brake fluid MITSUBISHI SHOGUN 2016 (in English) User Guide

During cold weather
E01006600019
To ensure proper operation of the washers at
low temperatures, use a fluid containing ananti-freezing agent.Brake fluid
E01000900847
To check the fluid level
The brake fluid level is monitored by a float.
When the brake fluid level falls below the “MIN” mark, the brake fluid warning lamp
lights up.

The brake fluid level must be between the
“MAX” and “MIN” marks on the reservoir.LHDRHD
If the level is below the “MIN” mark, check
according to the following procedure: 1. Turn the ignition switch to the “LOCK”
or “ACC” position.
2. Repeatedly depress the brake pedal until
significant resistance is felt (normally af-
ter about 40 times).
3. Check the brake fluid level in the reser-
voir.
The brake fluid level must be between the “MAX” and “MIN” marks on the
reservoir.
The fluid level falls slightly with wear of the brake pads, but this does not indicate any ab-
normality.
If the brake fluid level falls markedly in a short length of time, it indicates leaks from
the brake system.
If this occurs, we recommend you to have the vehicle checked.
Fluid type
Use brake fluid conforming to DOT3 or
DOT4 from a sealed container. The brake
fluid is hygroscopic. Too much moisture in the brake fluid will adversely affect the brake
system, reducing the brake performance.
CAUTIONl Take care in handling brake fluid as it is
harmful to the eyes, may irritate your skin
and also damage painted surfaces.
Brake fluid
10-09OVWE16E1Maintenance10

CAUTIONlUse only the specified brake fluid.
Do not mix or add different brands of brake fluid to prevent chemical reactions.
Do not let any petroleum-based fluid touch, mix with, or get into the brake fluid.
This will damage the seals.
l Keep the reservoir tank cap closed to pre-
vent the brake fluid from deteriorating ex- cept maintenance.
l Clean the filler cap before removing and
close the cap securely after maintenance.Clutch fluid*
E01001001507
To check the fluid level
The clutch fluid in the master cylinder should
be checked when performing other under- hood service. In addition, the system shouldbe checked for leakage at the same time.
Check to make certain that the clutch fluid
level is always between the “MAX” and
“MIN” level markings on the fluid reservoir.
If the fluid level falls markedly in a short length of time, it indicates leaks from the
clutch system.
If this occurs, we recommend you to have the
vehicle checked.
Fluid type
Brake fluid conforming to DOT 3 or DOT 4 should be used.
The reservoir cap must be fully tightened to avoid contamination from foreign matter or
moisture.
DO NOT ALLOW PETROLEUM-BASED
FLUID TO CONTACT, MIX WITH, OR
OTHERWISE CONTAMINATE THE BRAKE FLUID. SEAL DAMAGE WILL
RESULT.WARNINGl Take care in handling brake fluid as it is
harmful to the eyes, may irritate your
skin and also damage painted surfaces. Wipe up any spills immediately.Power steering fluid
E01001102459
To check the fluid level
Check the fluid level in the reservoir whilethe engine is idling.
Clutch fluid*
10-10OVWE16E1Maintenance10

No.ItemQuantityLubricants
1Engine oil
3000 modelsOil pan4.3 litres
Refer to page 10-04.
Oil filter0.3 litre
3200 models
Oil pan7.5 litresOil filter1.0 litreOil cooler1.3 litres
3800 models
Oil pan4.3 litresOil filter0.3 litreOil cooler0.3 litre
2Automatic transmission flu-
id3000 models, 3800 models9.7 litresMITSUBISHI MOTORS GENUINE ATF SPIII3200 models *110.9 litresMITSUBISHI MOTORS GENUINE ATF-PA*1
: 3200 models do not have a dipstick.CAUTIONl For the automatic transmission fluid, use only the MITSUBISHI MOTORS GENUINE ATF.
Use of a different fluid could damage the transmission.No.ItemQuantityLubricants3Brake fluidAs requiredBrake fluid DOT3 or DOT44Clutch fluidAs required
5Washer fluid
Front5.1 litres
—Rear *11.4 litres*1
: Rear washer fluid container is located on the backdoor. (Refer to “Rear window washer fluid” on page 10-08.)
Refill capacities
11-15OVWE16E1Specifications11

