MERCEDES-BENZ CLK550 2008 C209 Owner's Manual

480 Technical data
Layout of poly-V-belt drive
CLK 350 / CLK 550
1Idler pulley
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)CLK 63 AMG
1Idler pulley
2Idler pulley
3Idler pulley
4Automatic belt tensioner
5Power steering pump
6Air conditioning compressor
7Crankshaft
8Coolant pump
9Generator (alternator)

481 Technical data
Engine
Engine
Model Coupe
CabrioletCLK 350 (209.356)1
CLK 350 (209.456)1
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equipment.
CLK 550 (209.372)1
CLK 550 (209.472)1CLK 63 AMG (209.477)1
Engine272273156
Mode of operation4-stroke engine,
gasoline injection4-stroke engine,
gasoline injection4-stroke engine,
gasoline injection
No. of cylinders688
Bore3.66 in (92.90 mm)3.85 in (98.00 mm)4.02 in (102.20 mm)
Stroke3.39 in (86.00 mm)3.56 in (90.50 mm)3.72 in (94.60 mm)
Total piston displacement213.5 cu in (3 498 cm3)333.25 cu in (5 461 cm3)378.8 cu in (6 208 cm3)
Compression ratio10.5:110.5:111.3:1
Output acc. to SAE J 1349268 hp / 6 000 rpm2
(200 kW / 6 000 rpm)
2Premium fuel required. Performance may vary with fuel octane rating.
382 hp / 6 000 rpm2
(285 kW / 6 000 rpm)
475 hp / 6 800 rpm2
(354 kW / 6 800 rpm)
Maximum torque acc. to SAE J
1349258 lb-ft/ 2 400 - 5 000 rpm
(350 Nm / 2 400 - 5 000 rpm)391 lb-ft / 2 800 - 4 800 rpm
(530 Nm /2 800 - 4 800 rpm)465 lb-ft / 5 000 rpm
(630 Nm / 5 000 rpm)
Maximum engine speed6300 rpm6500 rpm7200 rpm
Firing order1-4-3-6-2-51-5-4-2-6-3-7-81-5-4-2-6-3-7-8
Poly-V-belt2404 mm2404 mm (CLK coupe)
2 380 mm (CLK cabriolet)2360 mm

482 Technical data
Rims and tires
!Only use tires which have been tested and
approved for your vehicle by Mercedes-Benz.
Tires approved by Mercedes-Benz are developed
to provide best possible performance in conjunc-
tion with the driving safety systems on your vehi-
cle such as ABS or ESP
®. Tires specially
developed for your vehicle and tested and ap-
proved by Mercedes-Benz can be identified by
finding the following on the tire’s sidewall:

MO = Mercedes-Benz Original equipment
tires
AMG vehicles:
Does not apply to all approved tires on AMG
vehicles. For information on tested and ap-
proved tires for AMG vehicles, contact an au-
thorized Mercedes-Benz Center.

MOE = Mercedes-Benz Original Extended
(tires with limited run-flat characteristics)
original equipment tires
Using tires other than those approved by
Mercedes-Benz may result in damage that is
not covered by the Mercedes-Benz Limited
Warranty.
iFor information on driving with MOExtended
tires, see “MOExtended system*” (
page 348).
!Using tires other than those approved by
Mercedes-Benz can have detrimental effects,
such as

