power steering Mercury Grand Marquis 2005 s User Guide

2. While the engine idles, turn the steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the
reservoir. It should be between the
MIN and MAX lines. Do not add
fluid if the level is in this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the range between the MIN and MAX lines. Be
sure to put the cap back on the reservoir.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels below the “MAX” line
that do not trigger the brake system
warning lamp are within the normal
operating range, there is no need to
add fluid. If the fluid levels are outside of the normal operating range,
the performance of your brake system could be compromised, seek
service from your dealer immediately.
TRANSMISSION FLUID
Checking automatic transmission fluid (if equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transmission does not
consume fluid. However, the fluid level should be checked if the
transmission is not working properly, i.e., if the transmission slips or
shifts slowly or if you notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is at normal operating
temperature (approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic during hot
DONOTOVERFILLPOWERSTEERINGFLUID
MAX
MIN
MAX
2005 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
236

REFILL CAPACITIES
Fluid Ford Part Name Capacity
Engine oil (includes
filter change)
6Motorcraft SAE 5W-20
Premium Synthetic
Blend Motor Oil (US)
Motorcraft SAE 5W-20
Super Premium Motor
Oil (Canada)6.0 quarts (5.7L)
Brake fluid Motorcraft High
Performance DOT 3
Motor Vehicle Brake
Fluid
1
Fill to line on reservoir
Power steering fluid Motorcraft MERCON
AT FFill to line on reservoir
Transmission fluid
(4R70/75 E)
2Motorcraft
MERCONVATF13.9 quarts (13.2L)3
Engine coolant4Motorcraft Premium
Gold Engine Coolant
(yellow-colored)18.6 quarts (17.6L)
Fuel tank N/A 19.0 gallons (71.9L)
Rear axle lubricant
5Motorcraft SAE
80W-90 Premium Rear
Axle Lubricant5.0 pints (2.4L)
Windshield washer
fluidMotorcraft Premium
Windshield Washer
ConcentrateFill to line on reservoir
1Use only brake fluids certified to meet Ford specifications. Refer to
Lubricant Specificationsin this chapter. DOT 3 fluid is recommended.
However, if DOT 3 is not available, DOT 4 fluid can be used.
2Ensure the correct automatic transmission fluid is used. MERCONand
MERCONV are not interchangeable. DO NOT MIX MERCONand
MERCONV. Refer to thescheduled maintenance informationto
determine the correct service interval.
3Indicates only approximate dry-fill capacity. Some applications may vary
based on cooler size and if equipped with an in-tank cooler. The amount
of transmission fluid and fluid level should be set by the indication on
the dipstick’s normal operating range.
4Add the coolant type originally equipped in your vehicle.
2005 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
241

Item Ford part
nameFord part
numberFord
specification
Hinges, latches,
striker plates,
fuel filler door
hinge and seat
tracksMulti-Purpose
GreaseXG-4 or XL-5 ESB-M1C93-B
Lock cylinders Motorcraft
Penetrating and
Lock LubricantXL-1 none
Power steering
fluidMotorcraft
MERCONAT FXT-2-QDX MERCON
Automatic
transmission
(4R70/75 E-W)Motorcraft
MERCONV
AT F
3
XT-5-QM
MERCONV
Rear Axle
Lubricant
2Motorcraft SAE
80W-90
Premium Rear
Axle LubricantXY-80W90-QL WSP-M2C197-A
Windshield
washer fluidMotorcraft
Premuim
Windshield
Washer
ConcentrateZC-32-A WSB-M8B16–A2
1Use only brake fluids certified to meet Ford specifications. DOT 3 fluid
is recommended. However, if DOT 3 is not available, DOT 4 fluid can be
used.
2Add 4 oz. (118 ml) of Additive Friction Modifier XL–3 or equivalent
meeting Ford specification EST-M2C118-A for complete refill of
Traction-Lok rear axles.
3Ensure the correct automatic transmission fluid is used. Transmission
fluid requirements are indicated on the dipstick or on the dipstick
handle. MERCONand MERCONV are not interchangeable. DO NOT
mix MERCONand MERCONV. Refer to yourscheduled maintenance
informationto determine the correct service interval.
2005 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
243

