roof MAZDA MODEL MX-5 MIATA 2018 Owner's Manual

NOTE
Moving the seats as far forward as
possible and folding the seatbacks forward
will facilitate the procedure.
Refer to Seat Operation on page 2-4.
1. Remove the antenna if it is installed.Refer to Antenna on page 5-19.
2. Insert the short end of the L-shaped hexagonal wrench (Large) into the
motor bracket bolt.
Bolt
NOTE
If it is difficult to see the bolt, remove
the windblocker and identify the bolt
from the center of the vehicle.
Windblocker
3. Turn the L-shaped hexagonal wrench
(Large) counterclockwise to loosen the
bolt slightly.
4. Remove the L-shaped hexagonalwrench (Large) once from the bolt,
then insert the long end of the wrench
into the bolt.
NOTE
The tip of the long end of the L-shaped
hexagonal wrench can be used at an
angle. Moving the wrench upward
slightly will increase the clearance
between the rear roof and the stored
front roof and facilitate the procedure.
5. Turn the L-shaped hexagonal wrench (Large) counterclockwise 13 times or
more while pressing the wrench
against the bolt.
If Trouble Arises
When the Roof Cannot be Closed
7-60
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

NOTE
The bolt cannot be removed
completely.
If it is hard to turn the bolt, repeat
Step 3 a few times.
6. Hook the wire to the link pin shown in the figure.
7. While one person pushes the rear roof
down, another person pulls the wire
until a latch sound is heard and the rear
roof unlocks.
Lock
Link Pin
Wire
Unlock
8. Do the same procedure on the other side.
9. While standing on both sides of the
vehicle, lift the rear roof to the position
it stops while keeping the height of its
left and right sides as parallel as
possible.
CAUTION
Do not let go of the rear roof on both
sides until it is fully open. The rear
roof could fall if it is released too soon
and cause injury.
 Do not attempt to forcefully lift the
rear roof. If the rear roof is forcefully
lifted without being unlocked, it
could damage vehicle parts.
 Lift the rear roof with its left and right
height as parallel as possible. If the
rear roof is lifted with the left or right
height slanted, it could deform the
link mechanism.
Closing the front roof
CAUTION
 Some steps in the procedure require
holding your body in a strained position
and if over exerted it could result in
injury.
 Do the procedure being very careful not
to get your hands and fingers caught
while closing the front roof. Otherwise,
your hands or
fingers could be injured.
 Removal of the headliner is included in
the procedure, however, never drive the
vehicle with the headliner removed.
Driving the vehicle with the headliner
removed is prohibited by law. Correctly
perform the procedure while following
the instructions.
If Trouble Arises
When the Roof Cannot be Closed
7-61
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

1. While standing on both sides of thevehicle, hold the front and rear sides of
the front roof and pull the front roof
upward.
2. Switch your hand on the rear side ofthe front roof to the front side and pull
the front roof forward.
3. Stop pulling the fr ont roof before it
completely closes.
NOTE
The next step cannot be done if the
front roof is closed completely.
4. Remove the link covers on the left and
right sides by pulling them out by
hand.
Link cover
5. Remove the fasteners and theheadliner.
6. Lightly press the front edge of thefront roof from outside of the vehicle
to close the front roof completely.
If Trouble Arises
When the Roof Cannot be Closed
7-62
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

7. Insert the short end of the hexagonalwrench (Small) into the gear (tool kit)
and assemble.
L-shaped hexagonal
wrench (Small)Gear (tool kit)
8. Insert the point of the gear (tool kit)
into the hole beside the top lock motor
gear with the hexagonal wrench
inserted into the gear tool.
Top lock motor
gear
Gear (tool kit)
CAUTION
Insert the gear (tool kit) securely until it
engages with the top lock motor gear. If
the gear (tool kit) is not inserted
securely, it may come off and be
damaged.
9. Rotate the hexagonal wrench and
move the hook in the lock direction so
that there is enough space for the
opening of the headliner to be attached
to the hook.
Unlock
Unlock
LockLock
NOTE
Turning the gear (tool kit) requires
some effort due to motor resistance.
Slowly operate the hexagonal wrench.
10. Insert the hook into the opening of the
headliner.
Hook
Headliner
If Trouble Arises
When the Roof Cannot be Closed
7-63
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

11. Turn the hexagonal wrench (Small)and gear (tool kit) counterclockwise
and engage the hook with the vehicle
body side.
NOTE
The top lock lever completely engages
with the vehicle body (locked
condition) at the position where the
teeth of the gear (tool kit) contact the
bracket.

