trunk MERCEDES-BENZ S CLASS 2005 Workshop Manual

404 Practical hintsBattery
Pull on the outer, right-hand side of
cover1 and remove it in the direction
of the arrow.
2Positive terminal
3Negative terminal
Disconnecting the battery
Turn off all electrical consumers.

Open the trunk lid (
page 103).

Remove the battery cover1.

Use a 10 mm open-end wrench to dis-
connect the battery negative lead3.

Remove cover from the positive
terminal2.

Disconnect the battery positive
lead2.
Removing the battery
Remove the screw securing the bat-
tery.

Remove the battery support and
bracket.

Take out the battery.
Charging and reinstalling the battery
Charge battery in accordance with the
instructions of the battery charger
manufacturer.

Reinstall the charged battery. Follow
the previously described steps in re-
verse order.Warning!
G
Never charge a battery while still installed in
the vehicle. Gases may escape during charg-
ing and cause explosions that may result in
paint damage, corrosion or personal injury.

407 Practical hints
Jump starting
The battery is located on the right side of
the trunk under the battery cover
(page 403).

Make sure the two vehicles do not
touch.

Turn off all electrical consumers.

Apply parking brake.

Shift gear selector lever to positionP.

Open the trunk lid.

Remove battery cover (
page 403).

Remove red cover from positive
terminal 1. 1Positive terminal of discharged battery
2Negative terminal of discharged
battery
3Positive terminal of charged battery
4Negative terminal of charged battery

Connect positive terminals 1 and3
of the batteries with the jumper cable.
Clamp cable to charged battery3
first.

Start engine of the vehicle with the
charged battery and run at idle speed.

Connect negative terminals2 and4
of the batteries with the jumper cable.
Clamp cable to charged battery4
first.

Start the engine of the disabled vehi-
cle.
Now you can again turn on the electrical
consumers. Do not turn on the lights under
any circumstances.

Remove the jumper cables first from
negative terminals2 and4 and then
from positive terminals1 and3.
You can now turn on the lights.

Have the battery checked at the near-
est authorized Mercedes-Benz Center.
Warning!
G
Keep flames or sparks away from battery.
Do not smoke.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 403).
!Never invert the terminal connections.

410 Practical hintsTowing the vehicle
Installing towing eye bolt
1Cover on right side of front bumper
2Cover on right side of rear bumperRemoving cover

Press mark on cover in direction of ar-
row.

Lift cover off to reveal threaded hole for
towing eye bolt.
Installing towing eye bolt

Take towing eye bolt and wheel wrench
out of trunk (
page 379).

Screw towing eye bolt clockwise into
its stop and tighten with wheel wrench.
Removing towing eye bolt

Loosen towing eye bolt counterclock-
wise with wheel wrench.

Unscrew towing eye bolt.

Store towing eye bolt and wheel
wrench in trunk.
Installing cover

Fit cover and snap into place.
!When towing the vehicle with all wheels
on the ground, please note the follow-
ing:
With the automatic central locking acti-
vated and the SmartKey in starter
switch position2, or KEYLESS-GO*
start/stop button (
page 35) in
position2, the vehicle doors lock if the
le ft f ront whe el as wel l a s t he rig ht rea r
wheel are turning at vehicle speeds of
approximately 9 mph (15 km/h) or
more.
Switch off the tow-away alarm
(
page 89).
To prevent the vehicle doors from lock-
ing, deactivate the automatic central
locking (
page 112).
Towing of the vehicle should only be
done using the properly installed tow-
ing eye bolt. Never attach tow cable,
tow rope or tow rod to vehicle chassis,
frame or suspension parts.

411 Practical hintsFuses
Fuses
Fuses are designed to protect the electri-
cal circuits in your vehicle from a short cir-
cuit. If a fuse is blown, the component(s)
and systems controlled by that fuse will
stop working.
The following aids are available to help you
replace fuses (
page 411):


Fuse chart


Spare fuses


Special fuse extractorYour vehicle’s electrical fuses are located
in various fuse boxes:


In the dashboard on the passenger side
(page 412)


In the rear passenger compartment un-
der the right rear seat (
page 412)


In the engine compartment on the driv-
er’s side (
page 413)


In the engine compartment on the pas-
senger side (
page 413)
Aids for replacing fuses
Fuse chart
A chart explaining fuse allocation and fuse
amperages can be found in the vehicle tool
kit in the trunk (
page 379).
Spare fuses
Spare Fuses are found in the vehicle tool
kit in the trunk (page 379).
Fuse extractor
The fuse extractor is found in the vehicle
tool kit in the trunk (page 379).
Warning!
G
Only use fuses approved by Mercedes-Benz
and which have the specified amperage. Us-
ing other fuses may cause an overload and
lead to a fire, or cause damage to electrical
components and/or systems.
!Never attempt to repair or bridge a
blown fuse. Have the cause determined
and remedied by an authorized
Mercedes-Benz Center.

