brake fluid MAZDA 323 1992 Suplement User Guide

P CONVENTIONAL BRAKE SYSTEM
FRONT BRAKE (DISC)
t nspection (on-ve hicte)
Disc pad
t. Jack up the front of the vehicle and support it with safety
stands.
2. Remove the wheels.
3. Sight through the caliper inspection hole and inspect the
remaining thickness of the pads.
1
Thickness: 2.Omm f 0.08 in ] min.
I LlL”r *-cl , a 4. Replace the pads as a set (right and left wheels) if either
is at br ‘less than the mintmum thickness.
Removal / inspection I installation
1. Remove in the order shown in the figure.
2. Inspect all parts and repair or replace as necessary.
3. Install in the reverse order of removal, referring to InstaHation Note.
4. After installation, perform the following.
(1) Add fluid and bleed the air.
(2) Check for fluid leakage.
(3) Depress the pedal a few times, then verify that the brakes do not drag while rotating the wheel by hand.

102-137 (10.4-14.0,
22-29 (2.2-3.0, 16-21)
75.3-1011
1. Flexible hose 7. Outer shim
2. Bolt 8. Inner shim
3. Callper 9. Guide plate
Disassembly I t nspection / IO. Mounting support
Assembly . _. . . . . _. ._. . . . . . . . . . . . , i.. . . ,:, . page P-l 2 t 1. Disc plate
4. Boot Inspection . . . . . . . . . . . . . . . . . . . . . . . . .,......_.. page P-1 2
5. V-spring
6. Disc pad
Inspection . . . . . . . . . . . . . . . . . . . . .._.__....._........... above InstaUation Note . . . . . . . . . . . . . . . . . .._...... page P-l 1 DlSC PAC
Reptacem
I. Remove
2. tnstatl in
1; Em
2. V-spring
3. Disc paa
fnstatle

P CONVENTIONAL BRAKE SYSTEM
f 6EOPX-073
REAR BRAKE (DISC)
inspection (on-vehicle)
Disc pad
1, Jack up the rear of the vehicle and support it with safety
stands.
2, Remove the wheel and tires.
3. Verify the remaining thickness of the pads.
Thickness: f .Omm fU.04 in) min.
Removal I Inspection / Installation
1. Remove in the order shown in the figure.
2. Inspect all parts and repair or replace as necessary.
3. Install in the reverse order of removal, referring to Installation Note.
4. After instaHation, check the following.
(1) Add fluid and bteed the air.
(2) Check for fluid leakage.
(3) Adjust the parking brake lever stioke.
(4) Depress the pedal a few times, then verify that the brakes do not drag while rotating the wheel bv hand,
1. Parking cable
7. Disc pad
13EOPX-32f page P-15 ,..
. . ..I...... above 2. Connecting bolt installation
3. Brake hose Note . ..*. 1 ,...... I.r. . . . . .
4. Lock bolt Inspection . ..-f...........III.I.......,,.
8. Outer shim
5. Caliper 9. Inner shim
Disassembly I Inspection I
Assem bty IO. Guide plate .
-. . . _. . . . . . . . . . . . . . . . . , . . . . . . . . . . . page P-l 7
Il. Bolt
6, V-spring 12. Mounting support
I 3. Disc plate
Inspection . . . . . . . . . . . . . . . . . . . .._...._.~
P-1 4 . . . page p-16 DISC PAD
Replacem
1 s Remove
2. Inspect
i 3. Install in
4. Adjust tF
1. Parking t
2. Ciip
3. Lock bolt
4. V-spring
5. Disc pad
Installa

