ignition MINI Coupe 2012 Service Manual

CareMOBILITY
161
Care
Vehicle equipment
In this chapter, all production, country, and
optional equipment that is offered in the model
range is described. Equipment is also described
that is not available because of, for example,
selected options or count ry version. This also
applies to safety related functions and systems.
Car-care products
Regular cleaning and care helps to maintain the
value of your MINI.
The manufacturer of your MINI recommends
using manufacturer-approved products to clean
and care for your vehicle.
Your MINI dealer would be pleased to advise
you on cleaning and care products and services
for your MINI.
The ingredients of original MINI Care
Products have been tested, and the
products have been tested in the laboratory
and in practice. They offer optimum care and
protection for your vehicle. <
Do not use any cleansers containing
alcohol or solvents as these may cause
damage. <
Cleaning agents may contain hazardous
or health-damaging substances. Follow
the warning and hazard instructions on the
packaging. For interior cleaning, always open
the doors or windows of the vehicle.
Do not use any products that are not intended
for cleaning the vehicle. <
External care
Washing your vehicle
Especially during the winter months the
vehicle should be frequently washed. Dirt
and road salt can damage the vehicle.<
After washing the vehicle, apply the
brakes briefly to dry them; otherwise,
water can reduce braking efficiency over the
short term and the brake rotors can corrode. <
Car washes
Preference should be given to cloth car washes.
Do not use automatic high-pressure car
washes; otherwise, water may drip into
the vehicle around the windows. <
Before driving into the car wash, check if the
system is suitable for your MINI. Observe the
following points:
> Vehicle dimensions, page 197.
> If necessary: fold in the outside mirrors,
page 49.
> Maximum permissible tire width.
Avoid car washes with tracks higher than
4 in/10 cm; otherwise, the chassis could
be damaged. <
Preparations for driving into the car wash:
> Unscrew the rod antenna.
> MINI Coupe, MINI Roadster: retract spoiler.
> Deactivate the rain sensor to prevent
unintentional wiping.
> Remove additional attachments, e.g.
spoilers or telephone antennas, if there is
a possibility that they could be damaged.
> Insert the remote control into the ignition
lock.
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG

MOBILITYCare
162
Automatic transmission
Before driving into the car wash, make sure that
the vehicle can roll:
1.Place the remote control, even with Comfort
Access, in the ignition lock.
2. Move the selector lever to position N.
3. Release the parking brake.
4. Switch off the engine.
5. Insert the remote control in the ignition lock
so that the vehicle can roll.
Steam jets/high-pressure washers
When using steam jets or high-pressure
washers, make sure that you maintain
sufficient distance from the vehicle and do not
exceed a maximum temperature of 140 7/
60 6 .
If the distance is too close, the pressure too high,
or the temperature too high, parts of the vehicle
can be damaged, or water can penetrate.
Observe the operating instructions for high-
pressure washers. <
Do not spray sensors, such as the Park
Distance Control, with high-pressure
washers for a long time or at a distance of less
than 1 ft/30 cm. <
Manual washing
Use a great deal of water and, if necessary, car
shampoo when washing your car by hand. Clean
the vehicle with a sponge or a washing brush
applying a slight amount of pressure.
Before cleaning the windshield, deacti-
vate the rain sensor or turn off the ignition
to prevent unintentional wiping. <
Observe local regulations regarding
washing vehicles by hand. <
Headlamps
Do not wipe dry and do not use abrasive or
corrosive cleaning agents. Remove dirt and
contamination, such as in sects, by soaking with
shampoo and then washing with plenty of
water. Do not remove accumulated ice and snow with
an ice scraper; use window deicers instead.
Windows
Clean the outside and inside of the windows and
mirrors with a window cleaner.
Do not clean the mirrors with cleaners
containing quartz. <
Wiper blades
Clean with soapy water and change regularly to
prevent the formation of streaks.
Wax, preservatives and dirt on the
windows cause streaks when the wind-
shield wipers are on, and can cause premature
wear of the wiper blades and interfere with the
rain sensor. <
Care of the convertible top
The appearance and service life of the conver-
tible top largely depends on its proper care and
operation.
Please follow these instructions:
>Never attempt to fold and stow the conver-
tible top in the convertible compartment
when the top is wet or frozen. Otherwise,
water stains, mildew, and chafe marks may
occur.
> If water spots occur on the inside headliner
despite precautions, remove them using a
microfiber cloth and interior cleaner.
> If the vehicle is parked in an enclosed area
for a longer period of time, make sure that
there is sufficient ventilation.
> Remove any bird droppings immediately,
since they have corrosive properties which
will corrode the conver tible top and damage
the rubber seals.
When attempting to remove stains from
the convertible top, do not use spot
removers, paint thinners, solvents, gasoline, or
similar fluids. These cleaners may damage the
rubber seals. The improper care or cleaning
methods may cause the convertible top and its
seams to leak. <
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG

Giving and receiving assistanceMOBILITY
179
Using a tow fitting
The screw-in tow fitting must always be carried
in the car. It can be screwed in at the front or
rear of the MINI.
It is stored in the toolkit in the cargo area under-
neath the cover on the right-hand side,
page165.
Use only the tow fitting provided with the
vehicle and screw it all the way in. Use the
tow fitting for towing on paved roads only. Avoid
lateral loading of the tow fitting, e.g. do not lift
the vehicle by the tow fitting. Otherwise, the tow
fitting and the vehicle could be damaged. <
Access to screw thread
Push out the cover of the towing eye out of the
recess in the bumper.
Front
Rear
John Cooper Works with aerodynamic bumper:
Pull out the bottom of the cover panel of the
towing eye in the bumper, arrow.
Being towed
Make sure that the ignition is switched on,
refer to page55; otherwise, the low
beams, tail lamps, turn signals, and windshield
wipers may be unavailable. Do not tow the
vehicle with just the rear axle raised, as this
would allow the steering to turn. <
There is no power assist while the engine is off.
Thus, braking and steering will require increased
effort.
Switch on the hazard warning flashers,
depending on local regulations.
Manual transmission
Gearshift lever in neutral position.
Automatic transmission
Tow vehicles with automatic transmission
only with a tow truck or with the front
wheels lifted; otherwise, the transmission can be
damaged. <
Towing with a tow bar
The towing vehicle must not be lighter
than the towed vehicle; otherwise, it may
be impossible to maintain control. <
The tow fittings used should be on the same side
on both vehicles. Should it prove impossible to
avoid mounting the tow bar at an angle, please
observe the following:
> Clearance and maneuvering capability will
be sharply limited during cornering.
> The tow bar will generate lateral forces if it is
attached offset.
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG

MOBILITYGiving and receiving assistance
180
Only attach the tow bar to the tow fittings,
as attachment to other vehicle parts can
lead to damage. <
Towing with a tow rope
When starting off in the towing vehicle, make
sure that the tow rope is taut.
To avoid jerking and the associated
stresses on vehicle components when
towing, always use nylon ropes or nylon straps.
Attach the tow rope to the tow fittings only, as
attaching it to other pa rts of the vehicle could
result in damage. <
Towing with a tow truck
Have the MINI transported by a tow truck with a
so-called lift bar or on a flat bed.
Do not lift vehicle by tow fitting or body
and chassis parts, otherwise damage may
result. <
Tow-starting
Avoid tow-starting the vehicle whenever possi-
ble; instead, jump-start the engine, page 177.
Vehicles with a catalyti c converter should only
be tow-started when the engine is cold, vehicles
with an automatic transmission cannot be tow-
started at all.
1. Switch on hazard warning flashers, comply
with local regulations.
2. Switch on the ignition, page 55.
3. Shift into 3rd gear.
4. Have the vehicle tow-started with the clutch
completely depressed and then slowly
release the clutch. Afte r the engine starts, immediately depress the clutch completely
again.
5. Stop at a suitable lo cation, remove the tow
bar or rope and switch off the hazard
warning flashers.
6. Have the vehicle checked.
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG

