maintenance Lexus GS350 2015 Warranty and Services Guide

67
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log
180 Months or 150,000 Miles
❑ Replace engine oil with 0W-20 oil; replace oil filter
❑ Replace cabin air filter
❑ Replace brake fluid
❑ Replace engine air filter
❑ Replace engine coolant (see page 69)
❑ Replace Smart Key battery
❑ Inspect the following:
__ Axle shaft boots
__ Ball joints and dust covers
__ Body
__ Brake lines and hoses
__ Brake rotor thickness and runout
__ Drive belt
__ Exhaust pipes and mountings
__ Front differential oil (AWD)
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
If you drive primarily under this special operating condition, perform these
additional items:
Driving on dirt roads or on dusty roads:
❑ Tighten nuts and bolts on chassis __ Fuel tank cap gasket
__ Rack-and-pinion assembly
__ Rear differential oil
__ Steering linkage and boots
__ Transfer case for signs of leakage (AWD)
__ Transmission for signs of leakage
__ Wiper blades
❑ Reset maintenance reminder light
❑ Rotate tires1
❑ Visually inspect brake pads, calipers and rotors
❑ Check installation of driver’s floor mat
❑ Road-test vehicle
1 Applies to models with same size front and rear tires and wheels.
Date: __________________________ Mileage: __________________________

68
EXPLANATION OF MAINTENANCE ITEMS
MAINTENANCE
Scheduled Maintenance Log
The following descriptions are provided
to give you a better understanding of
the maintenance services that should
be performed on your vehicle. The
scheduled maintenance log indicates
at which time/mileage intervals each
service should be performed. Please
note that many maintenance services
should be performed only by a
qualified technician.
Axle Shaft Boots
Check the axle shaft boots and
clamps for cracks, deterioration
and damage. Replace any damaged
parts and, if necessary, repack
the grease. A qualified technician
should perform these operations.
Ball Joints and Dust Covers
Check the suspension and steering
linkage ball joints for looseness
and damage. Check all dust covers
for deterioration and damage. A
qualified technician should perform
these inspections.
Body Inspection
Visually check for corrosion, scratches
and other damage. Check outer
body panels, inner panels of the
hood and doors, and underneath the
vehicle. Apply touch-up paint to any
chips and scratches or have them
repaired by a qualified technician.
Brake Fluid
Replace using fluid type specified in
your Owner’s Manual. A qualified tech-
nician should perform this operation.
Brake Lines and Hoses
Visually inspect for proper installation.
Check for chafing, cracks, deterioration
and signs of leakage. Replace any
deteriorated or damaged parts.
A qualified technician should perform
these operations.
Brake Pads, Calipers and Rotors
Check brake pads and rotors for
excessive wear; check brake rotors for
runout. Check brake calipers for fluid
leakage. Some models are equipped
with directional rotors. When servicing
these rotors, reinstall at same location.
A qualified technician should perform
these operations.
For further information on
maintenance services that you
can perform yourself, see the
maintenance sections of your
Owner’s Manual.

69
EXPLANATION OF MAINTENANCE ITEMS
MAINTENANCE
Scheduled Maintenance Log
Cabin Air Filter
Replace at specified intervals. More
frequent replacement may be required
when driving in dusty conditions,
heavy traffic areas, urban areas, desert
areas or dirt roads. Refer to your
Owner’s Manual for service details.
Differential Oil
Inspect each differential component for
signs of leakage. If you discover any
leakage, have it repaired immediately
by a qualified technician. Refer to your
Owner’s Manual for fluid specifications.
Drive Belt
Inspect for cracks, excessive wear
and oiliness. Check the belt tension
and adjust if necessary. Replace the
belt if it is damaged.
Driver’s Floor Mat
•
Only use the driver’s floor mat
de signed specifically for the model
and model year of your vehicle,
such as Lexus Genuine floor mats.
• Always properly secure the
driver’s floor mat using the
retaining hooks.
• Never install another floor mat
on top of the existing driver’s
floor mat.
• Never install the driver’s floor
mat upside down.
Engine Air Filter
Check for excessive dirt, damage
and oiliness. Replace if necessary.
Engine Coolant
When inspecting, visually check
the engine coolant level on the
see-through reservoir. Add coolant
as necessary. When replacing,
drain the cooling system and refill
with coolant. Always use Genuine
Toyota Super Long-Life Coolant
or similar high-quality non-silicate,
non-amine, non-nitrate, non-borate
ethylene-glycol coolant with long-life
hybrid organic acid technology
(i.e., a combination of low phosphates
and organic acids). Check that the
radiator is not blocked with leaves,
dirt or insects and clean if necessary.
Also check the hose connection for
cor rosion and condition of installation.
A qualified technician should perform
these operations.
Note: Initial replacement is at
120 months/100,000 miles.
Replace every 60 months/
50,000 miles thereafter.

