transmission MERCEDES-BENZ C230 KOMPRESSOR 2003 W203 Owner's Guide
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2003, Model line: C230 KOMPRESSOR, Model: MERCEDES-BENZ C230 KOMPRESSOR 2003 W203Pages: 376, PDF Size: 5.97 MB
Page 307 of 376
307 Practical hints
Jump starting
The battery is located in the engine
compartment on the right hand side. The
terminals for jump starting are located in
front of the battery.
Make sure that the two vehicles do not
touch.
Turn off all electrical consumers.
Apply parking brake.
Shift selector lever to positionP (man-
ual transmission to Neutral).1Positive terminal of charged battery
2Positive under hood terminal in front of
discharged battery
3Negative terminal of charged battery
4Negative under hood terminal in front
of discharged battery
Connect positive terminal1 of the
charged battery with the under hood
terminal2 in front of the discharged
battery with the jumper cables. Clamp
cable to charged battery1 first.
Start engine of the vehicle with the
charged battery and run at idle speed.
Connect negative terminal3 of the
charged battery with the under hood
terminal4 of the discharged battery
with the jumper cables. Clamp cable to
charged battery3 first.
Start the engine of the disabled vehi-
cle.
Now you can again turn on the electrical
consumers. Do not turn on the lights under
any circumstances.
Remove the jumper cables first from
negative terminals3 and4 and then
from positive terminals1 and2.
Have the battery checked at the near-
est authorized Mercedes-Benz Center.
Warning!
G
Keep flames or sparks away from battery.
Do not smoke.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 240).
!Vehicles with automatic transmission
and/or 4MATIC*:
Do not tow-start the vehicle.
Page 308 of 376
308 Practical hintsTowing the vehicle
Towing the vehicleMercedes-Benz recommends that the
vehicle be transported with all wheels off
the ground using flatbed or appropriate
wheel lift/dolly equipment. This method is
preferable to other types of towing.When circumstances do not permit the
recommended towing methods, the
vehicle may be towed with all wheels on
the ground or front wheels raised (except
vehicles with 4MATIC*) only so far as
necessary to have the vehicle moved to a
safe location where the recommended
towing methods can be employed.
!Use flatbed or wheel lift/dolly equip-
ment with key in starter switch turned
to position0.
Do not tow with sling-type equipment.
Towing with sling-type equipment over
bumpy roads will damage radiator and
supports.
To prevent damage during transport,
do not tie down vehicle by its chassis or
suspension parts.
Switch off the tow-away alarm
(page 80) and deactivate the auto-
matic central locking (
page 129).
!Vehicles with automatic transmission
and/or 4MATIC*:
Do not tow-start the vehicle.!Vehicles with 4MATIC*:
Do not tow with one axle raised. Doing
so could damage the transfer case,
which is not covered by the
Mercedes-Benz Limited Warranty.
All wheels must be on or off the ground.
Observe instructions for towing the
vehicle with all wheels on the ground.
!If the vehicle is towed with the front
axle raised (not permissible for vehicles
with 4MATIC*), the engine must be
shut off (key in starter switch
position0 or1). Otherwise the ESP will
immediately be engaged and will apply
the rear wheel brakes.
When towing the vehicle with all wheels
on the ground, the selector lever must
be in positionN (manual transmission:
gears disengaged) and the key must be
in starter switch position2.
When towing the vehicle with all wheels
on the ground or the front axle raised,
the vehicle may be towed only for
distances up to 30 miles (50 km) and
at a speed not to exceed 30 mph
(50 km/h).
Page 329 of 376
329 Technical data
Fuels, coolants, lubricants etc.
Fuels, coolants, lubricants etc.
Capacities
Vehicle components and their respective
lubricants must match. Therefore use only brands tested and
recommended by Mercedes-Benz. Please refer to the Factory Approved
Service Products pamphlet, or inquire at
your Mercedes-Benz Center.
Model
Capacity
Fuels, coolants, lubricants etc.