A
Accessory (Installation).....................................2-04
Accessory socket............................................... 7-77
Active stability & traction control (ASTC)....... 6-44
Additional equipment...................................... 10-19
Air conditioning Front automatic air conditioning................... 7-03
Important operation tips for the air conditioning................................................. 7-11
Rear air conditioning.....................................7-09
Air purifier (with deodorizing function)........... 7-11
Airbag................................................................ 4-36 Caution for installing the child re-straint on vehicle with a front pas-
senger’s airbag............................................. 4-39
Antenna............................................................. 7-50
Anti-lock brake system (ABS).......................... 6-41 Warning lamp................................................6-43
Approach lamps.................................................3-08
Armrest..................................................... 4-08,4-10
Ashtray.............................................................. 7-76
Audio LW/MW/FM radio/CD player...................... 7-12
To listen to a disc in the Video En- tertainment System...................................... 7-39
Troubleshooting............................................ 7-47
Auto-cutout function......................................... 7-82
Automatic headlamp levelling.......................... 5-42
Automatic high-beam system............................ 5-36 Automatic high-beam system warning lamp 5-39
Automatic transmission
Fluid............................................................ 11-14
Selector lever operation................................ 6-19
Selector lever position...................................6-21
Sports mode.................................................. 6-21
B
Backdoor........................................................... 3-08
Battery............................................................. 10-11 Charge warning display................................ 5-12
Discharged battery (Emergency starting)..... 8-02
Specification............................................... 11-11
Bleeding the fuel system................................... 8-06
Bluetooth® 2.0 interface................................... 7-50
Bonnet............................................................. 10-03
Brake Anti-lock brake............................................. 6-41
Brake assist system....................................... 6-41
Braking.......................................................... 6-39
Fluid.................................................. 10-09,11-14
Parking brake................................................ 6-05
Power brakes................................................. 6-40
Warning lamp................................................5-10
Bulb capacity........................................ 10-25,10-26
C
Card holder................................................7-75,7-84
Cargo loads........................................................6-64
Catalytic converter.......................................... 10-02 Cautions on handling of 4-wheel drive vehicles................................................... 6-38
Central door locks............................................. 3-07
Centre console box............................................ 7-83
Centre information display................................ 5-12
Changing a fuse............................................... 10-23 Charge warning display.....................................5-12Check engine warning lamp.............................. 5-11Child restraint.................................................... 4-26 Caution for installing the child re-straint on vehicle with a front pas-
senger’s airbag............................................. 4-39
Child-protection rear doors............................... 3-08
Cigarette lighter................................................. 7-76
Cleaning Aluminium wheels........................................ 9-05Chrome parts................................................. 9-05
Exterior of your vehicle................................ 9-03
Genuine leather............................................. 9-03
Interior of your vehicle................................. 9-02
Plastic, vinyl leather, etc............................... 9-02
Polishing....................................................... 9-04
Sunroof.......................................................... 9-06
Washing........................................................ 9-03
Waxing.......................................................... 9-04
Clutch
Fluid.................................................. 10-10,11-14
Coat hooks......................................................... 7-88
Combination headlamps and dipper switch...... 5-34
Convenient hook............................................... 7-87
Coolant (engine)....................................10-06,11-14
Cruise control.................................................... 6-48
Cup holder......................................................... 7-85
Curtain airbag system........................................ 4-44
D
Daytime dipper button.......................................5-07
Daytime running lamps..................................... 5-35
Alphabetical index
12- 1
OVWE16E1Alphabetical index

