service MAZDA MODEL TRIBUTE 2009 (in English) Repair Manual

These temporary malfunctions can be corrected by filling the fuel tank
with good quality fuel, properly closing the fuel fill inlet or letting the
electrical system dry out. After three driving cycles without these or any
other temporary malfunctions present, theService engine soon
indicator should stay off the next time the engine is started. A driving
cycle consists of a cold engine startup followed by mixed city/highway
driving. No additional vehicle service is required.
If theService engine soon
indicator remains on, have your vehicle
serviced at the first available opportunity. Although some malfunctions
detected by the OBD-II may not have symptoms that are apparent,
continued driving with the Service engine soon
indicator on can
result in increased emissions, lower fuel economy, reduced engine and
transmission smoothness, and lead to more costly repairs.
Readiness for Inspection/Maintenance (I/M) testing
Some state/provincial and local governments may have
Inspection/Maintenance (I/M) programs to inspect the emission control
equipment on your vehicle. Failure to pass this inspection could prevent
you from getting a vehicle registration. Your vehicle may not pass the I/M
test if the Service engine soon
indicator is on or not working
properly (bulb is burned out), or if the OBD-II system has determined
that some of the emission control systems have not been properly
checked. In this case, the vehicle is considered not ready for I/M testing.
If the Service engine soon
indicator is on or the bulb does not
work, the vehicle may need to be serviced. Refer to the On board
diagnostics (OBD-II) description in this chapter.
If the vehicle’s engine or transmission has just been serviced, or the
battery has recently run down or been replaced, the OBD-II system may
indicate that the vehicle is not ready for I/M testing. To determine if the
vehicle is ready for I/M testing, turn the ignition key to the on position
for 15 seconds without cranking the engine. If the Service engine
soon
indicator blinks eight times, it means that the vehicle is not
ready for I/M testing; if the Service engine soon
indicator stays on
solid, it means that the vehicle is ready for I/M testing.
The OBD-II system is designed to check the emission control system
during normal driving. A complete check may take several days. If the
vehicle is not ready for I/M testing, the following driving cycle consisting
of mixed city and highway driving may be performed:
15 minutes of steady driving on an expressway/highway followed by
20 minutes of stop-and-go driving with at least four 30-second idle
periods.
2009 Tribute (j14)
Owners Guide, 1st Printing
USA (fus)
Maintenance and Specifications
288

Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete. If
the vehicle is still not ready for I/M testing, the above driving cycle will
have to be repeated.
BRAKE/CLUTCH FLUID
Brake and clutch systems are supplied from the same reservoir.
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the “MIN” and
“MAX” lines are within the normal
operating range; there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range the performance of the
system could be compromised; seek
service from your authorized dealer
immediately.
TRANSMISSION FLUID
Checking automatic transmission fluid
Refer to your scheduled maintenance section for scheduled intervals for
fluid checks and changes. Your transmission does not consume fluid.
However, the fluid level should be checked if the transmission is not
working properly, i.e., if the transmission slips or shifts slowly or if you
notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal, start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
2009 Tribute (j14)
Owners Guide, 1st Printing
USA (fus)
Maintenance and Specifications
289

MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES
ItemApplicationMazda part name or
equivalent Capacity
Brake fluid and (clutch fluid–if equipped) AllHigh Performance DOT 3
Motor Vehicle Brake Fluid Between MIN and MAX
on reservoir
Engine coolant 2.5L engine
Mazda yellow-colored
Premium Engine Coolant
1
7.4 quarts (7.0L)
3.0L engine 9.5 quarts (9.0L)
Engine oil (including filter change) 2.5L engine
SAE 5W-20 Motor Oil 5.0 quarts (4.73 L)
3.0L engine 6.0 quarts (5.7L)
Transfer case fluid 4WD with
automatic
transmission API service GL-5
SAE 75W-140 Synthetic Lubricant 12 ounces (0.35L)
4WD with manual transmission API service GL-5
SAE 80W-90
Manual transmission fluid Manual
transmission API service GL-4
SAE 75W-90 2.4 quarts (2.3L)
2
Automatic transmission
fluid Automatic
transmission MERCON
LV AT F
3
9 quarts (8.5L)
4
Rear axle fluid 4WDSAE 80W-90 Axle
Lubricant 2.4 pints (1.15L)
5
Windshield washer fluid All Ultra-Clear Windshield
Washer Concentrate 4.8 quarts (4.5L)
2009 Tribute
(j14)
Owners Guide, 1st Printing
USA (fus)
Maintenance and Specifications
293

