brake pads Mercury Mariner Hybrid 2007 Owner's Manuals

BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Check fluid levels with the ignition
in the RUN position. Fluid levels
between the “MIN” and “MAX” lines
are within the normal operating
range; there is no need to add fluid.
If the fluid levels are outside of the
normal operating range the
performance of your brake system could be compromised; seek service
from your authorized dealer immediately.
Brake pad replacement information
The Regenerative Braking System checks the integrity of the brake
system at times when the vehicle is parked. This is done by developing
brake pressure for short periods of time. In order to change the brake
pads, it is necessary to enter the Pad Service Mode. This will prevent
brake pressure from being applied.
To enter the Pad Service Mode, perform the following with the vehicle
stationary:
1. Place the vehicle in Park and turn ignition to the ON position.
2. Apply the brake pedal.
3. Turn the ignition OFF, then ON three times and then release the brake
pedal. The total time elapsed for the three ignition cycles and brake
release must be less than 3 seconds.
The brake warning lamp will:
•flash as stored hydraulic pressure is released.
•remain illuminated once the pressure is completely released.
•flash if the brake is applied.
To exit the Pad Service Mode:
1. Apply the brake pedal and turn the ignition OFF then ON. This will
cause brake pressure to be developed within the brake system. Once
brake pressure is developed, the brake warning light will turn off.
2. The Pad Service Mode will also be exited if the gear shift lever is
moved from the (P) Park position, the vehicle is moved (wheels rotate)
or the ignition is turned OFF.
MAX
MIN
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
288

site. You’ll also find important warranty information, customer assistance,
technical expertise, frequently asked questions and much more. The Web
site location is: www.ford.com.
Then go to the vehicles and services pick at the Web site.
U.S. SCHEDULE
5,000 miles (8,000 km)
❑Inspect tires for wear and measure tread depth❑Rotate tiresDEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
10,000 miles (16,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect high voltage battery A/C filter, replace if necessary
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
20,000 miles (32,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Inspect steering linkage, suspension and, if equipped, half-
shafts, driveshaft and ball joints
❑Inspect exhaust system and heat shields❑Replace high voltage battery A/C filter
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
307

30,000 miles (48,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect high voltage battery A/C filter, replace if necessary❑Replace engine air filter
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
40,000 miles (64,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Inspect steering linkage, suspension and, if equipped, half-
shafts, driveshaft and ball joints
❑Inspect exhaust system and heat shields❑Replace high voltage battery A/C filter
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
50,000 miles (80,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect high voltage battery A/C filter, replace if necessary
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
308

60,000 miles (96,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Inspect steering linkage, suspension and, if equipped, half-
shafts, driveshaft and ball joints
❑Inspect exhaust system and heat shields❑Replace high voltage battery A/C filter❑Replace engine air filter
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
70,000 miles (112,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect high voltage battery A/C filter, replace if necessary
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
80,000 miles (128,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Inspect steering linkage, suspension and, if equipped, half-
shafts, driveshaft and ball joints
❑Inspect exhaust system and heat shields❑Replace high voltage battery A/C filter
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
309

90,000 miles (144,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect high voltage battery A/C filter, replace if necessary❑Replace engine air filter
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
100,000 miles (160,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Inspect steering linkage, suspension and, if equipped, half-
shafts, driveshaft and ball joints
❑Inspect exhaust system and heat shields❑Replace high voltage battery A/C filter❑Replace fuel filter❑Replace engine coolant and motor/electrical coolant (see
Motorcraft Premium Gold Coolant Change Record)
❑Inspect accessory drive belt❑Replace spark plugs
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
110,000 miles (176,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect high voltage battery A/C filter, replace if necessary
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
310

120,000 miles (192,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Inspect steering linkage, suspension and, if equipped, half-
shafts, driveshaft and ball joints
❑Inspect exhaust system and heat shields❑Replace high voltage battery A/C filter❑Replace engine air filter
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
130,000 miles (208,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect high voltage battery A/C filter, replace if necessary
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
140,000 miles (224,000 km)
❑Change engine oil and replace oil filter❑Inspect tires for wear and measure tread depth❑Rotate tires❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Inspect steering linkage, suspension and, if equipped, half-
shafts, driveshaft and ball joints
❑Inspect exhaust system and heat shields❑Replace high voltage battery A/C filter
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
311

18,500 miles (30,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Lubricate hinges, latches and locks❑Lubricate weatherstrips❑Inspect steering linkage, suspension and, if equipped, drive-
shaft and ball joints
❑Replace high voltage battery A/C filter❑Inspect engine air filter*❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
28,000 miles (45,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect high voltage battery A/C filter, replace if necessary*❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
37,500 miles (60,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Lubricate hinges, latches and locks❑Lubricate weatherstrips❑Inspect steering linkage, suspension and, if equipped, drive-
shaft and ball joints
❑Replace high voltage battery A/C filter❑Replace engine air filter*❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
313

47,000 miles (75,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect high voltage battery A/C filter, replace if necessary*❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
56,000 miles (90,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Lubricate hinges, latches and locks❑Lubricate weatherstrips❑Inspect steering linkage, suspension and, if equipped, drive-
shaft and ball joints
❑Replace high voltage battery A/C filter❑Inspect engine air filter*❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
65,000 miles (105,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect high voltage battery A/C filter, replace if necessary*❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
314

75,000 miles (120,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Lubricate hinges, latches and locks❑Lubricate weatherstrips❑Inspect steering linkage, suspension and, if equipped, drive-
shaft and ball joints
❑Replace high voltage battery A/C filter❑Replace engine air filter*❑Replace fuel filter*❑Replace engine coolant and motor/electrical coolant* (see
Motorcraft Premium Gold Coolant Change Record)
❑Multipoint inspection*❑Inspect PCV valve for flow, replace if required*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
84,000 miles (135,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect high voltage battery A/C filter, replace if necessary*❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
94,000 miles (150,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Lubricate hinges, latches and locks❑Lubricate weatherstrips❑Inspect steering linkage, suspension and, if equipped, drive-
shaft and ball joints
❑Replace high voltage battery A/C filter❑Inspect engine air filter*❑Multipoint inspection*❑Replace spark plugs*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
315

103,000 miles (165,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect high voltage battery A/C filter, replace if necessary*❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
112,000 miles (180,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect brake pads, shoes, rotors, drums, brake lines and
hoses and parking brake
❑Inspect engine and motor/electrical cooling system and hoses❑Lubricate hinges, latches and locks❑Lubricate weatherstrips❑Inspect steering linkage, suspension and, if equipped, drive-
shaft and ball joints
❑Replace high voltage battery A/C filter❑Replace engine air filter*❑Replace engine coolant and motor/electrical coolant* (see
Motorcraft Premium Gold Coolant Change Record)
❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
120,000 miles (195,000 km)
❑Change engine oil and replace oil filter*❑Inspect tires for wear and measure tread depth❑Inspect high voltage battery A/C filter, replace if necessary*❑Multipoint inspection*
DEALERVALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
316