radiator Lexus GS250 2014 Owner's Manual

4486-3. Do-it-yourself maintenance
GS350_250_OM_OM30E16E_(EE)
Light bulbs (→P. 5 1 4 )
• Bulb with same number and wattage
rating as original
• Phillips-head screwdriver
•Flathead screwdriver
•Wrench
Radiator and condenser ( →P. 4 6 1 )
Tire inflation pressure ( →P. 4 8 3 )•Tire pressure gauge
• Compressed air source
Wa s h e r f l u i d ( →P. 4 6 5 )
• Water or washer fluid containing anti-
freeze (for winter use)
• Funnel (used only for adding water or washer fluid)
CAUTION
The engine compartment contains many mechanisms and fluids that may move sud-
denly, become hot, or become electrically energized. To avoid death or serious
injury, observe the following precautions.
■When working on the engine compartment
●Keep hands, clothing and tools away from the moving fan and engine drive belt.
●Be careful not to touch the engine, radiator, exhaust manifold, etc. right after driv-
ing as they may be hot. Oil and other fluids may also be hot.
●Do not leave anything that may burn easily, such as paper and rags, in the engine
compartment.
●Do not smoke, cause sparks or expose an open flame to fuel or the battery. Fuel
and battery fumes are flammable.
●Be extremely cautious when working on the battery. It contains poisonous and
corrosive sulfuric acid.
●Take care because brake fluid can harm your hands or eyes and damage painted
surfaces. If fluid gets on your hands or in your eyes, flush the affected area with
clean water immediately. If you still experience discomfort, consult a doctor.
ItemsParts and tools
GS350_250_OM_OM30E16E_(EE).book Page 448 Tuesday, July 8, 201 4 7:11 PM

449 6-3. Do-it-yourself maintenance
6
Maintenance and care
GS350_250_OM_OM30E16E_(EE)
CAUTION
■When working near the electric cooling fans or radiator grille
Be sure the engine switch is off.
With the engine switch in IGNITION ON mode, the electric cooling fans may
automatically start to run if the air conditioning is on and/or the coolant tempera-
ture is high. (→P. 4 6 1 )
■Safety glasses
Wear safety glasses to prevent flying or falling material, fluid spray, etc. from get-
ting in your eyes.
NOTICE
■If you remove the air cleaner filter
Driving with the air cleaner filter removed may cause excessive engine wear due to
dirt in the air.
■If the fluid level is low or high
It is normal for the brake fluid level to go down slightly as the brake pads wear or
when the fluid level in the accumulator is high.
If the reservoir needs frequent refilling, it may indicate a serious problem.
GS350_250_OM_OM30E16E_(EE).book Page 449 Tuesday, July 8, 201 4 7:11 PM

4546-3. Do-it-yourself maintenance
GS350_250_OM_OM30E16E_(EE)
Engine compartment
For right-hand drive vehicles:
The battery and the fuse box in front of the battery are located on the opposite side
of the engine compartment.
Fuse boxes (→P. 4 9 2 )
Battery ( →P. 4 6 1 )
Engine oil level dipstick (→ P. 4 5 6 )
Engine coolant reservoir (→ P. 4 5 9 ) Engine oil filler cap (
→P. 4 5 7 )
Washer fluid tank ( →P. 465)
Electric cooling fans
Condenser ( →P. 4 6 1 )
Radiator ( →P. 4 6 1 )1
2
3
4
5
6
7
8
9
GS350_250_OM_OM30E16E_(EE).book Page 454 Tuesday, July 8, 201 4 7:11 PM

459 6-3. Do-it-yourself maintenance
6
Maintenance and care
GS350_250_OM_OM30E16E_(EE)
The coolant level is satisfactory if it is between the “FULL” and “LOW”
lines on the reservoir when the engine is cold.Reservoir cap
“FULL” line
“LOW” line
If the level is on or below the “LOW”
line, add coolant up to the “FULL” line.
(→ P. 6 2 5 )
■Coolant selection
Only use “Toyota Super Long Life Coolant” or a similar high quality ethylene glycol
based non-silicate, non-amine, non-nitrite, and non-borate coolant with long-life
hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a mixture of 50% coolant and 50% deionized
water. (Minimum temperature: -35 °C [-31 °F])
For more details about engine coolant, contact any authorized Lexus dealer or
repairer, or another duly qualified and equipped professional.
■If the coolant level drops within a short time of replenishing
Visually check the radiator, hoses, engine coolant reservoir caps, drain cock and
water pump.
If you cannot find a leak, have any authorized Lexus dealer or repairer, or another
duly qualified and equipped professional, test the cap and check for leaks in the
cooling system.
Engine coolant
1
2
3
GS350_250_OM_OM30E16E_(EE).book Page 459 Tuesday, July 8, 201 4 7:11 PM

461 6-3. Do-it-yourself maintenance
6
Maintenance and care
GS350_250_OM_OM30E16E_(EE)
Check the radiator and condenser and clear away any foreign objects.
If either of the above parts is extremely dirty or you are not sure of their
condition, have your vehicle inspected by any authorized Lexus dealer or
repairer, or another duly qualified and equipped professional.
Check the battery as follows.
■Caution symbols
The meanings of each caution symbol on the top of the battery are as
follows:
Radiator and condenser
CAUTION
■When the engine is hot
Do not touch the radiator or condenser as they may be hot and cause serious inju-
ries, such as burns.
Battery
No smoking, no naked
flames, no sparksBattery acid
Shield eyesNote operating instruc-
tions
Keep away from childrenExplosive gas
GS350_250_OM_OM30E16E_(EE).book Page 461 Tuesday, July 8, 2014 7:11 PM

