ABS MITSUBISHI LANCER EVOLUTION IX 2005 User Guide

204G6 – ROCKER ARM / CAMSHAFT
2. Ensure that the cutaways in the intake side cover and the tabs on the
gasket are aligned with the positions shown in the diagram, and
tighten at the specified torque of 14 ±1 N-m. The exhaust side cover
and gasket do not have a specified installation direction.
Comment :
The cover and gasket do not have distinct front and rear sides.
No cutawayNo installation direction Exhaust side
Intake side
Ta b Ta b
Cutaway
Cutaway

*

*


A


*


*


*


*


*


*



*

*

LAYOUT DIAGRAMS - ENGINE COMPARTMENT1-4
A-01 (2-grey) Side turn signal lamp (RH)
A-02 (2-grey) Brake fluid level switch
A-04 (2-grey) Side turn signal lamp (LH)
A-05 (2-black) Front ABS sensor (LH)
A-06X Fog lamp relay or spare connector for fog
lamp relay
A-07X Horn relay
A-08X Condenser fan relay (LO)
A-09X Condenser fan relay (HI)
A-11X Radiator fan control relay
A-12X Front ECUA-13X (11) Front ECU
A-14 (2-black) Junction between front harness (LH) and
control harness
A-16 (2-black) Headlamp (HI : LH)
A-19 (3-grey) Radiator fan controller
A-20 (1-black) Horn (HI)
A-21 (2-brown) External air temperature sensor (vehicle
fitted with fully automatic A/C)
A-22 (1-black) Horn (LO)
A-23 (2-black) Headlamp (HI: RH)
A-28 Spare connector for fog lamp
A-29 Dummy connector
ENGINE COMPARTMENT
Connector Symbol
Front harness (RH)

LAYOUT DIAGRAMS - ENGINE COMPARTMENT1-5
A-31 (2-black) Front ABS sensor (RH)
A-32 (4-black) Dummy connector
A-33 (4-black) Headlamp ASSY (LH) (except discharge
headlamps)
(8-black) Headlamp ASSY (LH) (discharge
headlamps)
A-34 (2) Intercooler water spray motor
A-35 (2-black) Fog lamp (LH)
A-36 (2-black) Condenser fan motor
A-37 (2-grey) Condenser fan motor
A-38 (1-black) Power steering fluid pressure switch
A-39 (1-black) A/C compressor (vehicle with manual
A/C, fully automatic A/C) or dummy
connector (vehicle with heater)A-40 (2-black) Fog lamp (RH)
A-41 (4-black) Headlamp ASSY (RH) (except discharge
headlamps)
(8-black) Headlamp ASSY (RH) (discharge
headlamps)
A-42 (2-brown) Dual pressure switch (vehicle with
manual A/C, fully automatic A/C) or
dummy connector (vehicle with heater)
A-52 (2-yellow) Front impact sensor (RH) (vehicle not
fitted with front passenger airbag)
A-53 (2-yellow) Front impact sensor (LH) (vehicle not
fitted with front passenger airbag)
Front harness (LH)

LAYOUT DIAGRAMS - ENGINE / TRANSMISSION1-8
B-106 (2-grey) Knock sensor
B-108 (2-black) Coolant temperature sensor
B-109 (34-black) ABS-ECU
B-114 (1-black) Water temperature gauge unit
B-115 (3-black) Exhaust cam position sensorB-119 (3-grey) Ignition coil 2
B-122 (3-black) Crank angle sensor
B-123 (3-grey) Ignition coil 1
B-124 (2-black) Fuel pressure solenoid valve
Engine / Transmission (continued)
Connector Symbol
Control harness
Battery harness

