heater MITSUBISHI iMiEV 2012 1.G User Guide

Comfort controls
5-39
5

In the following circumstances, moisture can form on
compact discs and inside the audio system, preventing
normal operation.
• When there is high humidity (for example, when it is
raining).
• When the temperature suddenly rises, such as right after
the heater is turned on in cold weather.
In this case, wait until the moisture has had time to dry
out.

When the CD player is subjected to violent vibrations,
such as during off-road driving, the tracking may not
work.

When storing compact discs, always store them in their
separate cases. Never place compact discs in direct sun-
light, or in any place where the temperature or humidity is
high.

Never touch the flat surface of the disc where there isn’t a
label. This will damage the disc surface and could affect
the sound quality. When handling a compact disc, always
hold it by the outer edge and the center hole.

To clean a disc, use a soft, clean, dry cloth. Wipe directly
from the center hole toward the outer edge. Do not wipe in
a circle. Never use any chemicals such as benzine, paint
thinner, a disc spray cleaner, or an anti-static agent on the
disc.

Do not use a ball point pen, felt pen, pencil, etc. to write
on the label surface of the disc.
Do not put additional labels or stickers on compact discs.
Also, do not use any compact disc on which a label or
sticker has started to peel off or any compact disc that has
stickiness or other contamination left by a peeled-off label
or sticker. If you use such a compact disc, the CD player
may stop working properly and you may not be able to
eject the compact disc.
BK0140800US.book 39 ページ ２０１１年９月２９日　木曜日　午後３時２８分

For emergencies
6-3
6
2. Position the vehicles close enough together so that the
jumper cables can reach, but be sure the vehicles are not
touching each other.
3. Set the parking brake firmly on your vehicle and move the
selector lever into the “P” (PARK) position.
4. Set the parking brake firmly on the other vehicle. Put the
automatic transaxle in “P” (PARK) or the manual
transaxle in “N” (Neutral).
5. Turn the ignition switch (the electric motor switch) on
each vehicle to the “LOCK” position.NOTE
Turn off all lights, heater, and other electrical loads. This
will help avoid sparks.6. Remove the battery cover, and then make sure your 12V
starter battery electrolyte is at the proper level. (Refer to
“Checking 12V starter battery electrolyte level” on page
7-14.)
7. Connect one end of one jumper cable to the positive
(+) terminal of the discharged battery (A), and then con-
nect the other end to the positive (+) terminal of the
booster battery (B).
CAUTION
!
Check the other vehicle. It must have a 12V battery.
If the other system is not 12V, both systems can be
damaged.
WA R N I N G
!
If the electrolyte fluid is not visible, or looks frozen,
DO NOT ATTEMPT JUMP STARTING!!
The battery might split open or explode if the tem-
perature is below the freezing point or if it is not
filled to the proper level.
BK0140800US.book 3 ページ ２０１１年９月２９日　木曜日　午後３時２８分

7
Vehicle care and maintenance
Service precautions . . . . . . . . . . . . . . . . . . . . . . . .7- 2
Hood. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7- 4
View under the hood and
electric motor unit room . . . . . . . . . . . . . . . . . . .7- 6
Coolant/Hot water heater fluid. . . . . . . . . . . . . . . .7- 7
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7- 11
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7- 12
12V starter battery . . . . . . . . . . . . . . . . . . . . . . . . .7- 13
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7- 18
Brake pedal free play . . . . . . . . . . . . . . . . . . . . . . .7- 25
Parking brake lever stroke . . . . . . . . . . . . . . . . . . .7- 25
Wiper blades . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7- 26
General maintenance . . . . . . . . . . . . . . . . . . . . . . .7- 27
For cold and snowy weather . . . . . . . . . . . . . . . . .7- 28
Fusible links . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7- 28
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7- 29
Replacement of light bulbs . . . . . . . . . . . . . . . . . .7- 35
Vehicle care precautions . . . . . . . . . . . . . . . . . . . .7- 49
Cleaning the inside of your vehicle . . . . . . . . . . . .7- 50
Cleaning the outside of your vehicle . . . . . . . . . . .7- 52
BK0140800US.book 1 ページ ２０１１年９月２９日　木曜日　午後３時２８分

