steering MERCEDES-BENZ SPRINTER 2020 MY20 with no MMS Operator’s Manual

4)
Only NAFTAt rail er cross member ,tow ing capa‐
cit y5 ,000 or 7,500 lbs.
6) In trailer operation, no individual maximu mper‐
missible gross weight of those specified in the
ta ble ma ybeexceeded.
8) The vehicle lengt hfor vehicles wit hthe model
series 90 7.65 7( Ca rgoV an) is 29 0in(7,36 7m m).
9) It is no tpossible to towat railer on vehicles
whic hhaven otbeen equipped wi thatrailer cou‐
plin gass tandard. In this case, them aximum per‐
missible gross vehicle weight cor responds tothe
maximu mpermissible gross weight of thev ehicle
combination.
% If
th et railer coupling is retrofitted ,the identi‐
fi cation pla tess hould be adap teda ccording ly
wit hthe altered, maximum permissible
we ights. Please consult an authorized
Mercedes-Benz Center if youh ave anyf ur‐
th er questions. The body builder label is
found on thef ront-end
module abo vether adiator and con tains them axi‐
mum permissible curb weight fort he vehicles. Lashing points and car
rier sy stems Information abou
tthe cargo tie-down points *
NO
TERisk of accident if them aximum
loading capacity of thec argo tie-down
point is exceeded If
yo uc ombin evarious cargo tie-down points
to secur eaload, alw ayst aket he maximum
loading capacity of thew eakes tcargo tie-
down poin tint oa ccount.
During maximum full- stop braking, forc es may
act whic hcan multipl ythe weight of thel oad. #
Alwaysu se se veralc argo tie-down
point stod istribut eand spread thel oad.
Distribut ethe load on thec argo tie-
down points evenly. The nominal
tensil estrengt histhe maximum per‐
missible tensil eforce.
Fu rther information on thec argo tie-down points
and tie-down eyes can be obtained in the" Trans‐
po rting" section (/ page 179).
Ti e-d owne yes
No minal tensile stre ngt hoft he tie-down eyes Ti
e-d owne yesN ominaltensile
st re ngth
Pa ssenger Van3 50 daN
Cargo Van8 00 daN Loading
rails
No minal tensile stre ngth of thec argo tie-
down point sinthe cargo compartment Cargo tie-down
point
No
minal tensile
st re ngth
Loading rails on cargo
compartment floor 500 daN
Lo we rloading rail on
side wall 200 daN
Up per loading rail on
side wall 12
5d aN The
values specified appl yonlytol oads resting
on thec argo compartmen tfloor if youo bse rve
th ef ollowing:
R The load is secured totwoc argo tie-down
points on ther ail
R The dis tance tothen eares tload-securing
point on thes ame rail is appr oximately 1m Information about
roof racks &
WARNING Risk of inju ryif maximum roof
load is exceeded
If yo up laceal oad on ther oof as well as any
ex tern al and internal attachments ,the vehi‐
cle's center of gr avity will be raised and the
usual drivin gcharacteristics, as well as the
st eering and braking characteristics, will
ch ange. During cornering ,the vehicle will tilt
mor eseve rely an dmayreact mor esluggishly
to steering mo vements.
If yo ue xceed them aximum roof load, the
driving characteristics, as well as thes teering 260
Tech nica ldata

and brakin
gcharacteristics, will be greatly
impaired. #
Alwaysc ompl ywitht he maximum roof
load and adjus tyour driving style. &
WARNING Danger of accident du eto
une venl oading
If yo ul oad thev ehicle une venly, theh andling
ch aracteristic saswell asthes teering‑ and
braking characteristic scan be heavily
impaired. #
Load thev ehicle evenly. #
Secu rethel oad agains tsliding. The driving, braking and
steering characteristics
of thev ehicle will chang ewitht he type of load,
th ew eight and thec enter of gr avity of thel oad.