Gear (tool kit)
Bracket
12. Lift the rear end of the headliner withit hinged on the opening of the
headliner.
13. Install the headliner to the front roofusing the fasteners at two locations.
NOTE
The fasteners in the five locations at
the front of the headliner are not
fastened. Do not lo se the fasteners
because they are needed for the
required servicing at the Authorized
Mazda Dealer.
If Trouble Arises
When the Roof Cannot be Closed
7-64
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

14. Install the left and right link covers
from the vehicle interior.
Link cover
Closing the rear roof
CAUTION
 Slowly close the rear roof. If the rear roof
is closed suddenly, a hand or other body
part may be pinched, leading to a serious
injury.
 Do not attempt to forcefully push the
rear roof. Pushing the rear roof forcefully
may damage vehicle parts.
1. Fold the rope in half and hook it to the link pin of the rear roof.
Rope Link pin
2. Do the same procedure on the other
side.
3. Close the rear roo f uniformly on both
sides using two adults, one on each
side of the vehicle.
CAUTION
Close the rear roof with its left and right
positions as parallel as possible. If the
rear roof is closed with its left or right
height slanted, it could deform the link
mechanism.
4. Slowly close the rear roof while lightly pulling the rope with one hand so that
the rope does not unhook.
Rope
NOTE
Route the rope rearward through the
clearance between the rear roof and
trunk.
5. One person pushes the rear roof down and the other person pulls the rope
strongly and straight back towards the
vehicle rear until a click sound is
heard.
Rope
If Trouble Arises
When the Roof Cannot be Closed
7-65
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

NOTE
The rear roof is locked completely if
the position where the rope is
hooked is at the rear end of the
bracket groove in the direction of the
vehicle rear, as shown in the figure,
when viewed from the vehicle
interior.
Rope
Link pin
If the rear roof is not locked
completely, the trunk will not open
even if the remote release button,the
electric trunk lid opener, or the trunk
button on the transmitter is
operated.
6. Do the same procedure on the other side.
7. Open the trunk and tie the rope to the trunk hinge.
Hinge
Rope
8. Tie off the other side rope the sameway.
9. Close the trunk lid.
After finishing the procedure
After finishing the procedure, have the
roof checked at an Authorized Mazda
Dealer as soon as possible.
WA R N I N G
Drive the vehicle at a speed of 40 km/h (24
mph) or lower before having the roof
checked at an Authorized Mazda Dealer:
The front roof may open while the vehicle is
being driven and cause an accident.
If Trouble Arises
When the Roof Cannot be Closed
7-66
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

▼Glossary of Terms
Tire Placard:
A label indicating the OE tire sizes, recommended inflation pressure, and the
maximum weight the vehicle can carry.
Tire Identification Number (TIN): A number on the sidewall of each tire providing
information about the tire brand and manufacturing plant, tire size, and date of manufacture.
Inflation Pressure: A measure of the amount of air in a tire.
kPa: Kilopascal, the metric u nit for air pressure.
psi: Pounds per square inch, the English unit for air pressure.
B-pillar: The structural member at the side of the vehicle behind the front door.
Original Equipment (OE): Describes components originally equipped on the vehicle.
Vehicle Load Limit: The maximum value of the combination weight of occupants and
cargo.
Bead Area of the Tire: Area of the tire next to the rim.
Sidewall Area of the Tire: Area between the bead area and the tread.
Tread Area of the Tire: Area on the perimeter of the t ire that contacts the road when it's
mounted on the vehicle.

Seating capacity means the total allowable numbe r of vehicle occupants. Seating capacity
is described on the tire label.

Production options weight is the combination weight of installed regular production
options weighing over 2.3 kilograms in excess of the standard i tems which they replace, and
not previously considered in the curb weight or accessory weigh t, including heavy duty
brakes, ride levelers, roof rack, heavy duty battery, and speci al trim.

