engine Lexus GS300h 2013 Repair Manual

8527-2. Steps to take in an emergency
GS450h_300h_OM_OM30D53E_(EE)
Indicates that the
hybrid battery (trac-
tion battery) is low
When stopping the
vehicle for a long
period of time, shift the
shift lever to P. The
battery cannot be
charged with the shift
lever in N.
Indicates that the
hybrid battery (trac-
tion battery) power has
dropped because a long
period of time has
elapsed after shifting
the shift lever to N
Restart the hybrid sys-
tem when starting the
vehicle.
Indicates that the gaso-
line engine cannot
operate or the shift
lever is in N for a long
time
Stop the vehicle and
shift the shift lever to P.
Indicates that the accel-
erator pedal is
depressed while the
shift position is in NRelease the accelerator
pedal and shift the shift
lever to D, S or R.
Wa r n i n g m e s s a g eDetailsCorrection procedure
(Flashes)
(Flashes)
(Flashes)
(Flashes)

8537-2. Steps to take in an emergency
7
When trouble arises
GS450h_300h_OM_OM30D53E_(EE)
*: For the EV drive mode operating conditions: P. 254
Indicates that the EV
drive mode is not avail-
able
*
The reason the EV
drive mode is not
available (the vehi-
cle is idling, battery
charge is low, speed
is higher than the EV
drive mode operat-
ing speed range,
accelerator pedal is
depressed too much)
may be displayed.
Use the EV drive mode
when it becomes avail-
able.
Indicates that the EV
drive mode has been
automatically can-
celed
*
The reason the EV
drive mode is not
available (the battery
charge is low, speed
is higher than the EV
drive mode operat-
ing speed range,
accelerator pedal is
depressed too much)
may be displayed.
Drive the vehicle for a
while.
Indicates that engine
oil level is lowCheck the level of
engine oil, and add if
necessary.
Wa r n i n g m e s s a g eDetailsCorrection procedure

8567-2. Steps to take in an emergency
GS450h_300h_OM_OM30D53E_(EE)
(If equipped)
Indicates that the LKA
(Lane-Keeping Assist)
system detects no-
handed driving (while
the lane keeping assist
function is operating)
The warning buzzer
sounds twice.
Grip the steering wheel
firmly.
(If equipped)
Indicates that the Blind
Spot Monitor sensors
or the surrounding area
on the bumper is dirty
or covered with ice
Clean the sensor and its
surrounding area on the
bumper.
Indicates that the
hybrid system has
overheated
This message may be
displayed when driv-
ing under severe
operating condi-
tions. (For example,
when driving up a
long steep hill.)
Stop and check.
(P. 917)
Indicates that the
hybrid system output is
limited because the
engine oil is over-
heatedDrive the vehicle at a
safe speed until the
warning message dis-
appears.
Wa r n i n g m e s s a g eDetailsCorrection procedure

8687-2. Steps to take in an emergency
GS450h_300h_OM_OM30D53E_(EE)
Inte-
rior
buzzerExterior
buzzerWarning messageDetailsCorrection
procedure

Power was turned
off due to the
automatic power
off function.
Next time
when start-
ing the
hybrid sys-
tem,
increase
the engine
speed
slightly
and main-
tain that
level for
approxi-
mately 5
minutes to
recharge
the 12-volt
battery.
Once
The electronic
key has a low bat-
tery.
Replace
the elec-
tronic key
battery.
(P. 779)

8837-2. Steps to take in an emergency
7
When trouble arises
GS450h_300h_OM_OM30D53E_(EE)
CAUTION
When using the compact spare tire
Remember that the compact spare tire provided is specifically designed
for use with your vehicle. Do not use your compact spare tire on another
vehicle.
Do not use more than one compact spare tire simultaneously.
Replace the compact spare tire with a standard tire as soon as possible.
Avoid sudden acceleration, abrupt steering, sudden braking and shifting
operations that cause sudden engine braking.
When the compact spare tire is attached
The vehicle speed may not be correctly detected, and the following systems
may not operate correctly:
• ABS & Brake assist
•VSC
•TRC
• Cruise control (if equipped)
• Dynamic radar cruise control
(if equipped)
• PCS (if equipped)
•EPS
• AFS (if equipped)
• LDH (if equipped)• DRS (if equipped)
• AVS (if equipped)
• LKA (Lane-Keeping Assist)
(if equipped)
• VGRS (if equipped)
• Lexus parking assist monitor
(if equipped)
• Lexus parking assist-sensor
(if equipped)
• Navigation system (if equipped)

