brakes MAZDA MODEL 626 2001 User Guide

Form No. 8P95-EA-00G
*Some models.
Driving Your Mazda5-40If the check engine light flashes
continuously, decrease your speed and
consult an Authorizd Mazda Dealer as
soon as possible.

053-12CE
 Door-Ajar Warning
Light
This warning light comes on when any
door or trunk isn’ t securely closed.
Q053-15IE
Antilock Brake System
(ABS) Warning Light*
The warning light stays on for a few
seconds when the ignition switch is
turned to the ON position.
If the ABS warning light stays on
while you’re driving, the ABS control
unit has detected a system
malfunction. If this occurs, your
brakes will function normally as if the
vehicle had no ABS. Should this
happen, consult an Authorized Mazda
Dealer as soon as possible.
NOTEWhen the engine is jump-started to
charge the battery, uneven rpm
occurs and the ABS warning light
comes on. This is due to a weak
battery, not a malfunction.
Recharge the battery.

Form No. 8P95-EA-00G
Appearance Care7-8Pay special attention to removing salt,
dirt, mud, and other foreign material
from the underside of the wings, and
make sure the drain holes in the lower
edges of the doors and rocker panels
are clean.
Insects, tar, tree sap, bird droppings,
industrial fallout, and similar deposits
can damage the finish if not removed
immediately. When prompt washing
with plain water is ineffective, use a
mild soap made for use on vehicles.
Thoroughly rinse off all soap with
lukewarm or cold water. Don’t allow
soap to dry on the finish. After washing the vehicle, dry it with a
clean chamois to prevent water spots
from forming.
WARNING
!
Driving with Wet Brakes:Driving with wet brakes is
dangerous. Increased stopping
distance or the vehicle pulling to
one side when braking could
result in a serious accident. Light
braking will indicate whether the
brakes have been affected. Dry
the brakes by driving very slowly
and applying the brakes lightly
until brake performance is
normal.

Waxing
Your vehicle needs to be waxed when
water no longer beads on the finish.
Always wash and dry the vehicle
before waxing it. In addition to the
vehicle body, wax the metal trim to
maintain its luster.
1. Use wax which contains no abrasives. Waxes containing
abrasive will remove paint and
could damage bright metal parts.
2. Use a good grade of natural wax for metallic, mica, and solid colors.
3. When waxing, coat evenly with the sponge supplied or a soft cloth.

Form No. 8P95-EA-00G
Appearance Care7-10
078-5A1E

Underbody Maintenance
Road chemicals and salt used for ice
and snow removal and solvents used
for dust control may collect on the
underbody. If not removed, they will
speed up rusting and deterioration of
such underbody parts as fuel lines,
frame, floor pan, and exhaust system,
even though these parts may be coated
with anticorrosive material.
Thoroughly flush the underbody and
wheel housings with lukewarm or cold
water at the end of each winter. Try
also to do this every month.
Pay special attention to these areas
because they easily hide mud and dirt. It will do more harm than good to
wet down the road grime without
removing it.
The lower edges of doors, rocker
panels, and frame members have drain
holes that should not be clogged.
Water trapped there will cause rusting.
WARNING
!
Driving with Wet Brakes:Driving with wet brakes is
dangerous. Increased stopping
distance or the vehicle pulling to
one side when braking could
result in a serious accident. Light
braking will indicate whether the
brakes have been affected. Dry
the brakes by driving very slowly
and applying the brakes lightly
until brake performance is
normal.

Form No. 8P95-EA-00G
Maintenance
8-3


082-1AE
Scheduled MaintenanceFollow Schedule 1 if the vehicle is operated mainly where none of the followin\
g conditions applies.
If any of them apply, follow Schedule 2 (Puerto Rico residents follow Schedule 2).
• Repeated short-distance driving
• Driving in dusty conditions
• Driving with an extended use of brakes
• Driving in areas where salt or other corrosive materials are being used
• Driving on rough or muddy roads
• Extended periods of idling or low-speed operation
• Driving for a prolonged period in cold temperatures or extremely humid c\
limates

Form No. 8P95-EA-00G
I: Inspect and repair, clean, adjust, or replace if necessary
L : Lubricate
Maintenance8-6Schedule 1 (Cont ’d)
MAINTENANCE
INTERVALS
Number of months or miles (kilometers), whichever comes first
INTERVALS
Months
6
12
18
24
30
36
42
48
MAINTENANCE

1000 km
12
24
36
48
60
72
84
96
MAINTENANCE

ITEM
(
1000 miles)
(7.5)
(15)
(22.5)
(30)
(37.5)
(45)
(52.5)
(60)
Drum brakes
I
I
Disc brakes
I
I
Steering operation and linkages
I
I
Front suspension ball joints
I
I
Driveshaft dust boots
I
I
Bolts and nuts on chassis and body
I
I
Exhaust system heat shields
I
I
All locks and hinges
L
L
L
L
L
L
L
L
Air-conditioner refrigerant (if installed)
I
I
I
I
Air-conditioner compressor (if installed)
I
I
I
I

Form No. 8P95-EA-00G
I: Inspect and repair, clean, adjust, or replace if necessary
L : Lubricate
Maintenance
8-9
Schedule 2 (Cont ’d)
MAINTENANCE
INTERVALS
Number of months or miles (kilometers), whichever comes first
INTERVALS
Months
4
8
12
16
20
24
28
32
36
40
44
48
MAINTENANCE