7-2 Vehicle care and maintenance
7Service precautions
N00937300361
Taking regular care of your vehicle helps preserve its value and
appearance as long as possible.
This vehicle is an electric vehicle and is equipped with many
high-voltage components. Refer to “High-voltage compo-
nents” on page 1-41.
You can do some of the maintenance work described in this
manual by yourself, but the rest must be performed only by a
certified i-MiEV dealer.
If you discover a malfunction or other problem, have it cor-
rected by a certified i-MiEV dealer.
Also follow the instructions and take note of the precautions
for each procedure.High voltage components and wiring cables are located as
shown in the figure below.
WA R N I N G
!
Never touch, remove or disassemble the high- volt-
age components including high- voltage wires col-
ored orange and their connectors. Doing so can
result in a fire, property damage, electrocution and
serious injury or death.
These components are affixed with a label indicating
precautions for handling. Follow the instructions on
the label. Take your vehicle to a certified i-MiEV
dealer for any necessary maintenance.
1- Regular charge port
2- MCU
3- Main drive lithium-ion battery
4- Heater
5- Air conditioner compressor
6- High voltage connector
7- Service plug
8- Electric motor (Electric motor unit)
9- On board charger/DC-DC converter
10- Quick charge port
BK0140800US.book 2 ページ ２０１１年９月２９日　木曜日　午後３時２８分

Vehicle care and maintenance
7-7
7 Coolant/Hot water heater fluid
N00937800539
To check the coolant levelCoolant1. Open the liftgate.
1- Windshield washer fluid reservoir
2- 12V starter battery
3- Hot water heater reservoir
4- Brake fluid reservoir
5- Coolant reservoirElectric motor unit room
WA R N I N G
!
Before checking the coolant level, make sure the
electric motor switch is in the “Lock” position to
avoid the risk of an electrical shock that can result in
serious injury or death.
The room under the hood and the electric motor
unit room (located under the luggage room carpet)
can be very hot after driving. Wait until they have
cooled down.
BK0140800US.book 7 ページ ２０１１年９月２９日　木曜日　午後３時２８分

Vehicle care and maintenance
7-9
7
4. Check the coolant level in the reservoir (D).
While the motor is cold, the coolant level must always be
between the “F (FULL)” and the “L (LOW)” marks. If
necessary, add coolant. Refer to “To add coolant” on page
7-10.
5. Reinstall the electric motor unit room lid and the luggage
room floor carpet by following the removal procedures in
reverse.
Hot water heater fluidThe reservoir (A) is located under the hood.
The coolant level in this reservoir should be kept between the
“F (FULL)” and the “L (LOW)” marks when measured while
the electric motor is cold. If necessary, add coolant. Refer to
“To add coolant” on page 7-10.
WA R N I N G
!
Never touch components inside the electric motor
unit room except the reservoir (D).
FULL
LOW
FULL
LOW
BK0140800US.book 9 ページ ２０１１年９月２９日　木曜日　午後３時２８分

Vehicle care and maintenance
7-31
7
*: Fusible link

Some fuses may not be installed on your vehicle, depend-
ing on the vehicle model or specifications.

The table above shows the main equipment corresponding
to each fuse.
No.
Symbol
Electrical system
Capacity
1 Tail light (left) 7.5 A
2Cigarette lighter/
12 V power outlet15 A
3 — — —
4Starter 7.5 A
5 Audio amplifier 20 A
6— — —
7 Tail light (right) 7.5 A
8 Outside rearview mirrors 7.5 A
9Control unit
(Electric motor unit)7.5 A
10 Control unit 7.5 A
11 Rear fog light 10 A
12 Door lock 15 A
13 Interior lights (Dome lights) 10 A
14 Rear window wiper 15 A
15 Gauges 7.5 A
16 Relay 7.5 A
17 Heated seat 20 A
18 Option 10 A
19Heated door outside rearview
mirrors7.5 A
20 Windshield wiper 20 A
21 Back-up lights 7.5 A
22 Defogger 30 A
23 Heater 30 A
24 12V starter battery 30 A*
25 Radio 10 A
26 Electronic controlled unit 15 A
27 — Electronic controlled unit 7.5 ANo.
Symbol
Electrical system
Capacity
BK0140800US.book 31 ページ ２０１１年９月２９日　木曜日　午後３時２８分

