transmission fluid LINCOLN MKZ HYBRID 2012 Owners Manual

has recently run down or been disconnected. If the vehicle does not
need I/M testing, do nothing. The vehicle is designed to check the
emission control system during normal driving. If the vehicle needs
I/M testing, refer to theReadiness for Inspection/Maintenance (I/M)
testingsection in theMaintenance and Specificationschapter.
•Illuminates with engine running:The light stays on after the
engine is started. It indicates that the on board diagnostics system has
detected a problem with the engine, transmission or an
emission-related component or system. Contact your authorized dealer
as soon as possible. The vehicle will usually be drivable and will not
require towing. Refer toOn-board diagnostics (OBD-II)section in
theMaintenance and Specificationschapter for information on
temporary malfunctions that may not require vehicle service.
•Blinks with engine running:The light stays on after the engine is
started and sometimes blinks. It indicates that the On Board
Diagnostics System has detected an engine misfire problem with the
engine. While the light is blinking, engine misfire is occurring which
could damage your catalytic converter. Drive in a moderate fashion
(avoid heavy acceleration and deceleration) and contact your
authorized dealer as soon as possible.
WARNING:Under engine misfire conditions, excessive exhaust
temperatures could damage the catalytic converter, the fuel
system, interior floor coverings or other vehicle components, possibly
causing a fire.
Brake system warning:To confirm
the brake system warning light is
functional, it will momentarily
illuminate when the ignition is
turned to the on position (when the
engine is not running), or in a position between on and start, or by
applying the parking brake when the ignition is turned to the on
position. If the brake system warning light does not illuminate at this
time, contact your authorized dealer as soon as possible. Illumination
after releasing the parking brake indicates low brake fluid level or brake
system malfunction. Contact your authorized dealer as soon as possible.
P!
BRAKE
Instrument Cluster
19
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)

SERVICE POWER STEERING NOW— The power steering system
has detected a condition within the power steering system that requires
service immediately.
SERVICE ADVANCETRAC— Displayed when the AdvanceTrac
system has detected a condition that requires service.
DRIVER DOOR AJAR— Displayed when the driver’s door is not
completely closed.
PASSENGER DOOR AJAR— Displayed when the passenger side door
is not completely closed.
REAR LEFT DOOR AJAR— Displayed when the rear left door is not
completely closed.
REAR RIGHT DOOR AJAR— Displayed when the rear right door is
not completely closed.
CHECK FUEL FILL INLET— Displayed when the fuel fill inlet may
not be properly closed. Refer toEasy Fuel“no cap” fuel systemin the
Maintenance and Specificationschapter.
FUEL LEVEL LOW— Displayed as an early reminder of a low fuel
condition.
BRAKE FLUID LEVEL LOW— Indicates the brake fluid level is low
and the brake system should be inspected immediately. Refer toBrake
fluidin theMaintenance and Specificationschapter.
CHECK PARK AID (if equipped)— Displayed when the transmission
is in R (Reverse) and the Reverse Sensing System (Park Aid) is disabled.
Refer toReverse Sensing System (Park Aid)in this section to enable.
LOW TIRE PRESSURE— Displayed when one or more tires on your
vehicle have low tire pressure. Refer toInflating your tiresin theTires,
Wheels and Loadingchapter.
TIRE PRESSURE MONITOR FAULT— Displayed when the tire
pressure monitoring system is malfunctioning. If the warning stays on or
continues to come on, contact your authorized dealer as soon as
possible.
TIRE PRESSURE SENSOR FAULT— Displayed when a tire pressure
sensor is malfunctioning, or your spare tire is in use. For more
information on how the system operates under these conditions, refer to
Tire Pressure Monitoring System (TPMS)in theTires, Wheels and
Loadingchapter. If the warning stays on or continues to come on,
contact your authorized dealer as soon as possible.
TRUNK AJAR— Displayed when the trunk is not completely closed.
Instrument Cluster
47
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)

