window MAZDA MODEL 3 HATCHBACK 2016 (in English) Workshop Manual
[x] Cancel search | Manufacturer: MAZDA, Model Year: 2016, Model line: MODEL 3 HATCHBACK, Model: MAZDA MODEL 3 HATCHBACK 2016Pages: 600, PDF Size: 8.05 MB
Page 438 of 600
6–34
Maintenance and Care
Owner Maintenance
Wiper Blades
CAUTION
¾ Hot waxes applied by automatic car
washers have been known to aff ect the
wiper's ability to clean windows.
¾ To prevent damage to the wiper blades,
do not use gasoline, kerosene, paint
thinner, or other solvents on or near
them.
¾ When the wiper lever is in the AUTO
position and the ignition is switched ON,
the wipers may move automatically in
the following cases:
¾ If the windshield above the rain
sensor is touched.
¾ If the windshield above the rain
sensor is wiped with a cloth.
¾ If the windshield is struck with a hand
or other object.
¾ If the rain sensor is struck with a hand
or other object from inside the vehicle.
Be careful not to pinch hands or fi ngers
as it may cause injury, or damage the
wipers. When washing or servicing the
vehicle, make sure the wiper lever is in
the OFF position.
Contamination of either the windshield or
the blades with foreign matter can reduce
wiper effectiveness. Common sources are
insects, tree sap, and hot wax treatments
used by some commercial car washes.
If the blades are not wiping properly,
clean the window and blades with a good
cleaner or mild detergent; then rinse
thoroughly with clean water. Repeat if
necessary.
Replacing Windshield Wiper
Blades
When the wipers no longer clean well, the
blades are probably worn or cracked.
Replace them.
CAUTION
To prevent damage to the wiper arms
and other components, do not try to
sweep the wiper arm by hand.
N O T E
When raising both windshield wiper arms,
raise the driver's side wiper arm ¿ rst.
When lowering the wiper arms, slowly
lower the wiper arm from the passenger's
side ¿ rst while supporting it with your
hand. Forcefully lowering the wiper arms
could damage the wiper arm and blade,
and may scratch or crack the windshield.
1. Raise the wiper arm.
2. Open the clip and slide the blade
assembly in the direction of the arrow.
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C
Page 439 of 600
6–35
Maintenance and Care
Owner Maintenance
3. Tilt the blade assembly and remove it
from the arm.
CAUTION
To prevent damage to the windshield
let the wiper arm down easily, do not
let it slap down on the windshield.
4. Pull down the blade rubber and slide it
out of blade holder.
5. Remove the metal stiffeners from each
blade rubber and install them in the
new blade.
CAUTION
¾ Do not bend or discard the stiff eners. You
need to use them again.
¾ If the metal stiff eners are switched,
the blade's wiping effi ciency could be
reduced.
So do not use the driver's side metal
stiff eners on the passenger's side, or vice
versa.
¾ Be sure to reinstall the metal stiff eners in
the new blade rubber so that the curve
is the same as it was in the old blade
rubber.
6. Carefully insert the new blade rubber.
Then install the blade assembly in the
reverse order of removal.
Replacing Rear Window Wiper
Blade (5-Door)
When the wiper no longer cleans well, the
blade is probably worn or cracked.
Replace it.
CAUTION
To prevent damage to the wiper arm
and other components, do not move
the wiper by hand.
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C
Page 440 of 600
6–36
Maintenance and Care
Owner Maintenance
1. Remove the cover.
2. (With stopper type)
Remove the stopper and raise the wiper
arm.
(Without stopper type)
Raise the wiper arm.
Stopper
3. Firmly rotate the wiper blade to the
right until it unlocks, then remove the
blade.
CAUTION
To prevent damage to the rear window,
do not let the wiper arm fall on it.
4. Pull down the blade rubber and slide it
out of the blade holder.
5. Remove the metal stiffeners from the
blade rubber and install them in the
new blade.
CAUTION
Do not bend or discard the stiff eners.
You need to use them again.
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C
Page 470 of 600
6–66
Maintenance and Care
Owner Maintenance
*Some models.