9-10 Specifications
9Refill capacities
N01148000989
*: similar high quality ethylene glycol based non-silicate, non-amine, non-nitrate and non-borate coolant with long life hybrid
organic acid technologyNo.
Item
Capacity
Lubricants
1
Windshield washer fluid 2.0 qt (1.9 L) —
2
Brake As required Conforming to Brake fluid DOT 3 or DOT 4
3
Hot water heater fluid
[Includes .42 qt (0.4 L) in reservoir]2.0 qt (1.9 L)
Dia Queen Super Long Life Coolant Premium or an equivalent*
4
Coolant
[Includes 1.2 qt (1.1 L) in reservoir]5.4 qt (5.1 L)
5
Transmission .79 qt (0.75 L) DIAMOND ATF SP III
6
Refrigerant (air conditioning)Refer to the “Air
conditioning label”
on page 9-2HFC-134a
BK0140800US.book 10 ページ ２０１１年９月２９日　木曜日　午後３時２８分

Alphabetical index
3
Specifications 9-8
Electric motor switch 3-30
Electric motor unit warning light 3-75
Electric power steering system (EPS) 3-44
Electric rear window defogger switch 3-89
Electronic immobilizer (Anti-theft starting system) 3-3
Energy level gauge 3-69
Energy usage indicator 3-60
EV charging cable 1-28
F
Floor mat 4-3
Fluid
Brake fluid 7-12
,9-10
Coolant 7-7
,9-10
Hot water heater fluid 7-7
,9-10
Washer fluid 7-11
,9-10
Fluid capacities and lubricants 9-10
Front fog lights
Bulb capacity 7-36
Indicator 3-72
Replacement 7-40
Switch 3-83
Front seats 2-3
Front side-marker lights
Bulb capacity 7-36
Replacement 7-38
Front turn signal lights
Bulb capacity 7-36Replacement 7-40
Fuses 7-29
Fusible links 7-28
G
Gauges 3-58
General maintenance 7-27
General vehicle data 9-6
Genuine parts 1-9
Glove compartment 3-129
H
Hazard warning flasher switch 3-83
Hazard warning lights 3-72
Head restraints 2-10
Headlights
Bulb capacity 7-36
Dimmer 3-81
Headlight flasher 3-81
Reminder buzzer 3-80
Switch 3-76
Heat
Cautions and actions to deal with intense heat 1-10
High beam indicator 3-72
High-mounted stop light
Bulb capacity 7-36
Replacement 7-45
High-Voltage components 1-41
Hood 7-4
BK0140800US.book 3 ページ ２０１１年９月２９日　木曜日　午後３時２８分

Alphabetical index
4Hood lock release mechanism and safety catch 7-27
Horn switch 3-90
Hot water heater fluid 7-7
,9-10
I
If the vehicle breaks down 6-2
i-MiEV 1-2
Cruising range 1-5
Main drive lithium-ion battery 1-4
Main features 1-2
Important facts to know in case of an accident 8-4
Indicator and warning light package 3-71
Indicators 3-72
Inside rearview mirror 3-26
Instrument cluster 3-58
Intense cold
Cautions and actions 1-12
Intense heat
Cautions and actions 1-10
Interior lights 3-124
J
Jump-starting 6-2
K
Key reminder buzzer 3-13
,3-31
Keyless entry system 3-7
Keys 3-2
L
Labeling 9-2
License plate lights
Bulb capacity 7-36
Replacement 7-47
Liftgate 3-16
Link System 3-90
Loading information 4-9
Lubricants 9-10
M
Main drive lithium-ion battery 1-4
Main Drive Lithium-ion Battery Level Indicator 1-63
MiEV Remote System 1-43
Mirror
Inside rearview mirror 3-26
Outside rearview mirrors 3-28
Modifications to and racing of your vehicle 1-7
O
Odometer 3-61
,3-62
Oil
Transmission oil 9-10
Operation under adverse driving conditions 6-22
Outside rearview mirrors 3-28
Outside temperature display 3-61
,3-67
BK0140800US.book 4 ページ ２０１１年９月２９日　木曜日　午後３時２８分