transmission MERCEDES-BENZ SPRINTER 2012 MY12 Warranty Manual

Service and Warranty12
Exchanged Parts May Be Used in War-
ranty Repairs
In the interest of customer satisfaction,
the vehicle warrantor may offer exchange
service on some vehicle parts. This service
is intended to reduce the amount of time
your vehicle is not available for your use
because of repairs. Parts used in exchange
service may be new, remanufactured, re-
conditioned, or repaired, depending on the
part involved.
All exchange parts that might be used
meet new parts standards and have the
same limited warranties.
Examples of the kinds of parts that might
be serviced in this way are:
• engine assemblies;
• transmission assemblies;
• instrument cluster assemblies;
• radios, tape and CD players;
• speedometers; and
• powertrain control modules.
To help control suspected ozone-depleting
agents, the EPA requires the capture,
purification, and reuse of automotive air-
conditioning refrigerant gases. As a result,
a repair to the sealed portion of your
airconditioning system may involve the
installation of purified reclaimed
refrigerant.Pre-Delivery Service
A defect in or damage to the mechanical,
electrical, sheet-metal, paint, trim, and
other components of your vehicle may
have occurred at the factory or while it was
being shipped to the authorized Sprinter
Dealer.
Such a defect or damage is usually
detected and corrected at the factory. In
addition, authorized Sprinter Dealers must
inspect each vehicle before delivery. They
repair any defects or damage detected
before the vehicle is delivered to you.
Production Changes
Changes may be made in vehicles sold by
the vehicle distributor and its authorized
Sprinter Dealers at any time without
incurring any obligation to make the same
or similar changes on vehicles previously
built or sold.
Other Terms of Your Warranties

Service and Warranty13
Federal Emission Warranty - Diesel-
Heavy Duty Vehicle
A. Parts Covered for 5 Years or 100,000
Miles
Diesel equipped heavy duty vehicles have
a diesel engine Emission Warranty which
warrants the following emission parts for
5 years or 100,000 miles, whichever oc-
curs first. These limits are counted from
the time when your New Vehicle Limited
Warranty begins, see (

Page 5).
The covered parts are:
I. Air Induction System
Air Cleaner Housing
Charge Air Cooler
Charge Air Distribution Line
Electric Intake Air Throttle (with Throttle Valve
Step Motor)
Intake Port Shutoff
Turbocharger
II. Fuel Metering System
Fuel Filter
Fuel Injector
Fuel Pressure Regulator
Fuel Pump (Electric)
Fuel Rail
Fuel Rail Pressure Sensor
High Pressure Pump
III. Ignition System
Glow Plug
Glow Time Control Module
IV. Exhaust Gas Recirculation System
EGR Cooler
EGR Valve
V. Positive Crankcase Ventilation
Crankcase Ventilation Valve/Line
Oil Filler CapVI. Fuel Evaporative Control
Fuel Tank (with Vent Valve and Fuel Filler Neck)
VII. Exhaust / Diesel Exhaust Fluid (DEF) System
DEF Delivery Pump (with Pressure Sensor)
DEF Injection Valve/Lines
DEF Tank (with Temperature Sensor and Fluid Level
Gauge)
Diesel Oxidation Catalyst with Diesel Particulate Filter
Exhaust Manifold
Exhaust Pipe (Front)
Selective Catalytic Reduction Catalyst
VIII. Engine Emissions Control Systems/Sensors
Accelerator Pedal Module
Camshaft Position Sensor
Charge Air Pressure Sensor
Charge Air Temperature Sensor
Crankshaft Position Sensor
DEF Control Module
Engine Control Module
Engine Coolant Temperature Sensor
Exhaust Back Pressure Sensor
Exhaust Differential Pressure Sensor
Exhaust Gas Temperature Sensor
Fuel Temperature Sensor
Heated Cooling Water Thermostat
Manifold Air Pressure Sensor
Mass Air Flow Sensor (with Integrated Intake Air
Temperature Sensor)
NO
X Sensor
O
2 Sensor
Transmission Control Module
Vehicle Speed Sensor (Front Wheels)
Vehicle Speed Sensor (Rear Wheels)
IX. On-Board Diagnostics
Data Link Connector (OBD)
Instrument Cluster (Malfunction Indicator Lamp)
X. Related Parts w/ Above Systems
Automatic Transmission Mode Selector
Emission Related:
Hoses, Clamps, Belts, Pulleys, Tubes,
Fittings, Sealing Devices, Mounting Hardware
included
Emission Warranties Required By Law