ItemApplicationMazda part name or
equivalent Capacity
Fuel tank All—16.5 gallons (62.5L)
1Add the coolant type originally equipped in your vehicle. Do not mix different colors or types of
coolant. Do not use Mazda Extended Life Engine Coolant (orange in color). Refer to Adding
engine coolant in this chapter.2Service refill capacity is determined by filling the transmission to the bottom of the filler hole with
the vehicle on a level surface.3Automatic transmissions that require MERCON LV should only use MERCON LV fluid. Refer to
scheduled maintenance to determine the correct service interval. Use of any fluid other than the
recommended fluid may cause transmission damage.4Indicates only approximate dry-fill capacity. Some applications may vary based on cooler size and
if equipped with an in-tank cooler. The amount of transmission fluid and fluid level should be set
by the indication on the dipstick’s normal operating range.5Fill from 1/4 inch to 9/16 inch (6mm to 14mm) below bottom of fill hole.
2009 Tribute (j14)
Owners Guide, 1st Printing
USA (fus)
Maintenance and Specifications
294

CELL PHONES
Use of cell phones and other devices by driver:
WARNING:Use of any electrical devices such as cell phones,
computers, portable radios, vehicle navigation or other devices
by the driver while the vehicle is moving is dangerous. Dialing a
number on a cell phone while driving also ties-up the driver’s hands.
Use of these devices will cause the driver to be distracted and could
lead to a serious accident. If a passenger is unable to use the device,
pull off the right-of-way to a safe area before use. If use of a cell phone
is necessary despite this warning, use a hands-free system to at least
allow the hands free to drive the vehicle. Never use a cell phone or
other electrical device while the vehicle is moving and, instead,
concentrate on the full-time job of driving.
In addition, the gasoline distributors are warning against using cell
phones during refueling procedures, due to their increased concern
about static electricity fires in the self-service pump environment.
2009 Tribute (j14)
Owners Guide, 1st Printing
USA (fus)
Accessories
298

Cleaning your vehicleengine compartment ..............248
instrument panel ....................250
interior .....................................251
Mazda car care products .......252
plastic parts ............................249
washing ....................................247
waxing .....................................247
wheels ......................................248
wiper blades ............................250
Climate control (see Air
conditioning or Heating) ............36
Clock ............................................19
Clutch fluid ..........................................289
operation while driving ..........198
recommended shift speeds ....199
Console ........................................52 overhead ....................................51
Controls power seat .................................86
Coolant checking and adding ..............271
refill capacities ................275, 293
specifications ..........................293
Cruise control .............................57
Cruise control
(see Speed control) ....................57
Customer
Assistance ..................236–237, 240
D
Daytime running lamps
(see Lamps) ................................40
Dipstick automatic transmission
fluid ..........................................289
engine oil .................................265 Driving under special
conditions ..................197, 201, 204
sand .........................................203
snow and ice ...........................205
through water .................203, 206
E
Electronic stability control ......187
Emergencies, roadside jump-starting ..........................228
running out of fuel .........228, 281
Emergency Flashers .................207
Emission control system ..........286
Engine ........................................295 cleaning ...................................248
coolant .....................................271
fail-safe cooling .......................276
idle speed control ...................269
lubrication specifications .......293
refill capacities ........................293
service points ..................261–262
starting after a collision .........207
Engine block heater .................182
Engine oil ..................................265 checking and adding ..............265
dipstick ....................................265
filter, specifications ................268
recommendations ...................268
refill capacities ........................293
specifications ..........................293
Event data recording ....................6
Exhaust fumes ..........................181
F
Fail safe cooling ........................276
Fluid capacities .........................293
Foglamps .....................................39
2009 Tribute (j14)
Owners Guide, 1st Printing
USA (fus)
Index
300