fuel LEXUS LS430 2005 Workshop Manual

CHASSIS
460
SPECIFICATIONS
– DIFFERENTIALOil capacity
1.35 L (1.42 qt., 1.19 lmp.qt.)
Oil type and
viscosityVehicles without synthetic oil
information labelHypoid gear oil API GL −5
Above –18 C (0F): SAE 90
Below –18C (0F): SAE 80W or SAE 80W −90
Vehicles with synthetic oil
information label*Toyota Genuine Differential Synthetic gear oil
API GL− 5 SAE 75W− 90 or its equivalent
NOTE:
*Vehicles with synthetic oil information label only:
The following label is affixed on the right side of the
differential carrier. Use the type and viscosity shown on
the label when the differential oil is replaced.
Synthetic oil information labelNOTICE
Vehicles with synthetic oil information label only:
Use of differential oil other than “Toyota Genuine
Differential Synthetic gear oil API GL5 SAE 75W90” or its
equivalent may damage the dif ferential gear of your vehicle
and diminish fuel efficiency. For the reasons mentioned
above, Lexus recommends use of “Toyota Genuine
Differential Synthetic gear oil API GL5 SAE 75W90”.
Another differential oil of matching quality can also be
used, (but note that despite the similarity in nomenclature
between “Toyota Genuine Differential Synthetic gear oil
API GL5 SAE 75W90” and oils that meet SAE 75W90
specifications, compliance with the SAE specification
does not guarantee that an oil has all characteristic
required to avoid the problem described above.) If you are
unable to locate an equivalent to “Toyota Genuine
Differential Synthetic gear oil API GL5 SAE 75W90”,
contact your Lexus dealer for further details or another
duly qualified and equipped professional.

CHASSIS
470
6. Install the tire valve cap.
If a gauge and air pump are not available, have your
vehicle checked by your Lexus dealer.
CAUTION
Be sure to reinstall the tire valve caps. Without the
valve caps, dirt or moisture could get into the
valve core and cause air leakage. If the caps have
been lost, have new ones put on as soon as
possible.
Incorrect tire inflation pressure may waste fuel, reduce
the comfort of driving, reduce tire life and make your
vehicle less safe to drive.
If a tire needs frequent refilling, have it checked by your
Lexus dealer.
CAUTION
Keep your tires properly inflated. Otherwise, the
following conditions may occur and cause an
accident resulting in death or serious injuries.
Low tire pressure (underinflation):
 Excessive wear
 Uneven wear
 Poor handling
 Possibility of blowouts from an overheated tire
 Poor sealing of the tire bead
 Wheel deformation and/or tire separation
 A greater possibility of tire damage from road
hazards
High tire pressure (overinflation):
 Poor handling
 Excessive wear
 Uneven wear
 A greater possibility of tire damage from road
hazards

CHASSIS
476
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation
pressuretire pressure when the vehicle has been parked for at least 3 hours or m\
ore, or it
has not been driven more than 1.5 km or 1 mile under that condition
Maximum inflation
pressurethe maximum cold inflation pressure to which a tire may be inflated and \
it is shown
on the sidewall of the tire
Recommended inflation
pressurecold tire inflation pressure recommended by a manufacturer
Accessory weight
the combined weight (in excess of those standard items which may be rep\
laced) of
automatic transmission, power steering, power brakes, power windows, pow\
er
seats, radio, and heater, to the extent that these items are available as
factory−installed equipment (whether installed or not)
Curb weight
the weight of a motor vehicle with standard equipment including the maxi\
mum
capacity of fuel, oil, and coolant, and, if so equipped, air conditionin\
g and
additional weight optional engine
Maximum loaded vehicle
weight
the sum of —
(a) curb weight;
(b) accessory weight;
(c) vehicle capacity weight; and
(d) production options weight

ELECTRICAL COMPONENTS
492
64L206
Engine compartment
No.FUSEAMPERECIRCUIT
1 TI & TE20Tilt and telescopic steering
2 PANEL7.5
Lexus park assist system, Rear
seat heater, Rear climate
control seat, Multi− information
display, Audio system,
Cigarette lighter, Instrument
panel light, Coin box light, Rear
mirror light, Glove box light,
Power rear seat, Electronically
modulated air suspension
system, Turn signal lights,
Clock, Shift lock system,
Vehicle stability control system,
Sunshade, Power rear view
mirror control system, Console
box light, Fuel opener system,
Adaptive Front Lighting System
(AFS)
3 D P/SEAT30Power seat system
4 GAUGE7.5Gauges and meters, Lexus
park assist system, Shift lock
system
5 MPXIG7.5
Tilt and telescopic steering,
Power door lock system, Power
seat system, Engine
immobilizer system
6 D S/HTR15Seat heater, Climate control
seat system
7 AIR SUS20Electronically modulated air
suspension system
8 DACC7.5Shift lock system, Theft
deterrent system