Climate control (see Air
conditioning or Heating) ............35
Clock adjust
6-CD in dash .............................31
AM/FM/CD .................................22
AM/FM/Tape/CD .......................26
Compass, electronic
set zone adjustment .................53
Console ........................................76
overhead ..............................51–52
Controls
power seat .................................94
steering column ........................66
Coolant
checking and adding ..............219
refill capacities ................223, 241
specifications ..................242, 244
Cruise control (see Speed
control) ........................................63
Cupholder(s) ...............................96
Customer Assistance ................180
Ford accessories for your
vehicle .....................................209
Ford Extended Service Plan .202
Getting assistance outside the
U.S. and Canada .....................203
Getting roadside assistance ...180
Getting the service you need 196
Ordering additional owner’s
literature .................................203
The Dispute Settlement
Board .......................................199
Utilizing the
Mediation/Arbitration
Program ...................................201
D
Daytime running lamps (see
Lamps) .........................................38Defrost
rear window ..............................37
Dipstick
automatic transmission
fluid ..........................................236
engine oil .................................213
Doors
lubricant specifications ..........242
Driving under special
conditions ..................................178
through water .........................179
E
Electronic message center .........72
Emergencies, roadside
jump-starting ..........................190
Emission control system ..........233
Engine ........................................244
cleaning ...................................206
coolant .....................................219
fail-safe cooling .......................224
idle speed control ...................217
lubrication
specifications ..................242, 244
refill capacities ........................241
service points ..........................212
starting after a collision .........181
Engine block heater .................166
Engine oil ..................................213
change oil soon warning,
message center .......................213
checking and adding ..............213
dipstick ....................................213
filter, specifications ........216, 240
recommendations ...................216
refill capacities ........................241
specifications ..................242, 244
Exhaust fumes ..........................166
2005 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
251

Keys .......................................78, 90
positions of the ignition .........163
L
Lamps
autolamp system .......................38
bulb replacement
specifications chart ..................43
daytime running light ...............38
headlamps .................................38
headlamps, flash to pass ..........39
instrument panel, dimming .....39
interior lamps ...............42–44, 48
replacing bulbs ....... 43–44, 46–48
Lane change indicator (see
Turn signal) .................................41
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........168
Limited slip axle (see Traction
Loc) ............................................178
Load limits .................................153
Locks
autolock .....................................85
childproof ..................................79
doors ..........................................78
Lubricant specifications ...242, 244
Lug nuts ....................................143
Lumbar support, seats ...............93
M
Message center ...........................72
reset button ..............................72
select button .............................73
Mirrors .........................................50
automatic dimming rearview
mirror ........................................62
fold away ...................................62heated ........................................62
side view mirrors (power) .......62
Moon roof ....................................67
Motorcraft parts ................230, 240
O
Octane rating ............................229
Oil (see Engine oil) ..................213
P
Parking brake ............................169
Parts (see Motorcraft parts) ....240
Passenger Occupant
Classification Sensor ...................97
Pedals (see Power adjustable
foot pedals) .................................63
Power adjustable foot pedals .....63
Power distribution box (see
Fuses) ........................................186
Power door locks ..................78, 85
Power mirrors .............................62
Power point .................................60
Power steering ..................171–172
fluid, checking and adding ....235
fluid, refill capacity ................241
fluid, specifications .................242
Power Windows ...........................61
R
Radio ................................20, 23, 28
Rear window defroster ...............37
Relays ................................182, 189
Remote entry system .................80
illuminated entry ......................84
2005 Grand Marquis(grn)
Owners Guide (post-2002-fmt)
USA(fus)
Index
253