poor handling characteristics

increased noise

increased fuel consumption
Moreover, tires and rims not approved by
Mercedes-Benz may, under load, exhibit dimen-
sional variations and different tire deformation
characteristics that could cause them to come
into contact with the vehicle body or axle parts.
Damage to the tires or the vehicle may be the
result.
iFurther information on tires and rims is
available at any authorized Mercedes-Benz Cen-
ter. A placard with the recommended tire infla-
tion pressures is located on the driver’s door
B-pillar. Some vehicles may have supplemental
tire inflation pressure information for driving at
high speeds (
page 340) or for vehicle loads
less than the maximum loaded vehicle condition
(
page 339).If such information is provided, it can be found
on the placard located on the inside of the fuel
filler flap. The tire inflation pressure should be
checked regularly and should only be adjusted
on cold tires. Follow tire manufacturer’s mainte-
nance recommendation included with vehicle.
iThe following pages also list the approved
wheel rim and tire sizes for equipping your vehi-
cles with winter tires. Winter tires are not avail-
able as standard or optional factory equipment,
but can be purchased from an authorized
Mercedes-Benz Center.
Depending on vehicle model and the standard or
optional factory-equipped wheel rim/tire config-
uration on your vehicle (Appearance Package,
Sport Package etc.), equipping your vehicle with
winter tires approved for your vehicle model may
also require the purchase of two or four wheel
rims of the recommended size for use with these
winter tires. See an authorized Mercedes-Benz
Center for more information.

483 Technical data
Rims and tires
Same size tires
ModelCLK 350CLK 550
Rims (light alloy)7.5 J x 17 H27.5 J x 17 H2
Wheel offset1.42 in (36 mm)1.42 in (36 mm)
Winter tires1,3
1Radial-ply tires
225/45 R17 91 H M+S.225/45 R17 91 H M+S.
Winter tires1,2,3
2Must be used in conjunction with Tire Pressure Monitoring System (U.S. vehicles) or Run Flat Indicator (Canada vehicles) only. 3Not available as factory equipment.
225/45 R17 91 H M+S.MOExtended225/45 R17 91 H M+S.MOExtended
ModelCLK 63 AMG cabriolet
Rims (light alloy)8 J x 18 H2
Wheel offset1.34 in (34 mm)
Winter tires1,2,3225/40 R18 92 V XL (Extra Load) M+S.
1Radial-ply tires2Not available as factory equipment.3For use with snow chains contact an authorized Mercedes-Benz Center.

484 Technical data
Rims and tires
Mixed size tires
ModelCLK 350CLK 550*
Front axle:
Rims (light alloy)7.5 J x 17 H27.5 J x 17 H2
AMG rims (light alloy)––
Wheel offset1.42 in (36 mm)1.42 in (36 mm)
All-season tires1
1Radial-ply tires
225/45 R17 91H–
Summer tires*1,2
2Must be used in conjunction with Tire Pressure Monitoring System (U.S. vehicles) or Run Flat Indicator (Canada vehicles) only.
225/45 R17 91W MOExtended225/45 R17 91W MOExtended
Rear axle:
Rims (light alloy)8.5 J x17 H28.5 J x17 H2
AMG rims (light alloy)––
Wheel offset1.18 in (30 mm)1.18 in (30 mm)
All-season tires1,3
3Must not be used with snow chains.
245/40 R17 91H–
Summer tires*1,2,3245/40 R17 91W MOExtended245/40 R17 91W MOExtended

485 Technical data
Rims and tires
ModelCLK 550CLK 63 AMG cabriolet
Front axle:
AMG rims (light alloy)7.5 J x 18 H28 J x 18 H2
Wheel offset1.46 in (37 mm)1.34 in (34 mm)
Summer tires1
1Radial-ply tires
225/40 ZR18 92Y XL (Extra Load)225/40 ZR18 92Y XL (Extra Load)
Rear axle:
AMG rims (light alloy)8.5 J x18 H28.5 J x18 H2
Wheel offset1.18 in (30 mm)1.18 in (30 mm)
Summer tires1,2
2Must not be used with snow chains.
255/35 ZR18 94Y XL (Extra Load)255/35 ZR18 94Y XL (Extra Load)

486 Technical data
Rims and tires
Minispare wheel
ModelAll Models (except CLK 63 AMG cabriolet)
Rim3.5 B x 17 H2
Wheel offset0.67 in (17 mm)
Tire1
1Must not be used with snow chains.
T 125/80 R 17 99M
!Please compare the recommended tire in-
flation pressure for your vehicle with the tire in-
flation pressure on the yellow label located on
the spare wheel rim.
If the tire inflation pressure on the yellow label
on the spare wheel rim differs from the values
given in this Operator’s Manual, inflate the spare
wheel tire to the recommended tire inflation
pressure given on the yellow label on the spare
wheel rim.
iPlease note that the tire inflation pressure of
the Minispare tire differs from the tire inflation
pressure of the road tires.
Make sure the Minispare tire is inflated to ap-
proximately 61 psi (4.2 bar).
iThe CLK 63 AMG cabriolet does not have a
spare wheel. The CLK 63 AMG cabriolet is
equipped with TIREFIT, see “Sealing tires with
TIREFIT (CLK 63 AMG only)” (
page 452).

