Compressor MITSUBISHI 3000GT 1994 2.G User Guide

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Cooling Circuit185

OPERATIONThe engine control module controls the power
transistors (high speed and low speed) in the moduleto provide radiator fan motor and condenser fan
motor rotation controls in accordance with the engine
coolant temperature and vehicle speed.
NOTEIn the event of faulty water temperature sensor,
the engine control module commands the fan motors
(for both radiator and condenser) to rotate at high
speeds.1. Radiator Fan (Low Speed Rotation)
l
When the engine control module turns onthe power transistor (low speed) in the
module, the current flows from the ignition
switch to the engine control module throughthe radiator fan motor relay (LO) coil.
If the current flows to the fan motor relay
coil, the switch of the relay turns on to supplythe motor driving power (for low speed
rotation). This will cause the current to flow
from the battery to the ground through the
radiator fan motor, relay switch and resistor,rotating the radiator fan at low speeds.
2. Condenser Fan (Low Speed Rotation)
l
The power from the NC compressor lock
controller turns on the condenser fan motorrelay (LO) to rotate the condenser fan at
low speeds.3. Radiator Fan, Condenser Fan (High
Speed Rotation)l
When the engine control module turns onthe power transistor (high speed) in the
module. the radiator fan motor relay (HI)
and condenser fan motor relay (HI) will
operate and the motor driving power (for
high speed rotation) is sent to the radiator
fan motor and condenser fan motor to rotate
the radiator fan and condenser fan at high
speeds.
TROUBLESHOOTING HINTS1. Neither the radiator fan nor condenser
fan rotate at all.
l Check fusible link No. 5.
2. Only the condenser fan does not
operate.l Check dedicated fuse No. 8.
3. The condenser fan do not operate in the
low speed mode, but operate otherwise.
(1) The A/C compressor magnet clutch does
not enter the “ON” state.l Check whether the output of the air
conditioning compressor lock controller
unit is available.
(2) The A/C compressor magnet clutch enters
the “ON” state.l
Check the condenser fan motor relay
(LO)-4. The radiator fan and condenser fan do
not operate in the high speed mode, but
operate otherwise.l Check the engine control unit.
Fan Operating Mode
VehicleA/C compressor lockspeedcontroller output
k%
80 or less[50 or less]
LO
(OV)
80 or more[50 or more]HI (12V)
,_ -
Engine coolanttemperature
$1
Approx. 95 [203] or less
Approx. 95
[203] or more
Approx. 105
[221] or more
Approx. 105
[221] or less
Approx. 105
[221] or more
Approx. 105
[221] or less
Approx. 105
12211 or moreTransistor
Transistor
in enginein engineRadiatorCondensercontrol unitcontrol unitfanfan
Low speedHigh speed
OFF
OFFOFFOFF
ONOFFLow speedOFF
ON
ONHigh speedHigh speed
OFF
OFFOFFOFF
ONONHigh speedHigh speed
ON
OFFLow speedLow speed
ON
ONHigh speedHigh speed
1 TSB Revision1