Engine with oil filter
C 230 Kompressor Sport
C240
C320
C320Sport
C2404MATIC
C3204MATIC
C3204MATICSport
C32AMG
5.8 US qt (5.5 l)
7.9 US qt (7.5 l)
7.9 US qt (7.5 l)
7.9 US qt (7.5 l)
7.4 US qt (7.0 l)
7.4 US qt (7.0 l)
7.4 US qt (7.0 l)
8.5 US qt (8.0 l)
Recommended engine oils
Automatic transmission
8.5 US qt (8.0 l)
MB Automatic Transmission Oil
1
1MB part no. 001 989 21 03 10Manual transmission
1.3 US qt (1.2 l)
MB Manual Transmission Oil
2
2MB part no. 001 989 26 03 10Rear axle
C 230 Kompressor Sport
C 240 (all models)
C 320 (all models)
C32AMG
1.2 US qt (1.1 l)
1.2 US qt (1.1 l)
1.2 US qt (1.1 l)
1.5 US qt (1.4 l)
Hypoid gear oil SAE 85 W 90
Page 330 of 376
330 Technical dataFuels, coolants, lubricants etc.
Model
Capacity
Fuels, coolants, lubricants etc.
Front axle
C2404MATIC
C3204MATIC
C3204MATICSport
0.5 US qt (0.46 l)
Hypoid gear oil SAE 85 W 90
Transfer case
C2404MATIC
C3204MATIC
C3204MATICSport
approx. 0.62 US qt (0.59 l)
MB Automatic Transmission Oil
1
Power steering
approx. 1.1 US qt (1.0 l)
MB Power Steering Fluid (Pentosin CHF 11S)
Front wheel hubs
approx. 2.1oz (60g) each
High temperature roller bearing grease
Brake system
0.5 US qt (0.5 l)
MB Brake Fluid (DOT 4+)
Cooling system
C 230 Kompressor Sport
C240 (all models)
C320 (all models)
C32AMG
approx. 8.5 US qt (8.0 l)
approx. 6.8 US qt (6.4 l)
approx. 6.8 US qt (6.4 l)
approx. 15.3 US qt (14.5 l)
MB 325.0 Anticorrosion / antifreeze agent
Fuel tank
including a reserve of
16.4 US gal (62.0 l)
2.1 US gal (8.0 l)
Premium unleaded gasoline:
Posted Octane 91 (Avg. of 96 RON / 86 MON)Flexible Fuel Vehicle (MY 2003 Mercedes-Benz
C 320 models, except those equipped with
manual transmission or 4MATIC*):
Alternative fuel -- Ethanol fuel (E85)
1MB part no. 001 989 21 03 10
Page 342 of 376
342 Technical termsCOMAND*
(C
ockpit M
anagement and D
ata
System)
Information and operating center for
vehicle sound and communications
systems, including the radio and navi-
gation system, as well as for other
optional equipment (CD changer,
telephone, etc.).
Control system
The control system is used to call up
vehicle information and to change
component settings. Information and
messages appear in the multifunction
display. The driver uses the buttons on
the multifunction steering wheel to
navigate through the system and to ad-
just settings.
Cruise control
Driving convenience system for auto-
matically maintaining the vehicle speed
set by the driver.Engine number
The number set by the manufacturer
and placed on the cylinder block to
uniquely identify each engine pro-
duced.
Engine oil viscosity
Measurement for the inner friction (vis-
cosity) of the oil at different tempera-
tures. The higher the temperature an
oil can tolerate without becoming thin,
or the lower the temperature it can tol-
erate without becoming viscous, the
better the viscosity.
ESP
(E
lectronic S
tability Pr
ogram)
Improves vehicle handling and direc-
tional stability.
ETD
(E
mergency T
ensioning D
evice)
Device which deploys in certain frontal
and rear collisions exceeding the sys-
tem's threshold to tighten the seat
belts.
->SRSFSS
(F
lexible S
ervice S
ystem)
Service indicator in the multifunction
display that informs the driver when
the next vehicle maintenance service is
due.
Gear range
Number of gears which are available to
the automatic transmission for shifting.
The automatic gear shifting process
can be adapted to specific operating
conditions using the selector lever.
GPS
(G
lobal P
ositioning S
ystem)
Satellite-based system for relaying
geographic location information to and
from vehicles equipped with special re-
ceivers. Employs CD digital maps for
navigation.
Instrument cluster
The displays and indicator/warning
lamps in the driver’s field of vision, in-
cluding the tachometer, speedometer
and fuel gauge.
Page 344 of 376
344 Technical termsPoly-V-belt drive
Drives engine-components (alternator,
AC compressor, etc.) from the engine.