428 Technical dataMain dimensions and weightsMain dimensionsWeightsModel
S 430 (220.070)
S 430 (220.170)
S 430 4MATIC (220.183)
S 500 (220.175)
S 500 4MATIC (220.184)
S 55 AMG (220.174)
S 600 (220.176)
Overall vehicle length
198.3 in (5038 mm)
203.1 in (5158 mm)
203.1 in (5158 mm)
203.1 in (5158 mm)
Overall vehicle width
73.0 in (1855 mm)
73.0 in (1855 mm)
73.0 in (1855 mm)
73.0 in (1855 mm)
Overall vehicle height
57.2 in (1454 mm)
57.2 in (1454 mm)
57.2 in (1454 mm)
57.4 in (1457 mm)
Wheelbase
116.7 in (2965 mm)
121.5 in (3085 mm)
121.5 in (3085 mm)
121.5 in (3085 mm)
Track, front
62.0 in (1574 mm)
62.0 in (1574 mm)
62.1 in (1578 mm)
62.0 in (1574 mm)
Track, rear
62.0 in (1574 mm)
62.0 in (1574 mm)
62.1 in (1578 mm)
62.0 in (1574 mm)
Max. roof load
220 lbs (100 kg)
Max. trunk load
220 lbs (100 kg)

443 Index
A
ABC 231, 437
Messages in display 349, 354
Setting vehicle level 230, 232
ABS 25, 80, 437
Malfunction indicator lamp 338
Messages in display 350
Warning lamp 338
Accelerator position, automatic
transmission 180
Accessory weight 322
Accident
In case of 54
Activating
Air conditioner (cooling) 203
Air conditioning 202
Air recirculation mode 199
Anti-theft alarm system 87
Central locking (control system) 168
Charcoal filter 200
Distance warning function* 226
Distronic* 222
Easy-entry/exit feature 170ESP 84
Exterior lamps 132
Exterior rear view mirror parking
position 187
Front and rear fog lamp 132, 134
Hazard warning flasher 136
Headlamps 50
High beams 135
Ignition 34
Ignition with KEYLESS-GO* start/stop
button 36
Immobilizer 57, 86
Limiting opening height of trunk
lid* 169
Manual shift program S 55 AMG 183
Rear window defroster 201
Residual heat 203
Seat heater 125, 126
Seat ventilation* 127
Tow-away alarm 89
Windshield wipers 52Adaptive Damping System (ADS) 229,
437
Adding
Coolant 293
Engine oil 291
Additional turn signals 390
Adjustable air vents, rear passenger
compartment 204
Adjusting 37
Air distribution 196
Air volume 198
Backrest tilt 38
Drive-dynamic seat* 172
Exterior rear view mirror 41
Head restraint height 39
Head restraint tilt 39
Instrument cluster illumination 140
Interior rear view mirror 41
Lumbar support 122
Mirrors 41
Multicontour backrest* 122
Power seat bench* 117
Seat cushion depth 38, 123

448 IndexClock 25
Closing 58
Cup holder 250
Glove box 244
Hood 287
Power tilt/sliding sunroof 211
Power windows 207, 208
Side windows 208
Trunk 105
Closing from the inside automatically*
Trunk 105
Closing in an emergency
Power tilt/sliding sunroof 386
Cockpit 22, 438
Cockpit management and data system
(COMAND) 438
Cold tire inflation pressure 322
COMAND 438
COMAND* see separate operating instruc-
tions
Combination switch 135
High beam 50
High beam flasher 135
Turn signals 51
Windshield wipers 52Control and operation of radio
transmitters 280
Control system 143, 438
AUDIO menu 148
Checking oil level 288
Convenience submenu 169
Display digital speedometer 148
Distronic* menu 156
Functions 145, 147
Instrument cluster submenu 163
Lighting submenu 164
Menus 146, 147
Multifunction display 143
Multifunction steering wheel 144
NAVI menu 155
Settings menu 160
Standard display menu 148
Submenus 145, 147
TEL* menu 153
Trip computer menu 157
Vehicle status message memory
menu 159
Vehicle submenu 168Convenience submenu 169
Activating easy-entry/exit
feature 170
Adjusting drive-dynamic seat* 172
Setting Key-dependency 169
Setting parking position for exterior
rear view mirror 171
Coolant 292
Adding 293
Checking level 292
Messages in display 358, 359
Temperature 282
Temperature gauge 141
Warning lamp 359
Coolant level
Checking 292
Coolant temperature gauge 25
Courtesy lighting 139