Downloaded from www.Manualslib.com manuals search engine 188CIRCUIT DIAGRAMS - EL(=-4 A/T Circuit
ELC-4 A/T CIRCUIT (1992 MODEL) (CONTINUED)
MGB6 EbAIR CONDITIONINGA/T FLUID
COMPRESSOR LOCK
CONTROLLER$$/g;;ATURE
I
--_-----_-
ENGINE CONTROL MODULE 1
I (cooL)(HOT)I45W-B1
G-RI1
G-‘
_-----
i
3o,(c-52:
7
(c-
I ! L-WWW-R II\3 (c-29)
drIOD OR0(G-RSTORAGECONNECTOR m^
I08E
(DOHC-Non-Turbo>
6--------- -_______818
(Y-W)
BR-C
4Y-W
Y-W
I
6m
10
I
SPEED
SENSOR
(@%*)
.I
1
‘iOFF- ON
------_
(P:
)P-------
P
)
IGNITION
POWER
TRANSISTOR;;;XbERATOR(Y-R)
SWITCH
(c-13)
AUTO-CRUISE =CONTROL UNITH
:A LINKJNECTOR-
HR07MOOBA
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - ELC-4 A/T Circuit
ELC-4 A/T CIRCUIT (1994, 1995 MODELS) (FEDERAL) (CONTINUED)
d
A/T FLUIDTEMPERATURE ENGINE CONTROL MODULE
SENSOR AIR CONDITIONING
COMPRESSOR LOCK
CONTROLLER
JL
l(c-52
L-W
!4----..
-----w-
T--
.FULL AUTO A/C.MAN'JAL A/C3
G-Y B-1G-R
MFI SYSTEMT
23.---_-----___ __
7
(c-54
W-L
17------_ G-R
11(c-77)2
----s
R-B
(c-29)
R-B 8
(A-67)
G-R
IOD OR
STORAGE
CONNECTOR
(A-11X)
(F>R-B
IDOOR LIGHTAND LUGGAGE~~ld~~"'"""'R-E‘d
DOME LIGHT,FOOT LIGHT
AND IGNITION
KEY CYLINDER
ILLUMINATION
LIGHT
HEADLIGHT
P
-I
61
G
1OFF - ON
-
Y-W
1
SPEED
SENSOR
(Y-
Y-
2B
DATA LINK CONNECTOR
(c-79)HR07M02BA
1 TSB Revision

Downloaded from www.Manualslib.com manuals search engine 200CIRCUIT DIAGRAMS - ELC-4 A/T Circuit
ELC-4 A/T CIRCUIT (1994, 1995 MODELS) (CALIFORNIA) (CONTINUED)
AIR CONDiTIONINGCOMPRESSOR LOCK
CONTROLLERENGINE CONTROLI,MODULE
3---
1
B-
i
2;-
i
7
SW-RI +G-RI
------.16
W-RI
loAO I.FULL AUTO A/C.MANUAL A/C
v(c-70) 1-- 2 (c-8cR R-Y
(F>R-
T-i
i12
1,
D 11
B
R-B(R-B)
(c-47),39
fIV
IOD ORSTORAGE
CONNECTOR
(A-11X)MFI SYSTEM 1/
(F)R-B
JDOOR LIGHT AND
LUGGAGE
COMPARTMENT
LIGHT
R-I
R-E3
1
I1~%“BF
4
l-
“i------
117
MFI(Y-W
SYSTEM
_TPI
BR-GY-W------------
10
w46 (c-47)MFI SYSTEM
(Y-W)!1I
IGNITION
?(c-14)
POWERTRANSISTOR
DOME 'LIGHTFOOT LIGHT'AND(c-46)
IGNITION KEY
CYLINDER
ILLUMINATION
LIGHT
(Y-R'HEADLIGHT
(P
(c-29)
2B
1=
SPEED
SENSOR(Y-RF
5
DATA LINK CONNECTOR
(c-79)%%““”SWITCH
(B-42)H
7M03BA
1 TSB Revision

