air condition MITSUBISHI MONTERO 1989 1.G Workshop Manual

x
Service Manual
MONTCRO
GROUP INDEX NrJDAA-A
Introduction and
Master Troubleshooting ......*....*...*..
Lubrication and Maintenance . . . . . . . . .
m.
1989 : Volume 1
FOREWORD
This Service Manual has been prepared with the
latest service information available at the time of
publication. It is subdivided into various group
categories and each section contains diagnosis,
disassembly, repair, and installation procedures
along with complete specifications and tightening
references. Use of this manual will aid in properly
performing any servicing necessary to maintain or
restore the high levels of performance and reliability
designed into these outstanding vehicles.
4liP A
.
n
WESUPPORT
VOLUNTARY TECHNICIAN
CE,TT,flCA~ONMROUGH
MITSUBISHI MOlUR SALES OF AMERICR Inr
Mitsubishi Motors corporation reserves the right to make changes in
design or to make additions to or improvements in its products without
imposing any obligations upon itself to install them on its products
previously manufactured.
Front Suspension . . . . . . . . . . . . . . . . . . . . . . . . . . . . . y
Rear Axle *.......*.......*................a.....*..
m
Service
Srakes- Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . &
Clutch ................................................
Hi
Cooling .............................................
w
Engine ............................................... m
Intake and Exhaust ,.......*..........*......
ml
Fuel System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
mE
Propeller Shaft and Universal
Joint . . . . . . . . m;
Rear Suspension . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . mt
Power Steering . . . . ..a*........................
m
Transmission - fity$tic . . . . . . . . . . . . . &!a
Wheels and Tires .............................
FP
Body .................................................. m
Heater and Air Conditioning ........... p!’
Emission Control Systems .............. &!!!!
NOTE
For Electrical refer to .._
Volume-2 “Electrical”
Q 198’8 Mitsubishi Motors Corporation Printed in Japan

INTRODUCTION AND MASTER TROUBLESHOOTING - How To Use This Manual
3
Page number
Group title Section title
7-io t COOLING - Thedostat
vrra-r I
THERML . -.
REMOVAL AND INSTALLATlON
I Indicates tightening
torque
Repair kit or set parts are
shown. fOnlv verv freouentlv
-
1. Connection of enginecoolant temperature
syitch connector (Vehicles with an air condition-
3. Water outlet fitting
4. Water outlet fitting gasket
+ee 5 Thermostat
I This number corresponds to
the number in “Removal
steps”, “Disassembly
steps”, “Installation steps”
or “Reassembly steps”.
L
SERVICE POINTS OF INSTALLATION-
S. INSTALIATION OF THERMOSTAT
Install the thermostat to the intake manifold as illustrated.
caution
The thermostat Range tits over
the manifold seat;
ensure that the thermostat is not installed at an angle.
An explanation of procedures, notes, etc.
regarding removal, installation. disassembly
and reassembly.