DESCRIPTION FUSE
RATING PROTECTED COMPONENT
19 CNG 15 A —
20 AT 15 A Transaxle control system
21 R.WIPER 15 A Rear window wiper
*
22 A/C 7.5 A Air conditioner
23 ENGINE3 15 A Engine control system
24 ENGINE2 15 A Engine control system
25 ENGINE1 15 A Engine control system
26 GLOW SIG 5 A —
27 EVVT 20 A Engine control system
28 WIPER 20 A Front window wiper and washer
29 DCDC REG 30 A —
30 FUEL PUMP2 30 A —
31 ADD FAN DE 40 A —
32 P.WINDOW1 30 A Power windows
33 H/L LOW R 15 A Headlight low beam (RH)
*2
34 H/L LOW L
HID L 15 A Headlight (LH)
*1 , Headlight low beam (LH) *2
35 METER1 10 A Instrument cluster
36 IG2 30 A For protection of various circuits
37 LPG 30 A —
38 FAN DE 40 A —
39 DCDC DE 40 A —
40 SRS1 7.5 A Air bag
41 ENGINE. IG1 15 A Engine control system
42 C/U IG1 15 A For protection of various circuits
43 — — —
*1 With xenon fusion headlights
*2 With halogen headlights
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C
Page 471 of 600
6–67
Maintenance and Care
Owner Maintenance
*Some models.
Fuse block (Left side)
DESCRIPTION FUSE
RATING PROTECTED COMPONENT
1 P.WINDOW3
P. S E AT D 30 A Power seat
*
2 D.LOCK 25 A Power door locks
3 P.WINDOW2 25 A Power windows
4 SEAT WARM 20 A Seat warmer
*
5 R.OUTLET3 15 A Accessory sockets
6 SRS2/ESCL 15 A Seat weight sensor
7 SUNROOF 10 A Moonroof
*
8 M.DEF 7.5 A Mirror defogger *
9 R.OUTLET1 15 A —
10 MIRROR 7.5 A Power control mirror
11 F.OUTLET 15 A Accessory sockets
12 ABS IG
A T I N D 7.5 A AT shift indicator
*
13 SRS1 7.5 A —
14 METER1 10 A —
15 C/U IG1 15 A —
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C
Page 475 of 600
6–71
Maintenance and Care
Appearance Care
CAUTION
Do not use steel wool, abrasive
cleaners, or strong detergents
containing highly alkaline or caustic
agents on chrome-plated or anodized
aluminum parts. This may damage the
protective coating; also, cleaners and
detergents may discolor or deteriorate
the paint.
Pay special attention to removing salt, dirt,
mud, and other foreign material from the
underside of the fenders, and make sure
the drain holes in the lower edges of the
doors and rocker panels are clean.
Insects, tar, tree sap, bird droppings,
industrial fallout, and similar deposits
can damage the ¿ nish if not removed
immediately. When prompt washing with
plain water is ineffective, use a mild soap
made for use on vehicles.
Thoroughly rinse off all soap with
lukewarm or cold water. Do not allow
soap to dry on the ¿ nish.
After washing the vehicle, dry it with a
clean chamois to prevent water spots from
forming.
WARNING
Dry off brakes that have become
wet by driving slowly, releasing the
accelerator pedal and lightly applying
the brakes several times until the brake
performance returns to normal:
Driving with wet brakes is dangerous.
Increased stopping distance or the
vehicle pulling to one side when
braking could result in a serious
accident. Light braking will indicate
whether the brakes have been aff ected.
When using an automatic car wash
y Retract the door mirrors.
y The automatic car wash brushes could
reduce the paint lustre or hasten paint
deterioration.
When using a high water pressure car
wash
High water temperature and high water
pressure car washers are available
depending on the type of car wash
machine. If the car washer nozzle is
put too close to the vehicle, the force of
the spray could damage or deform the
molding, affect the sealability of parts,
and allow water to penetrate the interior.
Keep a suf ¿ cient space (30 cm (12 in) or
more) between the nozzle and the vehicle.
In addition, do not spend too much time
spraying the same area of the vehicle, and
be very careful when spraying between
gaps in doors and around windows.
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C
Page 480 of 600
6–76
Maintenance and Care
Appearance Care
N O T E
y Do not wipe leather parts using alcohol,
chlorine bleach, or organic solvents
such as thinner, benzene, or gasoline.
Otherwise, it may cause discoloration
or stains.
y Scratches or nicks on the panels and
metallic trim resulting from the use
of a hard brush or cloth may not be
repairable.
y Be particularly careful when cleaning
high lustre panels and metallic trim as
they can be easily scratched.
Maintenance of the Active Driving
Display
The combiner and mirror surface have a
special coating. When cleaning, do not use
a hard or rough-surface cloth, or cleaning
detergent. In addition, if a chemical
solvent gets on the active driving display,
wipe it off immediately. Otherwise, the
combiner and mirror could be damaged
and the surface coating could be scratched.
Use a ¿ ne, soft cloth such as those used
for cleaning eyeglasses.
Cleaning the Lap/Shoulder Belt
Webbing
Clean the webbing with a mild soap
solution recommended for upholstery or
carpets. Follow instructions. Do not bleach
or dye the webbing; this may weaken it.
After cleaning the belts, thoroughly dry
the belt webbing and make sure there is no
remaining moisture before retracting them.