INSTRUMENT CLUSTER
ILLUMINATION LAMP
;REFER TO SECTION I-4
c l INSTRUMENT CLUSTER &i WARNING LAMPS 0 .F.R.GERMAI
*....ABS
COMBINATION SWITCH
(SECTION E-l. 21
ENGINE CONTROL UNIT
(SECTIIXJ
B-ICI
SECTION F-2. 3)
l-l rr
II l-l
* * w
,,“,, W/R G/ G/Y Y l-l II
II rl
WY & * 2% l-l II II l-l
R R/B
* Y/L B B/G G/W 6/B 767 G/R
B/O * * L/W V * L
1.J II iH 1G *r- fk io IC pJ ipi * Y/R * W/E R/Y
a 2% 2.3 21 w 28 n- a a x ZB 2A
K 3 34 31 3 Lx+ 3 * a x 33 3*
-02 OIL PRESSURE
SWITCH(E) C-03 BRAKE FLUID SWITCH C-04 PARKING BRAKE
(0 SWITCH(R) C-05 WASHER LEVEL SENSO C-07 WATER THERMOSENSOR
(Fg
(INJ)
pjlfzJ
ma
f
38

PARTS INDEX
PARTS NAME PAGE
PARTS NAME PAGE
I KNOCK CONTROL UNIT...................30
KNOCK SENSOR.........................30 .82
.82
.82
.82
.82
.32
.26
.72
a LICENSE PLATE LIGHT...............48.5 0
B MAIN RELAY(FUEL INJ)
............... ..2 8
1 NEUTRAL SWITCH.......................3 2
$3 OIL PRESSURE SWITCH..................3 8
OXYGEN SENSOR........................2 8
J PANEL LIGHT CONTROL..................7 0
PARKING BRAKE SWITCH.................3 8
POSITION LIGHT....................44,5 0
POWER DDOR LOCK SWITCH...............7 6
POWER DDOR LOCK TIMER UNIT...........7 6
POWER DOOR LOCK ACTUATOR.............7 6
POWER OUTSIDE MIRROR MOTOR...........7 0
POWER OUTSIDE MIRROR SWITCH..........7 8
POWER STEERING PRESSURE SWITCH.......3 2
POWER WINDOW MAIN SWITCH.............7 4
POWER WINDOW MOTOR...................7 4
e
1 BACK-UP LIGHT SWITCH.................60
BACK-UP LIGHT....
BLOWER MOTOR.....:::::::::::::::::::’
.E
BLOWER SWITCH........................62
BRAKE FLUID SWITCH...................38
POWER WINDOW SWITCH..................74
J D REAR FOG LIGHT RELAY.
REAR FOG LIGHT SWITCH
REAR FOG LIGHT.......
REAR SPEAKER......... ................
................ zz
................
52
................
................ E
................ 42
............... .
..: 2
.Riik+‘::::::::..6 4
SWITCH.........6 4
................
................ :z
................ 62
............. 44, 48
I CIGARETTE LIGHTER..
CIRCUIT OPENING REL
CLUTCH SWITCH...
COMBINATION SWITCH:
CONDENSER.......
COOLING FAN MOTOR::
COOLING FAN RELAY..
COURTESY LAMP.....,
CPU................ . .64
/ii’::::::::::::::..2 8
..................
... 44, 46, 48, 50, 52, %
..................
.................. 2:
..................
.................. 2:
............... 42, 66
B DIAGNOSIS CONNECTOR.....
DIGITAL CLOCK...........
n-rnnc ............
............ E
............
............ %
............
............ ZE
TURN LIGHT....
WASHER MOTOR.. REAR
REAR
REAR
REAR
REAR
REAR
REAR
REAR
-ih .ER
-ER
RESISTOR ASSEMBLY..
RUNNING LIGHT RELAY
il SEAT WARMER...........
SEAT WARMER REALY.....
SEAT WARMER SWITCH....
SHORT CONNECTOR.......
SLIDING SUNROOF MOTOR.
SLIDING SUNROOF RELAY.
SLIDING SUNROOF SWITCH
SLIDING SUNROOF.......
SOLENOID RESISTOR.....
SOLENOID VALVES
PRC HIGH TEMP........
PRC LOW TEMP.........
PURGE CONTROL........
WASTEGATE............
SPEED SENSOR..........
SPOT LAMP.............
STARTER...............
