steering MAZDA MODEL MX-5 2018 (in English) Service Manual

DESCRIPTIONFUSE
RATING PROTECTED COMPONENT
17 AUDIO1 25 A Audio system
18 A/C MAG 7.5 A Air conditioner
19 AT P U M P
H/L HI 20 A ―
20 AT 15 A Transmission control system
*
21 D LOCK25 A Power door locks
22 H/L RH 20 A Headlight (RH)
23 ENG
B2 7.5 A Engine control system
24 TAIL 20 A Taillights, License plate lights, Parking lights
25 DRL 15 A ―
26 ROOM 25 A Overhead light
27 FOG 15 A ―
28 H/CLEAN 20 A ―
29 STOP 10 A Brake lights
30 HORN 15 A Horn
31 H/L LH 20 A Headlight (LH)
32 ABS/DSC S 30 A ABS, Dynami c stability control system
33 HAZARD 15 A Hazard warning fl ashers, Turn signal lights
34 FUEL PUMP 15 A Fuel system
35 ENG
B3 5 A ―
36 WIPER 20 A Windshield wipers
37 CABIN
B 50 A
For protection of various circuits
38 ― ― ―
39 ― ― ―
40 ABS/DSC M 50 A ABS, Dynami c stability control system
41 EVVT
A/R PUMP 20 A Engine control system
42 EVPS 30 A Brake control system
43 FAN1 30 A Cooling fan
44 FAN2 40 A ―
45 ENG.MAIN 40 A Engine control system
46 EPS 60 A Power steering system
47 DEFOG 30 A Rear window defogger
48 IG2 30 A For protection of various circuits
49 INJECTOR 30 A Engine control system
50 HEATER 40 A Air conditioner
Maintenance and Care
Owner Maintenance
6-52*Some models.
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

If the tire inflation pressure does not
increase, repair of the tire is not
possible. If the tire does not reach
the specified tire inflation pressure
within 10 minutes, it may have
received extensive damage. In this
case, the repair using the emergency
flat tire repair kit was not successful.
Contact an Authorized Mazda
Dealer.
13. Adhere the speed restriction sticker to
an area where it can be viewed easily
by the driver.
14. Adhere the repaired tire sticker to thewheel of the flat tire.
WA R N I N G
Do not adhere the speed restriction
sticker to the padded area on the
steering wheel:
Adhering the speed restriction sticker to
the padded area on the steering wheel
is dangerous because the air bag may
not operate (deploy) normally resulting
in serious injury. In addition, do not
adhere the sticker to areas where
warning lights or the speedometer
cannot be viewed.
15. When the tire inflates to the specified tire inflation pre ssure, turn the air
compressor switch off, turn the sleeve
of the injection hose to the left, and
pull it out of the tire valve.
16. Remove the air compressor hose from
the injection valve of the bottle. After
that, install the injection hose to the
injection valve of t he bottle to prevent
leakage of any remaining sealant.
CAUTION
The remaining sealant in the hose may
spray out when the hose is removed.
Remove the hose carefully because you
may not be able to remove the sealant
contacting clothing or other objects.
If Trouble Arises
Flat Tire
7-9
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

NOTE
Do not throw away the empty tire
sealant bottle after use. Return the
empty tire sealant bottle to an
Authorized Mazda Dealer when
replacing the tire. The empty tire
sealant bottle will need to be used to
extract and dispose of the used sealant
from the tire.
14. After that, install the injection hose to
the tab of the bottle to prevent leakage
of any remaining sealant.
Tab
15. Adhere the speed restriction sticker toan area where it can be viewed easily
by the driver.
WA R N I N G
Do not adhere the speed restriction
sticker to the padded area on the
steering wheel:
Adhering the speed restriction sticker to
the padded area on the steering wheel
is dangerous because the air bag may
not operate (deploy) normally resulting
in serious injury. In addition, do not
adhere the sticker to areas where
warning lights or the speedometer
cannot be viewed.
16. Pull out the air compressor hose and the air compressor plug from the air
compressor.
Compressor hose
17. Install the air compressor hose to the tire valve.
Valve Compressor hose
If Trouble Arises
Flat Tire
7-13
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

