engine coolant Lexus GS450h 2014 User Guide

800
GS450h_OM_OM30D52U_(U)
7-2. Steps to take in an emergency
If your vehicle overheats
■If the needle of the engine coolant temperature gauge enters the red
zone
Stop the vehicle in a safe place and turn off the air conditioning sys-
tem, and then stop the hybrid system.
If you see steam:
Carefully lift the hood after the steam subsides.
If you do not see steam:
Carefully lift the hood.
After the hybrid system has cooled down sufficiently, inspect the
hoses and cooling system for leaks.
Radiator
Cooling fans
If a large amount of coolant
leaks, immediately contact your
Lexus dealer.
The following may indicate that your vehicle is overheating.
●The needle of the engine coolant temperature gauge ( →P. 91) enters
the red zone or a loss of hybrid system power is experienced. (For
example, the vehicle speed does not increase.)
●“Hybrid System Overheat” ( →P. 762) is shown on the multi-informa-
tion display.
●Steam comes out from under the hood.
Correction procedures
1
2
3
1
2
GS450h_OM_OM30D52U_(U).book Page 800 Monday, July 29, 2013 12:07 PM

8017-2. Steps to take in an emergency
GS450h_OM_OM30D52U_(U)
7
When trouble arises
The coolant level is satisfactory if it is between the “FULL” and
“LOW” lines on the reservoir.Reservoir
“FULL”
“LOW”
Coolant inlet cap
Add coolant if necessary.
(→ P. 803)
Water can be used in an emer-
gency if engine coolant is unavail-
able.
Start the hybrid system and turn the air conditioning system on to
check that the radiator cooling fans operate and to check for coolant
leaks from the radiator or hoses.
The fans operate when the air conditioning system is turned on immediately
after a cold start. Confirm that the fans are operating by checking the fan
sound and air flow. If it is difficult to check these, turn the air conditioning sys-
tem on and off repeatedly. (The fans may not operate in freezing tempera-
tures.)
If the fans are not operating:
Stop the hybrid system immediatel y and contact your Lexus dealer.
If the fans are operating:
Have the vehicle inspected at the nearest Lexus dealer.
4
1
2
3
4
5
6
7
GS450h_OM_OM30D52U_(U).book Page 801 Monday, July 29, 2013 12:07 PM

8047-2. Steps to take in an emergency
GS450h_OM_OM30D52U_(U)
CAUTION
■When inspecting under the hood of your vehicle
Observe the following precautions.
Failure to do so may result in serious injury such as burns.
●If steam is seen coming from under the hood, do not open the hood until the
steam has subsided. The engine compartment may be very hot.
●After the hybrid system has been turned off, check that the indicator on the
power switch and the “READY” indicator are off.
When the hybrid system is operating, the gasoline engine may automatically
start, or the cooling fan may suddenly operate even if the gasoline engine stops.
Do not touch or approach rotating parts such as the fan, which may lead to fin-
gers or clothing (especially a tie, a scarf or a muffler) getting caught, resulting in
serious injury.
NOTICE
■When adding engine/power control unit coolant
Add coolant slowly after the hybrid system has cooled down sufficiently. Adding
cool coolant to a hot hybrid system too quickly can cause damage to the hybrid
system.
■To prevent damage to the cooling system
Observe the following precautions:
●Avoid contaminating the coolant with foreign matter (such as sand or dust etc.).
●Do not use any coolant additives.
●Do not loosen the coolant inlet cap or the
coolant reservoir cap while the hybrid sys-
tem and radiator are hot.
High temperature steam or coolant could
spray out.
GS450h_OM_OM30D52U_(U).book Page 804 Monday, July 29, 2013 12:07 PM

GS450h_OM_OM30D52U_(U)
8138-1. Specifications
8
Vehicle specifications
Cooling system
Capacity
Gasoline
engine9.9 qt. (9.4 L, 8.3 Imp.qt.)
Pow e r
control unit3.3 qt. (3.1 L, 2.7 Imp.qt.)
Coolant typeUse either of the following:• “Toyota Super Long Life Coolant”
• Similar high-quality ethylene glycol-based non-silicate, non-amine, non-nitrite, and non-borate
coolant with long-life hybrid organic acid tech-
nology
Do not use plain water alone.
Ignition system
Spark plug
Make
GapDENSO FK20HBR8
0.031 in. (0.8 mm)
NOTICE
■Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.
GS450h_OM_OM30D52U_(U).book Page 813 Monday, July 29, 2013 12:07 PM