The OBD-II system is designed to check the emission control system
during normal driving. A complete check may take several days. If the
vehicle is not ready for I/M testing, the following driving cycle consisting
of mixed city and highway driving may be performed:
15 minutes of steady driving on an expressway/highway followed by
20 minutes of stop-and-go driving with at least four 30-second idle
periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete. If
the vehicle is still not ready for I/M testing, the above driving cycle will
have to be repeated.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Check fluid levels with the ignition
in the on position. Fluid levels
between the MIN and MAX lines are
within the normal operating range;
there is no need to add fluid.
If the fluid levels are outside of the
normal operating range the performance of your brake system could be
compromised; seek service from your authorized dealer immediately.
TRANSMISSION FLUID
Checking electronically controlled continuously variable
transmission (eCVT)
The eCVT does not have an underhood transmission fluid dipstick.
Your transmission does not consume fluid. It is designed to be filled for
life. However, the fluid level should be checked if the transmission is not
working properly, or if you notice some sign of fluid leakage.
Transmission fluid should be checked and, if required, fluid
should be added by an authorized dealer.
Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transmission components.
Maintenance and Specifications
312
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)

Item CapacityFord Part Name or
equivalentFord Part Number / Ford
Specification
Engine oil 5.0 quarts (4.7L)MotorcraftSAE 5W-20
Premium Synthetic
Blend Motor Oil (US)
MotorcraftSAE 5W-20
Super Premium Motor
Oil (Canada)
2
XO-5W20-QSP (US)
CXO-5W20-LSP12 (Canada)
/
WSS-M2C945-A with API
Certification Mark
eCVT transmission
fluid5.3 quarts
(5.0L)
3
Motorcraft
MERCONLV AT F
4
XT-10-QLV /
MERCONLV
Windshield washer
fluidFill as requiredMotorcraftPremium
Windshield Washer
Concentrate (US)
Premium Quality
Windshield Washer
Fluid (Canada)ZC-32-A (US)
CXC-37-(A, B, D, and F)
(Canada) /
WSB-M8B16-A2/- -
Fuel tank17.5 gallons
(66.2L)——
1Add the coolant type originally equipped in your vehicle.2Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C945-A and the API Certification mark.3Indicates only approximate dry-fill capacity.4Using any transmission fluid other than those that meet the recommended specification may cause
internal transmission damage. Do not use MotorcraftContinuously Variable Chain Type
Transmission Fluid (blue). This vehicle uses MotorcraftMERCONLV approved ATFs.
Maintenance and Specifications
317
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)

Multi-point inspection
In order to keep your vehicle running right, it is important to have the
systems on your vehicle checked regularly. This can help identify
potential issues and prevent major problems. Ford Motor Company
recommends the following multi-point inspection be performed at every
scheduled maintenance interval to help ensure your vehicle keeps
running great.
Multi-point inspection – Recommended each visit
Accessory drive belt(s) Half-shaft dust boots (if equipped)
Battery performance Horn operation
Clutch operation (if equipped) Radiator, cooler, heater and A/C hoses
Engine air filter Suspension component for leaks or
damage
Exhaust system Steering and linkage
Exterior lamps and hazard
warning system operationTires for wear and proper pressure,
including spare
Fluid levels*; fill if necessary Windshield for cracks, chips or pits
For oil and fluid leaks Washer spray and wiper operation
*Brake, coolant recovery reservoir, manual and automatic transmission
(with an underhood dipstick), power steering (if equipped) and
window washer
Be sure to ask your dealership service advisor or technician about the
multi-point vehicle inspection. It’s a comprehensive way to perform a
thorough inspection of your vehicle. It’s your checklist that gives you
immediate feedback on the overall condition of your vehicle. You’ll know
what’s been checked, what’s okay, as well as those things that may
require future or immediate attention. The multi-point vehicle inspection
is one more way to keep your vehicle running great!
Scheduled Maintenance
331
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)

