check engine MERCEDES-BENZ E350 2006 W211 Service Manual
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2006, Model line: E350, Model: MERCEDES-BENZ E350 2006 W211Pages: 521
Page 455 of 521
454 Practical hintsJump starting
If the battery is discharged, the engine can
be started with jumper cables and the bat-
tery of another vehicle. Observe the follow-
ing:
Jump starting should only be performed
when the engine and catalytic
converter
1 are cold.
Do not start the engine if the battery is
frozen. Let the battery thaw out first.
Only jump start from batteries with the
same voltage rating (12-V). Jump start-
ing with a more powerful battery could
damage the vehicle’s electrical system,
which will not be covered by the
Mercedes-Benz Limited Warranty.
Use only jumper cables with sufficient
cross-section and insulated terminal
clamps.
Always make sure the jumper cables
are not on or near pulleys, fans or other
parts that move when the engine is
started or running.
Warning!
G
Failure to follow these directions will cause
damage to the electronic components, and
can lead to a battery explosion and severe
injury or death.
Never lean over batteries while connecting
or jump starting, you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water, and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and very explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking, etc.
Attempting to jump start a frozen battery
can result in it exploding, causing personal
injury.
Read all instructions before proceeding.
1Vehicles with gasoline engine only.
!Jump starting may only be performed
on the main battery installed in the
trunk.
Avoid repeated and lengthy starting at-
tempts.
Do not attempt to start the engine us-
ing a battery quick charge unit.
If the engine does not run after several
unsuccessful starting attempts, have it
checked at the nearest authorized
Mercedes-Benz Center.
Excessive unburned fuel generated by
repeated failed starting attempts may
damage the catalytic converter
1.
Make sure the jumper cables do not
have loose or missing insulation.
Make sure the cable clamps do not
touch any other metal part while the
other end is still attached to a battery.
Page 457 of 521
456 Practical hintsJump starting
Start engine of the vehicle with the
charged battery and run at idle speed.
Connect negative terminals4 and2
of the batteries with the jumper cable.
Clamp cable to charged battery4
first.
Start the engine of the disabled vehi-
cle.Now you can again turn on the electrical
consumers. Do not turn on the lights under
any circumstances.
Remove the jumper cables first from
negative terminals2 and4 and then
from positive terminals1 and3.
Now you can turn on the lights.
Have the battery checked at the near-
est authorized Mercedes-Benz Center.
iThe message
Malfunction - electric
consumers switched off
may appear
in the instrument cluster. It will disap-
pear as soon as the battery is suffi-
ciently charged.
!Do not tow-start the vehicle.
Page 490 of 521
489 Technical data
Fuels, coolants, lubricants etc.
In areas where carbon deposits may be en-
countered due to lack of availability of gas-
olines which contain these additives,
Mercedes-Benz recommends the use of
additives approved by us for use on
Mercedes-Benz vehicles. Refer to Factory
Approved Service Products Pamphlet for a
listing of approved product(s). Follow di-
rections on product label.
Do not blend other fuel additives with fuel.
This only results in unnecessary costs and
may be harmful to the engine operation.
Damage or malfunction resulting from
poor fuel quality or from blending addition-
al fuel additives other than those tested
and approved by us for use on
Mercedes-Benz vehicles listed in the Fac-
tory Approved Service Products pamphlet
are not covered by the Mercedes-Benz
Limited Warranty.
Fuel requirements
Gasoline engine
Use only premium unleaded gasoline
meeting ASTM standard D 439:
The octane number (posted at the
p um p) mu st b e 9 1 m i n. It is a n ave ra ge
of both the Research (R) Octane Num-
ber and the Motor (M) Octane Number:
(R+M) / 2). This is also known as the
ANTI-KNOCK INDEX.
Unleaded gasoline containing oxygenates
such as ethanol, IPA, IBA and TBA can be
used provided the ratio of any one of these
oxygenates to gasoline does not exceed
10%; MTBE must not exceed 15%.
The ratio of methanol to gasoline must not
exceed 3% plus additional cosolvents.
Using mixtures of ethanol and methanol is
not allowed. Gasohol, which contains 10%
ethanol and 90% unleaded gasoline, can be
used.These blends must also meet all other fuel
requirements, such as resistance to spark
knock, boiling range, vapor pressure, etc.