Rim is the metal support (wheel) for a tire or a tire and tube ass embly upon which the tire
beads are seated.
Customer Information and Reporting Safety Defects
Tire Information (U.S.A.)
8-33
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

Index
Emergency TowingTiedown hooks......... ................... 7-31
Towing description...................... 7-30
Emission Control System..................3-24
Ending Screen Display......................4-69
Engine Coolant.........................................6-24
Engine compartment overview.... 6-21
Exhaust gas.................................. 3-25
Hood release............................ .... 6-19
Oil................................................ 6-22
Starting...........................................4-5
Engine Coolant Temperature
Gauge................................................ 4-13
Essential Information.......................... 6-2
Event Data Recorder......................... 8-21
Exhaust Gas...................................... 3-25
Exterior Care..................................... 6-54 Aluminum wheel maintenance.... 6-59
Bright-metal maint enance........... 6-58
Convertible Top (Retractable
Hardtop) Maintenance................. 6-61
Convertible Top (Soft Top)
Maintenance.................................6-59
Maintaining the finish................. 6-55
Plastic part maintenance.............. 6-63
F
Flasher Hazard warning........................... 4-55
Headlights.................................... 4-44
Flat Tire............................................... 7-3 Mounting the tire.... ..................... 7-20
Removing a tire........................... 7-17
Floor Mat.......................................... 3-51
Fluid Brake/Clutch................................ 6-26
Washer......................................... 6-26
Fluids Classification................................. 9-4
Foot Brake.........................................4-60
Forward Sensing Camera (FSC)....... 4-94
FuelFiller lid and cap......................... 3-26
Gauge........................................... 4-14
Requirements............................... 3-23
Tank capacity.................................9-5
Fuel Consumption Display............... 4-69
Fuel Economy Monitor..................... 4-68 Ending screen display................. 4-69
Fuel consumption display............4-69
Fuel-Filler Lid When fuel-filler lid cannot be
opened..........................................7-29
Fuses.................................................. 6-49 Panel description......................... 6-51
Replacement................................ 6-49
G
Gauges............................................... 4-11
H
Hardtop.............................................. 3-40
When the roof cannot be
closed........................................... 7-58
Hazardous Driving............................ 3-51
Hazard Warning Flasher....................4-55
Headlights Coming home light......................4-47
Control......................................... 4-44
Flashing....................................... 4-47
High-low beam............................ 4-47
Leaving home light..................... 4-48
Leveling....................................... 4-48
Head Restraint..................................... 2-6
High Beam Control System
(HBC)................................................ 4-76 High Beam Control System (HBC)
indicator light (green)..................4-77
Hill Launch Assist (HL A)................ 4-62
10-4
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27

Index
Emergency towing....................... 7-30
Flat tire.......................................... 7-3
Overheating................................. 7-27
Parking in an emergency............... 7-2
When fuel-filler lid cannot be
opened..........................................7-29
When the roof cannot be
closed........................................... 7-58
When trunk lid cannot be
opened..........................................7-53
Trunk Lid.......................................... 3-19 Inside trunk release lever............ 3-21
When trunk lid cannot be
opened..........................................7-53
Turn Signals...................................... 4-49
V
Vanity Mirrors................................. 5-139
Vehicle Information Labels................. 9-2
W
Warning Lights.................................. 4-26
Warning Sound is Activated............. 7-49
Air bag/seat belt pr etensioner system
warning beep............................... 7-49
Blind Spot Monitoring (BSM)
System warning beep.................. 7-52
Ignition not switched off (STOP)
warning beep............................... 7-50
Key left-in-trunk compartment
warning beep (With the advanced
keyless function)..........................7-51
Key left-in-vehicle warning beep
(With the advanced keyless
function).......................................7-51
Key removed from vehicle warning
beep..............................................7-50
Lane Departure Warning sound... 7-52
Lights-on reminder...................... 7-49
Power steering warning buzzer....7-51
Request switch inoperable warning
beep (With the advanced keyless
function).......................................7-51
Retractable hardtop warning
beep..............................................7-50
Seat belt warning beep................ 7-49
Tire inflation pressure warning
beep..............................................7-52
Warranty............................................ 8-16
Weights................................................ 9-6
Windblocker.................................... 5-148
Windows Power windows........................... 3-32
Windshield Washer........................... 4-53
Windshield Wipers............................ 4-50
Winter Driving.................................. 3-52
Wiper
Replacing windshield wiper
blades........................................... 6-28
10-8
MX-5_8GF7-EA-17J_Edition2 2017-10-31 14:07:27