Demister (rear window).................................... 5-50
Diesel particulate filter (DPF)........................... 6-16
Diesel preheat indication lamp.......................... 5-09
Digital clock Time Setting.................................................. 7-44
Dimensions...................................................... 11-04
Dipper (High/Low beam change)......................5-36
Door ajar warning lamp.....................................5-12
Door courtesy lamps............................... 7-82,10-26 Bulb capacity.............................................. 10-26
Replacement................................................ 10-33
Doors
Central door locks......................................... 3-07
Child-protection............................................ 3-08
Lock and unlock............................................ 3-06
Driving, alcohol and drugs................................ 6-02
E
Economical driving........................................... 6-02
Electric window control.................................... 3-16 Switch........................................................... 3-16
Timer function.............................................. 3-17
Electrical system............................................. 11-11
Electronic immobilizer (Anti-theft starting system)................................................ 3-03
Emergency starting............................................8-02
Engine Coolant..............................................10-06,11-14MIVEC.......................................................... 6-15
Number....................................................... 11-03
Oil..................................................... 10-04,11-14
Overheating................................................... 8-04
Specifications.............................................. 11-10
Used engine oils safety instructions and disposal information............................. 2-05
Water temperature gauge.............................. 5-06
Exterior and interior lamp operation............... 10-19
F
FluidAutomatic transmission fluid...................... 11-14
Brake fluid........................................ 10-09,11-14
Clutch fluid....................................... 10-10,11-14
Engine coolant.................................. 10-06,11-14
Power steering fluid.......................... 10-10,11-14
Washer fluid..................................... 10-08,11-14
Fog lamp switch................................................ 5-43
Foot lamps and ceiling lamp............................. 7-81
For cold and snowy weather............................10-19
Front automatic air conditioning....................... 7-03
Front fog lamps Bulb capacity.............................................. 10-25
Indication lamp............................................. 5-09
Replacement................................................ 10-28
Switch........................................................... 5-43
Front passenger’s airbag OFF indication lamp. 4-40
Front seats......................................................... 4-05
Front turn-signal lamps
Bulb capacity.............................................. 10-25
Replacement................................................ 10-28
Fuel consumption............................................ 11-12
Fuel Filling the fuel tank....................................... 2-03Fuel filter indication lamp............................. 5-10
Fuel gauge..................................................... 5-05 Fuel selection................................................ 2-02
Low fuel warning lamp................................. 5-06
Modification/alterations to the electrical or fuel systems............................. 2-05
Tank capacity................................................ 2-03
Fuses................................................................ 10-20
Fusible links.................................................... 10-19
G
Gauges.......................................................5-02,5-08
General maintenance....................................... 10-19
General vehicle data........................................ 11-04
Genuine parts.....................................................2-05
Glove box.......................................................... 7-83
Glove box lamp Bulb capacity.............................................. 10-26
Replacement................................................ 10-33
H
Hazard warning flasher switch.......................... 5-42
Hazard warning indication lamps......................5-09
HDMI port......................................................... 7-74
Head restraints................................................... 4-12
Headlamp levelling........................................... 5-40
Headlamp washer switch...................................5-48
Headlamps Bulb capacity.............................................. 10-25
Headlamp flasher.......................................... 5-39 Replacement................................................ 10-26
Switch........................................................... 5-34
Heated mirror.................................................... 6-11
Heated seats....................................................... 4-09
High-beam indication lamp............................... 5-09
Alphabetical index
12- 2 OVWE16E1Alphabetical index

High-mounted stop lamp (bulb type)Bulb capacity.............................................. 10-25
Replacement................................................ 10-30
Hinges and latches lubrication........................ 10-19
Horn switch....................................................... 5-50
I
If the vehicle breaks down................................ 8-02
Ignition switch................................................... 6-11
Indication and warning lamps........................... 5-08
Indication lamps................................................ 5-09
Inside rear-view mirror......................................6-08
Inspection and maintenance following rough road operation........................................ 6-37
Installation of accessories..................................2-04
Installation position for warning triangle.......... 7-89
Instruments........................................................ 5-02
Interior lamp switch.......................................... 7-78
Interior lamps.................................................... 7-78
J
Jack handle........................................................ 8-09Storage.......................................................... 8-09
Jack.................................................................... 8-07
Storage.......................................................... 8-07
Jump starting (Emergency starting).................. 8-02
K
Keyless entry system......................................... 3-03
Keys...................................................................3-02
L
Labeling...........................................................11-02
Lamp monitor buzzer........................................ 5-36
Lamps (headlamps, fog lamp, etc.) auto-cutout function......................................... 5-35
Leakage (Fuel, engine coolant, oil and exhaust gas)............................................. 10-19
Licence plate lamps Bulb capacity.............................................. 10-25
Replacement................................................ 10-31
Link System.......................................................7-50
Low fuel warning lamp..................................... 5-06
Lubricants........................................................ 11-14
Luggage compartment lamp.............................. 7-80 Bulb capacity.............................................. 10-26
Replacement................................................ 10-32
Luggage floor box............................................. 7-84
Luggage hooks.................................................. 7-88
M
Making a flat seat.............................................. 4-20
Making a luggage area...................................... 4-13
Manual transmission......................................... 6-17 Oil............................................................... 11-14
Mirror
Inside rear-view mirror................................. 6-08
Outside rear-view mirrors............................. 6-09
MIVEC engine.................................................. 6-15
Modification/alterations to the electri- cal or fuel systems............................................2-05
N
NOx trap catalyst...............................................6-16
O
Odometer........................................................... 5-02
Oil pressure warning lamp................................ 5-12
Oil Differential oil............................................. 11-14
Engine oil.................................................... 10-04
Manual transmission oil.............................. 11-14
Transfer oil.................................................. 11-14
Operation under adverse driving conditions..... 8-19
Outside rear-view mirrors................................. 6-09
Overheating....................................................... 8-04
P
Parking.............................................................. 6-06Parking brake................................................ 6-05
Position lamps
Bulb capacity.............................................. 10-25
Indication lamp............................................. 5-09
Replacement................................................ 10-27
Power brakes..................................................... 6-40
Power steering Fluid.................................................. 10-10,11-14
System........................................................... 6-44
Precautions to observe when using wipers and washers.......................................... 5-49
Pregnant women restraint.................................. 4-25
Puncture (Tyre changing).................................. 8-09
Alphabetical index
12- 3
OVWE16E1Alphabetical index