* NO
TERisk of accident if them aximum
permitted roof load is exceeded. If
th ew eight of ther oof luggage, including the
ro of rack ,e xceeds them aximum permitted
ro of load, ther eisar isk of an accident. #
Ensur ethat thew eight of ther oof lug‐
ga ge and roof rack toget her does not
exc eed them aximum permitted roof
load. #
The roof rack 's supporting feet mus tbe
ar ranged at aunifo rm distan ce from
ea ch other. #
Mercedes-Benzr ecommendsyoui nstall
as tabilizer bar on thev ehicle's front
axle. Fu
rther information about saf etym easures can
be found in the" Transport" section
(/ page179).
Max. roof load/pair sofsupporting roof rack
fe et Ve
hicles
with Maximum
ro
of load Minimum
number of
pair
sofs up‐
porting feet
Normal roof 66 1lbs
(300 kg) 6
High roof 33 1lbs
(150 kg) 3 This information applies if
thel oad is distributed
eve nly across thee ntir eroof area.
If th er oof rack is shor ter,re duce thel oad propor‐
tionatel y.The maximum load per pair of support‐
ing roof rack feet is110l bs (50 kg).
The loading guidelines and other information
about load distribution and load securing can be
fo und in the" Transport" sectio n(/pag e179). Te
ch nica ldata 261

Displa
ymessages
Possible causes/consequences and 0050 0050Solutions #
Stop in accordance wit hthe tra ffic conditions. #
Clean all sensor s(/pag e195). #
Restar tt he engine.
SOS NOT READY *T
he emergency call sy stem is no tavailable.
Po ssible causes fort his include:
R The ignition is switched off.
R The emer gency cal lsyst em is malfunctioning. #
Switc hont he ignition.
If an emergency call is una vailable, amessag etothis ef fect will
appea ronthe multifunction displa yofthe instrument clus ter. #
Visit aq ualified specialis tworks hop.
% Yo
uc an find mor einformation on ther egional availabilit yofthe
emergency call sy stem at :http://www.mercedes-benz.com/
connect_ecall
007A
0025
00E5 Inoperative See Opera-
tor's Manual *
EBD,A BS and ESP ®
arem alfunctioning.
Other driving sy stems and driving saf etys ystems ma yalso be mal‐
functioning. &
WARNING Risk of skidding if EBD, ABS and ESP ®
arem al‐
functioning
If EBD, ABS and ESP ®
arem alfunctioning ,the wheels can lock
when braking and ESP ®
canno tcarry out vehicle stabilization.
The steering capability and braking characteristic sarethus
se verely impaired .The brakin gdista nc einane mergency brak‐
ing situation can increase. In addition, other driving saf etys ys‐
te ms ar eswitched off. #
Driv eonc arefully. #
Have theb rake system checkedi mmediately at aqualified
specialis tworks hop. #
Driv eonc arefully. #
Consult aqualified specialis tworks hop immediatel y.
00E5 Inoperative See Opera-
tor's Manual *
ESP ®
is malfunctioning.
Other driving sy stems and driving saf etys yst ems ma yalso be mal‐
functioning.
The brak esystem continues working wit hthe normal ef fect. The
braking dis tance ma yincrease in eme rgency braking situations. &
WARNING Risk of skidding if ESP ®
is malfunctioning
If ESP ®
is malfunctioning ,ESP ®
canno tcarry out vehicle stabili‐
zation .Inaddition ,other driving saf etys ystems ar eswitched off. #
Driv eonc arefull y. #
Have ESP ®
ch eckedataq ualified specialis tworks hop. 266
Displa ymessages and warning and indicator lamps

Displa
ymessages
Possible causes/consequences and 0050 0050Solutions #
Driv eonc arefull y. #
Consult aqualified specialis tworks hop immediatel y.
00E5 Currently Unavailable
See Operator's Manual *
ESP ®
is temp orarily una vailable.