Diesel engine
Only use commercially available vehicular
diesel fuels No. 2 or No. 1 (ASTM D975
No.2-D or No.1-D).
To prevent malfunctions, diesel fuel with
better cold flow quality is offered in the
winter months. Check with your fuel
retailer.
!Do not fill the tank with gasoline. Do
not mix diesel fuel with gasoline or
kerosene. The fuel system and engine
will otherwise be damaged, which is
not covered by the Mercedes-Benz
Limited Warranty.
Page 491 of 521
490 Technical dataFuels, coolants, lubricants etc.Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which pro-
vides:
Corrosion protection
Freeze protection
Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and corro-
sion protection.
If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).
The coolant solution must be used
year-round to provide the necessary corro-
sion protection and increase boil-over pro-
tection. Refer to Maintenance Booklet for
replacement interval.Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 anticorrosion/antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products pam-
phlet) are used to renew the coolant con-
centration or bring it back up to the proper
level.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze [equivalent to freeze
protection to approximately - 22°F
(-30°C)]. If you use a solution that is more
than 55% anticorrosion/antifreeze [freeze
protection to approximately - 49°F
(-45°C)], the engine temperature will in-
crease due to the lower heat transfer capa-
bility of the solution. Therefore, do not use
more than this amount of anticorro-
sion/antifreeze.If the coolant level is low, water and
MB 325.0 anticorrosion/antifreeze should
be used to bring it up to the proper level
(have cooling system checked for signs of
leakage). Please make sure the mixture is
in accordance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult your authorized Mercedes-Benz
Center.
Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum
parts. (Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life.)
Page 503 of 521
502 Index
Gear shifting malfunctions 196
Kickdown 186
Kickdown, Manual shift program
E55AMG 195
Manual (One-touch) gearshifting 190
Manual shift program E 55 AMG 193
Shift program mode selector
switch 189
Shift program mode selector switch,
Manual shift program
E55AMG 193
Starting engine 50
Steering wheel gearshift control
one-touch gearshifting
E55AMG 191
Winter program mode 189
B
Backrest 271
Seat 41
Seat, multicontour 134
Backup lamps
Messages in display 412
Replacing bulbs 433
Bar 354
BAS 94, 493Batteries, SmartKey
Changing 431, 432
Checking battery condition 110, 116
Batteries, SmartKey with KEYLESS-GO*
Changing 431, 432
Checking battery condition 116
Batteries, Vehicle
Charging 452
Disconnecting 451
Installing 452
Jump starting 454
Messages in display 389, 398, 399
Reconnecting 453
Removing 452
Bead 354
Beverage holder see Cup holders
Bi-Xenon headlamps* see Headlamps
Bleeding the fuel system 449
Block heater* (Canada only) 359
Brake Assist System see BAS
Brake fluid
Checking 318
Messages in display 402Brake lamp
Cleaning lenses 367
Messages in display 412
Replacing bulbs 433
Brake pads
Message in display 400
Brakes 304
Warning lamp 376
Break-in period 302
Bulbs see Replacing bulbs
C
CAC 493
California retail buyers and lessees, impor-
tant notice for 11
Can holder see Cup holders
CAN system 493
Capacities and recommended
fuel/lubricants 484
Cargo area see Trunk
Cargo tie-down rings 275
Carpets, cleaning 371
Catalytic converter 312
CD player 160
Page 504 of 521
503 Index
Center console
Lower part 28
PASS AIR BAG OFF indicator
lamp 384
Upper part 27
Centigrate see Temperature display mode
Central locking
Automatic 129, 174
Locking/unlocking from inside 129
Central locking switch 129
Certification label 468
Checking
Oil level 320
Children in the vehicle 78
Air bags 68
Blocking of rear window operation 89
