Transmission Mercury Monterey 2005 s Owner's Guide

BRAKE FLUID RESERVOIR
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the “MIN” and
“MAX” lines are within the normal
operating range; there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range the performance of your
brake system could be
compromised; seek service from
your dealer immediately.
TRANSMISSION FLUID
Checking automatic transmission fluid
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transaxle does not consume
fluid. However, the fluid level should be checked if the transaxle is not
working properly, i.e., if the transaxle slips or shifts slowly or if you
notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Maintenance and Specifications
279

7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated areas for normal operating temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is at the bottom of the dipstick
and the outside temperatures are
above 50°F (10°C).
Correct fluid level
The transmission fluid should be checked at normal operating
temperatures 150°F-170°F (66°C-77°C) on a level surface. The normal
operating temperature can be reached after approximately 20 miles (30
km) of driving.
The transmission fluid should be in
this range if at normal operating
temperature (150°F-170°F
[66°C-77°C]).
High fluid level
Fluid levels above the safe range
may result in transaxle failure. An
overfill condition of transmission
fluid may cause shift and/or
engagement concerns and/or possible damage.
High fluid levels can be caused by an overheating condition.
Adjusting automatic transmission fluid levels
Before adding any fluid, make sure the correct type is used. The type of
fluid used is normally indicated on the dipstick and also in the
Lubricant specificationssection in this chapter.
Use of a non-approved automatic transmission fluid may cause
internal transaxle component damage.
If necessary, add fluid in 1/2 pint (250 mL) increments through the filler
tube until the level is correct.
If an overfill occurs, excess fluid
should be removed by a qualified
technician.
An overfill condition of
transmission fluid may cause shift and/or engagement concerns
and/or possible damage.
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Maintenance and Specifications
280

Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transmission components.
AIR FILTER MAINTENANCE
Refer toscheduled maintenance informationfor the appropriate
intervals for changing the air filter element.
When changing the air filter element, use only the Motorcraft air filter
element listed. Refer toMotorcraft part numbersin this chapter.
Note:Do not start your engine with the air cleaner removed and do not
remove it while the engine is running.
Changing the air filter element
1. Disconnect the Mass Air Flow
Sensor electrical connector from the
air outlet tube.
Reposition the locking clip (on the
connector) and squeeze connector
to remove.
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Maintenance and Specifications
281

2Ensure the correct automatic transmission fluid is used MERCONand
MERCONV are not interchangeable. DO NOT MIX MERCONand
MERCONV. Refer toscheduled maintenance informationto
determine the correct service interval.
ENGINE DATA
Engine 4.2L OHV V6 engine
Cubic inches 256
Required fuel 87 octane
Firing order 1-4-2-5-3-6
Ignition system EDIS
Spark plug gap 0.052–0.054 inch (1.32–1.42mm)
Compression ratio 9.27:1
VEHICLE DIMENSIONS
Vehicle dimensions Wagon - inches (mm)
(1) Overall length 201.0 (5105)
(2) Overall width 76.4 (1941)
(3) Overall height
*68.7 (1745)
(4) Wheelbase 120.8 (3069)
(5) Track - Front 64.7 (1644)
(5) Track - Rear 62.8 (1595)
*Equipped with P235/60R16 tires.
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Maintenance and Specifications
289

1. World manufacturer identifier
2. Brake type and gross vehicle
weight rating (GVWR)
3. Vehicle line, series, body type
4. Engine type
5. Check digit
6. Model year
7. Assembly plant
8. Production sequence number
Engine number
The engine number (the last eight numbers of the vehicle identification
number) is stamped on the engine block, transmission, frame and
transfer case (if equipped).
Transmission/Transaxle code designations
You can find a transmission/transaxle code on the vehicle certification
label. The following table tells you which transmission or transaxle each
code represents.
Code Description
N Four-speed automatic (AX4N)
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Maintenance and Specifications
292