Other driving sy stems and driving saf etys yst ems ma yalso be mal‐
functioning. &
WARNING Risk of skidding if ESP ®
is malfunctioning
If ESP ®
is malfunctioning ,ESP ®
canno tcarry out vehicle stabili‐
zation .Inaddition ,other driving saf etys ystems ar eswitched off. #
Driv eonc arefull y. #
Have ESP ®
ch eckedataq ualified specialis tworks hop. #
Carefully driv esome gentle cur vesatas peed greater than
19 mp h(30 km/h) on asuitable stre tchofr oad. #
Ifth ed ispla ymessag edoes no tdisappear ,visit aqualified spe‐
cialis tworks hop immediately .Drive carefully when doing so.
0025
00E5
Currently Unavailable
See Operator's Manual *
ABS and ESP ®
aret emporarily una vailable.
Other driving sy stems and driving saf etys ystems ma yalso be tem‐
porarily una vailable. &
WARNING Risk of skidding if ABS and ESP ®
arem alfunc‐
tioning
If ABS and ESP ®
arem alfunctioning ,the wheels could loc kwhen
braking and ESP ®
cann otcar ryout vehicle stabilization.
The steering capability and braking characteristic sarethus
se verely impaired .The brakin gdista nc einane mergency brak‐
ing situation can increase. In addition, other driving saf etys ys‐
te ms ar eswitched off. #
Driv eonc arefully. #
Have ABS and ESP ®
ch eckedi mmediately at aqualified
specialis tworks hop. #
Carefully driv esome gentle cur vesatas peed greater than
19 mp h(30 km/h) on asuitable stre tchofr oad. #
Ifth ed ispla ymessag edoes no tdisappear ,visit aqualified spe‐
cialis tworks hop immediately .Drive carefully when doing so.
0025
00E5
Inoperative See Opera-
tor's Manual *
ABS and ESP ®
arem alfunctioning.
Other driving sy stems and driving saf etys ystems ma yalso be mal‐
functioning.
The brak esystemc ontinues working wit hthe normal ef fect. The
braking dis tance ma yincrease in eme rgency braking situations. Displa
ymessages and warning and indicator lamps 267

Displa
ymessages
Possible causes/consequences and 0050 0050Solutions &
WARNING Risk of skidding if ABS and ESP ®
arem alfunc‐
tioning
If ABS and ESP ®
are malfunctioning ,the wheels could loc kwhen
braking and ESP ®
cann otcar ryout vehicle stabilization.
The steering capability and braking characteristic sarethus
se verely impaired .The brakin gdista nc einane mergency brak‐
ing situation can increase. In addition, other driving saf etys ys‐
te ms ar eswitched off. #
Driv eonc arefully. #
Have ABS and ESP ®
ch eckedi mmediately at aqualified
specialis tworks hop. #
Driv eonc arefully. #
Consult aqualified specialis tworks hop immediatel y. Drivin
gsystems Displa
ymessages
Possible causes/consequences and 0050 0050Solutions
ð
Maximum Speed Excee-
ded *Y
ou ha veexc eeded them aximum permitted speed (specific coun‐
tries only). #
Driv emores lowl y.
Cruise Control Inopera-
tive *C
ruise control is malfunctioning. #
Visit aq ualified specialis tworks hop.
00B2
Off *C
ruise control has been deactivated.
If aw arning tone also sounds, this means cruise control has deacti‐
va tedi tself automatically (/ page151).
00B2 --- mph *C
ruise control canno tbeactivated as no tall activation conditions
ha ve been met. #
Obser vethea ctivation conditions of cruise cont rol
( / pag e151).
Active Dist ance Assist
Inoperative *A
ctiv eDista nce Assi stDISTRONI Cismalfunctioning.
Other driving sy stems and driving saf etys ystems ma yalso be mal‐
functioning. #
Visit aq ualified specialis tworks hop.