Indicator lamp, front passenger front
air bag
Infant and child restraint systems 78
LATCH-type child seat anchors 88
Occupant Classification System (OCS)
Cigarette lighter 282Climate control system
4-zone automatic climate
control 214
Air conditioning refrigerant 487
Air conditioning, Cooling 212, 227
Air distribution 208, 222
Air recirculation mode 210, 224
Air volume 209, 223
Automatic mode 206, 220
Control panel, Rear 213, 229
Deactivating system 206, 219
Dual-zone automatic climate
control 202
Front defroster 209, 223
Maximum cooling MAX COOL 224
Rear climate control 229
Residual engine heat (REST) 228
Clock 25, 168
Setting time 169
Cockpit 22, 493
Cockpit Management and Data System
see COMAND
Cold tire inflation pressure 354
Collapsible tire 480
Collapsible wheel chock 424
COMAND 494COMAND see separate COMAND operat-
ing instructions
Combination switch 55, 145
Control system 153, 494
Multifunction display 153
Multifunction steering wheel 154
Resetting to factory default 164
Control system menus 156, 157
AUDIO 159
Distronic* 161
NAV* 161
Settings 163
Standard display 159
TEL* 180
Trip computer 178
Vehicle status message memory 162
Control system submenus 155
Convenience 175
Instrument cluster 166
Lighting 170
Time/Date 168
Vehicle 174
Controller Area Network see CAN system
Convenience submenu
Setting parking position for exterior
rear view mirror 176
Page 507 of 521
506 IndexEngine
Belt layout 469
Block heater* (Canada only) 359
Cleaning 366
Compartment 319
Malfunction indicator lamp 377, 378,
403
Maximum engine speed 471
Message in the display 377, 378,
403
Number 468, 494
Starting 50
Starting with KEYLESS-GO* 51
Starting with the SmartKey 51
Tachometer 25
Technical data 471
Turning off with KEYLESS-GO* 62
Turning off with the SmartKey 62
Engine compartment
Hood 319
Engine coolant see Coolant
Engine malfunction indicator lamp 377,
378, 403Engine oil
Adding 323
Additives 487
Changing 323
Checking level (Control system) 321
Checking level (Dipstick) 322
Consumption 320
Filler neck 324
Messages in display 321, 408
Recommended engine oils and oil
filter 487
Viscosity 494
Engine oil level 318
ESP
®
94, 494
Four wheel electronic traction system
with ESP
®
100
Messages in display 391
Warning lamp 375
ETD 494
Safety guidelines 70
Exterior rear view mirrors
Parking position 176
F
Factory, SmartKey with
KEYLESS-GO* 114
Filler neck, Engine oil 324First aid kit 422
Flat tire 441
Lowering the vehicle 447
Mounting the spare wheel 441, 444
Preparing the vehicle 441
Spare wheel 441
Flexible Service System see FSS
Floormats 284
Fluids
Automatic transmission fluid 484
Brake fluid 485
Capacities 484
Engine coolant 485
Engine oil 484
Power steering fluid 485
Windshield washer and headlamp
cleaning system 486
Fog lamps 144
Messages in display 412
Replacing bulbs 435
Four wheel electronic traction system with
ESP
® see 4MATIC
4MATIC 100
Front air bags 71
Front lamps see Headlamps
Page 510 of 521
509 Index
K
Key, Mechanical 426
Key, SmartKey
Battery check lamp 106
Changing batteries 431
Factory setting 108
Locking/unlocking 34
Locking/unlocking, Global
setting 108
Locking/unlocking, Selective
setting 108
Loss of 110
Messages in display 411
Opening and closing the power
tilt/sliding sunroof* or panorama
roof with power tilt/sliding
panel* 234
Opening and closing the
windows 234
Positions in starter switch 36
Remote control 106
Starting the engine 50
Turning off engine 62Key, SmartKey with KEYLESS-GO*
Battery check lamp 111
Changing batteries 431, 432
Factory setting 114
Locking, Trunk lid 114
Locking/unlocking 35
Locking/unlocking, Selective
setting 115
Loss of 118
Messages in display 410
Opening and closing the the power
tilt/sliding sunroof* or panorama
roof with power tilt/sliding
panel* 234
Opening and closing the
windows 234
Starting the engine 51
Turning off engine 62
Unlocking, Trunk lid 118
KEYLESS-GO* 495
KEYLESS-GO* see Key, SmartKey with