487 Technical data
Electrical system
Electrical system
ModelCLK 350CLK 550CLK 63 AMG
Generator (alternator)14 V/150 A14 V/180 A14 V/180 A
Starter motor12 V/1.4 KW12 V/1.7 KW12 V/2.2 KW
Battery12 V/100 Ah12 V/100 Ah12 V/100 Ah
Spark plugsBosch Platin Y 7 MPP 33
NGK PLKR 6ABosch F8 DPP 332
NGK PFR 5R-11NGK ILZKAR 7A10
Electrode gap0.031 in (0.80 mm)0.039 in (1.00 mm)0.039 in (1.0 mm)
Tightening torque15 - 22 lb-ft (20 - 30 Nm)18.5 - 22 lb-ft (25 - 30 Nm)14.75 - 18.5 lb-ft (20 - 25 Nm)

488 Technical data
Main dimensions and weights
Main dimensions
Weights
ModelCLK 350CLK 550CLK 63 AMG
Overall vehicle length183.3 in (4 657 mm)183.3 in (4 657 mm)183.3 in (4 657 mm)
Overall vehicle width
(exterior rear view mirrors
folded out) 78.4 in (1 991 mm)78.4 in (1 991 mm)78.4 in (1 991 mm)
Overall vehicle height
Coupe:
Cabriolet:
55.4 in (1 408 mm)
55.6 in (1 413 mm)55.4 in (1 408 mm)
55.4 in (1 408 mm)
55.3 in (1 400 mm)
Overall vehicle height when
opening/closing soft top80.2 in (2 038 mm)81.0 in (2 057 mm)80.6 in (2 047 mm)
Wheelbase106.9 in (2 715 mm)106.9 in (2 715 mm)106.9 in (2 715 mm)
Track, front58.8 in (1 493 mm)58.9 in (1 497 mm)58.9 in (1 495 mm)
Track, rear58.0 in (1 474 mm)58.2 in (1 478 mm)58.0 in (1 474 mm)
Roof load max.
(CLK coupe only)
220 lbs (100 kg)
Trunk load max.220 lbs (100 kg)

489 Technical data
Fuels, coolants, lubricants, etc.
Fuels, coolants, lubricants, etc.
Capacities
Vehicle components and their respective
lubricants must match. Therefore only use
products tested and approved by
Mercedes-Benz.
Please refer to the Factory Approved
Service Products pamphlet (USA only), or
inquire at an authorized Mercedes-Benz
Center.
Warning!G
Comply with all valid regulations with
respect to handling, storing, and disposing
of service fluids. Otherwise you could
endanger persons or the environment.
Keep service fluids out of the reach of
children.
For health reasons, you should prevent
service fluids from coming into direct
contact with your skin and clothing.
If a service fluid is swallowed, contact a
physician immediately.
ModelCapacityFuels, coolants, lubricants, etc.
Engine with oil filterCLK 350
CLK 550
CLK 63 AMG8.5 US qt (8.0 l)
9.0 US qt (8.5 l)
9.3 US qt (8.8 l)Approved engine oils
Automatic transmissionCLK 350
CLK 550
CLK 63 AMG9.0 US qt (8.5 l)
9.5 US qt (9.0 l)
9.2 US qt (8.7 l)MB Automatic Transmission Fluid
Rear axleCLK 350
CLK 550
CLK 63 AMG1.16 US qt (1.1 l)
1.27 US qt (1.2 l)
1.27 US qt (1.2 l)Hypoid gear oil SAE 85 W 90
Fuchs Titan EG 5010D