engine coolant Lexus ES350 2010 Scheduled Maintenance Guide

Introduction
GENERAL MAINTENANCE AND REGULAR USE
MAINTENANCE
44
In addition to scheduled maintenance,
your Lexus requires ongoing general
maintenance such as fluid checks and
visual inspections. The recommended
guidelines for inspections are listed
below. Please refer to the “Mainte
nance” section of the Owner’s Manual
for a detailed description of inspec
tion procedures.
When Refueling
When refueling, perform these
inspections:
•Check engine oil level using
the dipstick
• Visually check engine coolant
level on the seethrough
reservoir (under cover)
• Visually check brake fluid level
on the seethrough reservoir
• Visually check power steering
fluid level on the seethrough
reservoir (under cover)
• Visually check condition of
battery (under cover)
• Check level of windshield
washer fluid
Every 30 Days
At least once every 30 days, perform
these inspections:
•Check tire pressure
• Check tires for damage
and wear
When Cleaning the Interior
•Remove dirt and dust with a
vacuum cleaner. Wipe dirty sur
faces with a soft cloth dampened
with warm water.
• When cleaning carpet or cloth
interior, remove dirt and dust
with a vacuum cleaner. Apply
a foamingtype carpet cleaner
with a sponge or brush, allowing
cleaner to work for a few min
utes to loosen dirt. Continue by
rubbing carpet or cloth interior
in a circular motion. Wipe off any
excess cleaner with a clean cloth.
If any dirt remains, repeat process.
Best results are obtained by
keeping carpet and cloth interior
as dry as possible.
• When cleaning leather interior,
remove dirt and dust with a
vacuum cleaner. Using a sponge,
apply a small amount of neutral
2010 Lexus Sedans_4147a 7/21/09 1:29 AM Page 44

SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log49
18 Months or 15,000 Miles
oReplace engine oil and oil filter; reset reminder light
o Rotate tires
2
oClean air conditioner filter (ES, GS, IS)
o Visually inspect brake pads, calipers and rotors
o Roadtest vehicle
o Inspect the following:
___Axle shaft boots
___Ball joints and dust covers
___Body
___Brake lines and hoses
___Engine coolant (see page 69)
___Exhaust pipes and mountings
Additional Maintenance Required If You Drive Primarily Under the Following Conditions
Driving on dirt roads or dusty roads:
o Inspect engine air filter
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
___Front differential oil (GS 350 AWD,
IS 250 AWD, LS 460 AWD)
___Rack and pinion assembly
___Rear differential oil (GS, IS, LS, SC)
___Steering linkage and boots
Date: ___________________________ Mileage: __________________________
Notes:
2010 Lexus Sedans_4880d 7/21/09 1:36 AM Page 49

SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log5 1
36 Months or 30,000 Miles
oReplace engine oil and oil filter; reset reminder light
o Rotate tires
1
oMeasure thickness and runout of brake rotors
o Measure thickness of brake pads (GS, IS, IS F, LS 460 with Sport Package)
o Replace air conditioner filter
o Replace brake fluid
o Replace engine air filter
o Replace Smart Key battery (all models except SC)
o Visually inspect brake pads, calipers and rotors
o Roadtest vehicle
o Inspect the following:
___Axle shaft boots
___Ball joints and dust covers
___Body
___Brake lines and hoses
___Engine coolant (see page 69)
___Exhaust pipes and mountings
___Front differential oil (GS 350 AWD, IS 250 AWD,
LS 460 AWD)
___Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses
Additional Maintenance Required If You Drive Primarily Under the Following Conditions
Driving on dirt roads or dusty roads:
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
___Fuel tank cap gasket
___Manual transmission oil (IS 250)
___Rack and pinion assembly
___Rear differential oil (GS, IS, LS, SC)
___Steering linkage and boots
___Transfer case for signs of leakage
(GS 350 AWD, IS 250 AWD,
LS 460 AWD)
___Transmission for signs of leakage
Date: _____________________________ Mileage: ____________________________
Notes:
2010 Lexus Sedans_4880d 7/21/09 1:44 AM Page 51

SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log53
54 Months or 45,000 Miles
oReplace engine oil and oil filter; reset reminder light
o Rotate tires
1
oClean air conditioner filter (ES, GS, IS)
o Visually inspect brake pads, calipers and rotors
o Roadtest vehicle
o Inspect the following:
___Axle shaft boots
___Ball joints and dust covers
___Body
___Brake lines and hoses
___Engine coolant (see page 69)
___Exhaust pipes and mountings
Additional Maintenance Required If You Drive Primarily Under the Following Conditions
Driving on dirt roads or dusty roads:
o Inspect engine air filter
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
___Front differential oil (GS 350 AWD,
IS 250 AWD, LS 460 AWD)
___Rack and pinion assembly
___Rear differential oil (GS, IS, LS, SC)
___Steering linkage and boots
Date: _____________________________ Mileage: ____________________________
Notes:
2010 Lexus Sedans_4880d 7/21/09 1:45 AM Page 53

SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log55
72 Months or 60,000 Miles
oReplace engine oil and oil filter; reset reminder light
o Rotate tires
1
oMeasure thickness and runout of brake rotors
o Measure thickness of brake pads (GS, IS, IS F, LS 460
with Sport Package)
o Replace air conditioner filter
o Replace brake fluid
o Replace engine air filter
o Inspect the following:
___Axle shaft boots
___Ball joints and dust covers
___Body
___Brake lines and hoses
___Drive belt
___Engine coolant (see page 69)
___Engine valve clearance (IS F, SC)
___Exhaust pipes and mountings
___Front differential oil (GS 350 AWD, IS 250 AWD,
LS 460 AWD)
___Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses
Additional Maintenance Required If You Drive Primarily Under the Following Conditions
Driving on dirt roads or dusty roads:
o Tighten nuts and bolts on chassis
Driving while towing:
o Replace transmission fluid (ES only; use type ATFWS or equivalent)
o Tighten nuts and bolts on chassis (ES)
___Fuel tank cap gasket
___Manual transmission oil (IS 250)
___Rack and pinion assembly
___Rear differential oil (GS, IS, LS, SC)
___Steering linkage and boots
___Transfer case for signs of leakage
(GS 350 AWD, IS 250 AWD,
LS 460 AWD)
___Transmission for signs of leakage
Date: _____________________________ Mileage: ____________________________
Notes:
2Required under the terms of the Emission Control Warranty.
o Replace rear differential oil (IS F)
o Replace Smart Key battery (all models
except SC)
o Replace spark plugs (GS, IS, IS F, LS)
2
oVisually inspect brake pads, calipers
and rotors
o Roadtest vehicle
2010 Lexus Sedans_4880d 7/21/09 1:47 AM Page 55

SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log57
90 Months or 75,000 Miles
oReplace engine oil and oil filter; reset reminder light
o Rotate tires
1
oClean air conditioner filter (ES, GS, IS)
o Visually inspect brake pads, calipers and rotors
o Roadtest vehicle
o Inspect the following:
___Axle shaft boots
___Ball joints and dust covers
___Body
___Brake lines and hoses
___Drive belt
___Engine coolant (see page 69)
Additional Maintenance Required If You Drive Primarily Under the Following Conditions
Driving on dirt roads or dusty roads:
o Inspect engine air filter
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
___Exhaust pipes and mountings
___Front differential oil (GS 350 AWD,
IS 250 AWD, LS 460 AWD)
___Rack and pinion assembly
___Rear differential oil (GS, IS, LS, SC)
___Steering linkage and boots
Date: _____________________________ Mileage: ____________________________
Notes:
2010 Lexus Sedans_4880d 7/21/09 1:48 AM Page 57

SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log59
108 Months or 90,000 Miles
oReplace engine oil and oil filter; reset reminder light
o Rotate tires
1
oMeasure thickness and runout of brake rotors
o Measure thickness of brake pads (GS, IS, IS F, LS 460
with Sport Package)
o Replace air conditioner filter
o Replace brake fluid
o Replace engine air filter
o Inspect the following:
___Axle shaft boots
___Ball joints and dust covers
___Body
___Brake lines and hoses
___Drive belt
___Engine coolant (see page 69)
___Exhaust pipes and mountings
___Front differential oil (GS 350 AWD, IS 250 AWD,
LS 460 AWD)
___Fuel lines and connections, fuel tank band and fuel tank vapor vent system hoses
Additional Maintenance Required If You Drive Primarily Under the Following Conditions
Driving on dirt roads or dusty roads:
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
___Fuel tank cap gasket
___Manual transmission oil (IS 250)
___Rack and pinion assembly
___Rear differential oil (GS, IS, LS, SC)
___Steering linkage and boots
___Transfer case for signs of leakage
(GS 350 AWD, IS 250 AWD,
LS 460 AWD)
___Transmission for signs of leakage
Date: _____________________________ Mileage: ____________________________
Notes:
o Replace Smart Key battery (all models
except SC)
o Replace timing belt (SC)
o Visually inspect brake pads, calipers
and rotors
o Roadtest vehicle
2010 Lexus Sedans_4880d 7/21/09 1:50 AM Page 59

SCHEDULED MAINTENANCE LOG
MAINTENANCE
114 Months or 95,000 Miles
oReplace engine oil and oil filter; reset
reminder light
o Rotate tires
1
oVisually inspect brake pads, calipers and rotors
o Roadtest vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
o Inspect axle shaft boots
o Inspect ball joints and dust covers
o Inspect engine air filter
o Inspect steering linkage and boots
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
120 Months or 100,000 Miles
oReplace engine oil and oil filter; reset
reminder light
o Rotate tires
1
oMeasure thickness of brake pads and rotors
(GS, IS, IS F, LS 460 with Sport Package)
o Replace air conditioner filter (LS, SC)
o Replace engine coolant (see page 69)
o Replace Smart Key battery (all models
except SC)
o Visually inspect brake pads, calipers and rotors
o Roadtest vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
o Inspect axle shaft boots
o Inspect ball joints and dust covers
o Inspect engine air filter
o Inspect steering linkage and boots
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
Scheduled Maintenance Log
60
1Applies to models with same size front and rear tires and wheels.
2010 Lexus Sedans_4880d 7/21/09 1:52 AM Page 60

SCHEDULED MAINTENANCE LOG
MAINTENANCE
132 Months or 110,000 Miles
oReplace engine oil and oil filter; reset
reminder light
o Rotate tires
1
oMeasure thickness of brake pads and rotors
(GS, IS, IS F, LS 460 with Sport Package)
o Replace air conditioner filter (LS, SC)
o Replace Smart Key battery (all models
except SC)
o Visually inspect brake pads, calipers and rotors
o Roadtest vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
o Inspect axle shaft boots
o Inspect ball joints and dust covers
o Inspect engine air filter
o Inspect steering linkage and boots
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
138 Months or 115,000 Miles
oReplace engine oil and oil filter; reset
reminder light
o Rotate tires
1
oInspect engine coolant (see page 69)
o Visually inspect brake pads, calipers and rotors
o Roadtest vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
o Inspect axle shaft boots
o Inspect ball joints and dust covers
o Inspect engine air filter
o Inspect steering linkage and boots
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
Scheduled Maintenance Log
62
1Applies to models with same size front and rear tires and wheels.
2010 Lexus Sedans_4880d 7/21/09 1:53 AM Page 62

SCHEDULED MAINTENANCE LOG
MAINTENANCE
150 Months or 125,000 Miles
oReplace engine oil and oil filter; reset
reminder light
o Rotate tires
1
oVisually inspect brake pads, calipers and rotors
o Roadtest vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
o Inspect axle shaft boots
o Inspect ball joints and dust covers
o Inspect engine air filter
o Inspect steering linkage and boots
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
156 Months or 130,000 Miles
oReplace engine oil and oil filter; reset
reminder light
o Rotate tires
1
oInspect engine coolant (see page 69)
o Measure thickness of brake pads and rotors
(GS, IS, IS F, LS 460 with Sport Package)
o Replace air conditioner filter (LS, SC)
o Replace Smart Key battery (all models
except SC)
o Visually inspect brake pads, calipers and rotors
o Roadtest vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
o Inspect axle shaft boots
o Inspect ball joints and dust covers
o Inspect engine air filter
o Inspect steering linkage and boots
o Tighten nuts and bolts on chassis
Driving while towing:
o Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
Scheduled Maintenance Log
6 4
1Applies to models with same size front and rear tires and wheels.
2010 Lexus Sedans_4880d 7/21/09 1:54 AM Page 64