NORMAL SCHEDULED MAINTENANCE AND LOG
Your vehicle is equipped with a oil minder system that indicates when
the engine oil should be changed under normal operating conditions.
This means you won’t have to remember to change the oil on a
mileage-based schedule; the vehicle lets you know when an oil change is
due by displaying ENGINE OIL CHANGE DUE NEXT SERVICE or OIL
CHANGE REQUIRED in the message center.
Normal Scheduled Maintenance
Every 10,000 miles
(16,000 km) or
12 monthsChange engine oil and filter
Rotate tires, inspect tire wear and measure tread
depth
Perform multi-point inspection (recommended)
Inspect automatic transmission fluid level (if
equipped with dipstick); consult dealer for
requirements
Inspect brake pads, shoes, rotors, drums, brake
linings, hoses and parking brake
Inspect cabin air filter (if equipped)
Inspect engine cooling system strength and hoses
(non-hybrid vehicles)
Inspect engine cooling system and
motor/electronics cooling system strength and
hoses (hybrid vehicles)
Inspect exhaust system and heat shields
Inspect half-shaft boots (if equipped)
Inspect rear axle and U-joints; lubricate if
equipped with grease fittings (AWD vehicles)
Inspect steering linkage, ball joints, suspension,
tie-rod ends, driveshaft and U-joints; lubricate if
equipped with grease fittings
Inspect wheels and related components for
abnormal noise, wear, looseness or drag
Reset your oil minder system after each engine oil and filter change;
refer to theInstrument Clusterchapter
Do not exceed one year or 10,000 miles (16,000 km) between
service intervals
Scheduled Maintenance
333
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)

Additional maintenance items
1
Miles (x 1,000) 20 30 40 60 80 90 100 120 140 150
Kilometers (x 1,000) 32 48 64 96 128 144 160 192 225 240
Replace cabin air filter (if equipped)• ••• •••
Replace climate-controlled seat filter (if equipped)•• • • •
Replace engine air filter (except Fusion Hybrid and MKZ Hybrid)
2
•• • • •
Change engine coolant
3
•
Change motor/electronics coolant (hybrid vehicles only)
3
•
Replace spark plugs•
Inspect accessory drive belt(s)••
Change rear axle fluid (AWD vehicles)•
Change transmission fluid (Fiesta)•
Replace accessory drive belt(s) if not replaced within the last
100,000 miles (160,000 km)•
Replace timing belt if not replaced within the last 150,000 miles
(240,000 km) or 10 years (Fiesta);failure to replace belt can cause
internal engine damage•
1Additional maintenance items can be performed within 3,000 miles (4,800 km) of the last oil change. Do not exceed
the designated distance for the interval.2Fusion Hybrid and MKZ Hybrid vehicles have an engine air filter that does not normally require replacement. Refer to
Air filterin theMaintenance and Specificationschapter for more information.3Initial replacement at 6 years or 100,000 miles (160,000 km), then every 3 years or 50,000 miles (80,000 km)
Scheduled Maintenance
334
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)

A
Accessory delay ..........................95
AdvanceTrac ..............................229
Airbag supplemental restraint
system ................159–160, 169, 172
and child safety seats ............161
description ..............160, 169, 172
disposal ....................................175
driver airbag ....160, 162, 170, 173
indicator light .........168, 171, 175
operation .........160, 162, 170, 173
passenger airbag ............160, 162,
170, 173
side airbag ...............................169
Air cleaner filter ...............313, 315
Air conditioning ....................66, 69
Ambient mood/lighting ...............81
AM/FM .........................................50
Anti-lock brake system
(see Brakes) ......................226–227
Anti-theft system ..............127, 130
arming the system ..........128, 130
disarming a triggered
system .....................................131
Audio system (see Radio) .........50
Automatic transaxle
fluid, adding ............................312
fluid, checking ........................312
Automatic transmission
driving an automatic
overdrive .................................235
fluid, refill capacities ..............316
fluid, specification ..................316
Auxiliary input jack (Line in) ....58
Axle
lubricant specifications ..........316
refill capacities ........................316B
Battery .......................................293
acid, treating emergencies .....293
jumping a disabled battery ....266
maintenance-free ....................293
replacement, specifications ...315
servicing ..................................293
Belt-Minder.............................154
Blind Spot Information
System .......................................242
Blind spot mirror ......................241
Booster seats .............................190
Brakes ........................................226
anti-lock ...........................226–227
anti-lock brake system (ABS)
warning light ...........................227
fluid, checking and adding ....312
fluid, refill capacities ..............316
fluid, specifications .................316
lubricant specifications ..........316
parking ....................................228
shift interlock ..........................234
Break-in period .............................5
Bulbs ............................................81
C
Capacities for refilling fluids ....316
Car2UHome Automation
System .......................................102
CD ................................................50
Cell phone use ............................15
Changing a tire .........................259
Child safety seats ......................181
attaching with tether straps ..188
in front seat ............................182
in rear seat ..............................182
Index
344
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)