ELECTRICAL COMPONENTS
494
No.FUSEAMPERECIRCUIT
35 P DOOR25
Power door lock system, Power
rear view mirror control system,
Outside rear view mirror
defogger, Door closer system,
Door courtesy lights, Power
windows
36 TEL7.5Audio system, Navigation
system
37 P B/ANC5Seat belts, Seat belt buckle
illumination
38 RR DOORRH20Power door lock system, Power
window, Door closer system,
Door courtesy lights
39 D DOOR25
Power door lock system, Door
closer system, Power rear view
mirror control system, Outside
rear view mirror defogger, Door
courtesy lights, Power windows
40 RR IG7.5
Lexus park assist system,
Electronically modulated air
suspension system, Theft
deterrent system, TEL
41 RR ACC7.5Audio system, TEL
42 RR ECUB7.5Rear air conditioning system,
Theft deterrent system, Trunk
light, Refreshing rear seat
43 RR A/C7.5Rear air conditioning system,
Air purifier
44 RR S/HTR30Seat heater, Climate control
seat system
No.FUSEAMPERECIRCUIT
45 RR
S/SHADE15Sunshade
46 LCE LP7.5License plate lights
47 S/ROOF30Moon roof
48 FUEL OPN10Fuel opener system, Trunk lid
closer system
49 AMP30Audio system
50 P P/SEAT30Power seat system
51 RR SEAT LH30Power seat system
52 RR SEATRH30Power seat system
53 LUG J/B50
All components in “RR SEAT
RH”, “RR SEAT LH”, “S/ROOF”,
“AMP”, “RR IG”, “RR ECU −B”,
“P P/SEAT”, “RR S/HTR”, “RR
S/SHADE”, “RR A/C”, “RR
ACC”, “FUEL OPN” and “LCE
LP”, Tail lights and Stop lights
54 ABS 250Vehicle stability control system
55 HEATER50Air conditioning system
56 ABS 130Vehicle stability control system
57 DEFOG40Rear window defogger
58 AIR SUS40Electronically modulated air
suspension system

ELECTRICAL COMPONENTS
495
No.FUSEAMPERECIRCUIT
59 R/B60
All components in “FR FOG”,
“TAIL”, “WASHER”, “FR IG”,
“WIP”, “H−LP CRN” and “A/C
IG”
60 FA N80Air conditioning system
61 DJ/B80
All components in “TI & TE”, “D
P/SEAT”, “A/C”, “OBD”,
“STOP”, “AM1”, “MPX −IG”,
“ABS− IG”, “GAUGE”,
“AIRSUS”, “D S/HTR”,
“SECURITY”, “PANEL”, “D
B/ANC”, “PWR OUTLET”,
“D− CIG”, “D RR− IG” and
“D−ACC”
62 ALT140Charging system
63 PJ/B80
All components in “RR DOOR
RH”, “RR DOOR LH”, “D
DOOR”, “H− LP LVL”, “P
DOOR”, “P S/HTR”, “P− IG”,
“P− ACC”, “P B/ANC”, “P −CIG”,
“TEL” and “P RR −IG”
64 BATT30All components in “RADIO
NO.1”, “AM2”, “HAZ” and “STR
LOCK”
65 ST30Starting system
66 D/C CUT20All components in “DOME”,
“MPX− B1”, “MPX− B2” and
“MPS−B3”
67 ALTS5Charging system
68 FA N50Air conditioning system
No.FUSEAMPERECIRCUIT
69 LUG J/B60
All components in “RR SEAT
RH”, “RR SEAT LH”, “S/ROOF”,
“AMP”, “RR IG”, “RR ECU −B”,
“P P/SEAT”, “RR S/HTR”, “RR
S/SHADE”, “RR A/C”, “RR
ACC”, “FUEL OPN” and “LCE
LP”, Tail lights and Stop lights
70 HLP R
LW R15Right− hand headlight (low
beam)
71 HLP L
LW R15Left− hand headlight (low beam)
72 EFI NO.27.5Multiport fuel injection
system/sequential multiport fuel
injection system
73 STA7.5Multiport fuel injection
system/sequential multiport fuel
injection system
74 INJ10Multiport fuel injection
system/sequential multiport fuel
injection system
75 IGN7.5Multiport fuel injection
system/sequential multiport fuel
injection system
76 FR IG7.5
Electric cooling fan, Headlight
cleaner, Charging system,
Starting system, Rear window
defogger
77 A/C IG7.5Air conditioning system
78 WIP30Windshield wiper

