audio MAZDA MIATA 1991 Factory Service Manual

A double-lock mechanism is used on clockspring connectors. DO NOT use excessive force when
disconnecting connectors, as damage to connector may occur.
DISABLING & ACTIVATING AIR BAG SYSTEM
AIR BAG SYSTEM
DISABLING SYSTEM
On Miata, obtain radio code number from customer, and deactivate audio anti-theft function. On all models,
turn ignition switch off. Disconnect and shield negative battery cable. Remove knee protector. Disconnect
Orange and Blue clockspring connectors at base of steering column. See Fig. 1
.
ACTIVATING SYSTEM
Reconnect battery and clockspring connectors. Turn ignition switch to RUN position. Check AIR BAG
indicator li
ght to ensure system is operating properly. See SYSTEM OPERATION CHECK. WARNING:Wait about 10 MINUTES after disabling air bag system before servicing.
Air bag system voltage is maintained for about 10 MINUTES after system
is disabled. Failure to wait 10 MINUTES before servicing system may
cause accidental air bag deployment and possible personal injury.

1991 Mazda MX-5 Miata
AIR BAG RESTRAINT SYSTEM MAZDA 1990-91 AIR BAGS
Microsoft
Sunday, July 05, 2009 2:11:16 PMPage 2 © 2005 Mitchell Repair Information Company, LLC.

CHARGING SYSTEM TROUBLE SHOOTING
TROUBLE SHOOTING PRECAUTIONS
Miata
Obtain code number and deactivate audio anti-theft system before disconnecting battery.
All Models
DO NOT reverse battery cable connections. Rectifier will be damaged.
DO NOT use high voltage type testers.
PROBLEM Possible CauseAction
NO START CONDITION
Dead BatteryCheck/Replace Battery
Bad Cable ConnectionsClean/Replace Cables
Ignition Switch/Circuit FaultCheck Switch/Circuit
CHARGING SYSTEM WARNING LIGHT STAYS ON
Loose/Worn Alternator BeltTighten/Replace Belt
Loose Alternator ConnectionsCheck/Repair
Connections
Warning Light WiringCheck/Repair Wiring
Faulty Stator/DiodesTest/Repair Alternator
Faulty Voltage RegulatorTest/Repair Regulator
WARNING LIGHT OFF WITH IGNITION SWITCH ON
Blown FuseCheck/Replace Fuse
Faulty AlternatorTest Alternator
Bad Warning Light BulbTest/Replace Bulb
WARNING LIGHT ON WITH IGNITION SWITCH OFF
Alternator Wiring ShortCheck/Repair Wiring
Faulty Rectifier BridgeTest/Repair Alternator
AMMETER INDICATES DISCHARGE
Loose/Worn Alternator BeltTighten/Replace Belt
Loose Alternator ConnectionsCheck/Repair
Connections
Faulty AmmeterTest/Replace Ammeter
NOISY Defective BatteryReplace Battery
Defective AlternatorTest/Repair Alternator
Defective RegulatorTest/Repair Regulator
NOTE: Observe the following precautions when trouble shooting or testing charging
system:

1991 Mazda MX-5 Miata
ALTERNATOR & REGULATOR 1990-92 ELECTRICAL Alternators & Regulators - Mitsubishi
Microsoft
Sunday, July 05, 2009 2:14:54 PMPage 3 © 2005 Mitchell Repair Information Company, LLC.

Drain coolant. Disconnect heater hoses at engine compartment firewall. Remove grommets from holes (if
equipped). Remove instrument panel. Remove heater case. Disassemble case and remove heater core. See Fig.
1 . To install, reverse removal procedure. Fill cooling system.
INSTRUMENT PANEL
Removal & Installation
Obtain code number and deactivate audio anti-theft system. Disconnect negative battery cable. Remove all
components in order listed in illustration. See Fig. 3
. To install, reverse removal procedure.
Fig. 3: Exploded View of Instrument Panel

Courtesy of MAZDA MOTORS CORP.
WIRING DIAGRAM

1991 Mazda MX-5 Miata
HEATER SYSTEM 1990-92 Heater Systems
Microsoft
Sunday, July 05, 2009 2:12:14 PMPage 5 © 2005 Mitchell Repair Information Company, LLC.

Removal & Installation
Obtain code number and deactivate audio anti-theft system. Disconnect negative battery cable. Remove all
components in order listed in illustration. See Fig. 4
. To install, reverse removal procedure.
Fig. 4: Exploded View of Instrument Panel

Courtesy of MAZDA MOTORS CORP.
WIRING DIAGRAMS

1991 Mazda MX-5 Miata
A/C-HEATER SYSTEM - MANUAL 1990-92 Manual A/C-Heater Systems
Microsoft
Sunday, July 05, 2009 2:11:52 PMPage 9 © 2005 Mitchell Repair Information Company, LLC.