Power train
Collective term designating all compo-
nents used to generate and transmit
motive power to the drive axles, includ-
ing
engine
clutch/torque converter
transmission
transfer case*
drive shaft
axle shafts/axles
Program mode selector switch
Used to switch the automatic transmis-
sion between standard operationS and
winter operationW.Remote Vehicle Diagnostics
Transmission of vehicle data and cur-
rent location to the Mercedes-Benz
Customer Assistance Center for sub-
scribers to Tele Aid service.
Restraint systems
Seat belts, belt tensioners, airbags and
child restraint systems. As indepen-
dent systems, their protective func-
tions complement one another.
RON
(R
esearch O
ctane N
umber)
The Research Octane Number for gaso-
line as determined by a standardized
method. It is an indication of a gaso-
line's ability to resist undesired detona-
tion (knocking). The average of both
the ->MON (Motor Octane Number)
and RON (Research Octane Number) is
posted at the pump, also known as
ANTI-KNOCK INDEX.Shift lock
When the vehicle is parked, this lock
prevents the transmission selector le-
ver from being moved out of positionP
without key turned and brake pedal
depressed.
SRS
(S
upplemental R
estraint S
ystem)
Seat belts, emergency tensioning de-
vice and airbags. Though independent
systems, they are closely interfaced to
provide effective occupant protection.
Page 347 of 376
347 Index
A
ABS 23, 73, 341
ABS control 74
Malfunction indicator lamp 257
Messages in display 262
Warning lamp 257
Accelerator position, automatic
transmission 143
Accident
In case of 50
Activating
Air conditioning (cooling) 154, 163
Air recirculation mode 152, 160
Anti-theft alarm system 79
Automatic climate control* 157
Central locking (control system) 129
Charcoal filter 161
Climate control 149
Climate control system 153
Defrosting 151
Easy-entry/exit feature* 129
ESP 77
Exterior headlamps 47
Exterior lamps 102
Exterior rear view mirror
parking position* 145Hazard warning flasher 104
Headlamps 47
High beams 104
Ignition 31
Immobilizer 53, 79
Rear fog lamp 102
Rear window defroster 153, 162
Residual heat 163
Seat heater* 97
Tow-away alarm 80
Windshield wipers 48
Adding
Coolant 239
Engine oil 237
Additional turn signals 290
Adjustable air vents, rear passenger
compartment 155, 164
Adjusting 32
Air distribution 151, 159
Air volume 151, 159
Backrest tilt 33, 35
Exterior rear view mirror 39
Head restraint height 33, 35, 37
Head restraint tilt 34, 35, 36
Head restraints 36
Inside rear view mirror 39Instrument cluster illumination 107
Manual seat 33
Mirrors 39
Multicontour seat* 96
Power seat* 34
Rear seat head restraints 35
Seat belt height 43
Seat cushion depth 96
Seat cushion tilt 33, 35
Seat fore and aft adjustment 33, 34
Seat height 33, 35
Seats 32, 33
Steering column height 37, 38
Steering column length 37, 38
Steering wheel 37
Air conditioner (cooling)
Turning off 154, 163
Turning on 154, 163
Air conditioning refrigerant 332
Air distribution
Adjusting 151, 159
Air pressure
see Tire inflation pressure 243
Air recirculation mode 152, 160
Activating 152, 160
Deactivating 152, 161
Page 348 of 376
348 IndexAir vents, rear passenger compartment
Adjustable 155, 164
Air volume
Adjusting 151, 159
AIRBAG OFF indicator lamp 260
Airbags 57
BabySmart
TM deactivation
system 67, 341
Children 58
Front 60
Passenger 61
Safety guidelines 59
Side impact 61
Window curtain 61
Alarm
Audible 72, 80
Canceling 80
Visual 79
Alarm system
Anti-theft 79
Tow-away 80
Alignment bolt (vehicle tool kit) 299, 341
Anticorrosion/antifreeze 337
Antiglare
Automatic* 144
Manual 144Antilock brake system (ABS) 341
Anti-theft alarm system
Arming 79
Canceling alarm 80
Disarming 80
Anti-theft systems 79
Anti-theft alarm system 79
Immobilizer 79
Tow-away alarm 80
Aquaplaning see Hydroplaning 227
Armrest
Storage compartment in front of 205
Storage spaces 206
Ashtray 207
ATF (automatic transmission fluid) 238
AUDIO menu 116
Selecting radio station 117
