torque MERCEDES-BENZ CLK320 COUPE 2003 C209 Owner's Manual
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2003, Model line: CLK320 COUPE, Model: MERCEDES-BENZ CLK320 COUPE 2003 C209Pages: 394, PDF Size: 6.6 MB
Page 263 of 394
263 Operation
Tires and wheels
Rotating wheels
On vehicles with the same wheel size all
around, wheels can be rotated every 3000
to 6000 miles (5000 to 10000 km), or
sooner if necessary, according to the de-
gree of tire wear. The same direction of tire
rotation must be retained.
Rotate the wheels before the characteris-
tic tire wear pattern becomes visible
(shoulder wear on front wheels and tread
center wear on rear wheels).
Thoroughly clean the inner side of the
wheels after each rotation. Check and en-
sure proper tire inflation pressure.Warning!
G
Rotate front and rear wheels only if they are
of the same size.
Warning!
G
Have the tightening torque checked after
changing a wheel. Wheels could become
loose if not tightened with a torque of
80 ft.lb. (110 Nm).
Only use genuine Mercedes-Benz wheel
bolts specified for your vehicle's rims.
Page 328 of 394
328 Practical hintsFlat tireLowering the vehicle
Lower vehicle by turning crank coun-
terclockwise until the full weight of the
vehicle is resting on the ground.
Remove the jack.
1-5 Wheel bolts
Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of 80 ft lb
(110 Nm).
Before storing the jack in the trunk, it
should be fully collapsed, with handle
folded in.Warning!
G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
80 ft lb (110 Nm).
Page 344 of 394
344 Technical dataEngine
EngineModel
CLK 320 (209.365
1)
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equipment.
CLK 500 (209.375
1)
CLK 55 AMG (209.376)
1
Engine
112
113
113
Mode of operation
4-stroke engine, gasoline injec-
tion
4-stroke engine, gasoline injec-
tion
4-stroke engine, gasoline injec-
tion
No. of cylinders
6
8
8
Bore
3.54 in (89.90 mm)
3.82 in (97.00 mm)
3.82 in (97.00 mm)
Stroke
3.31 in (84.00 mm)
3.31 in (84.00 mm)
3.60 in (92.00 mm)
Total piston displacement
195.2 cu.in. (3199 cm
3)
302.9cu.in. (4966cm
3)
331.8 cu.in. (5439 cm
3)
Compression ratio
10:1
10:1
11:1
Output acc. to SAE J 1349
215 hp / 5700 rpm
(160 kW / 5700 rpm)
302hp/5600rpm
(225 kW / 5600 rpm)
362 hp / 5750 rpm
(270 kW / 5750 rpm)
Maximum torque acc. to SAE J
1349
229ft.lb/3000rpm
(310 Nm / 3000 rpm)
339 ft.lb / 2700 rpm
(460 Nm / 2700 rpm)
369ft.lb/4000rpm
(510 Nm / 4000 rpm)
Maximum engine speed
6000 rpm
6000 rpm
6700 rpm
Firing order
1-4-3-6-2-5
1-5-4-2-6-3-7-8
1-5-4-2-6-3-7-8
Poly-V-belt
7ft 10in (2390mm)
7 ft 10 in (2390 mm)
7ft 10in (2390mm)
Page 348 of 394
348 Technical dataElectrical system
Electrical systemModel
CLK 320
CLK 500
CLK 55 AMG
Generator (alternator)
14 V/120 A
14 V/150 A
14 V/150 A
Starter motor
14 V/1.4 KW
14 V/1.7 KW
14 V/1.7 KW
Battery
12 V/100 Ah
12 V/100 Ah
12 V/100 Ah
Spark plugs
Bosch F8 DPP 332U
NGK PFR 5R-11
Bosch F8 DPP 332U
NGK PFR 5R-11
NGK ILFR 6A
Electrode gap
0.039 in (1.00 mm)
0.039 in (1.00 mm)
0.031 in (0.8 mm)
Tightening torque
18.5 - 22 ft.lb (25 - 30 Nm)
18.5 - 22 ft.lb (25 - 30 Nm)
18.5 - 22 ft.lb (25 - 30 Nm)
Page 364 of 394
364 Technical termsMemory function*
Used to store three individual seat,
steering wheel and mirror positions for
each key or, if so equipped, KEY-
LESS-GO* feature.
Menu
The control system displays are ar-
ranged in menus. Each menu contains
a number of commands for particular
systems. In the Audio menu, for exam-
ple, you will find the commands
Select
radio station
or Operate CD player
.
Using commands you can directly
change the settings for your vehicle.
MON
(M
otor O
ctane N
umber)
The Motor Octane Number for gasoline
as determined by a standardized meth-
od. It is an indication of a gasoline's
ability to resist undesired detonation
(knocking). The average of both the
MON (Motor Octane Number) and
->RON (Research Octane Number) is
posted at the pump, also known as AN-
TI-KNOCK INDEX.Multifunction display
Display field in the speedometer used
to present information provided by the
control system.
Multifunction steering wheel
Steering wheel with buttons for operat-
ing the control system.
Overspeed range
Engine speeds within the red marking
of the tachometer dial. Avoid this en-
gi ne sp ee d ra nge , a s it m ay re su lt i n s e-
rious engine damage that is not
covered by the Mercedes-Benz Limited
Warranty.