Service and Warranty16
California Emission Warranty (cont’d)
Coverage
SHORT-TERM EMISSION-RELATED
PARTS (CA, CT, MA, MD, ME, NJ, NM, OR,
PA, RI, VT, WA):
I. Air Induction System
Air Cleaner Housing
Charge Air Cooler
Charge Air Distribution Line
Electric Intake Air Throttle (with Throttle Valve
Step Motor)
Intake Port Shutoff
Turbocharger
II. Fuel Metering System
Fuel Filter
Fuel Injector
Fuel Pressure Regulator
Fuel Pump (Electric)
Fuel Rail
Fuel Rail Pressure Sensor
High Pressure Pump
III. Ignition System
Glow Plug
Glow Time Control Module
IV. Exhaust Gas Recirculation System
EGR Cooler
EGR Valve
V. Positive Crankcase Ventilation
Crankcase Ventilation Valve/Line
Oil Filler Cap
VI. Fuel Evaporative Control
Fuel Tank (with Vent Valve and Fuel Filler Neck)
VII. Exhaust / Diesel Exhaust Fluid (DEF) System
DEF Delivery Pump (with Pressure Sensor)
DEF Injection Valve/Lines
DEF Tank (with Temperature Sensor and Fluid Level
Gauge)
Diesel Oxidation Catalyst with Diesel Particulate Filter
Exhaust Manifold
Exhaust Pipe (Front)
Selective Catalytic Reduction CatalystVIII. Engine Emissions Control Systems/Sensors
Accelerator Pedal Module
Camshaft Position Sensor
Charge Air Pressure Sensor
Charge Air Temperature Sensor
Crankshaft Position Sensor
DEF Control Module
Engine Control Module
Engine Coolant Temperature Sensor
Exhaust Back Pressure Sensor
Exhaust Differential Pressure Sensor
Exhaust Gas Temperature Sensor
Fuel Temperature Sensor
Heated Cooling Water Thermostat
Manifold Air Pressure Sensor
Mass Air Flow Sensor (with Integrated Intake Air
Temperature Sensor)
NO
X Sensor
O
2 Sensor
Transmission Control Module
Vehicle Speed Sensor (Front Wheels)
Vehicle Speed Sensor (Rear Wheels)
IX. On-Board Diagnostics
Data Link Connector (OBD)
Instrument Cluster (Malfunction Indicator Lamp)
X. Related Parts w/ Above Systems
Automatic Transmission Mode Selector
Emission Related:
Hoses, Clamps, Belts, Pulleys, Tubes,
Fittings, Sealing Devices, Mounting Hardware
included
Emission Warranties Required By Law

Service and Warranty17
California Emission Warranty (cont’d)
Coverage
LONG-TERM EMISSION-RELATED PARTS
(CA, CT, MA, MD, ME, NJ, NM, OR, PA, RI,
VT, WA):
Part Description:
Charge Air Cooler
Charge Air Distribution Line
DEF Control Module
DEF Delivery Pump (with Pressure Sensor)
DEF Tank (with Temperature Sensor and Fluid Level
Gauge)
Diesel Oxidation Catalyst with Diesel Particulate Filter
EGR Cooler
EGR Valve
Electric Intake Air Throttle
Engine Control Module
Exhaust Manifold
Exhaust Pipe (Front)
Fuel Injector
Fuel Pump (Electric)
Fuel Rail
Fuel Tank (with Vent Valve and Fuel Filler Neck)
Glow Time Control Module
High Pressure Pump
Instrument Cluster (Malfunction Indicator Lamp)
Intake Port Shutoff
Mass Air Flow Sensor (with Integrated Intake Air
Temperature Sensor)
NO
X Sensor
Selective Catalytic Reduction Catalyst
Transmission Control Module
Turbocharger
Emission Warranties Required By Law