SignalWarning
(Red)
High Engine Coolant
Temperature Warning
Indication/Warning
Light The light flashes when the engine coolant temperature is extrem
ely high, and illumi-
nates when the engine coolant temperature increases further.
Handling Procedure
Flashing light
Drive slowly to reduce engine l oad until you can find a safe place to stop the vehicle
and wait for the engine to cool down.
Illuminated light
This indicates the possibility of overheating. Park the vehicle in a safe place immedi-
ately and stop the engine.
Refer to Overheating on page 7-27.
CAUTION
Do not drive the vehicle with the high engi ne coolant temperature warning light illumi‐
nated. Otherwise, it could resu lt in damage to the engine.
Power Steering Mal-
function Indicator Light The light illuminates if the electric power steering has a malf
unction.
If the light illuminates, stop the vehicle in a safe place and do not operate the steering
wheel. There is no problem if the light turns off after a while . Contact an Authorized
Mazda Dealer if the light illuminates continuously.
NOTE
If the indicator light illuminates, the powe r steering will not operate normally. If this
happens, the steering wheel can still be op erated, however, the operation may feel
heavy compared to normal, or the steer ing wheel could vibrate when turning.
Repeatedly jerking the steering wheel left and ri ght while the vehicle is stopped or
moving extremely slowly will cause the po wer steering system to go into protective
mode which will make the steering feel heavy, but this does not indicate a problem. If
this occurs, park the vehicle safely and wait several minu tes for the system to return
to normal.
If Trouble Arises
Warning/Indicator Lights and Warning Sounds
7-35
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

Vehicles without advanced keyless
function
If the key is taken out of the vehicle while
the ignition is not switched OFF and all
the doors are closed, a beep will be heard
in the cabin 6 times and the KEY warning
light (red) in the instrument cluster turns
on continuously to notify the driver that
the ignition has not been switched OFF.
NOTE
Because the key utilizes low-intensity
radio waves, the Key Removed From
Vehicle Warning may activate if the key is
carried together with a metal object or it
is placed in a poor signal reception area.
▼ Request Switch Inoperable Warning
Beep (With the advanced keyless
function)
If the request switch is pressed with the
door open or ajar, or the ignition is not
switched OFF with a key being carried, a
beep will be heard outside for about 2
seconds to notify the driver that the door
or trunk lid cannot be locked.
▼Key Left-in-trunk Compartment
Warning Beep (With the advanced
keyless function)
If the key is left in the trunk with all the
doors locked and the trunk lid closed, a
beep will be heard outside for about 10
seconds to notify the driver that the key is
in the trunk. In this case, take out the key
by pressing the electric trunk lid opener
and opening the trunk lid. The key taken
out of the trunk may not operate because
its functions have been temporarily
stopped. To restore the key's functions,
perform the applicable procedure (page
3-8).
▼Key Left-in-vehicle Warning Beep
(With the advanced keyless
function)
If all the doors and trunk are locked using
another key while the key is left in the
cabin, the beep which sounds outside of
the vehicle will be heard for about 10
seconds to notify the driver that the key is
in the cabin. In this case, take out the key
by opening the door. A key taken out of
the vehicle using this method may not
operate because its functions have been
temporarily stopped. To restore the key's
functions, perform the applicable
procedure (page 3-8).
▼Power Steering Warning Buzzer
If the power steering system has a
malfunction, the power steering
malfunction light turns on or flashes and
the buzzer operates at the same time.
Refer to Warning Indication/Warning
Lights on page 4-26.
If Trouble Arises
Warning/Indicator Lights and Warning Sounds
7-51
MX-5_8GF7-EA-17J_Edition2
2017-10-31 14:07:27

(With limited-slip differential)
Don't use the following:
Tires not of the designated size
 Tires of different sizes or types at the same time
 Tires not sufficiently inflated
If these instructions aren't followed, the rotati on of the left and right wheels will be different
and will thus apply a consta nt load on the limited-slip
differential.
This will cause a malfunction.
▼ Replacing a Tire
WA R N I N G
Always use tires that are in good condition:
Driving with worn tires is dangerous. Reduced br
aking, steering, and traction could result in
an accident.
If a tire wears evenly, a wear ind icator will appear as a solid band across the tread.
Replace the tire when this happens.
New tread Tread wear indicator
Worn tread
You should replace the tire before the band crosses the entire tread.
NOTE
Tires degrade over time, even when they are not being used on the road. It is recommended
that tires generally be replaced when they are 6 years or older. Heat caused by hot climates
or frequent high loading conditions can accelerate the aging process. The period in which
the tire was manufactured (both week and year) is indicated by a 4-digit number.
Refer to Tire Labeling on page 8-25.
Customer Information and Reporting Safety Defects
Tire Information (U.S.A.)
8-35
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