WARNING
Have an Authorized Mazda Dealer
replace damaged seat belts
immediately:
Using damaged seat belts is
dangerous. In a collision, damaged
belts cannot provide adequate
protection.
Cleaning the Window Interiors
If the windows become covered with an
oily, greasy, or waxy ¿ lm, clean them with
glass cleaner. Follow the directions on the
container.
CAUTION
¾ Do not scrape or scratch the inside of
the window glass. It could damage the
thermal fi laments and the antenna lines.
¾ When washing the inside of the window
glass, use a soft cloth dampened in
lukewarm water, gently wiping the
thermal fi laments and the antenna lines.
Use of glass cleaning products could
damage the thermal fi laments and the
antenna lines.
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C
Page 595 of 600
10–3
Index
Climate Control System ........................ 5-2
Automatic Climate Control ............. 5-9
Dual-Zone Automatic Climate
Control........................................... 5-12
Gas speci ¿ cations ............................ 9-9
Manual Climate Control .................. 5-5
Operating Tips ................................. 5-2
Vent Operation ................................ 5-3
Clock ................................................... 5-28
Collision warning ................................ 7-38
Control Status Display ........................ 4-70
Cruise Control ................................... 4-119
Cruise Control Switch ................. 4-119
Cruise Control Set Vehicle Speed
Display ................................................ 4-16
Cup Holder ........................................ 5-138
Customer Assistance ............................. 8-2
D
Dashboard Illumination ...................... 4-15
Daytime Running Lights ..................... 4-45
Defogger
Mirror ............................................ 4-53
Rear window ................................. 4-52
Dimensions ........................................... 9-6
Direct Mode
Automatictransaxle ....................... 4-38
Door Locks .......................................... 3-11
Drive selection .................................... 4-71
Driving In Flooded Area ..................... 3-48
Driving Tips
Automatic transaxle ...................... 4-39
Break-in period.............................. 3-44
Driving in À ooded area.................. 3-48
Driving on uneven road ................. 3-50
Floor mat ....................................... 3-45
Hazardous driving ......................... 3-45
Overloading ................................... 3-49
Rocking the vehicle ....................... 3-46
Winter driving ............................... 3-46
Driving on Uneven Road .................... 3-50 Dynamic Stability Control (DSC) ....... 4-64
DSC OFF Indicator Light.............. 4-65
DSC OFF Switch........................... 4-65
TCS/DSC Indicator Light ............. 4-64
E
Emergency Starting
Push-Starting ................................. 7-18
Starting a Flooded Engine ............. 7-18
Emergency Towing
Tiedown Hooks ............................. 7-22
Towing Description ....................... 7-21
Emission Control System .................... 3-27
Ending Screen Display ........................ 4-70
Engine
Coolant .......................................... 6-30
Engine Compartment Overview .... 6-26
Exhaust gas.................................... 3-28
Hood release .................................. 6-24
Oil .................................................. 6-27
Starting ............................................ 4-5
Essential information ............................ 6-2
Event Data Recorder ........................... 8-20
Exhaust Gas ........................................ 3-28
Exterior Care ....................................... 6-68
Aluminum Wheel Maintenance .... 6-73
Bright-Metal Maintenance ............ 6-72
Maintaining the Finish .................. 6-70
Plastic Part Maintenance ............... 6-73
F
Flasher
Hazard warning ............................. 4-54
Headlights ..................................... 4-40
Flat Tire ................................................. 7-3
Mounting the Spare Tire................ 7-10
Removing a Flat Tire ....................... 7-7
Floor Mat ............................................ 3-45
Fluid
Brake/Clutch ................................. 6-32
Washer ........................................... 6-32
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C
Page 597 of 600
10–5
Index
Inspecting Washer Fluid Level............ 6-32
Interior Care ........................................ 6-74
Cleaning the Lap/Shoulder Belt
Webbing ........................................ 6-76
Cleaning the Upholstery and Interior
Trim ............................................... 6-74
Cleaning the Window Interiors ..... 6-76
Dashboard Precautions .................. 6-74
Maintenance of the Active Driving
Display .......................................... 6-76
Interior Lights ................................... 5-135
Luggage Compartment Light ...... 5-135
Map Lights .................................. 5-135
Overhead Lights .......................... 5-135
J
Jack ....................................................... 7-4
Jump-Starting ...................................... 7-15
K
Key Suspend Function .......................... 3-8
Key left-in-luggage compartment warning
beep (With the advanced keyless
function) .............................................. 7-37
Key left-in-vehicle warning beep (With the
advanced keyless function) ................. 7-37
Keyless Entry System ........................... 3-3
Key removed from vehicle warning
beep ..................................................... 7-36
Keys ...................................................... 3-2
Key suspend function ...................... 3-8
Transmitter ...................................... 3-4
L