9137-2. Steps to take in an emergency
7
When trouble arises
GS450h_300h_OM_OM30D53E_(EE)
If the 12-volt battery is discharged
If you have a set of jumper (or booster) cables and a second vehicle
with a 12-volt battery, you can jump start your vehicle by following
the steps below.
Open the trunk lid and remove
the 12-volt battery cover.
In the event that the trunk opener
cannot be used, use the mechanical
key to open the trunk. (P. 910)
Connect the jumper cables according to the following procedure:
Positive (+) battery terminal on your vehicle
Positive (+) battery terminal on the second vehicle
Negative (-) battery terminal on the second vehicle
Negative (-) battery terminal on your vehicle
Start the engine of the second vehicle. Increase the engine speed
slightly and maintain at that level for approximately 5 minutes to
recharge the 12-volt battery of your vehicle.
The following procedures may be used to start the hybrid system if
the 12-volt battery is discharged.
You can also call any authorized Lexus dealer or repairer, or
another duly qualified and equipped professional.
1
2
1
2
3
4
3

9147-2. Steps to take in an emergency
GS450h_300h_OM_OM30D53E_(EE)
Open and close any of the doors of your vehicle with the power
switch off.
Maintain the engine speed of the second vehicle and start the
hybrid system of your vehicle by turning the power switch to ON
mode.
Make sure the “READY” indicator comes on. If the indicator
does not come on, contact any authorized Lexus dealer or
repairer, or another duly qualified and equipped professional.
Once the hybrid system has started, remove the jumper cables in
the exact reverse order from which they were connected.
Once the hybrid system starts, have the vehicle inspected at any
authorized Lexus dealer or repairer, or another duly qualified and
equipped professional as soon as possible.
Starting the hybrid system when the 12-volt battery is discharged
The hybrid system cannot be started by push-starting.
To prevent 12-volt battery discharge
Turn off the headlights and the audio system while the hybrid system is off.
Turn off any unnecessary electrical components when the vehicle is running
at a low speed for an extended period, such as in heavy traffic.
Charging the 12-volt battery
The electricity stored in the 12-volt battery will discharge gradually even
when the vehicle is not in use, due to natural discharge and the draining
effects of certain electrical appliances. If the vehicle is left for a long time,
the 12-volt battery may discharge, and the hybrid system may be unable to
start. (The 12-volt battery recharges automatically while the hybrid system is
operating.)
4
5
6
7

9177-2. Steps to take in an emergency
7
When trouble arises
GS450h_300h_OM_OM30D53E_(EE)
If your vehicle overheats
If the needle of the engine coolant temperature gauge enters the
red zone
Stop the vehicle in a safe place and turn off the air condition-
ing system, and then stop the hybrid system.
If you see steam:
Carefully lift the hood after the steam subsides.
If you do not see steam:
Carefully lift the hood.
The following may indicate that your vehicle is overheating.
The needle of the engine coolant temperature gauge (P. 109)
enters the red zone or a loss of hybrid system power is experi-
enced. (For example, the vehicle speed does not increase.)
“Hybrid System Overheat” (P. 856) is shown on the multi-
information display.
Steam comes out from under the hood.
Correction procedures
1
2

9197-2. Steps to take in an emergency
7
When trouble arises
GS450h_300h_OM_OM30D53E_(EE)
Add coolant if necessary. (P. 923)
Water can be used in an emergency if engine coolant is unavailable.
Start the hybrid system and turn the air conditioning system on
to check that the radiator cooling fans operate and to check for
coolant leaks from the radiator or hoses.
The fans operate when the air conditioning system is turned on immedi-
ately after a cold start. Confirm that the fans are operating by checking
the fan sound and air flow. If it is difficult to check these, turn the air
conditioning system on and off repeatedly. (The fans may not operate in
freezing temperatures.)
If the fans are not operating:
Stop the hybrid system immediately and contact your Lexus
dealer.
If the fans are operating:
Have the vehicle inspected at the nearest Lexus dealer.
5
GS300hGS450h
6
7

9247-2. Steps to take in an emergency
GS450h_300h_OM_OM30D53E_(EE)
CAUTION
When inspecting under the hood of your vehicle
Observe the following precautions.
Failure to do so may result in serious injury such as burns.
If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot.
After the hybrid system has been turned off, check that the indicator on
the power switch and the “READY” indicator are off.
When the hybrid system is operating, the gasoline engine may automati-
cally start, or the cooling fan may suddenly operate even if the gasoline
engine stops. Do not touch or approach rotating parts such as the fan,
which may lead to fingers or clothing (especially a tie, a scarf or a muf-
fler) getting caught, resulting in serious injury.
Do not loosen the coolant inlet cap or
the coolant reservoir caps while the
hybrid system and radiator are hot.
High temperature steam or coolant
could spray out.