Active Distance Assist
Currently Unavailable
See Operator's Manual *A
ctiv eDista nce Assi stDISTRONI Cistemporaril yunavailable.
The ambien tcondition sareoutsid ethe sy stem limits (/ page152). #
Driv eon.
Whe nthe ambient conditions ar ewithin thes ysteml imits, the
sy stem will be available again. 268
Displa ymessages and warning and indicator lamps

Ti
res Displa
ymessages
Possible causes/consequences and 0050 0050Solutions
Tire Pressure Monitor
Inoperative No Wheel
Sensors *T
he ins talled wheels do no thave suitable tir epressur esensors. The
tir ep ressur emonitor has been switched off. #
Install wheels wit hsuitable tir epressur esensors.
0077
Tire Press .Sen.M issing *T
he tir epressur esensor signal is missing from one or mor etires.
No pressur evalue is displa yedf or thet ireinq uestion. #
Have thef aulty tir epressur esensor replaced at aqualified spe‐
cialis tworks hop.
Tire Press. Monitor Cur-
rently Unavailable *T
her eisi nterfere nce from apowe rful source of radio wav es As a
re sult, no signals from thet irep ressur esensor sare re ceived. The
tir ep ressur emonitor is temp orarily una vailable. #
Continue driving.
As soon as thec ause has been eliminated, thet irep ressure
monitor automaticall yswitches on.
0077 Warning Tire Malfunction *T
he pressur einone or mor etires suddenl yfalls. The wheel position
is shown. &
WARNING Risk of an accident from driving wi thaflat tire
Flat tires ar edangerous in thef ollowing ways:
R The tires can overheat and cause afire.
R The driving characteristics, as well as steering and braking,
ma ybeg reatl yimp aired.
Yo uc oul dthen lose contro lofthevehicle. #
Do no tdrive wit haf lat tire. #
Obser vethen otes on flat tires. In
fo rm atio nabout flat tires (/ page201). #
Stop thev ehicle in accordance wit hthe tra ffic conditions. #
Chec kthe tires.
0077 Check Tires *T
he pressur einone or mor etires has fallen significantl y.The wheel
position is shown. &
WARNING Risk of an accident du etoinsufficient tir epres‐
sure
Ti re pressures that ar etoo lo wpose thef ollowing hazards:
R The tires ma yburst,e speciall yasthe load and vehicle speed
increase.
R The tires ma ywear excessivel yand/or une venly ,w hich may
greatly impair tir etraction.
R The driving characteristics, as well as steering and braking,
ma ybeg reatl yimp aired.
Yo uc oul dthen lose contro lofthevehicle. #
Obser vether ecommended tir epressu re. 276
Displaymessa gesa nd warning and indicator lamps

Displa
ymessages
Possible causes/consequences and 0050 0050Solutions
003B
Inoperative Battery Low *T
he on-boar delectrical sy stem voltag eist oo lo w.
The stationar yheater has swit ched off. #
Driv eane xtende ddista nc eu ntil theb atter yhas been suf fi‐
ciently charge da gain.
00CC
Steering Malfunction
Increased Physical Effort
See Operator's Manual *T
hesteering po werassi stanc eism alfunctioning. &
WARNING Risk of an accident du etoaltered steering char‐
acteristics
If th ep owe rassi stanc eoft hesteering fails partiall yorcom‐
ple tely,y ou will need touse mor eforce tosteer. #
If saf esteering is possible, driv eoncarefully. #
Visit or consult aqualified specialis tworks hop immedi‐
atel y. #
If saf esteering is possible, driv eoncarefully. #
Visit or consult aqualified specialis tworks hop immediately.
