coolant reservoir MERCEDES-BENZ C240 2005 W203 Owner's Manual

277 Operation
At the gas station
Check regularly and before a long trip
1Coolant
2Brake fluid (fuse box cover removed)
3Windshield washer and headlamp
cleaning system*Coolant
For normal replenishing, use water (pota-
ble water quality). For more information,
see “Coolant level” (
page 283) and see
“Fuels, coolants, lubricants, etc.”
(
page 387).
Brake fluid
Removing fuse box cover (
page 370).Windshield washer and headlamp
cleaning system*
For more information on filling up the
washer reservoir, see “Windshield washer
system and headlamp cleaning system*”
(
page 285).
Engine oil level
For more information on engine oil level,
see “Engine oil” (
page 279).
Vehicle lighting
Check function and cleanliness. For more
information on replacing light bulbs, see
“Replacing bulbs” (page 344).
Exterior lamp switch (page 109).
Tire inflation pressure
More information on tire inflation pressure
(
page 287).
iOpening the hood, see (
page 278).
!If you find that the brake fluid in the
brake fluid reservoir has fallen to the
minimum mark or below, have the
brake system checked for brake pad
thickness and leaks immediately.
Notify an authorized Mercedes-Benz
Center immediately. Do not add brake
fluid as this will not solve the problem.
For more information, see “Practical
hints” (
page 303).

283 Operation
Engine compartment
Coolant level
The engine coolant is a mixture of water
and anticorrosion/antifreeze. To check
the coolant level, the vehicle must be
parked on level ground and the engine
must be cool.
The coolant expansion tank is located on
the passenger side of the engine compart-
ment.
1Coolant expansion tank
2Cap

Using a rag, turn cap2 slowly approx-
imately one half turn to the left to
release any excess pressure.

Continue turning the cap to the left and
remove it.
The coolant level is correct if the level

for cold coolant: reaches the black
top part of the reservoir


for warm coolant: is approx. 0.6 in
(1.5 cm) higher

Add coolant as required.

Replace and tighten cap.
For more information on coolant, see
“Coolants” (
page 394).
Warning!
G
In order to avoid any possibly serious burns:

Use extreme caution when opening the
hood if there are any signs of steam or
coolant leaking from the cooling system,
or if the coolant temperature gauge indi-
cates that the coolant is overheated.


Do not remove pressure cap on coolant
reservoir if coolant temperature is
above 158°F (70°C). Allow engine to
cool down before removing cap. The
coolant reservoir contains hot fluid and
is under pressure.


Using a rag, slowly open the cap
approximately
1/2 turn to relieve excess
pressure. If opened immediately, scald-
ing hot fluid and steam will be blown out
under pressure.


Do not spill antifreeze on hot engine
parts. Antifreeze contains ethylene
glycol which may burn if it comes into
contact with hot engine parts.

396 Technical dataFuels, coolants, lubricants, etc.Windshield washer and headlamp cleaning system*
Both the windshield washer and headlamp
cleaning system* are supplied from the
windshield washer fluid reservoir.
The washer fluid reservoir has a capacity of
approx.:

3.2 US qt (3.0 l) in vehicles without
headlamp cleaning system*


6.4 US qt (6.0 l) in vehicles with
headlamp cleaning system*

Refill the reservoir with MB Windshield
Washer Concentrate “S” and water
(or concentrate and commercially
available premixed windshield washer
solvent/antifreeze, depending on
ambient temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point, use
MB Windshield Washer Concentrate “S”
and water:


1 part “S” to 100 parts water
(1.34floz [40ml]“S” to 1gallon [4.0l]
water)
For temperatures below freezing point, use
MB Windshield Washer Concentrate “S”
and commercially available premixed
windshield washer solvent/antifreeze:


1 part “S” to 100 parts solvent
(1.34floz [40ml]“S” to 1gallon [4.0l]
solvent)
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You could be seriously burned.

410 IndexCharging
Vehicle battery 361
Checking
Brake fluid 277
Coolant level 277, 283
Engine oil level 277, 280
Tire inflation pressure 277
Vehicle lighting 277
Washer reservoir level 277
Child safety 67
Air bags 60
Infant and child restraint
systems 64, 67
LATCH-type child seat anchors 73
Child safety switch see
Blocking of rear door window operation
Child seat anchors see
LATCH-type child seat anchors
Cigarette lighter 246
Cleaning
Cloth upholstery 300
Cup holders 299
Gear selector lever 299Hard plastic trim items 299
Headlamps 168
Headliner and shelf below
rear window 299
Instrument cluster 298
Leather upholstery 299
Light alloy wheels 298
MB Tex upholstery 300
Plastic and rubber parts 300
Seat belts 299
Steering wheel 299
Upholstery 299
Windows 298
Windshield 52
Wiper blades 298
Wood trims 300
Climate control 174
Clock 25, 121, 137, 138
Closing
Cup holder, in rear seat armrest 245
Glove box 241
Hood 279Tilt/sliding sunroof* 227
Tilt/sliding sunroof*
in an emergency 341
Tilt/sliding sunroof*
with SmartKey 229
Trunk lid 94
Windows 223, 224
Windows with SmartKey 225
Cloth upholstery
Cleaning 300
Cockpit 22, 399
Cockpit Management and
Data System see COMAND*
Collapsible tire 383
Collapsible tire (C 55 AMG only) 334
Collapsible wheel chock 332
COMAND* 400
COMAND* see separate
operating instructions
Combination switch 113
High beam flasher 50
Turn signals 50
Windshield wipers 51