Downloaded from www.Manualslib.com manuals search engine 244CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit
MANUAL AIR CONDITIONING CIRCUIT (1992 MODEL) (CONTINUED)
G-R
G-R
(A-67)
G-R
(G-R)G-R
AIR CONDITIONING
ENGINE COOLANT
&#FF'EATURE
ON-OFF:115’C(239’F)OFF-ON: 108’ C (226’ F)
L-R
(c-54)
r-
3----1IIIIII
I
I
!III
I I
IIIIIIi
115
G-O 2(G-0)
ON-OFF:210kPa (29.9~~ i)OFF-ON: 235kPa (33.4~5 i )ON-OFF
,\”DUAL;;FPJE;RE
(A-35):2100kPa(299Psi)
'1
W-G
,,s
THERMOSTAT'ON-OFF:155’C(311’F)OFF-ON: 110’ C (230’ F)OFF ‘*ON,(B-20) G-R“3
4t
EYWKB SEb
r-----I
i G-I;IIIIIII
I
I
I/I/
1 L
j G-k
L-----
B-\
pbw;;1c
RELAY
(A-33X)
B-W
.----___
G
-------
G
B-W
,-
ENGINE
E!6EL
COMPARISON
COMPRESSOR SPEED
OPERATION CIRCUIT
-
--3
1
(Y-G
IO.----
9
13
0 cci5) GEE)(B-03) [B-20) (c-02)(c-52)
HR12MOlBA
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit245
AIR~~~~~~10"'""J/B
ib#&PURPOSE1
AIR CONDITIONING
COMPRESSOR LOCK
CONTROLLER
11
CIRCUITI
I%%I%;:Y,C"IT\GNDGND
(W-E
COMBINATIONMETERCTACHO)
-.c
W(W-B
IGPPO)TRI
(G-Y)
i(D-42)
ION
ISTOR
14
I(B
7
;
I
)(B)
28
HR12MOlBB
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit247
AIR CONDITIONINGCOMPRESSOR LOCK BLCONTROLLERSW
(G-!
I6VT7
RHEOSTAT
W-E
'ER
FHw
1.25R-'
G-WG-h
(c-18)
AIRg&I;;;IONINGG-b
,3,\
,$IG
J
I 6
HT
-
DEDICATED
FUSE
J/B
,VIv\/ \, ,
"2
"45 6
R-YL-B(B-R) B-YB-Y0
B-Y
HR12MOlCB
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 250
CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit
MANUAL AIR CONDITIONING CIRCUIT (1993 MODELS) (CONTINUED)
Iji
G-RG
(A-67)
G-R
(G-R)(
MODULEAIR CONDITIONENGINE COOLAN#fK[ATURE
NG
iONON-OFF: 115’ C (239’ F)OFF-ON: 108’ C (226’ F)
F)G-E
(F)L-R
ON-OFF:210kPa(29.9Psi)OFF-ON: 235kPa (33.4PS i )ON-OFF&OlOE” (384Ps i 1
:2100kPa(299Dsi)
(F>W-
THERMOSTATON-OFF: 155’ C (311’ F)OFF-ONi:llO’C(230’F) OF’
0 (F>G
3---_1I,IIIIIII/1I:---
i G
IIIIIIII
I
I
I
IIIIII/II
I
I
I GL---
L-------
-R [
-R
B-W36--------
c1T
-..LL
"3
-YE
G
E
G
)*2
0
(F)B-W
;
'21
(G-l
r
----_
B-
COMPARISONI
COMPRESSOR SPEED
OPERATION CIRCUIT
3
(Y-F
3-------.
I
1
9
?
1 :
(F)Y-F
(B-20
1
(Y-G
10.---_
$‘(
1
-0‘L
TSB Revision1
HR12M02BA

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Manual Air Conditioning Circuit251
AIR&~~;$IONING
i
G
J/B
(MULTI-PURPOSE
FUSE @)
(B-R)AIR CONDITIONING
5COMPRESSOR LOCK
CONTROLLER11
ENGINE SIOPERATIOI
i
COMBINATIONMETERCTACHO)
lz
W
(W-B
;EEl
b
(G-k
IGNITION POWERTRANSISTOR
I(B(B:
10 (c-40)
SNDV-
I
4)
2EQ
a
HR12M02BB
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Manual Air Conditionina Circuit
L-k
(c-25)
AIR CONDITIONING
CONTROLLERCOMPRESSOR LOCK g6'
f
1
(G-k(G-Y
‘_----_
W-E
(c-18)
AIR~;B;;;IONING
------
oFF4!ji-jL; (
;;[i;IGHT
l.,,,-wl
G-WI
J/BG-W
'-"I
3
G-W
I2
>2 4
R-YL-B
I I7
2.-__------ ------~
9
G
IB-'r41
B-k, 11
IB-k
v
(c-15)
RHEOSTAT
HR12M02CB
1 TSB Revision