Audio system 165
Audio and telephone, operation 165
Button and soft key operation 168
Cassette mode 174
CD mode 178
Operating and display elements 166
Operating safety 165
Operation 168
Radio mode 171Switching off 168
Switching on 168
Telephone operation 182
Automatic antiglare*
for rear view mirror 144
Automatic central locking
Activating/deactivating
(control system) 129
Automatic climate control* 156
Activating 157
Adjusting air distribution 159
Adjusting air volume 159
Air recirculation mode 160
Deactivating 157
Defrosting 160
Rear window defroster 153, 162
Residual heat utilization 163
Residual ventilation 163
Setting the temperature 158
Automatic headlamp mode 102
Automatic lighting control
Activating 105
Deactivating 105
Automatic locking when driving 91
Page 349 of 376
349 Index
Automatic transmission 138
Accelerator position 143
Emergency operation
(Limp Home Mode) 143
Fluid level 238
Gear ranges 140
Gear selector lever position 141
Gear shifting malfunctions 143
Kickdown 143
Manual shifting 139
One-touch gearshifting 139
Program mode selector switch 142
Selector lever position 138
Starting with 44
Transmission fluid 238
Winter program mode 142
Auxiliary fuse box 313
B
BabySmart
TM
Airbag deactivation system 67, 341
Compatible child seats 67, 341
Self-test 67
Backrest
Folding forward 200
Folding rearward 200
Backrest tilt 33Backup lamps 291, 295
Bulbs 291
BAS 74, 341
Messages in display 263
Batteries, SmartKey
Changing 286, 287
Check lamp 85
Checking 86
Battery discharged
Jump starting 306
Battery, vehicle 240, 303
Charging 304
Disconnecting 304
Messages in display 278
Reconnecting 305
Reinstalling 304
Removing 304
Bi-Xenon headlamps* 341
Bi-Xenon type*
Front lamp bulbs 293
Block heater 246
Blocking
Rear door window operation 71
Bolts
For Minispare wheel 284
For spare wheel 282Brake assist system (BAS) 341
Brake fluid 332
Checking 234
Brake lamp bulbs 291
Brake lamp, high mounted 291
Brake pads
Message in display 265
Brakes 224
Warning lamp 258
Break-in period 222
Bulbs, replacing 290
Additional turn signals 290
Backup lamps 291
Brake lamps 291
Fog lamps 290
Front lamps 290
High beam 290
High mounted brake lamp 291
License plate lamps 291, 295
Low beam 290
Parking lamps 290, 291, 293, 294
Rear fog lamp 291, 295
Side marker lamps 290, 294
Standing lamps 290, 291, 293, 294
Tail lamp assemblies 291, 295
Turn signal lamps 290, 291
Page 353 of 376
353 Index
Driving
Driving abroad 230
General instructions 41, 223
Hydroplaning 227
In winter 228
Problems 49
Safety systems 73
Through standing water 229
Driving abroad 230
Driving instructions 223
Driving off 225
Driving safety systems
4MATIC 78
ABS 73
BAS 74
ESP 75
Driving systems 193
Cruise control 193
Driving safety systems 73
E
Easy-entry/exit feature* 93
Activating 129
Interrupting movement 93, 130
Electrical fuses 312
Electrical system
Technical data 326Electronic Stability Program
see ESP 23, 75, 342
Emergency call system* 210
Emergency calls
Initiating an emergency call 212
Telephone* 185
With Tele Aid* 211
Emergency operation
(Limp Home Mode) 143
Emergency operations
Closing sliding/pop-up roof* 289
Locking the vehicle 286
Opening sliding/pop-up roof* 289
Releasing trunk lid from inside 89
Remote door unlock 216
Unlocking the vehicle 285
Emergency tensioning device
see ETD 64, 342
Emission control 231
Emission control label 318
Ending
A call (telephone) 135
Engine 320
Compartment 235
Message in display 259Starting with automatic
transmission 44
Starting with manual
transmission 44
Starting with the key 44
Turning off with the key 53
Engine cleaning 250
Engine compartment 235
Fuse box in 312
Hood 235
Engine malfunction indicator
lamp 23, 259
Engine number 342
Engine oil 236, 332
Adding 237
Additives 332
Checking level 236
Consumption 236
Display messages 270
Filler neck 237
Messages in display 238, 270
Viscosity 342
Engine oil level see Oil level 234
ESP 23, 75, 342
Four wheel electronic traction
system with ESP 78