Vehicle Loading
WA R N I N G
Do not tow a trailer with this vehicle:
Towing a trailer with this vehicle is dangerous because it has not been designed to tow a
trailer and doing so will affect the drive sy stem which could result in vehicle damage.
This section will guide you in the proper loading of your vehic le, to keep your loaded
vehicle weight within its desig n rating capability. Properly loading your vehicle will provide
maximum return of vehicle design performance. Before loading yo ur vehicle, familiarize
yourself with the following term s for determining your vehicle's weight ratings, from the
vehicle's Safety Certification La bel and Tire and Load Information Label:
WA R N I N G
Overloaded Vehicle:
Overloading a vehicle is dangerous. The results of overloading can have serious consequences
in terms of passenger safety. Too much weight on a vehicle's suspension system can cause
spring or shock absorber failure, brake failure , handling or steering problems, irregular tire
wear, tire failure or other damage.
Overloading makes a vehicle harder to drive and control. It also increases the distance
required for stopping. In cases of serious overl oading, brakes can fail completely, particularly
on steep grades. The load a tire will carry safely is a combination of the size of the tire, its load
range, and corresponding inflation pressure.
Never overload the vehicle and always observe th e vehicle's weight ratings from the vehicle's
Safety Certification and Tire and Load Information labels.
Customer Information and Reporting Safety Defects
Tire Information (U.S.A.)
8-37
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

Index
Lighting Control................................4-44
Lights-on Reminder.......................... 7-49
Light BulbsReplacement................................ 6-40
Specifications.................................9-7
Lubricant Quality................................ 9-4
M
Maintenance Information.................................... 6-2
Scheduled.......................................6-4
Maintenance Monitor........................ 6-15
Manual Transmission Operation....... 4-31
Message Indicated in Multi-information
Display.............................................. 7-46
Message Indicated on Display.......... 7-47
Meters and Gauges............................4-11
Mirrors Outside mirrors............................ 3-29
Rearview mirror.......................... 3-30
Mirror Defogger.......... ...................... 4-54
Multi-information Disp lay................ 4-18
Average fuel econom y.................4-23
Compass Display......................... 4-24
Cruise control set vehicle speed
display..........................................4-24
Current fuel economy. .................4-23
Distance-to-empty... .................... 4-22
Engine Coolant Temperature
Gauge........................................... 4-21
Fuel gauge................................... 4-21
Lane Departure Warning System
(LDWS) Display..........................4-24
Maintenance monitor...................4-23
Odometer and trip meter............. 4-20
Outside temperatur e display........ 4-22
Retractable Fastback Operation
Display......................................... 4-24
Warning (display indication)....... 4-25
O
Odometer and Trip Meter................. 4-12
Outside Mirrors................................. 3-29
Outside Temperature Display............4-15
Overhead Light............................... 5-139
Overheating....................................... 7-27
Overloading....................................... 3-55
Owner Maintenance
Closing the hood......................... 6-20
Engine compartment overview.... 6-21
Key battery replacement..............6-33
Opening the hood.................. ...... 6-19
Owner maintenance
precautions................................... 6-17
P
Parking Brake....................................4-61
Personalization Features..................... 9-9
Power Steering.................................. 4-73
Power Steering Warning Buzzer....... 7-51
Power Windows................................ 3-32
R
Radar Sensors (Rear)........................ 4-96
Rearview Mirror................................3-30
Rear Cross Traffic Alert (RCTA)...... 4-91
Rear Window Defogger.................... 4-53
Recommended Oil.............................6-22
Recording of Vehicle Data................ 8-22
Recreational Towing......................... 3-57
Registering Your Vehicle in A Foreign
Country.............................................. 8-18
Replacement
Fuse..............................................6-49
Key battery.................................. 6-33
Light bulbs...................................6-40
Tires............................................. 6-38
Wheel........................................... 6-39
Wiper........................................... 6-28
10-6
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