LATCH .....................................185
recommendations ...................178
Child safety seats - booster
seats ...........................................190
Cleaning your vehicle
engine compartment ..............281
instrument panel ....................283
interior .....................................284
plastic parts ............................282
washing ....................................280
waxing .....................................281
wheels ......................................281
wiper blades ............................283
Climate control (see Air
conditioning or Heating) ......66, 69
Clock ............................................51
Clock adjust
AM/FM .......................................51
AM/FM/CD/MP3 ........................51
Compass, electronic ....................90
calibration .................................91
set zone adjustment .................90
Console
overhead ....................................89
Controls
power seat ...............................135
steering column ........................99
Coolant
checking and adding ......296–297
refill capacities ................300, 316
specifications ..........................316
Cross Traffic Alert ....................242
Cruise control (see Speed
control) ........................................97
Cupholder(s) .............................144
Customer Assistance ................249
Ford Extended Service
Plan ..................................323, 326Getting assistance outside
the U.S. and Canada ..............276
Getting roadside assistance ...249
Getting the service you
need .........................................271
Ordering additional owner’s
literature .................................278
Utilizing the
Mediation/Arbitration
Program ...................................276
D
Daytime running lamps
(see Lamps) ................................78
Defrost
rear window and rearview
mirrors .......................................69
windshield .................................69
Dipstick
automatic transmission
fluid ..........................................312
engine oil .................................291
Driving under special
conditions ..................................236
through water .........................248
E
Electronic message center .........35
Emergencies, roadside
jump-starting ..........................266
running out of fuel .........265, 305
Emission control system ..........309
Engine ........................................318
cleaning ...................................281
idle speed control ...................293
lubrication specifications .......316
refill capacities ........................316
service points ..................289–290
Index
345
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)

Steering
speed sensitive .......................233
Steering wheel
controls ......................................99
tilting .........................................88
Stereo
6-CD in dash .............................50
CD-MP3 .....................................50
SYNC..........................................65
T
Tilt steering wheel ......................88
Tire Pressure Monitoring
System (TPMS)
Tires, Wheels and Loading ....209
Tires ...........................194–195, 259
alignment ................................203
care ..........................................198
changing ..................................259
checking the pressure ............198
inflating ...................................196
label .........................................208
replacing ..................................200
rotating ....................................203
safety practices .......................202
sidewall information ...............204
snow tires and chains ............213
spare tire .................................260
terminology .............................195
tire grades ...............................195
treadwear ........................194, 199
Towing .......................................219
recreational towing .................220
trailer towing ..........................219
wrecker ....................................269
Transmission .............................235brake-shift interlock (BSI) ....234
fluid, checking and adding
(automatic) .............................312
fluid, refill capacities ..............316
lubricant specifications ..........316
Trunk .........................................119
remote release ................109, 123
Turn signal ..................................80
U
Universal garage door opener ..102
USB port ......................................60
V
Vehicle Identification Number
(VIN) ..........................................319
Vehicle loading ..........................213
Ventilating your vehicle ...........224
W
Warning lights (see Lights) .......18
Washer fluid ..............................290
Water, Driving through .............248
Windows
opening using remote
entry system .....................94, 122
power .........................................93
Windshield washer fluid and
wipers ..........................................87
checking and adding fluid .....290
replacing wiper blades ...........290
Wrecker towing .........................269
Index
349
2012 MKZ Hybrid(hkz)
Owners Guide, 1st Printing
USA(fus)