70
EXPLANATION OF MAINTENANCE ITEMS
MAINTENANCE
Scheduled Maintenance Log
Engine Oil and Oil Filter
Replace the oil filter and drain and
refill the engine oil at specified intervals.
SAE 0W-20 oil is the best choice
for good fuel economy and good
starting in cold weather. If SAE 0W-20
is not available, SAE 5W-20 may be
used; however, it must be replaced
with SAE 0W-20 at the next oil
change. See your Lexus dealer for
oil specifically formulated for your
vehicle’s engine.
Your vehicle is equipped with a
replaceable oil-filter element and
oil-filter cap O-ring; replace both
at each oil change. For instructions
on how to reset the reminder light,
refer to your Owner’s Manual.
Note: If you do the majority of your
driving under any of the special
operating conditions indicated on
page 44, you should replace the
engine oil and oil filter every six
months or 5,000 miles, regardless
of the oil used or the certification
of the vehicle.
Exhaust Pipes and Mountings
Visually inspect the exhaust pipes,
muffler and hangers for cracks,
deterioration and damage. Start the
engine and listen carefully for any
exhaust leakage. Tighten connections
and replace parts as necessary.
Fuel Lines and Connections,
Fuel Tank Band and Fuel Tank
Vapor Vent System Hoses
Visually inspect for corrosion,
damage, cracks, and loose or leaking
connections. Tighten connections
and replace parts as necessary.
Fuel Tank Cap Gasket
Visually inspect for cracks,
deterio ration and damage
and replace if necessary.
Nuts and Bolts on Chassis
Check that tightness of the seat-
mounting bolts and front/rear
suspension-member retaining bolts
matches torque measurements
specified in the Repair Manual.
Rack-and-Pinion Assembly
Inspect the rack-and-pinion assembly
for signs of leakage, damage and
loose electrical connections. Tighten
connections and if you discover any
leakage or damage, have it repaired
immediately by a qualified technician.
Road Test
While driving the vehicle, check
for proper operation of engine,
transmission, brakes and steering.
Also check the parking brake, and
check for ab normal noise or vibration
from any part of the vehicle.

71
EXPLANATION OF MAINTENANCE ITEMS
MAINTENANCE
Scheduled Maintenance Log
Spark Plugs
Replace at specified interval. Install
new plugs of the same type as origi-
nally equipped. A qualified technician
should perform this operation.
Steering Linkage and Boots
With the vehicle stopped, check for
excessive freeplay in the steering wheel.
Inspect the linkage for bending and
damage and the dust boots for deterio-
ration, cracks and damage. Replace any
damaged parts. A qualified technician
should perform these operations.
Timing Chain
The timing chain requires no
periodic inspection.
Tire Rotation
See your Owner’s Manual for tire
rotation requirements. Check tire
pressure and check tires for damage
and uneven wear. If the vehicle is
equipped with a spare tire, check the
condition and pressure of the spare.
Tire-Pressure Warning Sensors
A tire-pressure sensor is mounted on
each full-size wheel. These sensors
do not require periodic maintenance.
When a sensor’s long-life lithium battery
becomes discharged, the battery should
be replaced by a qualified technician
following procedures in Lexus service
and repair publications.
Transmission/Transfer Case
Inspect transmission/transfer case for
signs of leakage. If you discover any
leakage, have it repaired immediately
by a qualified technician.
Note: The trans mission/transfer case
and transmission fluid are a completely
sealed unit. Therefore, periodic checks
and replacement of the transmission
fluid are not required, and there is no
dipstick on the transmission. Any repairs
that require adding or replacing fluid
should be performed by a qualified
technician following procedures in
Lexus service and repair publications.
Wiper Blades
The wiper blades should not show
any signs of cracking, splitting, wear,
contamination or deformation. The
wiper blades should clear the wind-
shield without streaking or skipping.