Label Information ................................. 9-2
Lane-Change Signals .......................... 4-47
Lane Departure Warning System
(LDWS) ............................................... 4-80
LDWS switch ................................ 4-83 Lane departure warning system (LDWS)
warning sound ..................................... 7-37
Laser Sensor (Front) ......................... 4-116
Liftgate ................................................ 3-20
When liftgate/trunk lid cannot be
opened ........................................... 7-40
Light Bulbs
Replacement .................................. 6-47
Speci ¿ cations .................................. 9-9
Lighting Control.................................. 4-40
Lights-on reminder .............................. 7-35
Lubricant Quality .................................. 9-5
Luggage Compartment Light ............ 5-135
M
Maintenance
Information ...................................... 6-2
Scheduled ........................................ 6-4
Maintenance Monitor .......................... 6-20
Manual Transaxle Operation ............... 4-26
Recommendations for shifting ...... 4-28
Map Lights ........................................ 5-135
Mazda Radar Cruise Control (MRCC) ... 4-98
Close proximity warning ............. 4-100
Display indication ....................... 4-100
Setting the system ....................... 4-101
Shift-up/shift-down request
display ......................................... 4-105
Mazda Radar Cruise Control (MRCC)
System warnings ................................. 7-38
Meters and Gauges .............................. 4-11
Mirror Defogger .................................. 4-53
Mirrors
Outside mirrors.............................. 3-32
Rearview mirror ............................ 3-33
Moonroof ............................................ 3-38
O
Odometer and Trip Meter .................... 4-12
Outside Mirrors ................................... 3-32
Outside Temperature Display .............. 4-16
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C
Page 598 of 600
10–6
Index
Over Rev. buzzer ................................. 7-39
Overhead Console ............................. 5-140
Overhead Lights ................................ 5-135
Overheating ......................................... 7-19
Overloading ......................................... 3-49
Owner Maintenance
Battery replacement ...................... 6-40
Closing the Hood........................... 6-25
Engine Compartment Overview .... 6-26
Opening the Hood ......................... 6-24
Owner Maintenance Precautions... 6-22
P
Parking Brake ...................................... 4-59
Personalization Features ..................... 9-12
Power Steering .................................... 4-73
Power Windows .................................. 3-35
Power steering warning buzzer ........... 7-38
R
Radar Sensor (Front) ......................... 4-113
Radar Sensors (Rear) ........................ 4-118
Rear Coat Hooks ............................... 5-141
Rear Cross Traf ¿ c Alert (RCTA) ........ 4-92
Rear Door Child Safety Locks ............ 3-19
Rear Seat ............................................... 2-8
Rear View Monitor............................ 4-127
Displayable range on the screen ... 4-129
Picture quality adjustment ........... 4-134
Rear view monitor operation ....... 4-131
Rear view parking camera
location ........................................ 4-128
Switching to the rear view monitor
display ......................................... 4-128
Variance between actual road conditions
and displayed Image
.................... 4-133
Viewing the display ..................... 4-130
Rear Window Defogger ...................... 4-52
Rear Window Washer .......................... 4-51
Rear Window Wiper ............................ 4-51
Rearview Mirror .................................. 3-33 Recommended Oil .............................. 6-27
Recording of Vehicle Data .................. 8-21
Recreational Towing ........................... 3-51
Registering Your Vehicle in A Foreign
Country ............................................... 8-17
Replacement
Electrical battery ........................... 6-40
Fuse ............................................... 6-63
Light Bulbs .................................... 6-47
Tires ............................................... 6-45
Wheel ............................................ 6-46
Wiper ............................................. 6-34
Rocking the Vehicle ............................ 3-46
S
SRS Air Bags
Front passenger occupant classi ¿ cation
system ............................................ 2-56
How the SRS air bags work .......... 2-49
Limitations to SRS air bag ............ 2-54
Monitoring..................................... 2-61
SRS air bag deployment criteria ... 2-53
Supplemental restraint system
components ................................... 2-47
Safety Defects, Reporting ................... 8-13
Satellite Radio ..................................... 5-47
Saving Fuel and Protection of the
Environment ........................................ 3-44
Scheduled Maintenance ........................ 6-4
Seat Belt System
2-point type ................................... 2-19
3-point type ................................... 2-16
Automatic locking ......................... 2-15
Emergency locking ........................ 2-15
Extender ........................................ 2-20
Pregnant women ............................ 2-15
Seat belt warning beep ........................ 7-36
Seats
Front seat ......................................... 2-5
Head restraint ................................ 2-11
Rear seat .......................................... 2-8
Seat warmer ..................................... 2-7
. B [ E B @ ' " & " ( @ & E J U J P O J O E C . B [ E B @ ' " & " ( @ & E J U J P O J O E C