1000 km
8
16
24
32
40
48
56
64
72
80
88
96
MAINTENANCE

ITEM
(
1000 miles)
(5)
(10)
(15)
(20)
(25)
(30)
(35)
(40)
(45)
(50)
(55)
(60)
Brake and clutch fluid level
I
I
I
I
I
I
I
I
I
I
I
I
Drum brakes
I
I
Disc brakes
I
I
I
I
Tire inflation pressure and tire wear
I
I
I
I
I
I
I
I
I
I
I
I
Steering operation and linkages
I
I
Power steering fluid level
I
I
I
I
I
I
I
I
I
I
I
I
Front suspension ball joints
I
I
Driveshaft dust boots
I
I
Bolts and nuts on chassis and body
I
I
I
I
Exhaust system heat shields
I
I
All locks and hinges
L
L
L
L
L
L
L
L
L
L
L
L

Form No. 8P95-EA-00G
J94A7014
Maintenance
8-25
9. After the engine has cooled,remove the cooling system cap and
inspect the coolant level. If it’ s low,
repeat steps 5 to 8.
Because this procedure requires
technical expertise, we recommend
that it be done by an Authorized
Mazda Dealer.NOTEMixing green coolant with orange
coolant could decrease the service
life expentancy of the coolant. Use
only genuine Mazda orange
colored or equivalent coolant


083-13A2EJ94A7013
Inspecting Brake/Clutch Fluid
Level
The brakes and clutch draw fluid from
the same reservoir. Inspect the fluid level in the reservoir
regularly. If it’
s low, add fluid until it
reaches MAX. It should be kept at
MAX.
Before adding fluid, thoroughly clean
the area around the cap.

Form No. 8P95-EA-00G
Maintenance
8-27
WARNING
!
Low Brake/Clutch Fluid Levels:Low brake/clutch fluid levels
could be dangerous. Low levels
could signal brake lining wear or
a brake system leak. Your brakes
could fail and cause an accident.
If you find a low fluid level, have
the brakes and clutch inspected.
Q083-15FE
J94A7015Inspecting Power Steering Fluid
Level
Inspect the fluid level at each engine
oil change. Add fluid if necessary; it
does not require periodic changing. J94A7016
(J18T7019)
Low
OK
High
The level must be kept between the
HIGH and LOW marks.

Form No. 8P95-EA-00G
Index11-2
PagePage Page
AAccessory Socket5-51
. . . . . . . . . . . . . . . .
Add-On Non-Genuine Parts and
Accessories 9-10
. . . . . . . . . . . . . . . . . . . .
Air Bag Restraint System 2-35
. . . . . . . . . .
Warning light 5-41
. . . . . . . . . . . . . . . . .
Air Filter 8-34
. . . . . . . . . . . . . . . . . . . . . . .
Aluminum Wheel Maintenance 7-11 . . . . .
Antenna 5-123
. . . . . . . . . . . . . . . . . . . . . .
Antilock Brake System (ABS) 5-22 . . . . . .
Warning light 5-40
. . . . . . . . . . . . . . . . .
Appearance Care 7-1
. . . . . . . . . . . . . . . . .
Audio System Cassette tape player 5-83
. . . . . . . . . . . .
Compact disc changer 5-83
. . . . . . . . . . .
Compact disc player 5-82, 5-83 . . . . . . .
Radio 5-82, 5-83
. . . . . . . . . . . . . . . . . .
Automatic Transaxle Controls 5-9
. . . . . . . . . . . . . . . . . . . . . .
Driving tips 5-12
. . . . . . . . . . . . . . . . . . . Fluid level
8-29
. . . . . . . . . . . . . . . . . . . .
Overdrive 5-14
. . . . . . . . . . . . . . . . . . . .
Shift-lock system 5-15
. . . . . . . . . . . . . .
Transaxle ranges 5-10
. . . . . . . . . . . . . . .
BBattery 8-38
. . . . . . . . . . . . . . . . . . . . . . . .
Charging system warning light 5-37 . . . .
Jump-starting 6-4
. . . . . . . . . . . . . . . . . .
Before Driving After getting in 4-8
. . . . . . . . . . . . . . . . .
Before getting in 4-7
. . . . . . . . . . . . . . . .
Body Lubrication 8-33
. . . . . . . . . . . . . . . .
Brakes
Antilock brake system (ABS) 5-22 . . . . .
Fluid level 8-25
. . . . . . . . . . . . . . . . . . . .
Foot brake 5-19
. . . . . . . . . . . . . . . . . . . .
Pad wear indicator 5-20
. . . . . . . . . . . . .
Parking brake 5-21
. . . . . . . . . . . . . . . . .
System warning light 5-36
. . . . . . . . . . . Break-In Period
4-8
. . . . . . . . . . . . . . . . . .
Bright-Metal Maintenance 7-9
. . . . . . . . . .
Bulb Replacement
Front, Interior 8-48
. . . . . . . . . . . . . . . . .
Headlight 8-45
. . . . . . . . . . . . . . . . . . . .
Rear 8-49
. . . . . . . . . . . . . . . . . . . . . . . .