625
7
7-2. Steps to take in an emergency
When trouble arises
GS350_250_OM_OM30E16E_(EE)
If your vehicle overheats
Stop the vehicle in a safe place and turn off the air conditioning system,
and then stop the engine.
If you see steam:
Carefully lift the hood after the steam subsides.
If you do not see steam:
Carefully lift the hood.
After the engine has cooled down sufficiently, inspect the hoses and
radiator core (radiator) for any leaks.
Radiator
Cooling fans
If a large amount of coolant leaks,
immediately contact any autho-
rized Lexus dealer or repairer, or
another duly qualified and
equipped professional.
The following may indicate that your vehicle is overheating.
●The needle of the engine coolant temperature gauge ( →P. 99)
enters the red zone or a loss of engine power is experienced. (For
example, the vehicle speed does not increase.)
●Steam is coming from under the hood.
Correction procedures
1
2
3
1
2
GS350_250_OM_OM30E16E_(EE).book Page 625 Tuesday, July 8, 201 4 7:11 PM

6267-2. Steps to take in an emergency
GS350_250_OM_OM30E16E_(EE)
The coolant level is satisfactory if it is between the “FULL” and “LOW”
lines on the reservoir.Reservoir“FULL”
“LOW”
Coolant inlet cap
Add coolant if necessary.
Water can be used in an emergency if
coolant is unavailable.
Start the engine and turn the air co nditioning system on to check that
the radiator cooling fans operate and to check for coolant leaks from
the radiator or hoses.
The fans operate when the air conditioning system is turned on immediately after
a cold start. Confirm that the fans are operating by checking the fan sound and air
flow. If it is difficult to check these, turn the air conditioning system on and off
repeatedly. (The fans may not operate in freezing temperatures.)
If the fans are not operating:
Stop the engine immediately and contact any authorized Lexus dealer
or repairer, or another duly qualified and equipped professional.
If the fans are operating:
Have the vehicle inspected at the nearest any authorized Lexus dealer
or repairer, or another duly qualified and equipped professional.
4
1
2
3
4
5
6
7
GS350_250_OM_OM30E16E_(EE).book Page 626 Tuesday, July 8, 201 4 7:11 PM

6277-2. Steps to take in an emergency
7
When trouble arises
GS350_250_OM_OM30E16E_(EE)
CAUTION
■When inspecting under the hood of your vehicle
Observe the following precautions.
Failure to do so may result in serious injury such as burns.
●If steam is seen coming from under the hood, do not open the hood until the
steam has subsided. The engine compartment may be very hot.
●Keep hands and clothing (especially a tie, a scarf or a muffler) away from the fans
and belts. Failure to do so may cause the hands or clothing to be caught, resulting
in serious injury.
NOTICE
■When adding engine coolant
Add coolant slowly after the engine has cooled down sufficiently. Adding cool
coolant to a hot engine too quickly can cause damage to the engine.
■To prevent damage to the cooling system
Observe the following precautions:
●Avoid contaminating the coolant with foreign matter (such as sand or dust etc.).
●Do not use any coolant additives.
●Do not loosen the coolant inlet cap or the
coolant reservoir cap while the engine and
radiator are hot.
High temperature steam or coolant could
spray out.
GS350_250_OM_OM30E16E_(EE).book Page 627 Tuesday, July 8, 2014 7:11 PM

682Alphabetical index
GS350_250_OM_OM30E16E_(EE)
Pre-Crash Safety system (PCS).....330Function ..................................................330
PCS OFF switch ..................................331
Warning light .......................................546
Warning message....554, 563, 569
Radar cruise control (dynamic radar cruise control) ........................289
Radiator ..................................................... 461
Radio
*
Radio Data System (RDS)*
Rear air conditioning system ............ 391
Rear door sunshades .......................... 427
Rear fog light .......................................... 270 Replacing light bulb ......................... 530
Switch ...................................................... 270
Rear personal lights ............................ 400
Rear seat heaters ................................... 419
Rear sunshade ....................................... 427
Operation .............................................. 427
Reverse operation feature ............428
Rear turn signal lights..........................253 Replacing light bulbs........................ 523
Turn signal lever ................................. 253
Wattage.................................................. 647
Rear view mirror Inside rear view mirror ..................... 196
Outside rear view mirrors.............. 199
Rear view monitor system
*
Rear window defogger .....................396 Refueling .................................................. 280
Capacity................................................. 634
Fuel types .............................................. 634
Opening the fuel tank cap ............ 282
When the fuel filler door cannot be opened......................... 283
Remote Touch
*.................................... 362
Replacing
Electronic key battery ..................... 489
Fuses ........................................................ 492
Light bulbs .............................................. 514
Tires ...........................................................577
Seat belt reminder light ..................... 547
Seat belts..................................................... 38 Adjusting the seat belt ....................... 39
Child restraint system installation ................................................71
Cleaning and maintaining
the seat belt......................................... 441
Emergency Locking
Retractor (ELR) ................................... 41
How to wear your seat belt ............ 38
How your child should wear the seat belt............................................ 41
Pre-crash seat belts ............................ 40
Pregnant women, proper seat belt use ..........................................42
Reminder light and buzzer........... 547
Seat belt pretensioners...................... 40
SRS warning light .............................. 545R
S
GS350_250_OM_OM30E16E_(EE).book Page 682 Tuesday, July 8, 201 4 7:11 PM