449 Index
Cruise control 214, 438
Canceling 215
Driving downhill 215
Driving uphill 215
Fine adjustment 216
Lever 221
Setting current speed 215
Setting to last stored speed (“Resume”
function) 216
Cruise control lever 214
Cup holder
Cleaning 335
Closing 250
In front seat armrest 248
In rear seat armrest 249
Opening 250
Curb weight 322
Customer Assistance Center (CAC) 437
D
Daytime running lamp mode 133
Setting 165
Deactivating
Air conditioner (cooling) 202
Air recirculation mode 200
Alarm 88
Anti-theft alarm system 88Automatic climate control 202
Central locking (control system) 168
Charcoal filter 201
Defrost 199
Distance warning function* 226
Distronic* 224
Engine with the SmartKey 57
ESP 83
Exterior lamps 132
Hazard warning flasher 136
Headlamps 57
Immobilizer 86
Interior illumination delayed
switch-off 167
Limiting opening height of trunk
lid* 169
Manual shift program S 55 AMG 185
Rear window defroster 201
Residual heat 203
Seat heater 125, 126
Seat ventilation* 127
Tow-away alarm 89
Deceleration
With Distronic* 220
Deep water see Standing water 280
Defrosting 199Delayed switch-off
Interior illumination 167
Department of Transportation see DOT
Dialing
A number (telephone) 154
Difficulties
While driving see Problems while
driving 54
Digital clock 25
Digital speedometer 148
Direction of rotation (tires) 299
Discharged battery
Jump starting 406
Disconnecting
Vehicle battery 404
Displays
Digital speedometer 148
Distronic* 219
Messages 289
Service indicator 328
Showing malfunctions 159
Vehicle status messages 347

452 IndexExterior rear view mirror
Auto-dimming on the driver’s
side 186
Exterior rear view mirrors
Adjusting 41
Folding electrically 188
Parking position for 171
F
Fahrenheit (°F)
Setting temperature units 163
Fastening the seat belts 43
Fine adjustment
Cruise control 216
Distronic* 223
First aid kit 379
Flat tire 398
Lowering the vehicle 402
Mounting the spare wheel 398
Preparing the vehicle 398
Flexible Service System (FSS) 328
Flexible Service System see FSS
Fog lamp, rear 134, 390
Replacing bulb 395Fog lamps
Replacing bulbs 390
Fog lamps, front
Messages in display 366
Switching on 134
Folding electrically
Exterior rear view mirrors 188
Four wheel electronic traction system
(4MATIC)
with ESP 85
4MATIC 85
Front air bags 65
Front lamps
Messages in display 366–369
Replacing bulbs 390, 392
Switching on 131
Front passenger front air bag off indicator
lamp 346
Front seat head restraints
Installing 116
Power seat 116
Removing 116
FSS (Flexible Service System) 328
FSS (Flexible Service System) (Canada
vehicles) 439Fuel 284
Fuel reserve warning lamp 341
Premium unleaded gasoline 284
Reserve warning lamp 25
Fuel consumption statistics
After start 157
Since last reset 158
Fuel filler flap 283
Locking 283
Opening 385
Unlocking 283
Fuel tank
Filler flap 283
Fuels, coolants, lubricants etc. 429
Functions (control system) 145, 147
Resetting 161
Fuse box 412, 413
Fuse chart 380
Fuses 411
Auxiliary fuse box in trunk 412
Fuse box in engine compartment 413
Fuse box in passenger
compartment 412
Fuse chart 380
Fuse extractor 380
Spare fuses 380

456 IndexLight alloy wheels
Cleaning 335
Light sensor 366
Lighter see Cigarette lighter 252
Lighting 131
Automatic headlamp mode 132
Combination switch 135
Courtesy lighting 139
Daytime running lamp mode 133
Door entry lamps 139
Exterior lamp switch 131
Front fog lamps 134
High beam flasher 135
High beams 135
Instrument cluster illumination 140
Interior 137
Locator lighting 133
Low beam 131
Manual headlamp mode 132
Night security illumination 133Parking lamps 131
Rear fog lamp 134
Settings (control system) 164
Trunk 138, 139
Limiting opening height of trunk lid* 105
Limiting the gear range 176
Limp Home Mode 185
Line of fall 440
Loading 240
Cargo tie-down hooks 241
Instructions 241
Roof rack 240
Loading terminology 322
Loading the vehicle 299
Locator lighting 133
Setting 166
Lock button 440
Door handle (KEYLESS-GO*) 58
SmartKey 92
SmartKey with KEYLESS-GO* 96Locking 55, 58, 92
Fuel filler flap 283
Global (SmartKey with
KEYLESS-GO*) 99
Global, SmartKey 94
Glove box 244
Vehicle in an emergency 384
Vehicle with KEYLESS-GO* 101
with the KEYLESS-GO* 58
with the SmartKey 58
Loss of SmartKey 96
Loss of Smartkey with
KEYLESS-GO* 102
Low beam headlamps
Messages in display 366, 367
Replacing bulbs 390
Lowering
Vehicle 402
Lumbar support adjustment 122