72
Model
In-service date
Mileage at delivery
Selling dealership
Selling dealership phone number
Vehicle Identification Number
VEHICLE IDENTIFICATION
MAINTENANCE
Scheduled Maintenance Log

INDEX
Axle shaft boots ....................................................... 48–67,* 6 8
Ball joints and dust covers ............................................. 48–67,* 6 8
Body inspection ....................................................... 48–67,* 6 8
Body repairs......................................................................7
Brakes
Fluid...................................................................42, 68
Lines and hoses .................................................. 48–67,* 6 8
Pads, calipers and rotors ......................................... 48–67,* 6 8
Cabin air filter ......................................................... 48–67,* 69
Complimentary services
Maintenance services ..............................................4, 45–46
Other services ...........................................................5–6
Differential oil ......................................................... 48–67,* 69
Dispute resolution .........................................................9–13, 21
Drive belt.............................................................. 48–67,* 69
Driver’s floor mat...................................................... 48–67,* 69
Emergency repairs ......................................................... 37–38
Engine air filter ........................................................ 48–67,* 69
Engine coolant .................................................... 42, 48–67,* 69
Engine oil and oil filter ............................................. 42, 48–67,* 70
Exhaust pipes and mountings.......................................... 48–67,* 70
Fuel lines and connections, fuel tank band and
fuel tank vapor vent system hoses ..................................... 48–67,* 70
Fuel tank cap gasket................................................... 48–67,* 70
Inspections, general maintenance ..........................................42–43
*See scheduled maintenance log for maintenance interval.
73

74
INDEX
Keys..............................................................................8
Lexus Personalized Settings................................................1, 4, 45
Loaner vehicle....................................................................5
Maintenance
As related to warranty coverage ..........................25, 29, 31, 35, 40
Complimentary first and second services ..........................4, 45–46
Explanation of maintenance items . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68–71
General maintenance and inspections ................................42–43
Importance of maintenance ............................................... 39
Maintenance intervals..................................................... 44
Scheduled maintenance log...........................................48–67
Where to obtain maintenance.......................inside front cover, 35, 41
Nuts and bolts on chassis.............................................. 48–67,* 70
Oil change ............................................................ 48–67,* 70
Owner responsibilities .........................................25, 29, 31, 35–38
Parts replacement................................................7, 16, 25, 32, 36
Pre-delivery service...............................................................1
Quality control ...................................................................7
Rack-and-pinion assembly ............................................ 48–67,* 70
Road test .............................................................. 48–67,* 70
Roadside assistance ............................................................1, 6
Service agreements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Service history ...................................................................7
Smog-check tests .......................................................... 26, 32
Spark plugs..............................................................55, 63, 71
*See scheduled maintenance log for maintenance interval.

75
INDEX
Steering linkage and boots ............................................. 48–67,* 7 1
Timing chain..................................................................... 71
Tire inspections................................................................. 42
Tire rotation ............................................................ 48–67,* 7 1
Tire-pressure warning sensors................................................... 71
Tires, warranty coverage ....................................................... 34
Transfer case ........................................................... 48–67,* 7 1
Transmission............................................................ 48–67,* 7 1
Travel protection .................................................................5
Warranty coverages
Basic .......................................................................18
California Emission Control ...........................................28–33
Corrosion perforation......................................................19
Coverages at a glance .....................................................15
Federal Emission Control.............................................. 22–27
General provisions ......................................................16–17
Powertrain..................................................................18
Restraint systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Tires ....................................................................... 34
Towing .....................................................................19
What is not covered . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17, 19–21, 23, 30
Wiper blades........................................................... 48–67,* 7 1
*See scheduled maintenance log for maintenance interval.

Lexus recommends having
maintenance and repairs for your
vehicle performed by an authorized
Lexus dealership. To locate your
nearest authorized Lexus dealership,
log on to www.lexus.com or contact
Lexus Customer Satisfaction
at (800) 255-3987.
AUTHORIZED
DEALERSHIP
MAINTENANCE
AND REPAIRS