LAYOUT DIAGRAMS - ENGINE / TRANSMISSION1-9
B-126 (6-black) Idle speed control servo
B-127 (4) Electric pump relay
B-128 (4) Fuel pump relay 3
B-129 (6-black) Register (for injector)
B-130 (2-black) Fuel pump register
B-131 (3-black) Vehicle speed sensorB-132 (2-black) Back-up lamp switch
B-133 (2-black) Secondary air control solenoid valve
B-134 (2-black) Oil feeder control valve
B-135 (3-black) Manifold absolute pressure sensor
Ground cable
Transmission harness

LAYOUT DIAGRAMS - FLOOR / ROOF1-16
D-01 (3) Door switch (front : RH)
D-02 (2-black) Seatbelt pre-tensioner (RH)
D-03 (8) Floor harness (RH) / Rear door harness
(RH) junction
D-04 (2) Front cabin lamp
D-05 (2-black) Rear ABS sensor (RH)
D-06 (2-grey) Rear cabin lamp (Vehicle not fitted with
sunroof)
D-07 (3) Door switch (rear : RH)
D-09 (3) Door switch (rear : LH)D-10 (5-grey) Fuel pump and fuel gauge unit (main)
D-11 (2-black) Rear ABS sensor (LH)
D-12 (8) Floor harness (RH) / Fuel harness
junction
D-13 (8) Floor harness (LH) / Rear door harness
(LH) junction
D-14 (2-black) Seatbelt pre-tensioner (LH)
D-15 (3) Door switch (front : LH)
FLOOR / ROOF
Connector Symbol
Roof harness
Floor
harness (RH)
Instrument panel harness
Console harness

PART INSTALLATION POSITIONS - SENSORS2-3
Manifold
absolute
pressure sensor
Knock sensor
connector
Transmission caseThrottle position
sensor Inlet
manifold
Knock sensor
Vehicle speed
sensor
Crank angle sensor
connectorCrank angle
sensor Air flow sensor
Air temp.
sensor

PART INSTALLATION POSITIONS - SENSOR2-5
Parking brake lever
Later G sensor
Front ABS sensor
connector
Rear ABS sensor
connectorHydraulic pressure
unit ASSY
Pressure sensor
Front/rear G sensor
Front ABS sensor
Parking brake
cableRear ABS sensor

3-2
Equipment
ABS ................................................................3-122
ACD (vehicle without AYC) ............................3-130
ACD, AYC ......................................................3-138
SRS airbags, seatbelt pre-tensioners
(vehicle without front passenger airbag)........3-148
SRS airbags, seatbelt pre-tensioners
(vehicle with front passenger airbag).............3-152Sunroof ..........................................................3-154
Ignition key reminder buzzer..........................3-157
Intercooler water spray ..................................3-158
Engine immobilizer system ............................3-160
Security alarm ................................................3-162
Spare connector for fog lamp ........................3-167
Generic spare connectors..............................3-168

CIRCUIT DIAGRAMS - J/C3-7
• Windscreen
washer / wiper
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer•Fog lamps
•Full auto A/C
•Headlights
•Headlight
levelling
system
•Manual A/C
•Cooling
• Windscreen
washer / wiper
• Turn signal
lights, hazard
lights• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer
• Fog lamps
• Headlights• Ignition key
reminder
buzzer
• Windscreen
washer / wiper
• Sunroof
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer• Power windows
• Fog lamps
• Headlight
• Rear washer /
wiper Generic spare
connector
Vehicle speed
sensor• Windscreen washer /
wiper
• Electric stowable
remote control door
mirrors
• Cabin lights, boot
compartment lights,
ignition key cylinder
illumination light, door
ajar indicator light
Diagnosis
connector• ABS
• ACD
(vehicle
w/out AYC)
• ACD, AYC Needle meters• Heater
• Full auto A/C
• Manual A/C
J/B
Sunroof
Power
windows• Windscreen
washer / wiper
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer
• Fog lamps
• Headlights
• Rear washer /
wiperDiagnosis
connectorReversing
lights
Rear washer/
wiper• Reversing lights
• Rear washer /
wiper Generic
fuse
(
)