A
Accessory delay ..........................65
AdvanceTrac ..............................211
Air bag supplemental restraint
system ................142–143, 149, 152
and child safety seats ............144
description ..............143, 149, 152
disposal ....................................155
driver air bag ..........145, 150, 153
indicator light .................149, 154
operation .................145, 150, 153
passenger air bag ...145, 150, 153
side air bag ..............................149
Air cleaner filter ...............281, 285
Air filter, cabin ............................40
Antifreeze
(see Engine coolant) ................263
Anti-lock brake system
(see Brakes) ......................210–211
Anti-theft system ......................107
arming the system ..................107
disarming a triggered
system .....................................107
Audio system
(see Radio) ......................17, 20, 23
Automatic transaxle .................214
fluid, adding ............................279
fluid, checking ........................279
fluid, refill capacities ..............286
fluid, specification ..................289
Automatic transmission
driving an automatic
overdrive .................................216
Auxiliary power point .................63
Axle
lubricant specifications ..........287
B
Battery .......................................261acid, treating emergencies .....261
jumping a disabled battery ....232
maintenance-free ....................261
replacement, specifications ...285
servicing ..................................261
BeltMinder .................................137
Brakes ........................................210
anti-lock ...........................210–211
anti-lock brake system (ABS)
warning light ...........................210
fluid, checking and adding ....279
fluid, refill capacities ..............286
fluid, specifications .........287, 289
lubricant specifications ..287, 289
parking ....................................211
shift interlock ..........................214
Bulbs ............................................48
C
Capacities for refilling fluids ....286
Cargo net .....................................89
Cassette tape player .......17, 20, 23
Cell phone use ............................71
Certification Label ....................291
Child safety restraints ..............155
child safety belts ....................155
Child safety seats ......................158
in front seat ............................159
in rear seat ..............................159
tether anchorage hardware ...162
Cleaning your vehicle
engine compartment ..............249
instrument panel ....................251
interior .....................................251
interior trim ............................251
plastic parts ............................250
washing ....................................248
waxing .....................................248
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
295

wheels ......................................249
wiper blades ............................250
Clock ............................................63
Compass, electronic ....................55
calibration .................................57
set zone adjustment .................56
Console ........................................71
overhead ....................................55
Controls
power seat ...............................110
steering column ........................71
Coolant
checking and adding ..............263
refill capacities ................267, 286
specifications ..................287, 289
Cruise control
(see Speed control) ....................68
Cupholder(s) .............................114
Customer Assistance ................222
Ford accessories for your
vehicle .....................................252
Ford Extended Service
Plan ..........................................245
Getting assistance outside the
U.S. and Canada .....................245
Getting roadside assistance ...222
Getting the service you
need .........................................239
Ordering additional owner’s
literature .................................246
The Dispute Settlement
Board .......................................242
D
Daytime running lamps
(see Lamps) ................................42Dipstick
automatic transmission
fluid ..........................................279
engine oil .................................257
Doors ...........................................58
lubricant specifications ..........287
power sliding ............................59
Driving under special
conditions ..................................217
through water .........................221
E
Emergencies, roadside
jump-starting ..........................232
Emission control system ..........276
Engine ........................................289
cleaning ...................................249
coolant .....................................263
idle speed control ...................261
lubrication
specifications ..................287, 289
refill capacities ........................286
service points ..........................256
starting after a collision .........223
Engine block heater .................209
Engine oil ..................................257
change oil soon warning,
message center .......................257
checking and adding ..............257
dipstick ....................................257
filter, specifications ........260, 285
recommendations ...................260
refill capacities ........................286
specifications ..................287, 289
Exhaust fumes ..........................209
F
Floor mats ...................................72
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
296

Transmission
brake-shift interlock (BSI) ....214
fluid, checking and adding
(automatic) .............................279
lubricant specifications ..........287
Turn signal ..................................46
V
Vehicle dimensions ...................289
Vehicle Identification Number
(VIN) ..........................................291
Vehicle loading ..........................194
Ventilating your vehicle ...........209W
Warning lights (see Lights) .......10
Washer fluid ..............................257
Water, Driving through .............221
Windows
power .........................................65
rear wiper/washer .....................53
Windshield washer fluid and
wipers ..........................................53
checking and adding fluid .....257
liftgate reservoir .....................257
replacing wiper blades .............54
Wrecker towing .........................238
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
300