ELECTRICAL COMPONENTS
496
No.FUSEAMPERECIRCUIT
79 FR FOG15Fog lights
80 WASHER20Windshield washer
81 TAIL7.5Tail lights, Parking lights, Side
marker lights
82 HLP CLN30Headlight cleaner
83 EFI NO.125Multiport fuel injection
system/sequential multiport fuel
injection system
84 HORN10Horns
85 ETCS10Multiport fuel injection
system/sequential multiport fuel
injection system
86 HLP HI20Headlights (high beam)
CHECKING BATTERY CONDITION
Precautions
CAUTION
BATTERY PRECAUTIONS
The battery produces flammable and explosive
hydrogen gas.
Do not cause a spark by contacting the battery
terminals with tools.
 Do not smoke or light a match near the battery.
The electrolyte contains poisonous and corrosive
sulfuric acid.
 Avoid contact with eyes, skin or clothes.
 Never inhale or swallow electrolyte.
 Wear protective safety glasses when working near
the battery.
 Keep children away from the battery.
EMERGENCY MEASURES
 If electrolyte gets in your eyes, flush your eyes with
clean water for at least 15 minutes and get immediate
medical attention. If possible, continue to apply
water with a sponge or cloth while traveling to the
medical office.

BODY
511
370.SPECIFICATIONS
– DIMENSIONS AND WEIGHTSOverall length
5015 mm (197.4 in.)
Overall width1830 mm (72.0 in.)
Overall height– with electronically modulated air suspension
– without electronically modulated air suspension
1470 mm (57.9 in.)*
1490 mm (58.7 in.)*
Wheelbase2925 mm (115.2 in.)
Tread
– Frontwith electronically modulated air suspension
without electronically modulated air suspension
– Rear with electronically modulated air suspension
without electronically modulated air suspension
1575 mm (62.0 in.)
1570 mm (61.8 in.)
1575 mm (62.0 in.)
1570 mm (61.8 in.)
Vehicle capacity weight (occupants + cargo)410 kg (900 lb.)
Towing capacity (trailer weight + cargo weight)907 kg (2000 lb.)
*Unladen vehicle
– FUEL TANK
Capacity
84 L (22.2 gal., 18.5 lmp.gal.)

GAS STATION INFORMATION
Fuel selection:
Select premium unleaded gasoline with an Octane Rating
of 91 (Research Octane Number 96) or higher for optimum
engine performance. However, if such premium type
cannot be obtained, you may temporarily use unleaded
gasoline with an Octane Rating as low as 87 (Research
Octane Number 91).
 Fuel tank capacity:
84 L (22.2 gal., 18.5 lmp.gal.)
 Engine oil:
“Toyota Genuine Motor Oil” or equivalent
Oil grade: API grade SL “Energy −Conserving” or ILSAC
multigrade engine oil.
Recommended oil viscosity − SAE 5W−30 if normal
temperatures are below 38 C (100F)
Oil capacity: L (qt., lmp.qt.)
Drain and refill with filter 5.1 (5.4 , 4.8)
without filter 4.5 (4.8 , 4.0)
See page 452 for detailed information.
 Engine coolant:
Capacity: 9.5 L (10.0 qt, 8.4 lmp.qt.)
Coolant type − “Toyota Super Long Life Coolant” or similar
high quality ethylene glycol based non −silicate, non −amine,
non−nitrite, and non −borate coolant with long −life hybrid
organic acid technology (Coolant with long −life hybrid
organic acid technology is a combination of low phosphates
and organic acids.) Do not use plain water alone.
For checking the engine coolant, see page 455.
 Automatic transmission:
Fluid type − “Toyota Genuine ATF WS”
See page 461 for detailed information.
 Tire information:
See page 468 through 485 for detailed information.
 Tire inflation pressure:
cold tires
kPa (kgf/cm
2 or bar, psi)
Ti
re sizeFrontRear
P225/55R17 95H 220 (2.2, 32) 220 (2.2, 32)
245/45R18 96W 230 (2.3, 33) 230 (2.3, 33)
P245/45R18 96V 230 (2.3, 33) 230 (2.3, 33)
For sustained high speeds above 160 km/h (100 mph), in
countries where such speeds are permitted by law, add the
tire pressure given below to the front tires and rear tires, but
never exceed the maximum cold tire pressure molded on
the tire sidewall.
P225/55R17 95H 20kPa (0.2 kgf/cm
2 or bar, 3 psi)
245/45R18 96W 40kPa (0.4 kgf/cm2 or bar, 6 psi)
P245/45R18 96V 40kPa (0.4 kgf/cm2 or bar, 6 psi)