STOPLIGHT CHECKER..... ........
........
........
........
........
........
........
........
........ ....... 84
.......
....... ::
.......
.... 66.2
.......
.... 66, Ei
.......
....... ........
........
........
........
........
........
........
........
........
........
.
. . . . . . z:
. . .
. . . . zoo
. 1 .
. . . . E
. . . .
56, ::
. . 56, 58
. . 56, 58
“J.“LJL................. DISTRIBUTOR ............
DOOR SPEAKER ........... .
DOOR SWITCH........: .... 8
3 ENGINE CONTROL UNIT............ ,28, 30. 32
3 FLASHER UNIT...
FRONT FOG LIGHT
FRONT FOG LIGHT
FRONT FOG LIGHT
FRONT SIDE TURN
FRONT TURN LIGH
FUEL METER.....
FUEL PUMP REALY
FUEL PUMP UNIT.
FUEL PUMP......
-. -- ............
............ 22 .
. . RiiA‘i 1
SWITCH
i&ii 1 ............ 52
............ .
............ 22
.....................
..................... %
.....................
..................... %
..................... 28 -
tust ....................
B
G SENSOR ................
13 HAZARD SWITCH............
HEADLIGHT CLEANER MOTOR..
HEADLIGHT CLEANER SWITCH.
HEADLIGHT LEVELING ACTUAT
HEADLIGHT LEVELING SWITCH
HEADLIGHT RELAY..........
ENI- IGHT. . . . . .
HORN RELAY...............
HORN SWITCH.............. ...
40, 46, 52, 64
: ........... 82
............ 54
........... .
..: ii
&::::::::..4 6
HORN..................I 1
HYDRAULIC UNIT ..........
01 IC REGURATOR ............
IG KEY CYLINDER LAMP ....
IGNITER .................
IGNITION COIL ...........
ILLUMINATION LAMP .......
AUDIO SYSTEM ...........
BLOWER SWITCH .......... ............
46
............ 44
......... 44, 46
............
............ E
............
............ E
...........
........... 2:
...........
........... 2
...........
........... 5:
...........
........... 5:
...........
........... 5::
...........
........... 5:
..........
.%
;ci:::::::.;;
........... CIGARETTE LIGHTER: ;.I:;::
FRONT FOG LIGHT SWITCH...
HAZARD SWITCH...........
HEADLIGHT CLEANER SWITCH:
HEADLIGHT LEVELING SWITCH
INSTRUMENT CLUSTER.......
REAR FOG LIGHT SWITCH....
REAR WINDOW DEFROSTER SW1
SEAT WARMER SWITCH.......
INDICATOR LAMP...........
...........
........... 33:: ...........
30 STOPLIGHT SWITCH ......
STOPLIGHT .............
0 TAChOMETER...........................3 8
TAILLIGHT.........................48,5 0
TEMP METER...........................3 8
THROTTLE SENSOR......................3 2
TRANSFER PUMP........................2 8
TRUNK COMPARTMENT LAMP SWITCH........6 8
TRUNK COMPARTMENT LAMP...............6 8
TURN SWITCH..........................5 4
q WARNING LAMP.........................3 8
WASHER LEVEL SENSOR..................3 8
WATER THERMOSENSOR................30,3 8
WATER THERMOSWITCH................... 6
WINDSHIELD WASHER MOTOR..............4 0
WINDSHIELD WASHER SWITCH.............4 0
WINDSHIELD WIPER MOTOR...............4 0
WINDSHIELD WIPER SWITCH..............4 0 INJECTOR..........:;.:::::
INJECTOR RESISTOR .........
INSTRUMENT CLUSTER .....
INTERIOR LAMP..........:::
ISC VALVE .................
. . . . . , . . . . .
. . . . . . . . . . . iz:
,..........
30