Parktronic*
System which uses visual and acoustic
signals to assist the driver during park-
ing maneuvers.
Poly-V-belt drive
Drives engine-components (alternator,
AC compressor, etc.) from the engine.Power train
Collective term designating all compo-
nents used to generate and transmit
motive power to the drive axles, includ-
ing
engine
clutch/torque converter
transmission
transfer case
drive shaft
differential
axle shafts/axles
Program mode selector switch
Used to switch the automatic transmis-
sion between regular operationS and
winter operationW.
CLK 55 AMG with steering wheel gear-
shift control and manual shift program.
In addition toS andC (for regularS or
comfortC operation, see above) you
can use theM for manual shift
program.
Page 366 of 394
366 Technical termsTele Aid System
(T
elematic A
larm I
dentification on D
e-
mand)
The Tele Aid system consists of three
types of response: automatic and man-
ual emergency, roadside assistance
and information. Tele Aid is initially ac-
tivated by completing a subscriber
agreement and placing an acquain-
tance call.
The Tele Aid system is operational pro-
viding that the vehicle’s battery is
charged, properly connected, not dam-
aged and cellular and GPS coverage is
available.
Telematics*
A combination of the terms “telecom-
munications” and “informatics”.Tightening torque
Force times lever arm (e.g. a lug
wrench) with which threaded fasteners
such as wheel bolts are tightened.
Tire speed rating
Part of tire designation; indicates the
speed range for which a tire is ap-
proved.
Traction
Force exerted by the vehicle on the
road via the tires.VIN
(V
ehicle I
dentification N
umber)
The number set by the manufacturer
and placed on the body to uniquely
identify each vehicle produced.
Voice control system*
Voice control system for car phones,
portable cell phones and audio sys-
tems (radio, CD, etc.).
Page 390 of 394
390 IndexTelephone* 24, 226
Answering a call 139
Dialing a number from the phone book
139
Ending a call 139
Hands-free microphone 27
Loading phone book* 139
Messages in display 301
Operating 138
Operation 182
Redialing 140
Temperature
Display mode 126
Grades of tires 359
Setting interior temperature 157
Setting units in display 126
Tires 262
Tie-down rings (Trunk) 218
Tightening torque 366
Tightening torque (Wheel bolts) 328
Time
Setting hours 128
Setting minutes 129
Tire inflation pressure
Checking 252, 262
Tire speed rating 245, 366Tire traction 245
Tires 260, 345
Consumer information 358
Direction of rotation 261
Driving instructions 244
Retreads 260
Rims and tires 345
Service life 261
Temperature 262
Temperature grades 359
Tread depth 264
Wear pattern 263
Winter 264
Tools 305
Tow-away alarm 25, 81
Arming 81
Disarming 81
Disarming for transport 81
Towing eye bolt (vehicle tool kit)
Installing 336
Towing the vehicle 334
Tracking services
For stolen vehicle 235
Traction 145, 358, 366
Transmission see Automatic transmission
256Transmission selector lever 313
Unlocking manually 313
Traveling abroad 247
Tread depth (tires) 264
Tread wear 358
Trip computer 136
Trip odometer
Resetting 112
Trunk
Auxiliary fuse box 338
Closing 94
Lock button, KEYLESS-GO* 91
Locking separately 94
Message in display 301
Opening 87
Opening from inside vehicle 92
Tie-down rings 218
Trunk lid 87
Trunk lock 311
Unlocking in an emergency 311
Unlocking separately 95
Unlocking with KEYLESS-GO* 90
Unlocking with SmartKey 86
Trunk lid emergency release 93
Turn signal lamps
Replacing bulbs 317
Page 392 of 394
392 IndexVehicle jack 306
Vehicle lighting
Checking 252
Vehicle tool kit 305
Alignment bolt 305
Spare fuses 305
Special fuse puller 305
Towing eye bolt 305
Vehicle jack 305
Wheel bolts 305
Wheel wrench 305
Vehicle washing 270
VIN (Vehicle Identification Number) 366
Voice control system* 366
Voice control system*
Hands-free microphone 27
W
Warning lamps see Lamps, indicator and
warning
Warning sounds
Distance warning function* 204
Distronic* 198
Drivers seat belts 62
Parking brake 45
Warranty coverage 341
Washer fluid see Windshield washer fluidWashing the vehicle 268
Wear pattern (tires) 263
Weights 350
Wheel change
Tightening torque 328
Wheels
Rotating 263
Tires and wheels 260
Window curtain airbags 61
Windows see Side windows
Windshield
Defogging 158
Refilling washer fluid 259
Replacing wiper blades 323
Washer fluid 259, 357
Washer system 357
Windshield washer fluid 357
Message in display 301
Mixing ratio 357
Refilling 259
Wiping with 48
Windshield washer system 357
Windshield wipers 47, 151
Fast wiper speed 48
Intermittent wiping 48
Replacing wiper blades 323Single wipe 48
Switching on 47
Wiping with windshield washer fluid 48
Winter driving 264
Block heater* 265
Snow chains 265
Tires 264
Transmission program mode 145, 147
Winter driving instructions 246
Winter tires 264
Wiper blades
Cleaning 272
Installing 323
Removing 323
Replacing 323
Wiping
And washing simultaneously 48
Interval 48
With windshield washer fluid 48
X
Xenon headlamps
Bi-Xenon 361