00CC
Steering Malfunction
Stop Immediately See
Operator's Manual *T
hesteering is malfunctioning. Steerability is heavily impaired. &
WARNING Risk of accident if steering capability is impaired
If th es teering does no tfunction as intended, thev ehicle's oper‐
ating saf etyisj eopardized. #
Pull overand stop thev ehicle safely as soon as possible,
paying attention toroad and traf ficc onditions. Do no tcon‐
tinue driving under an ycircums tances. #
Consult aqualified specialis tworks hop. #
Stop thev ehicle immediately in accordance wit hthe traf ficc on‐
ditions. Do no tcontinu edriving. #
Consul taqualified specialis tworks hop.
Shift to 'P' or 'N' to Start
Engine *
Yo uh ave attem pted tostar tt he engine in transmission position 005B
or 005E. #
Shif tthe transmission toposition 005Dor005C.
To Engage Transmiss.
Position RFirst Depress
the Brake *
Yo uh ave attem pted toshif tfromp osition 005Bor005C toposition 005E. #
Depress theb rake pedal. #
Shif tthe transmission toposition 005E.
Air Conditioning Malfunc-
tion See Operator's Man-
ual *T
he function of thec limat econt rols ystemist emporarily restricted.
The quantity of air and flow of fresh air ar econt rolled automaticall y. #
Have thec limat econt rols ystemc heckedataq ualified specialist
wo rkshop.
Auxiliary Battery Mal-
function *T
he auxiliary batteryfor thet ransmission is no longer being
ch arge d. #
Visit aq ualified specialis tworks hop. #
Until then, alw ayss hiftthe transmission toposition 005Dmanually
befor eyou switc hoffthee ngine. Displa
ymessages and warning and indicator lamps 279

Wa
rning/indicator
lamp Po
ssible causes/consequences and 0050 0050Solutions
00E5
ESP ®
wa rning lamp
fl ashes The ESP
®
ye llo ww arning lam pflashes during ajou rney.
* ESP ®
inter venes (/ page 147). #
Adapty our driving styletot heweather and road conditions.
00BB ESP ®
OFF warning lamp The ESP
®
OFF yello ww arning lam plight supw hilethee ngine is on.
* ESP ®
has been switched off. &
WARNING Risk of skidding whe ndriving wi thESP ®
deacti va‐
ted
If ESP ®
is deactivated, ESP ®
canno tcarry out vehicle stabilization.
The availabilit yoffurther driving saf etys yst ems is also limited. #
Driv eonc arefull y. #
Only deactivat eESP®
forasl ong as thes ituation requ ires.
If ESP ®
canno tbeactivated, ESP ®
is malfunctioning. #
Have ESP ®
ch eckedi mmediately at aqualified specialist
wo rkshop. #
Compl ywithi nstructions toswitc hESP®
of f(/pag e147).
0025 ABS warning lamp The AB
Syello ww arning lam plight supw hilethee ngine is on.
*AB Sism alfunctioning.
If an additional warning tone sounds, this means theE BD is malfunc‐
tioning.
Other driving sy stems and driving saf etys ystems ma yalso be mal‐
functioning. &
WARNING Thereisrisk of skidding if EBD or ABS is malfunc‐
tioning
If EBD or ABS is malfunctioning, thew heels could loc kwhen brak‐
ing
The steering capability and braking characteristic sarethus
se verely impaired .The brakin gdista nc einane mergency braking
situation can increase. In addition, other driving saf etys yst ems
ar es witched off. #
Driv eonc arefull y. #
Have theb rake system checkedi mmediately at aqualified
specialis tworks hop. #
Driv eonc arefully. #
Obser vethem essages on them ultifunction displa y. #
Visit aq ualified specialis tworks hop. 288
Displa ymessages and warning and indicator lamps

Seat belt
Wa
rning/indicator
lamp Po
ssible causes/consequences and 0050 0050Solutions
0076
Seat belt warning lamp
fl ashes The seat belt
redw arning lam pflashes and an intermit tent wa rning tone
sounds.
*The driver or front passenger doe snothave their belt on while the
ve hicle is in motion (speeds abo ve15 mp h(25 km/h)). #
Putont he seat belt (/ page34).
