t he vehi cl e on s afet y s tands .
Rais e and s upport t he vehi cl e.
1.
Remove t he rear wheel.
Refer t o: W heel and Ti re (204-04 W heel s and Tires, Removal andInst all at ion).
2.
3.
4.
5.