MOBILITYIndicator and warning lamps
182
Lights up briefly:
Approx. 2.1 US gal/8 liters of fuel are
still in the tank
Remains on:
Cruising range is no more than
30 miles/50 km, page65
Engine refuses to start Depress th e brake or clutch in order to
start the engine, page 55.
Ignition switched on and driver's door
open Switch off the ignition, page
55, or
close the driver's door.
Lamps still on
Roadside parking lamps on
Door open
Hood open
Tailgate open
Cargo area cover in the MINI
Convertible Convertible top cannot be activated.
Bring cargo area cover in required
position, re
fer to page 109.
Lights up in red:
Convertible top not locked Convertible top not locked. First
completely open or close the
convertible top, and then continue
the trip, page 35 and 42.
12Cause What to do
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG

MOBILITYIndicator and warning lamps
188
Lights up in red:Have the system in question checked
without delay.
> Starter failed or The engine cannot be restarted.
> Ignition malfunctioning. Engine
restart only possible when brake
is depressed or
> Lighting system failed. Low
beams/tail lamps and brake
lamps still operational. All other
lamps failed Depress the brake to start the engine
again.
Lights up in yellow:
> Control of the brake lamps failed
or
> fuel supply malfunctioning You can continue your journey, but
moderate your speed and exercise
due caution. Have the system in
question checked without delay.
> Drive malfunctioning You can continue your journey, but
moderate your speed and exercise
due caution. Transmission limp-home
program active with restricted range
of gears. Have the system checked
immediately.
Flashing:
Dynamic Stability Control DSC or
Dynamic Traction Control DTC is
controlling drive and braking forces,
refer also to page 76
Dynamic Traction Control DTC is
activated, refer also to page 77
The Dynamic Stability Control DSC
and Dynamic Traction Control DTC
are deactivated, refer also to page 76Driving stability limited during
acceleration and cornering.
Driving style must be adjusted.
12Cause What to do
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG

MOBILITYIndicator and warning lamps
192
Selector lever position P not engaged.
Ignition cannot be switched offEngage selector lever position P when
you wish to switch off the ignition,
page
55.
Cruise control system fail edHave the system checked.
Park Distance Control fail edHave the system checked.
Bulb of exterior lighting system failed Have the exterior lighting checked as
soon as possible.
Low-beam headlamp or fog lamp
failed Have the lamps checked as soon as
possible.
High-beam headlamp failed Have the high-beam headlamps
checked.
Rear fog lamp failed Have the rear fog lamp checked.
Headlamp beam throw adjustment
system failed Have the headlamp beam throw
adjustment system checked.
Coolant level too low Add coolant immediately, page158.
Engine oil pressure too low Stop immediately and switch off the
engine. You cannot continue your
journey. Contact your MINI dealer.
Lights up in red:
Service appointment overdue Arrange a service appointment.
Check service requirements, page 71.
Lights up in yellow:
Service due Arrange a service appointment.
Check service requirements, page 71.
12Cause What to do
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG

REFERENCEEverything from A to Z
208
Cleaning headlamps62
– washer fluid 62
Clock
– setting time 73
– 12 h/24 h mode 70
Closing
– from inside 27
– from outside 23
Clothes hooks 100
Cockpit 10
Cold start, refer to Starting the engine 56
Comfort Access 31
– replacing the battery 33
– what to observe before entering a car wash 32
Comfort area, refer to Around the center console 14
Compartment for remote
control, refer to Ignition
lock 55
Compressed audio files 121
Computer 66
Condensation, refer to When the vehicle is parked 108
Condition Based Service CBS 159
Configuring settings, refer to
Personal Profile 22
Connecting vacuum cleaner,
refer to Connecting electrical
appliances 101,102
Consumption, refer to Average
fuel consumption 66
Control Display
– settings 68
Controls and displays 10
Convenience operation
– windows 24
Convenient access, refer to Comfort Access 31
Convenient start, refer to
Starting the engine 56
Convertible top 34
– manual 39
– mechanical 39 Coolant
158
– checking level 158
– filling 158
– temperature 158
Cooling, maximum 97
Cooling fluid, refer to Coolant 158
Copyright 2
Cornering light, refer to Adaptive Light Control 90
Cruising range 66,67
Cupholders 101
Curb weight, refer to
Weights 203
Current fuel consumption 67
D
Dashboard, refer to Cockpit
10
Dashboard instruments, refer to Displays 12
Dashboard lighting, refer to
Instrument lighting 92
Data 196
– capacities 205
– dimensions 197
– engine 196
– weights 203
Data memory 160
Date
– setting 73
Daytime running lights 89
DBC Dynamic Brake Control,
refer to Brake Assist 76
Deactivating front passenger airbags 85
Deadlocking, refer to Locking 25
Defect
– door lock 27
– fuel filler flap 140
Defogging windows 96,98
Defrosting windows 96,98
Defrosting windows and removing condensation
– air conditioner 96
– automatic climate control 98Defrosting windshield, refer to
Defrosting windows 96,98
Defrost positi on, refer to
Defrosting windows 96,98
Differential, breaking in 106
Digital radio, refer to HD Radio 119
Dimensions 197
Dipstick, engine oil 156
Directional indicators, refer to
Turn signals 60
Displacement, refer to Engine data 196
Display lighting, refer to Instrument lighting 92
Displays 12
– care 164
– instrument panel 12
Displays and controls 10
Disposal
– of coolant 158
– remote control battery 33
– vehicle battery 176
Distance remaining to service, refer to Service
requirements 71
Distance warning, refer
to Park
Distance Control PDC 75
Door key, refer to Integrated key/remote control 22
Door lock 26
Door lock, confirmation signals 25
Doors, manual operation 27
DOT Quality Grades 151
Drinks holders, refer to
Cupholders 101
Drive-off assistant, refer to Hill Assist 78
Driving dynamics control, refer to Sport button 78
Driving lamps, refer to Parking
lamps/low beams 88
Driving notes 106
Driving off on inclines, refer to
Hill Assist 78
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG

Everything from A to ZREFERENCE
209
Driving stability control systems 76
Driving through water 107
Driving tips, refer to Driving
notes 106
Dry air, refer to Cooling function 98
DSC Dynamic Stability Control 76
DTC Dynamic Traction
Control 77
Dynamic Brake Control DBC, refer to Brake Assist 76
Dynamic Stability Control DSC 76
Dynamic Traction Control
DTC 77
E
Eject button 122
Electrical malfunction
– convertible top 36,42
– door lock 27
– fuel filler flap 140
– tailgate 28
Electric power windows
– initializing 33
Electronic brake-force distribution 76
Electronic Stability Program ESP, refer to Dynamic
Stability Control DSC 76
Emergency operation, refer to Manual operation
– convertible top 36,42
– door lock 27
– fuel filler flap 140
– transmission lock, automatic
transmission 59
Emergency operation, see manual operation
– tailgate 28
Emergency services, refer to Roadside Assistance 177
Emergency unlocking 29
Ending a call 134 Engine
– breaking in
106
– data 196
– overheated, refer to Coolant
temperature 158
– speed 196
– starting, Comfort Access 31
Engine compartment 155
Engine coolant, refer to Coolant 158
Engine oil
– additives, refer to Approved engine oils 157
– alternative oil types 157
– approved engine oils 157
– capacity 157
– checking level 156
– dipstick 156
– intervals between changes,
refer to Service
requirements 71
– MINI Maintenance
System 159
Engine oil level, checking 156
Engine output, refer to Engine
data 196
Engine starting, refer to Starting the engine 56
ESP Electronic Stability Program, refer to Dynamic
Stability Control DSC 76
Exhaust system, refer to Hot exhaust system 107
Exterior mirrors 49
– adjusting 49
– auto