KEYLESS-GO*
Kickdown 186, 495
Kilopascal 354L
Labels
Certification 468
Emission control information 468
Emission control vacuum line
routing 468
Lamp sensor
Message in display 414
Lamps, exterior
Light sensor 414
Messages in display 412, 413, 414,
415
Lamps, indicator and warning
ABS 25, 374
Battery (SmartKey) 108, 115
Brakes 376
CHECK ENGINE 377, 378
Coolant 379
Distance warning lamp* 250
Electrohydraulic brake system 97
Engine diagnostics 377, 378
Engine malfunction 25, 377, 378
ESP
®
25, 375
Fog lamps 144
Front passenger front air bag off 27,
72, 384, 385
Page 512 of 521
511 Index
Multifunction display 153, 496
Changing settings see Control system
menus and Control system sub-
menus
Selecting language 166
Multifunction display messages 388
ABS
Batteries 389, 398, 399
Brake fluid 402
Brake lamps 412
Brake pads 400
Check engine 377, 378
Coolant 403, 404, 405
Cruise control 389
Distronic* 389
Door 406
Electrohydraulic brake system 400,
401
Engine oil 321, 407, 408, 409
ESP
®
391, 392
Fog lamps 412, 413
Fuel reserve tank 411
Headlamps 412, 413, 414
Hood 410
Key, SmartKey 411Key, SmartKey with
KEYLESS-GO* 410
Panorama roof with power tilt/sliding
panel* 417
Parking brake 401
Parking lamps 413
Power tilt/sliding sunroof* 417
Seat belts 417
SRS 418
Telephone* 419
Tires 416
Trunk 419
Turn signals 415
Windshield washer fluid 419
Multifunction steering wheel 26, 154,
496
Button operation 154
N
Navigation system
See separate COMAND operating
instructions 161
Net, parcel 278
Neutral gear position 185
Night security illumination 144
Normal occupant weight 355Number, vehicle identification (VIN) 468
O
Occupant Classification System see OCS
Occupant distribution 355
Occupant safety 66
Air bags 67
Children and air bags 68
Children in the vehicle 78
Fastening the seat belt 47
Front passenger front air bag off indica-
tor lamp 85
Infant and child restraint systems 78
LATCH-type child seat anchors
OCS
Seat belts 47, 70
OCS
Self-test 86
Odometer 153
Oil level see Engine oil, Checking level
Oil see Engine oil
One-touch gearshifting 190
Operating safety 16
Ornamental moldings, Cleaning 367
Outside temperature see Displays
Overdue maintenance service 360, 361
Overhead control panel 29
Page 516 of 521
515 Index
Starting difficulties, Engine 52
Starting, Engine 50
Steering column 43
Steering wheel 42
Buttons 26
Steering wheel gearshift control one-touch
gearshifting E 55 AMG
Automatic transmission 191
Steering wheel, Cleaning 371
Stolen Vehicle Recovery services 293
Storage compartments 30
Center console 276
Cup holder 279
Glove box 276
Parcel net in front passenger footwell
Rear center console 277
Ruffled storage bags 277
Storing
Tires 330
Submenus
In control system
Submenus see Control system submenus
Sun visors 199
Sunroof see Power tilt/sliding sunroof*
Sunshade* 200
Supplemental Restraint System see SRSSuspension tuning
For comfortable driving style 259
For sporty driving style 259
Suspension tuning see Airmatic DC (Dual
Control)*
Symbols used in this operator’s
manual 15
T
Tachometer 25, 152
Overspeed range 152
Tail lamps 438
Cleaning lenses 367
Messages in display 415
Replacing bulbs 438
Tar stains 365
Technical data
Air conditioning refrigerant 487
Brake fluid 487
Capacities fuels, coolants, lubricants
etc. 484
Coolant 490
Electrical system 481
Engine 471
Engine oil additives 487
Engine oils 487Fuel requirements 489
Gasoline additives 488
Premium unleaded gasoline 488
Rims and tires 473
Weights 483
Windshield washer and headlamp
cleaning system 486
Tele Aid 286, 498
Emergency calls 287
Information 290
Initiating an emergency call
manually 288
Message in display 418
Remote door unlock 292
Roadside Assistance 289
SOS button 288
Stolen Vehicle Recovery
services 293
System self-check 286
Telematics* 498
Telephone* 26, 180, 285
Answering/ending a call 181
Message in display 419
Operation 180
Phone book* 181
Redialing 182