828
GS450h_OM_OM30D52U_(U)
8-1. Specifications
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation pres-
sureTire pressure when the vehicle has been parked for
three hours or more, or has not been driven more
than 1 mile or 1.5 km under that condition
Maximum inflation pres-
sureThe maximum cold inflated pressure to which a tire
may be inflated, shown on the sidewall of the tire
Recommended inflation
pressureCold tire inflation pressure recommended by a man-
ufacturer
Accessory weight
The combined weight (in excess of those standard
items which may be replaced) of hybrid transmission,
power steering, power brakes, power windows,
power seats, radio and heater, to the extent that these
items are available as factory-installed equipment
(whether installed or not)
Curb weight
The weight of a motor vehicle with standard equip-
ment, including the maximum capacity of fuel, oil and
coolant, and if so equipped, air conditioning and
additional weight optional engine
Maximum loaded vehicle
weight
The sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight
Normal occupant weight150 lb. (68 kg) times the number of occupants speci-
fied in the second column of Table 1
* that follows
Occupant distributionDistribution of occupants in a vehicle as specified in
the third column of Table 1
* below
Production options weight
The combined weight of installed regular production
options weighing over 5 lb. (2.3 kg) in excess of the
standard items which they replace, not previously
considered in curb weight or accessory weight,
including heavy duty brakes, ride levelers, roof rack,
heavy duty 12-volt battery, and special trim
RimA metal support for a tire or a tire and tube assembly
upon which the tire beads are seated
GS450h_OM_OM30D52U_(U).book Page 828 Monday, July 29, 2013 12:07 PM

872Alphabetical index
GS450h_OM_OM30D52U_(U)
Eco drive mode .....................................305
EDR (Event data recorder) .................... 11
Electric motor (traction motor) ..........72
Electric Power Steering (EPS) .......308Function ................................................. 308
Warning light .......................................738
Warning message ............................. 752
Electronic key ......................................... 120 Battery-saving function .................... 129
If the electronic key does not operate properly.............................793
Replacing the battery ...................... 694
Emergency, in case of
If a warning buzzer sounds........... 737
If a warning light turns on............... 737
If a warning message is displayed ........................................ 747
If the 12-volt battery is discharged .........................................796
If the electronic key does not operate properly ........793
If the hybrid system will not start....................................... 788
If the parking brake cannot be released..........................791
If the shift lever cannot be shifted from P ........... 790
If you have a flat tire .......................... 775
If you think something is wrong............................................... 736
If your vehicle becomes stuck .... 805
If your vehicle has to be stopped in an emergency ............................. 729
If your vehicle needs to be towed .......................................730
If your vehicle overheats ...............800 Emergency flashers .............................728
Energy monitor .........................................112
Engine
Accessory mode .................................194
Compartment .....................................663
Engine switch ........................................193
Hood....................................................... 660
How to start the hybrid system ....193
Identification number ...................... 809
Ignition switch
(power switch) ..................................193
Overheating........................................ 800
Power switch .........................................193
Engine compartment cover..............664
Engine coolant ...................................... 668 Capacity .................................................. 813
Checking .............................................. 668
Preparing and checking
before winter .................................... 342
Engine coolant temperature
gauge .......................................................... 91
Engine oil ................................................. 665
Capacity .................................................... 811
Checking ...............................................665
Oil level warning message ........... 759
Oil pressure warning message........................... 748
Preparing and checking
before winter .................................... 342
Engine oil maintenance data ........... 650
Engine switch........................................... 193
EPS (Electric Power Steering) ....... 308
Function ................................................. 308
Warning light ....................................... 738
Warning message............................. 752
EV drive mode ...................................... 200
Event data recorder (EDR).....................11
E
GS450h_OM_OM30D52U_(U).book Page 872 Monday, July 29, 2013 12:07 PM