matic heating 50
– folding in and out 49
External audio device 99,116
External care 161
External temperature display
– change units of measure 70
– in the onboard computer 70
Eyes
– for tow-starting and towing away 179
– for tying down loads 111
F
Failure messages, refer to
Check Control 73
Failure of an electrical consumer 176
Fastening safety be lts, refer to
Safety belts 48
Fast forward
– CD 121
Fault messages, refer to Check
Control 73
Filter
– microfilter/activated- charcoal filter for automatic
climate control 98
– microfilter for air conditioner 96
Fine wood, care 164
First aid pouch 177
Fixture for remote control, refer to Ignition lock 55
Flash when locking/ unlocking 25
Flat tire
– run-flat tires 152
– Tire Pressure Monitor TPM 82
Flat Tire Monitor FTM 80
– indicating a flat tire 81
– initializing the system 80
– snow chains 80
– system limits 80
Flat tires, refer to Tire
condition 151
Floor mats, care 164
Fog lamps
– replacing bulb 168,170
Folding roof, refer to Convertible top with
integrated sliding sunroof 34
Footbrake, refer to Braking safely 107
Footwell lamps 92
For your own safety 4
Front airbags 85
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG

REFERENCEEverything from A to Z
210
Front fog lamps91
– indicator lamp 181
– replacing bulb 168
Front seat adjustment 46
Frost on windows, refer to Defrosting windows 96,98
FTM, refer to Flat Tire
Monitor 80
Fuel 141
– fuel tank volume 205
– gauge 65
– high-quality brands 141
– quality 141
Fuel clock, refer to Fuel gauge 65
Fuel consumption display
– average fuel consumption 66
Fuel display, refer to Fuel gauge 65
Fuel filler flap 140
– releasing in the event of electrical malfunction 140
Fuel specifications 141
Fuses 176
G
Gasoline
– refer to Average fuel
consumption 66
– refer to Required fuel 141
Gasoline display, refer to Fuel gauge 65
Gear indicator
– automatic transmission with Steptronic 58
Gear shifting
– automatic transmission 58
– manual transmission 57
Gearshift lever
– automatic transmission with Steptronic 58
– manual transmission 57
General driving notes 106Glass roof, electric
– convenience operation
24
– remote control 24
Glove compartment 99
Gong
– volume 116
Grills, refer to Air vents 94
Gross vehicle weight, refer to Weights 203
H
Halogen lamps
– replacing bulb 167
Handbrake, refe r to Parking
brake 57
Hands-free system 14,136
Hazard warning flashers 14
HD Radio 119
Head airbags 85
Headlamp control, automatic 88
Headlamp flasher 60
– indicator lamp 11,95,181
Headlamp glass lens 166
Headlamps
– care 162
– replacing bulb 167
Head Light, refer to Adaptive Light Control 90
Head restraints 47
– sitting safely 45
Heated
– mirrors 50
– rear window 95,98
– seats 48
Heating 94
– mirrors 50
– rear window 95,98
– seats 48
Heavy loads, refer to Stowing cargo 111
Height, refer to Dimensions 197 Height adjustment
– seats
46
– steering wheel 50
High beams 91
– headlamp flasher 91
– indicator lamp 95,181
– replacing bulb 167
High water, refer to Driving through water 107
Hill Assist 78
Hills 107
Holders for cups 101
Homepage 4
Hood 156
Horn 10
Hot exhaust system 107
Hydroplaning 107
I
IBOC, refer to HD Radio 119
Ignition 55
– switched off 56
– switched on 55
Ignition key, refer to
Integrated key/remote
control 22
Ignition key position 1, refer to
Radio readiness 55
Ignition key position 2, refer to
Ignition on 55
Ignition lock 55
Imprint 2
Incoming call 133
Indicator and warning lamps 13,181
– Tire Pressure Monitor TPM 83
Indicator lighting, refer to Instrument lighting 92
Individual air distribution 96
Individual settings, refer to Personal Profile 22
Inflation pressure monitoring, refer to Tire Pressure Monitor
TPM 82
Online Edition for Part no. 01 40 2 914 786 - \251 07/12 BMW AG