Index
Request Switch Inoperable Warning
Beep (With the advanced keyless
function)............................................ 7-51
Retractable hardtop warning beep..... 7-50
Rocking the Vehicle.......................... 3-52
S
Safety Defects, Reporting................. 8-14
Saving Fuel and Protection of the
Environment...................................... 3-50
Scheduled Maintenance...................... 6-4
Seat...................................................... 2-4
SeatsHead restraint........ ........................ 2-6
Seat warmer................................... 2-5
Seat Belt System Automatic locking......................... 2-9
Emergency locking........................ 2-9
Extender....................................... 2-13
Pregnant women............................ 2-9
Seat belt precautions ..................... 2-7
3-point type................................. 2-10
Seat Belt Warning Beep.................... 7-49
Seat Side Box..................................5-146
Security System Immobilizer system..................... 3-46
Theft-deterrent system................. 3-48
Specifications...................................... 9-4
Speedometer...................................... 4-12
SRS Air Bags How the SRS air bags work........ 2-34
Limitations to SRS air bag.......... 2-38
Monitoring................................... 2-44
Passenger occupant classification
system.......................................... 2-40
SRS air bag deployment
criteria.......................................... 2-37
Supplemental restraint system
components.................................. 2-32
Starting the Engine..............................4-5
Steering Wheel.................................. 3-28
Horn............................................. 4-55
Storage Compartments.................... 5-146 Back trim storage box............... 5-147
Console box............................... 5-146
Seat side box............................. 5-146
Sunvisors......................................... 5-139
T
Tachometer........................................ 4-13
Theft-Deterrent System ..................... 3-48
Tiedown Hook............................................ 7-31
Tires................................................... 6-36 Flat tire.......................................... 7-3
Replacing a tire........................... 6-38
Replacing a wheel....................... 6-39
Snow tires.................................... 3-53
Specifications.................................9-8
Tire chains................................... 3-54
Tire inflation pressure................. 6-36
Tire rotation................................. 6-37
Uniform tire quality grading system
(UTQGS)..................................... 8-23
Tire Inflation Pressure Warning
Beep...................................................7-52
Tire Information................................ 8-25
Tire Pressure Monitoring System.... 4-103
To w i n g Recreational towing.....................3-57
Trailer towing.............................. 3-57
Towing Description........................... 7-30
Traction Control System (TCS)........ 4-65 TCS/DSC indicator light............. 4-65
Transmitter.......................................... 3-4
Trip Computer................................... 4-16
Trip Meter......................................... 4-12
Trouble Battery runs out........................... 7-23
Emergency starting...................... 7-26
10-7
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

Index
Emergency towing....................... 7-30
Flat tire.......................................... 7-3
Overheating................................. 7-27
Parking in an emergency............... 7-2
When fuel-filler lid cannot be
opened..........................................7-29
When the roof cannot be
closed........................................... 7-58
When trunk lid cannot be
opened..........................................7-53
Trunk Lid.......................................... 3-19 Inside trunk release lever............ 3-21
When trunk lid cannot be
opened..........................................7-53
Turn Signals...................................... 4-49
V
Vanity Mirrors................................. 5-139
Vehicle Information Labels................. 9-2
W
Warning Lights.................................. 4-26
Warning Sound is Activated............. 7-49
Air bag/seat belt pr etensioner system
warning beep............................... 7-49
Blind Spot Monitoring (BSM)
System warning beep.................. 7-52
Ignition not switched off (STOP)
warning beep............................... 7-50
Key left-in-trunk compartment
warning beep (With the advanced
keyless function)..........................7-51
Key left-in-vehicle warning beep
(With the advanced keyless
function).......................................7-51
Key removed from vehicle warning
beep..............................................7-50
Lane Departure Warning sound... 7-52
Lights-on reminder...................... 7-49
Power steering warning buzzer....7-51
Request switch inoperable warning
beep (With the advanced keyless
function).......................................7-51
Retractable hardtop warning
beep..............................................7-50
Seat belt warning beep................ 7-49
Tire inflation pressure warning
beep..............................................7-52
Warranty............................................ 8-16
Weights................................................ 9-6
Windblocker.................................... 5-148
Windows Power windows........................... 3-32
Windshield Washer........................... 4-53
Windshield Wipers............................ 4-50
Winter Driving.................................. 3-52
Wiper
Replacing windshield wiper
blades........................................... 6-28
10-8
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27