*Ther eareobject sonthe front passenger seat. #
Remo vetheo bject sfromt he front passenger seat.
0076
Seat belt warning lamp
light sup The seat belt
redw arning lam plight supa fter thee ngine has star ted.
Aw arning tone ma yalsos ound.
*Whe nthe vehicle is stationary: The seat belt warning lam preminds
driver sand front passenger stoput on their seat belt. #
Put on thes eat belt (/ page34).
Objects on thef ront passenger seat ma ypreve nt thes eat belt warn‐
ing lam pfromg oing out. Driving sy
stems Wa
rning/indicator
lamp Po
ssible causes/consequences and 0050 0050Solutions
00BA
Dis tance warning lamp The
redd ista nce warning lam plight supw hileyoua redrivin gand a
wa rning tone sounds.
*Y ou ar eapproaching an obs tacle at tooh igh aspeed. #
Beready toappl ythe brakes immediatel y. #
Increase thed ista nce. Ve
hicle Wa
rning/indicator
lamp Po
ssible causes/consequences and 0050 0050Solutions
00CC
Po we rsteering sy stem
wa rning lamp The po
wersteering sy stem redw arning lam plight supw hilethee ngine
is on.
*The po wersteering assis tance or thes teering itself is malfunctioning. &
WARNING Risk of accident if steering capability is impaired
If th es teering no longer functions as intended, thev ehicle's oper‐
ating saf etyisj eopardized. #
Consult aqualified specialis tworks hop. #
Obser vethem essages on them ultifunction displa y. Displ
aymessa gesa nd warning and indicator lamps 289

Wa
rning/indicator
lamp Po
ssible causes/consequences and 0050 0050Solutions
00B9
Engine diagnosis warning
lamp The
yello wC heckEngine warning lam plight supw hilethee ngine is on.
*A malfunction has occur redint he engine, thee xhau stsystem or the
fuel sy stem.
The emissions limit value ma yhave been exceeded and thee ngine
ma yber unninginemergency ope ratio nm ode. #
Have thev ehicle checkedass oon as possible at aqualified spe‐
cialis tworks hop. Ti
res Wa
rning/indicator
lamp Po
ssible causes/consequences and 0050 0050Solutions
0077
Ti re pressur emonitoring
sy stem warning lamp
fl ashes The
yello wt irep ressur emonitoring sy stem warning lam p(pressure
loss/malfunction) flashes forr oughly one minut eand then lights up per‐
manentl y.
*The ti repressur emonitoring sy stem is malfunctioning. &
WARNING Thereisar isk of an accident if thet irep ressure
monitoring sy stem is malfunctioning
If th et irep ressur emonitoring sy stem is malfunctioning, it is not
able toissue awarning if ther eisp ressur eloss in one or mor eof
th et ires.
Un derinflated tires ma y,fore xamp le, impair thed riving, steering
and braking characteristics. #
Have thet irep ressur emonitoring sy stem checkedataq uali‐
fi ed specialis tworks hop. #
Visit aq ualified specialis tworks hop.
0077
Ti re pressur emonitoring
sy stem warning lamp
light sup The tir
epressur emonitor yello ww arning lam p(pressur eloss/malfunc‐
tion )light sup.
*The tir epressur emonitor has de tected atirep ressur elossinatl east
one tire. &
WARNING Risk of an accident du etoinsufficient tir epres‐
sure
Ti re pressures that ar etoo lo wpose thef ollowing hazards:
R The tires ma yburst,e speciall yasthe load and vehicle speed
increase.
R The tires ma ywear excessively and/or une venly, whic hmay
greatl yimp air tir etraction.
R The drivin gcharacteristics, as well as steering and braking,
ma ybeg reatl yimp aired.
Yo uc oul dthen lose contro lofthevehicle. #
Obser vether ecommended tir epressu re. #
Adjus tthe tir epressur eifn ecessar y. Displ
aymessa gesa nd warning and indicator lamps 291